You are on page 1of 86
HCD-H50/H55/H1100 SERVICE MANUAL HCD-H50, HCD-HS5 and HCD-H1100 are the tuner, deck, CD and amplifier section in FHB5OCD, FH-B55CD and MHC-1100 respectively olay noise reduction manufactured under lense trom Dolby Laboratories Licensing Corporation. ‘DOLBY and the double-O symbol DO) ar trademarks of Dolby Laboratories Licensing Corporation. PHOTO: He US Model Canadian Model E Model Australian Model HCD-H50 AEP Model HOD.H55 HCD-H1100 UK Model HCD-H1100 cons bomber [Model Name Using Similar Me (CD Mechanism Name jechanism | HCD-H5 (CDMi3A-5BD3 Base Unit Name [Bu-sBD3 SPECIFICATIONS AUDIO POWER co SPECIFICATIONS (US model) — POWER OUTPUT AND TOTAL HARMONIC DECK DISTORTION : Section With 6 ohm loads, both Model Name Using Similar Me jechanism | HCD-HS ‘Tape Transport DECK A_| TCM-180VAN2_ [Mechanism Type DECK B | TCM180VBN2 channels driven, from For AEPUK, Gand EE model MW: 531—1,602kH2 60Hz—20 kHz; rated LW: 183-279KHe 16 watts per channel For & ER and AUS model MW §31—1,602KH2 minimum RMS power, with no more than 1% total SW: 5.95~17.9MHe extemal harmonic distortion from 250 Aatenna carne milliwatts to rated output. Interact equncy “onke Tuner Sec! System ise, FAM ‘Amplifier Section ‘pereterdye tee Continoous RMS power output "204 20wats (6 ohms at 1H, 5% THO) 27.~1o0mie music power outit Antena Telescope antonra tA and AUS race) (C0 H50/H55), 240 wate (6 ohms) Fed arte opts MX MIC (ioc) Heo 100 serait Antenna temas 75 ohn unbalanced Impedance Intec eqeney 600 ome 10.7MHe ‘AM tuner section Tuning range For US, Canadian model MW: 530-1,720KHe For IT modal Mw: 522-1611 @ LW: 144—2aente For HCOHSS/HL100 PHONO (Phono jac): sanity 8, Impedance 47 kit COMPACT DISC —continsed on nest pase DECK RECEIVER SONY. HCD-H50/H55/H1100 For HODMSO Cassette Deck Section Dimensions Approx. 615%285%255mm VIDEO/AUX (phono jack Recording system track 2-channa stereo (winia) ‘sensitivity 400 mv, Frequency response (DOLBY NR OFF) (24,/011°/,%10'/ nes) Impedance 47 kiohrs 60-1300 Hz (3 a8), incl projecting pats ane outputs HEADPHONES (ster sing TYPE T cassette controls rinse): (Gory HFS) Weight ‘Approx 12.28 (26 1b 14 02) accepts headphones of ohms or more 60=14.000 He (23 48), sing TYPE Tt cassette Aceessorias supped ‘AM lop antenna (1) “SPEAKER: Wow and fatter 0.155 WRMS £0.35 (OIN) Remote eomtnandet (1) accepts speakers of 6 to Sony SUM (NS) batteries 16 ohms. @ General FM ead anteons (1) Compact Disc Player Section (HCD:H1100 ony) System Compact isc eigital ausio _[Pstiation [Power Power system requeronts __|consumation | pasign and speciation subj fo change Laser Semiconductor ler [US |120VA0, 60 He [60 watts | without notice 2700) [anadian [120 VAG, 60 He [BO watts | acy ar tat mason durin: = ee te eemany, FT: Hakan, Continuous = ee eee EA: Saudi Arabia, AUS: Austrakian, Laser output Maw 446 : EE: East European ‘This outputs the vale |G ITEE [220-230 VAC, [60 watts ressured at sstace of about ‘50 He eee ied 200 mm trom the objective [EEA AUS|110-100 Vor [60 watte Tie mci cates a tens surace onthe Optical '220~240 v ac, } cuss Asst pea Prekup Block, sdstatie 50/60 He | | histoandonme rw Signal to nase retioMore than 95 68 ) i 40 AG, SOHZ _|120Wat [ee Dynamse range More than 90.68 [240 AG; SOHs _|120¥a ts TABLE OF CONTENTS Section Title Page 1. SERVICING NOTES 3 2. GENERAL 2.41, Parts Identifications 6 2.2. Tuner Section 8 2.3, Amplifier Section 10 24, CD Section 10 25. Deck Section 13 3. DISASSEMBLY 3.1. Case Ascy. 19 3.2, Power Assy 19 33, Main Board 19 34, CD Block 20 35, Cassette Deck Block 20 36, VR, Display, Jack, SW Boards 20 4, MECHANICAL ADJUSTMENTS 21 5, ELECTRICAL ADJUSTMENTS 21 ‘Section Title Page 6. DIAGRAMS. 61, Semiconductor Lead Layouts 26 62, Circuit Boards Location 2 63. Printed Wiring Boards —Tuner/CD/Deck Section— 30 64. Schematic Diagram—Tuner Section— 33 65. Schematic Diagram—CD Section— 36 66. Schematic Diagram—Deck Section 39 67. Schematic Diagram —Power/Amplifier/Display Section— 48 68, Printed Wiring Boards —Power/Amplifier/Display Section—. a7 69. Pin Functions 53 7. EXPLODED VIEWS. 7-1. Case, Power Supply Block st 7.2, Front Panel, Main Board Block 58 7.3, MD Chassis Block 59 7-4, Mechanism Deck Block (1) 0 7.5, Mechanism Deck Block (2) 61 76 CD Block (1) 62 7-7. CD Block (2) 6 8 ELECTRICAL PARTS LIST 6 SAFETY-RELATED COMPONENT WARNINGI! COMPONENTS IDENTIFIED BY MARK /f, OR DOTTED LINE WITH MARK (A ON THE SCHEMATIC DIAGRAMS AND IN THE PARTS LIST ARE CRITICAL TO SAFE OPERATION. REPLACE THESE COMPONENTS WITH SONY PARTS WHOSE PART NUMBERS APPEAR AS SHOWN IN THIS MANUAL OR IN SUPPLEMENTS PUB- LISHED BY SONY. ATTENTION AU COMPOSANT AYANT RAPPORT ‘A LA SECURITE! LES COMPOSANTS IDENTIFIES PAR UNE MARQUE /h SUR LES DIAGRAMMES SCHEMATIQUES ET LA LISTE DES PIECES SONT CRITIQUES POUR LA SECURITE DE_FONCTIONNEMENT. NE REMPLACER CES COM: POSANTS QUE PAR DES PIECES SONY DONT LES NUMEROS SONT DONNES DANS CE MANUEL OU —2.— DANS LES SUPPLEMENTS PUBLIES PAR SONY. HCD-H50/H55/H1100 MODEL IDENTIFICATION SAFETY CHECK-OUT = Specification Labels — SECTION 1 SERVICING NOTES Lid engee Seep After correcting the original service problem, sanadian, €, EA, AUS model: HCD-H50 zs US canta & tA AS nd HOO HED perform the folowing nifty check before velening Dl these (othe customer Check theantenna terminals, metal trim, “metalized” knobs, screws, and all other exposed metal parts for SONY: wove. no ZZ AC leakage. Check leakage as described below. COMPACT DISC DECK RECEIVER LEAKAGE TEST ‘The AC leakage from any exposed metal part to SERIAL NO, earth ground and from all exposed metal parts to any MADE IN JAPAN ‘exposed metal part having a return to chassis, must ot exceed 0.SmA (500 microampers). Leakage current can be measured by any one of three US model: AC: 120V~GoH2 60 \Carasian model: AC: 120V~60H2 SOW AEP rndol: AC: 220~230¥~S0/60He methods, IT model: AC: 220-230V~80H2 1. A commercial leakage tester, such as the EE model: AC: 220~230V~50Hs OW ea aCe oie ae EA, AUS model: AC: 110-120/220~240V~0/60H 6OW eli aa ee LS ans ‘UK madel; AG: 240¥—20Ke manufacturers’ instructions to use these instru ments, 2. Abbattery-operated AC milliammeter, The Data Bolore operating the stereo system, check Precision 245 digital multimeter is suitable for that the operating votage of your system is this job. ‘entcal wih the votage of your local power Measuring the voltage drop across a resistor by oe means of a VOM of battery-operated AC vol [WS canadian moder [120V A0, cone | meter. The “limit” indication is 0.75, so [Ae moc SOV AC BOER aial_metes must have an aserate fw TT-EE mesa [ 220~250V 20-50 voltage scale. The Simpson 250 and Sanwa nian SH-63Trd are examples of a passive VOM that ee loot is suitable. Nearly all battery operated digital adjustable, S0/60H multimeters that have a 2V AC range are Uk model | 240V AG, SoHE suitable. (See Fig. A) On operation ———________ Tro Exposed Metal + the system ao not operate due to power Parts on Sot noise, ress the system reset buon at \ the rea. The system wil resume Earth Ground [Fig. A. Using an AC voltmeter to check AC leakage,

You might also like