in 2g systems, capacity of a sector is calculated by the
number of available TCH timeslots.
a a 7 2 3 7 5 @ 7
i weer | soa [ee ew | reef en [eee
2) seen | ven [ tee] ven | em | ves | vem | im
3 [seen [tee | ee | ime | we | vee | tH | 1H
aL ar er [ee ee fem | ee i]
Full Rate Users: 27
Half Rate Users:* in 3G systems, capacity of sector is calculated by the
number of available CE. Utilization of CE varies for
different traffic classes / bearers / services.
* describes the SW licensed capacity resources required
for a dedicated channel (DCH or E-DCH).
* the number of channel elements, N.,, required in a
RBS is based on the traffic type, and is dependent on
the radio bearers to be used, as well as on the
number of simultaneous users for each specific radio
bearer.* each time a dedicated channel is allocated, channel
elements will be consumed in UL and DL.
* the consumption can be described as a cost, and
depends on the type of radio bearer for the dedicated
channel.
° if there is an insufficient amount of channel elements
available, blocking might occur. To avoid blocking, a
best effort user will be switched down to a lower rate
to make channel elements available for the requested
dedicated channel.
* channel elements are asymmetrically allocated, which
means that the CEs are allocated separately in uplink
and downlink. Thus the CE requirements for the Node
B must be computed separately for UL and DL using
the individual service bit rates, and consider which
among the UL and DL CE requirements is higher.
* for HSDPA, aside from the 32 CEs reserved for HS-
DSCH downlink traffic, the corresponding A-DDCH
(Associated DCH) on uplink and SRB (Signaling Radio
Bearer) on downlink must be considered.
* for UL A-DCH the channel elements needed is based
on the bearer rate, while for DL SRB only one CE is used
in each connection.INPUTS REQUIRED:
* number of subscribers per Node B
traffic usage per subscriber per application: AMR,
C564, PS64, PS128, PS384, HSDPA
or
* traffic usage per application
ASSUMPTIONS:
* Soft Handover Overhead (SHO) = 30%DIMENSIONING PROCESS:
* compute separately for UL and DL CE Requirements
* determine the total traffic per application per Node B
* compute the number of CEs required per application
(R99 CE)
* compute CEs needed by A-DCH based on HSDPA
bearer rate for UL and 1 CE on each connection for DL
* add the CEs required for R99 and HSDPA A-DCH
* compute for the Soft Handover CE eenroment oy!
multiplying the above result by SHO
* add the CEs for HSDPA scheduler reserved block
° add the CEs needed for control channels
* sum up the CEs required for R99 and A-DCH, SHO,
HSDPA scheduler and control channels to get the
total required CEs for ULand DL
* compare the DL and UL CE requirements; use the
higher value to compute the number of modules
required: eg. 1 module = 192 CEs* Node B with 3 sectors
* BH Traffic mix: 12 x AMR,
3x CS64,
5 x 64/128 PS,
2 x 64/384 PS,
2x 384/HSPDA
* SHO = 30%
* Max 16 HSDPA users per BTS
Compute for the DL and UL CE Requirements
12.2 kbps AMR, porary
5.64 kbps 340
PS 64/128 kbps 5*4=20
PS 64/384 kbps 2428
384 ADCH HSDPA 216 =32
84
84*0.3=26.