PLCs. Create a new project on TIA portal V11. 1. First open the software TIA portal V11 by double clicking on the TIA portal icon. 2. Then click on create new project. After that you must choose a name to your new project and click on the create button. (Fig.1) 3. Choose the hardware options (the PLCs and its modules) by clicking the configure a device option. (Fig. 2) 4. Click on add new device and select a PLC, then select the PLCs modules (inputs, outputs, etcetera). (Fig. 3) 5. Create your program, clicking on program blocks then main [OB1]. (Fig. 4) 6. Select the instructions that the program will have. (Fig. 4) 7. Finally save the project clicking the save project icon. (Fig. 4)
Fig. 2 Select devices options.
PLCS PLCS modules
Fig. 3 Add PLCs modules.
Save project Main [OB1] Fig. 4 Creating the ladder program.
Fig. 1 Create new project.
Instructions
Temperature controller Watlow
PM 6. Programing a temperature alarm on a Watlow PM 6. 1. First of all connect the 98 and 99 inputs to AC current. That will turn on the temperature controller. (Fig. 5) 2. Press the up and down buttons at the same time for three seconds. At the upper side of the screen will appears the message A1 and oper below. (Fig. 6) 3. Navigate by the menu pressing the up or down buttons until the screen shows the word ALM. At this point press the green button to enter into the alarm menu. (Fig. 7) 4. Select the temperature which will activate the alarm by pressing the up or down buttons. 5. Finally press the infinite button for two seconds to go back to the start page which shows the temperature of any temperature sensor. (Fig. 8)