Professional Documents
Culture Documents
ON
AUTOMATIC CABLE CAR
Project Guide
Ms.Surinder Kour BaliSyed Gazanfer(399/11)
(H.O.D AE&IE DEPT)
22\5\2015
Contents
Introduction
Classification of cable cars
Comparison between cable car and fuel car
Technical defaults
Proposed system
Signal flow
Circuit components
Circuit diagram
Future scope
References
22\5\2015
Introduction
Fig1:cable car
Contd
Contd
The system also consists of a passenger
counting system for single trip and also the
total passenger count based on an IR sensor .
The PLC is used to control the Motors for door
opening and closing as well as movement and
stoppage of cable car system.
22\5\2015
CLASSIFICATION
FIXED GRIP
Fig2:Fixed Grip
22\5\2015
OF
CABLE
CAR
DETACHABLE GRIP
Fig4:Monocable
22\5\2015
BI-CABLE
Fig5:Bicabl
e
FUEL CAR
Pollution free.
Environment friendly.
Accidents rare.
Large carrying capacity.
High efficiency
22\5\2015
Pollution present.
Not friendly.
Accidents prone.
Low carrying capacity.
Low efficiency
Technical
Defaults
Limitations:
Mechanical opening and closing of doors of
cabin.
Lack of evenly distribution of load in the
cabins.
Overloading in cabins as there is no counting
of boarders.
Time independent opening and closing of
doors of cabin.
22\5\2015
Proposed system
To make this process fully automatic a PLC
unit is used.
Fig6:block diagram
22\5\2015
10
22\5\2015
11
SIGNAL FLOW
22\5\2015
12
Circuit Components
1. IR Sensors:
. IR Sensors work by using a specific light sensor to
detect a select light wavelength in the Infra-Red (IR)
spectrum.
Fig7:IR
Sensor
MAHANT
BACHITTAR SINGH
22\5\2015
13
2.MOTER DRIVE
Fig8:Schematic of Motor
Fig9:Pin Diagram of Motor
Drive
Drive
MAHANT BACHITTAR SINGH
22\5\2015
14
Fig10:PLC
22\5\2015
15
CIRCUIT DIAGRAM
Fig11:Circuit Diagram
22\5\2015
16
FUTURE SCOPE
The cable system car system can be made fully
automated and safe by including weight
measurement in the cable car using load cells.
Transistor an receiver can be used for
communication between PLC and IR sensor.
22\5\2015
17
References
http://www.skilifts.org/old/tech_fact
s_liftmaintenance_pebblecreek.htm
http://www.liftchairsrus.com/Troubles
hooting-lift-chair-electrical-compone
nts_b_3.html
http://gulmarggondola.com/index.ph
p
http://robotix.in/tutorial/category/au
to/motor_driver
22\5\2015
18