Pipe is normally used to convey fluids, so the internal cross-sectional area (defined by the ID) is important. Tube is more frequently used in structures so the OD is the important number. Wall thickness under tolerance is up to 12.5% applied for all pipes as and welded fittings as per ASME B16.
Pipe is normally used to convey fluids, so the internal cross-sectional area (defined by the ID) is important. Tube is more frequently used in structures so the OD is the important number. Wall thickness under tolerance is up to 12.5% applied for all pipes as and welded fittings as per ASME B16.
Pipe is normally used to convey fluids, so the internal cross-sectional area (defined by the ID) is important. Tube is more frequently used in structures so the OD is the important number. Wall thickness under tolerance is up to 12.5% applied for all pipes as and welded fittings as per ASME B16.
1 Pipe is normally used to convey fluids, so Tubing is more frequently used in the internal cross-sectional area (defined structures so the OD is the important by the ID) is important number
2 Pipe is specified by the nominal diameter Tube is specified by the outside
(DN or NPS) and Schedule (Thickness) diameter and thickness as per ASME B36.10M , ASME B36.19M and API 5L
3 Wall thickness under tolerance is up to -No permissible wall thickness under
12.5% applied for all pipes as and welded tolerance for tube sizes less than 2 in fittings as per ASME B16.9 -For tubes 2 in and larger the permissible wall thickness under tolerance is up to 10% for seamless tubes and up to 5% for welded tubes As per ASME PBV code, Sec. II , SA- 450