You are on page 1of 5

Nicz 5/18/2013 I use a single light bulb, and a garden solar light photo resistor tapped to the bulb,

and connected to my volt meters ohm setting, to gauge the bulb brightness, by the given resistance value. Shokac 5/17/2013 C2, L3 and L4 is in serial resonance. For "induction cooker" use ZVS with 50V. ZVS is circuit with automatic resonance, but without capacitor in primary windings. Please, look this akula0083 video. http://www.youtube.com/watch?v=5w9nJahkFB0

T-1000 5/17/2013 Test Case 1 For everyone who got time and want to do series of experiments, please see test case 1 attached:

T-1000 5/16/2013 Post: To begin remaking circuit you need induction cooker type circuit connected to your yoke then apply resonance in series to air coil. It wil be ok only when will start to heat up wrench inside of air coil. Next, you need to modulate that magnetic field with choke inside of air coil and see what output you get in coil on top of air coil. Resonance in series plus resonance in parallel is best approach and that follows with ou effects when properly tuned.

L1 & L3 CW L2 CCW

Also there is interesting part of involving Tesla one wire resonant power transmission system which was shortened down to transmitter coil having receiver coil straight on same air core transformer. I think this is where all fun stuff happened because they got magnetically coupled and part of selenoid is shorted with capacitor to another part which got free oscillation. The transformer is also interesting because you can have 2 primaries inside looped core and secondary on top of both halves. This bit have association for me to what E. Leedskalnin was doing in 1930's.

PM: The best approach is with air core transformer and air core choke inside of it. If you choose core then it comes down to core's own resonant frequency and to levels where NMR starts to occur and is better to avoid that because it is not what you are intended to test. The main target is to get strong magnetic field in air core transformer with help of resonance in series then try to modulate it with secondary magnetic field coming from choke. For the start induction oven circuit is good enough for driving just needs some modification for low voltages. The input power drops to minimal in resonance on parallel and you most likely know about it. This is another step to minimize input power. To test magnetic field strength inside of air core the wrench or similar amount of metal is enough. They should get hot in relatively small time frame. If they do heat up you are on correct path. It is best to keep with Tesla coil building rules because that choke gets in same

magnetic coupling with air core transformer coil in regards to wave lengths and common frequency. So 1:4 ratios are just easy tuning targets later on. When you get time, just drop skype contact request to lt_t-1000 so we can talk live then.

T-1000 5/16/2013 Post: You need to get this replicated on air core transformer first before next step to Dally/Romanov/akula devices replication. T1000_firstStep_1.mp4 T1000_firstStep_2.mp4

To begin remaking circuit you need induction cooker type circuit connected to your yoke then apply resonance in series to air coil. It will be ok only when will start to heat up wrench inside of air coil. Next, you need to modulate that magnetic field with choke inside of air coil and see what output you get in coil on top of air coil. Resonance in series plus resonance in parallel is best approach and that follows with ou effects when properly tuned.

Cepren B 5/15/2013 Roman aka: Akula0083 Re: 's fuelless generator Kapanadze Message ROMAN 06 Jan 2013, 18:16 Contrary to listen all addle eggs and it's a real shame for experimenters !! all they do is say say and discuss!! And those who start with experiments and move from theory to theory bear all the costs on their verification and what is pity are all those who only talk are straight guru in the world of electronics and themselves they cant make simple inverter !! For all experimenters !! I have that or similar WORKING DEVICE LIKE KAPANADZE and working for me a long time. I have warmed house and all domestic devices with active load working on him!!

I am glad to help anyone who want to build and get it for home and for the house!! Contact email akula0083@mail.ru skype akula0083 A little elucidation to ensure that you're not getting at any jungle such as resonances and excitations !! This is all interesting but only for experiments !! I would say different kinds of games!! Our first and the basic task is to increase the current !! I see two ways to make this. First is when we take some ready voltage and convert it through the amplifier. Second when we forming needed voltage right in the amplifier. To the point of matter in Kapanadze device main role play the second inverter - in fact trans of inverter which was placed in the field built by amplifier. Make a simple trans 12-220, 24-220, 36-220 how to be at one's ease or how one's have radio parts. Put the trans in the field generated by inductor of a simple induction heater scheme. To make a tangible result the field must have the force to heat up the metal object which is equal in dimension with trans . This is an observation from my personal experience take a piece of iron about the same size as our trans and place him in the inductor turn on induction heater as so speak and if metal warming very quickly, well somewhere about in 120 seconds and if already difficult to keep metal in the hands all will work. Complexity is in that to make windings of trans on such a way so the current build by inductor dont hamper the work of the transistors or thyristors shape 220 volt 50 hertz. Here do as you want.wind bifilars or if you want put intervening transformer.

You might also like