Professional Documents
Culture Documents
com/engr_nasir/shelf
PROJECT
POWER SUPPLY
NASIR AHMED KHAN 2010 – EE – 043
Maaz Iqbal 2010 – EE –
001
Mohammed Mohsin 2010 – EE – 008
Syed Amin Hussain 2010 – EE - 027
“2A”
Basic Electronic Engineering
DEPARTMENT OF
ELECTONIC ENGINEERING
Mam. Amber Israr
Introduction
It is a regulated dc power supply by using LM317 IC for a regulation. This circuit starts
from a 220 vrms as a circuit input and gives us 0-25 v dc as an output.
http://www.scribd.com/engr_nasir/shelf
Calculation
Data:
Vrms=28.3 v
Sol:
b\c vrms = 0.707 X Vp in
so 28.3/0.707 = Vp in = 40.028 V
Vp out = Vp in – 1.4 = 40.028 – 1.4 = 38.628 V
Vdc = 0.318 X 2 X Vp = 0.318 X 2 X 38.628 =24.5679 V (out put)
1. 5 Diodes (1N4001)
4. LED
6. IC1 (LM317)
9. Potentiometer (5K)
11. Breadboard
Circuit Description
As it mentioned above that circuit starts from 220 vrms input. A
transformer step down that voltage to 28 V, which enters into
the bridge rectifier and gives pulsating DC. So we put two
capacitors on load for filtration and one LED with resistor to
check the circuit. After that step we put an IC and potentiometer
to regulate from 0 – 25 dc Voltage. And one diode to its parallel
of avoids the defusing current. And at the last we put another
capacitor to receive more pure dc output.
http://www.scribd.com/engr_nasir/shelf
Precautions
Conclusion
The project of power supply was amazing and learning full to us. A simple circuit who
convert 220 Vrms to Vdc.
Dedication
All dedication goes to our teachers who help us into the making of power supply.
Specially our theory teacher miss Amber who teaches us as her sons. We can’t complete
this project without the knowledge that we gain from our teachers.
http://www.scribd.com/engr_nasir/shelf