Ford Van 4FDKE30L8FHC05271
Assigned to Police Dept Purchased 4/30/1998 Fuel Unleaded
‘Odometer ‘Completed Labor Cost Material Cost
63,898
63,846 7110/2006, $57.42 $4.90
LUBE-OIL-FILTER CHECK ALL LIGHTS AND LEVELS . REPAIR WIRE AT STROBE
LAMP ON SQUAD # 153,
63,713 712712005 $112.00 $287.28
‘Squad 153, Command Vehicle..Could you please check the brakes because | received
‘an e-mail advising that that the brake pedal is hard to push down and there is no give
‘when pushing it in, The brakes don't seem to grab, just applies enough pressure on the
brake to slowly bring vehicle to a stop. After the vehicle is parked, the brakes groan
ke they were sti fin stil tying to release
REPLACED FRONT BRAKE ROTORS,PADS AND CALIPERS
63,665 5/27/2005 $161.78 $4.80
‘Squad 153..Could you please check spotlight, | was advised it needs to be repaired, no
further info. Could you please check the lighting and signals to see if there working
properly. Thanks.
pm / check. over power wash under carriage. tighten oil filter adpter . check all lights.
‘spot lights out.
63,544 4211412004 $48.54 $4.80
LUBE-OIL-FILTER CHECK ALL LIGHTS AND LEVELS ON COMMAND UNIT # 153
63,429 2111/2004 $127.10 $171.60
‘SQUAD #153 REPAIR EXHAUST LEAKS AT PIPE FLANGE AND MUFFLER INLET.
REPAIR TRANS DIPSTICK TUBE. REPLACE FRONT TIRES AND CHECK OVER
TRUCK.
63,411 1211912003 $57.78 $9.86
LUBE-OIL-FILTER SERVICE TRANS CHECK ALL LIGHTS AND LEVELS ON SQUAD
#153
Prepared Thursday, September 18, 2008Ford Van 4FDKE30L8FHC05271
Assigned to Police Dept Purchased 4/30/1998 Fuel Unleaded
(Odometer Completed Labor Cost Material Cost
63,348 8/21/2003, $23.11 $4.56
LUBE-OIL-FILTER CHECK ALL LITES AND LEVELS ON COMMAND UNIT # 153
63,329
63,214
8/31/2005 $162.75 $68.95
‘squad #153 battery not taking charge. check system at 2 e oak. replaced Ift battery.
battery out of water may be over charged. by wall charger.
412612004 $23.11 $10.94
‘Command Vehicle #153, right windshield wiper needs to be replaced. Thanks
REPLACED WIPER BLADES
8/2/2005 $49.78 $4.80
squad #153 lof / check over.
3/8/2005 $49.78 $0.56
Squad 153..could you please check the turn signals because | was advised that they
are not working correctly. REPLACED TWO FRONT PARK LAMP BULBS
4126/2004 $34.66 $0.00
SQUAD 163 . CHECK OVER AND TEST ALL LIGHTS. NO OIL CHANGE NEEDED AT
THIS TIME (NO MILES).
8/17/2007 $342.12 $136,00
#183 no start. replaced batteries and install fuel system.
4/16/2008 $720.63 $44.76
#153 INSTALL MAIN KENWOOD RADIO AND FUEL SYSTEM
Prepared Thursday, September 18, 2008Ford Van AFDKE30L8FHC05271
Assigned to Police Dept Purchased 4/30/1998 Fuel Unleaded
Odometer Completed Labor Cost Material Cost
3/16/2008 $136.90 $85.30
‘squad #153 generator. replaced carb and air filter. includes time to pick parts and
remove and install generator in squad.
8/1/2008, $107.48 $0.00
#183 tear down and remove light bar
31712008, $638.61 $0.00
#183 setup new new incident comand vehicle. take to body shop for repair of warranty
crack in roof.
112412007 $133.20 $0.00
ROAD CALL TO PD START COMMAND UNIT # 153 PUT IN 2 EAST OAK
9/25/2008 $160.87 $0.00
#153 remove decals for auction
412412007 $133.20 $0.00
ROAD CALL TO PD START COMMAND UNIT # 153 PUT IN 2 EAST OAK
Labor Material
wa $3,280.82 $838.11
Prepared Thursday, September 18, 2008