Professional Documents
Culture Documents
TECHNICAL BULLETIN
August 2006
"Plus" Sizing
Speed Rating changes
Passenger Tire vs. Light Truck Tire fitments
P-Metric vs. Euro-Metric
Standard Load (SL) vs. Extra-Load (XL) or Reinforced fitments
A combination of items, including those above
This technical bulletin presents general guidelines and recommendations for tire replacement,
including substitute tire sizes, to promote retailer and consumer education, satisfaction, and
safety.
_____________________________________________________________________________
8/7/2006
_____________________________________________________________________________
8/7/2006
Check the vehicle tire placard and/or the vehicle owner's manual for the OE tire
size(s), speed symbol, and recommended inflation pressure(s).
Carefully note any differences between recommendations for front and rear axle
positions regarding the tire size and/or inflation pressure.
Note that the vehicle may have specific recommendations regarding winter tires, or
other optional tires.
If a vehicle tire placard or vehicle owner's manual is not available, consult the vehicle
or tire manufacturer for assistance.
In some situations, it may be permissible to select replacement tires that are not
the original size or type. Refer to and follow the recommendations and procedures
in this technical bulletin, beginning on the following page.
See also:
SIZE DESCRIPTION: .. Page 5
SERVICE DESCRIPTION: . Page 5
LOAD INDEX: ... Page 6
SPEED SYMBOL / SPEED RATING: ... Page 7
WINTER TIRES (Including Studded Tires): .. Page 14
LOW ASPECT RATIO TIRES: ... Page 16
TIRE MIXING: Page 17
_____________________________________________________________________________
8/7/2006
Never select a tire with a smaller size, or with less load carrying capacity, than the tire
specified on the vehicle tire placard.
Substitute tires should never be inflated below the pressure shown on the vehicle tire
placard.
Never exceed the maximum load capacity and/or inflation pressure listed on the sidewall
of the tire.
Never exceed the maximum load capacity and/or inflation pressure of the wheel.
Never utilize an unapproved wheel or one that does not meet the approved rim width
range for the selected tire size.
Acceptable load capacity and/or overall tire diameter do not imply acceptable vehicle
clearance. Body and chassis clearance must be checked on the vehicle's front and rear
axles.
If a vehicle tire placard or vehicle owner's manual is not available, consult the vehicle or
tire manufacturer for assistance.
IN ORDER TO PROPERLY:
- Select a substitute tire size, which includes: plus sizing, applying a light truck
tire in place of a passenger car tire, and applying Euro-metric in place of Pmetric (or vice-versa)
- Select and notify the consumer of the proper inflation pressure
ALWAYS:
REFER TO THE ABOVE-AND ALL SECTIONS OF THIS BULLETIN AS NEEDED-AND
FOLLOW THE PROCEDURE FOR SPECIFYING AND SELLING SUBSTITUTE TIRE
SIZES, BEGINNING ON PAGE 18.
_____________________________________________________________________________
8/7/2006
Size Description
Tires for light vehicles (most passenger cars and light trucks) are typically part of one of the
following groups:
Size Description
Passenger Car
Light Truck
Example
P-Metric
P205/55R16
Euro-Metric
205/55R16
Temporary Use
T125/80R15
LT-Metric
LT235/85R16
High Flotation
31X10.50R15LT
These groups of tires have numerous differences in their load and inflation characteristics; some
are adjusted for load capacity if they are applied to a light truck versus a passenger car (see page
13, PASSENGER CAR TIRES APPLIED TO LIGHT TRUCKS).
Therefore it is necessary to carefully note the complete tire size designation, including prefix and
service description (if applicable, see below), when considering replacement tires.
Service Description
The service description is distinct from the size designation and consists of the load index (a twoor three-digit number) and the speed symbol (a letter).
Service Description
Load Index
Speed Symbol
P205/60R15
90T
90
P235/75R15
105S
105
235/45R17
93V
93
T125/80R15
95M
95
115/112R
115 (Single)
112 (Dual)
104Q
104
LT215/85R16
Load Range E
30X9.50R15LT
Load Range C
_____________________________________________________________________________
8/7/2006
Load Index
The load index is a numerical code associated with the maximum load a tire can carry at the
speed indicated by the tire's speed symbol under certain specified service conditions.
Tires with the same load index, regardless of tire size, may carry the same load,
but not always, and they may require substantially different inflation pressures.
The load index may not be used independently to determine replacement tire
acceptability for load capacity. An equal or greater load index does not always
correspond to equal or greater load capacity at all inflation pressure settings,
particularly when comparing P-metric and Euro-metric passenger car tires.
For example, note the following standard load (SL) tires with the same load index:
Size
P205/65R15
205/65R15
Load
Index
92 (SL)
92 (SL)
26 psi
44 psi
(180 kPa)
(200 kPa)
220 kPa)
(240 kPa)
(260 kPa)
(280 kPa)
(300 kPa)
1213
1069
1279
1157
1334
1257
1400
1345
1400*
1389*
1400*
1389*
1400*
1389*
In the above example, the Euro-metric tire has less load capacity at all inflation pressures
(particularly below 35 psi), even though both tires have the same load index.
The load index is often used to distinguish certain tires from others. For instance,
some tire sizes are available in more than one load index, particularly Euro-metric
standard load (SL) passenger car tires and tires with light load (LL) or
reinforced/extra load (XL) versions.
In the following table, note the differences in load capacity for the tires listed, each with a different
load index:
Load Capacity (lbs) at Various Inflation Pressures
Load
26 psi
29 psi
32 psi
35 psi
38 psi
41 psi
44 psi
Size
(180 kPa)
(200 kPa)
220 kPa)
(240 kPa)
(260 kPa)
(280 kPa)
(300 kPa)
Index
P205/55R16 89 (SL)
1091
1157
1213
1279
1279*
1279*
1279*
205/55R16 90 (SL)
1014
1102
1190
1279
1323*
1323*
1323*
205/55R16 91 (SL)
1047
1135
1224
1312
1356*
1356*
1356*
205/55R16 94 (XL)
1003
1102
1179
1268
1356
1433
1477*
* See page 8: MAXIMUM TIRE LOAD CAPACITY and INFLATION PRESSURE
_____________________________________________________________________________
8/7/2006
To avoid reducing the speed capability of the vehicle, replace a speed rated tire
only with another tire having at least the same speed rating. It is the "top speed" of the
"slowest" tire on the vehicle which limits the vehicle's top speed without tire failure.
If the OE tires are not speed rated carefully consider the type of vehicle and service
conditions expected by the consumer. Replacement tires may be speed rated, if desired.
Non-speed rated tires are usually for ordinary passenger or light truck service and not for
high speed driving.
For winter tires, it is generally acceptable to apply a tire with a lower speed rating than the
OE tire for use in winter conditions; however, speed should be reduced accordingly. All
winter tires applied should be the same speed rating. Some vehicles have specific
recommendations regarding winter tires and their usage; always check and follow the vehicle
tire placard and/or the vehicle owner's manual.
Tires with different speed ratings may vary in ride, handling, and/or other performance
characteristics. Thus, care should be taken when mixing tires of different speed ratings on
the same vehicle. It is the "top speed" of the "slowest" tire on the vehicle which limits the
vehicle's top speed without tire failure.
ZR**
Speed Symbol
M
Q
R
S
T
U
H
V
W
Y
(Y)
Speed Category*
MPH
KPH
81
130
99
160
106
170
112
180
118
190
124
200
130
210
149
240
168
270
186
300
>186
>300
_____________________________________________________________________________
8/7/2006
Passenger
Tire Type
Load Version
Light Load
(LL)
Minimum Inflation
Pressure for
Maximum Load
Typical Maximum
Inflation Pressure
Sidewall Markings
35 psi (240 kPa)
P-Metric
Standard Load
(SL)
Euro-Metric
Extra Load
(XL)
Standard Load
(SL)
Extra Load
(XL) / Reinforced
Light Truck tires-including LT-Metric and High Flotation tires-have load range codes such as B,
C, D, and E with associated maximum load and inflation specifications. Maximum inflation
pressures for these tires are not always the same for a given load range (i.e. Load Range C tires
are not always 50 psi maximum inflation pressure).
"T"-Type Temporary Use tires (i.e. T125/80R15) are to be inflated to 60 psi (420kPa) in all
applications, whether light load (LL) or standard load (SL).
_____________________________________________________________________________
8/7/2006
Example
P-Metric
P205/55R16
Euro-Metric
205/55R16
These groups of tires have differences in their load and inflation characteristics, (including a
difference in their load capacity if they are applied to a light truck - see page 13, PASSENGER
CAR TIRES APPLIED TO LIGHT TRUCKS).
P-metric and Euro-metric passenger car tires have different load and inflation
standards that require careful observation. These differences also apply to tires that have
nearly the same size designations (i.e. P205/55R16 vs. 205/55R16).
Euro-metric tires use load index tables to identify their load capacity at various
inflation pressures. Furthermore, these tires have different load index tables for standard
load and reinforced (extra load) versions. Carefully utilize the correct table.
P-metric (and LT-metric and High Flotation) tires do not use load index values to
identify their load capacity at various inflation pressures. For these tires, the load index
is not an absolute indicator of the tire's load capacity.
Euro-metric standard load tires may have more than one load index per size. This
occurs with certain Euro-metric sizes more than others (i.e. 205/55R16). Carefully determine
and compare the size code and load index for the OE tire (using information from the vehicle
tire placard and/or owner's manual) and any specific replacement tire.
The load index may not be used independently to determine replacement tire
acceptability for load capacity. An equal or greater load index does not always
correspond to equal or greater load capacity at all inflation pressure settings,
particularly when comparing P-metric and Euro-metric passenger car tires.
_____________________________________________________________________________
8/7/2006
1400
1300
1200
1100
1000
900
800
26
29
32
35
38
41
44
P205/55R16 89 (SL)
1091
1157
1213
1279
1279
1279
1279
205/55R16 90 (SL)
1014
1102
1190
1279
1323
1323
1323
*205/55R16 91 (SL)
1047
1135
1224
1312
1356
1356
1356
See also:
LOAD INDEX: .. Page 6
REINFORCED / EXTRA-LOAD (XL) TIRES: . Page 11
LIGHT LOAD (LL) TIRES: . Page 12
PASSENGER CAR TIRES APPLIED TO LIGHT TRUCKS: Page 13
_____________________________________________________________________________
8/7/2006
10
1600
1500
1400
1300
1200
1100
1000
29
32
35
38
41
44
P195/65R15 89 (SL)
1168
1235
1279
1279
1279
1279
205/55R16 90 (SL)
1102
1190
1278
1322
1322
1322
*P205/55R16 94 (XL)
1102
1179
1268
1356
1433
1477
* See page 8:
The P-metric tire, with the lowest load index, has equal or greater load capacity at the
standard load inflation pressures shown.
The reinforced Euro-metric tire, with the highest load index, has equal or less load capacity
than its standard load version at the standard load inflation pressures.
_____________________________________________________________________________
8/7/2006
11
_____________________________________________________________________________
8/7/2006
12
Passenger car-sized tires applied to light trucks must have their load capacity, at all inflation
pressures, reduced by a service factor. OE passenger car-sized tires have already had this
reduction taken into account by the vehicle manufacturer.
To determine the load capacity of a passenger car tire when applied to a light truck vehicle,
divide the load capacity (at a specific inflation pressure) of the passenger car tire by 1.1 and
round to the nearest pound (or kilogram). Follow the same procedure for all inflation
pressures.
For example: P235/70R15 at 35 psi
Reference load: 1896 lbs (860kg) for passenger car use
Divide by 1.1: 1896 lbs 1.1 = 1724 lbs (782 kg) for light truck use
OE passenger car-sized tires may not be optimum for a particular light truck consumer's
driving needs. In such cases, it may be desirable to substitute an appropriately sized LTmetric or High Flotation light truck tire, typically at a higher inflation pressure. However:
Always refer to and follow the vehicle manufacturer's replacement tire
recommendations.
In some cases, a vehicle manufacturer may specifically advise against the
application of replacement tires that are not the original size or type. Always refer
to and follow these recommendations.
For light truck vehicles that have LT-metric or High Flotation light truck tires as original
equipment:
It is NOT RECOMMENDED to replace OE LT-metric or High Flotation light truck
tires with P-metric or Euro-metric passenger car tires, unless otherwise specified
by the vehicle manufacturer.
_____________________________________________________________________________
8/7/2006
13
If winter tires are applied to the front axle of any vehicle, they must also be installed on
the rear. Do not apply winter tires to only the front axle - this applies to all passenger cars
and light trucks, including front wheel drive, 4x4 and all-wheel drive vehicles.
If winter tires are installed on the rear axle of any vehicle, it is recommended (but not
required) that they also be installed on the front axle.
All winter tires applied should be the same speed rating. It is generally acceptable to apply
winter tires with a lower speed rating than the OE tires for use in winter conditions; however,
speed should be reduced accordingly. It is the "top speed" of the "slowest" tire on the vehicle
which limits the vehicle's top speed without tire failure.
Never place bias ply or bias belted tires on the rear axle if radial tires are on the front axle,
regardless of which axle is the drive axle, unless the vehicle has duals on the rear.
Studded winter tires follow the same recommendations above. In addition, only new tires
should be fitted with studs. Consult the Bridgestone or Firestone P/LT Data Book for
government regulations regarding the use of studded winter tires.
_____________________________________________________________________________
8/7/2006
14
Plus Sizing
The concept of plus sizing is not new, but has expanded in the marketplace beyond high
performance sports cars. It is important to remember the following:
Always refer to and follow the vehicle manufacturer's replacement tire
recommendations.
In some cases, a vehicle manufacturer may specifically advise against the
application of replacement tires that are not the original size or type. Always refer
to and follow these recommendations.
Plus sizing typically aids handling performance, but may result in a less comfortable ride; the
substitute tires - and their wheels - may also be more susceptible to damage by impact with
potholes, road hazards, and other objects such as curbs.
Never select a tire with a smaller size, or with less load carrying capacity, than the tire
specified on the vehicle tire placard.
Substitute tires should never be inflated below the pressure shown on the vehicle tire placard.
Never exceed the maximum load capacity and/or inflation pressure listed on the sidewall of
the tire.
Never exceed the maximum load capacity and/or inflation pressure of the wheel.
Never utilize an unapproved wheel or one that does not meet the approved rim width range
for the selected tire size.
The overall diameter of replacement tires should be within vehicle manufacturer tolerances.
If tolerances are not provided, use a guideline of +/-3% from the overall tire diameter of the
tire specified on the vehicle tire placard.
Acceptable load capacity and/or overall tire diameter do not imply acceptable vehicle
clearance. Body and chassis clearance must be checked on the vehicle's front and rear
axles.
See also:
LOAD INDEX: Page 6
MAXIMUM TIRE LOAD CAPACITY and INFLATION PRESSURE: Page 8
P-METRIC vs. EURO-METRIC PASSENGER CAR TIRES: . Page 9
REINFORCED / EXTRA LOAD (XL) TIRES: Page 11
LIGHT LOAD (LL) TIRES: Page 12
PASSENGER CAR TIRES APPLIED TO LIGHT TRUCKS: .. Page 13
LOW ASPECT RATIO TIRES: Page 16
_____________________________________________________________________________
8/7/2006
15
_____________________________________________________________________________
8/7/2006
16
Tire Mixing
Tires of different constructions and sizes may have different handling and/or other performance
characteristics. Therefore, note the following:
Unless otherwise specified by the vehicle manufacturer, it is recommended that all
tires on a vehicle be the same size, construction (i.e. radial, bias ply), and speed
rating.
Never mix tires of different size or construction on an axle (except for temporary
use of a spare).
Additionally:
4x4 and AWD Vehicles: It is particularly important to match all tire sizes and constructions
on four-wheel-drive (4x4) or all-wheel-drive (AWD) vehicles, unless otherwise specified by
the vehicle manufacturer.
Winter Tires: Winter tires are best applied to all vehicle positions. If winter tires are applied
to the front axle of any vehicle, they must also be installed on the rear. Do not apply winter
tires to only the front axle --- this applies to all passenger cars and light trucks, including front
wheel drive, 4x4 and all-wheel drive vehicles. For additional information, see page 14:
WINTER TIRES (Including Studded Tires).
Speed Rating: Tires with different speed ratings may vary in ride, handling, and/or other
performance characteristics. Thus, care should be taken when mixing tires of different speed
ratings on the same vehicle. It is the "top speed" of the "slowest" tire on the vehicle which
limits the vehicle's top speed without tire failure.
Bias / Radial Tires: It is preferable to never mix bias ply, bias belted, or radial tires on a
passenger car or light truck. If necessary, the following applies to these vehicles, regardless
of drive axle(s), except for temporary use of a spare:
o
Never mix bias ply, bias belted, or radial tires on the same axle.
Do not mix bias ply, bias belted, or radial tires on 4x4 or AWD vehicles.
Never place bias ply or bias belted tires on the rear axle if radial tires are on the front
axle, regardless of which axle is the drive axle, unless the vehicle has duals on the rear.
(This also applies to winter tires.)
_____________________________________________________________________________
8/7/2006
17
_____________________________________________________________________________
8/7/2006
18
Safety Warning: Using the wrong size or type of tire can result in tire failure,
which can lead to an accident resulting in serious personal injury or death.
Safety Warning: In some cases, particularly for SUV's and light trucks, failure to
follow vehicle manufacturer's recommendations for tire replacement may
adversely affect the handling of the vehicle and make it easier to lose control,
leading to a serious or fatal accident.
Continue to Step 2
_____________________________________________________________________________
8/7/2006
19
From a resource such as the Bridgestone or Firestone P/LT Data Book, record the
approved rim width range for the substitute tire size (F).
J. If retaining the current wheels on the vehicle, confirm that the current rim widths (C) fall
within the rim width range of the candidate substitute tire size (I).
K. If purchasing new wheels, select and record candidate rim widths for use with the
substitute tires. The candidate rim width must meet the requirements of the
candidate substitute tire size as indicated in (I). If not, another rim width (or another
substitute tire size) must be selected (repeat STEP 3 and/or STEP 4).
Note: The rim diameter identified in either (J) or (K) must be the same as the candidate
substitute tire size diameter (F).
Continue to Step 5
_____________________________________________________________________________
8/7/2006
20
STEP 7: NOTIFICATION
P. Mount the new tires on the vehicle and inflate to the new recommended inflation
pressures determined in (N).
Q. Notify the consumer of the new tire sizes and the new recommended inflation pressures.
On the Substitute Tire Size Application form included on page A3 of this Technical
Bulletin, fill in the appropriate vehicle information (year, make, model, and VIN), the OE
tire sizes (A), and the OE recommended inflation pressures (B). Then fill in the new
substitute tire sizes (F) and the new recommended inflation pressures (N). Explain to the
consumer the possible effects of these tire changes and have him/her sign the form.
R. Make a copy of the signed Substitute Tire Size Application form and place it in the vehicle
glove box with the vehicle owner's manual. If the vehicle owners manual is not available,
leave the Substitute Tire Size Application in the glove box. Retain the original for your
records.
S. Clearly fill in the Auxiliary Tire Information label (placard) included on page A4 of this
Technical Bulletin with the new Substitute Tire Sizes (F) and the new recommended
inflation pressures (N). Affix this Auxiliary Tire Information label (placard) in the
immediate vicinity of the existing vehicle tire placard, but NOT covering the existing
vehicle tire placard. Cover the Auxiliary Tire Information label (placard) with clear
plastic tape and show the consumer where this new placard exists. Explain again the
new recommended tire inflation pressures for the new tires.
_____________________________________________________________________________
8/7/2006
21
Appendix A - Forms
Replacement Tire Selection Worksheet
A2
A3
A4
_____________________________________________________________________________
8/7/2006
A1
Information
Front Tire
Rear Tire
YES or NO
YES or NO
YES or NO
YES or NO
YES or NO
YES or NO
YES or NO
YES or NO
YES or NO
YES or NO
OE Tire Size
OE Inflation Pressures
Step 7: Notification
P
_____________________________________________________________________________
8/7/2006
A2
The vehicle has been altered from its original state. The new tires installed are not the
original equipment (OE) size.
Handling, traction, ride comfort, and other vehicle performance parameters may be
adversely affected.
There may be an increased risk of loss of vehicle control, rollover, or other serious
accident that can lead to serious personal injury or death.
Aggressive driving - including high speed operation and sudden, sharp turns - further
increases the risk of loss of vehicle control, rollover, or other serious accident that can
lead to serious personal injury or death.
_____________________________________________________________________________
Vehicle Information:
Year: _________ Make: _______________ Model: __________________________
VIN: __________________________________________
OE Tire Size: Front: ____________________
OE Inflation:
Rear: ____________________
Front: ___________
Rear: ___________
The SUBSTITUTE TIRE SIZES applied to this vehicle are the following:
Front: _______________________
Rear: _______________________
The inflation pressures that are required for these substitute tire sizes to carry the vehicle's
maximum load are the following:
Front: ________
Rear: ________
These changes, and the possible effects, have been explained to me. I understand and assume
all risks associated with these changes and their possible consequences.
Signed: __________________________________________
Printed: __________________________________________
Date: ___________
_____________________________________________________________________________
_____________________________________________________________________________
8/7/2006
A3
TIRE
COLD INFLATION
PRESSURE
FRONT
REAR
SEE VEHICLE AND TIRE OWNERS MANUALS FOR ADDITIONAL INFORMATION
BRIDGESTONE / FIRESTONE NORTH AMERICAN TIRE, LLC: 1-800-847-3272
Affix this Auxiliary Tire Size Information label (placard) in the immediate vicinity of
the existing vehicle tire placard, but NOT covering the existing vehicle tire
placard.
Cover the Auxiliary Tire Information label (placard) with clear plastic tape and
show the consumer where this new placard exists.
_____________________________________________________________________________
8/7/2006
A4
_____________________________________________________________________________
8/7/2006
B1
70 Series
P-Metric
Euro-Metric
P165/70R12 (SL)
165/70R12 (SL)
Load
Index
72
74
76
77
Nominal
Tire O.D.*
21.3
21.1
21.7
21.8
Rim Width
Range
3.5 - 5.0
3.5 - 5.0
4.0 - 5.0
4.0 - 5.0
Load
Index
76
77
Nominal
Tire O.D.*
21.1
21.1
Rim Width
Range
4.0 - 5.5
4.0 - 5.5
26
664
705
749
794
26
772
694
27
685
716
772
809
27
787
716
Load
Index
155/70R13 (SL)
165/70R13 (SL)
P175/70R13 (SL)
175/70R13 (SL)
P185/70R13 (SL)
185/70R13 (SL)
P195/70R13 (SL)
195/70R13 (SL)
P205/70R13 (SL)
65 Series
P-Metric
Euro-Metric
P165/65R13 (SL)
165/65R13 (SL)
185/65R13 (SL)
60 Series
P-Metric
Euro-Metric
175/60R13 (SL)
185/60R13 (SL)
P185/60R13 (SL)
794
805
886
900
33
860
849
34
871
860
35
36
37
38
39
40
41
41 - 50
Note C
42 - 51
Note D
36 - 51
Note B
36
37
38
39
40
41
41 - 50
Note C
42 - 51
Note D
816
915
35
35 - 51
Note A
882
882
908
Rim Width
Range
4.0 - 5.0
4.0 - 6.0
4.0 - 6.0
4.5 - 6.0
4.0 - 5.5
4.5 - 6.0
4.5 - 6.0
5.0 - 6.5
4.5 - 6.0
5.0 - 7.0
5.0 - 6.5
5.5 - 7.5
26
661
728
728
816
739
893
805
992
904
1080
981
1179
27
672
743
743
831
761
911
827
1007
926
1098
1003
1198
28
683
757
757
845
772
930
838
1021
937
1117
1025
1216
29
716
772
772
860
805
948
871
1036
981
1135
1069
1235
30
739
783
783
875
838
963
915
1054
1014
1153
1113
1257
31
750
794
794
889
849
977
926
1073
1025
1172
1124
1279
32
772
805
805
904
871
992
948
1091
1058
1190
1157
1301
33
794
821
821
915
904
1007
981
1106
1091
1209
1201
1319
34
805
837
837
926
915
1021
992
1120
1113
1227
1213
1338
35
827
Load
Index
76
77
84
Nominal
Tire O.D.*
21.4
21.4
22.4
Rim Width
Range
4.5 - 6.0
4.5 - 6.0
5.0 - 6.5
26
761
694
849
27
776
716
871
28
790
728
882
29
805
761
926
30
816
794
959
31
827
805
970
32
838
816
992
33
853
849
1036
34
867
860
1047
35
Load
Index
77
80
80
Nominal
Tire O.D.*
21.3
21.7
21.7
Rim Width
Range
5.0 - 6.0
5.0 - 6.5
5.0 - 6.5
26
694
761
860
27
716
783
875
28
728
794
889
29
761
827
904
30
794
860
919
31
805
871
933
32
816
893
948
33
849
926
963
34
860
937
977
185R13 (SL)
P155/70R13 (SL)
P155/70R13 (XL)
P165/70R13 (SL)
34
Nominal
Tire O.D.*
21.6
21.6
21.6
22.1
22.1
22.7
22.7
23.2
23.2
23.8
23.8
24.3
83
84
86
88
70 Series
P-Metric
Euro-Metric
32
849
816
33
90
79
80
165R13 (SL)
P185/80R13 (SL)
31
838
805
32
783
783
882
871
Load
Index
75
75
77
78
79
82
82
85
86
88
89
91
75
P165/80R13 (SL)
P175/75R13 (SL)
P175/80R13 (SL)
P185/75R13 (SL)
30
827
794
31
765
768
862
860
Rim Width
Range
3.5 - 5.0
3.5 - 5.0
4.0 - 5.0
4.0 - 5.0
4.5 - 6.0
4.0 - 5.5
4.0 - 5.5
4.5 - 6.0
4.5 - 6.0
5.0 - 6.5
4.5 - 6.0
4.5 - 6.0
155R13 (SL)
P155/80R13 (SL)
P165/75R13 (SL)
29
816
761
30
745
754
839
849
Nominal
Tire O.D.*
22.4
22.1
22.8
22.8
22.8
23.5
23.4
23.3
24.0
23.9
24.6
24.7
145R13 (SL)
P145/80R13 (SL)
28
801
728
29
725
739
817
838
36 - 51
Note B
Tire Load Limits in Pounds (lbs.) at Various Cold Inflation Pressures in Pounds Per Square Inch (psi)
28
705
728
794
823
26
702
750
795
838
871
858
926
959
1025
1058
1011
1124
27
723
761
820
853
886
884
944
977
1043
1076
1042
1146
28
745
772
844
867
900
910
963
996
1062
1094
1073
1168
29
766
783
868
882
915
936
981
1014
1080
1113
1104
1190
30
787
798
892
897
930
962
996
1029
1098
1131
1134
1209
31
808
812
916
911
944
988
1010
1043
1117
1150
1164
1227
32
827
827
937
926
959
1013
1025
1058
1135
1168
1194
1246
33
34
35
35 - 51
Note A
838
849
860
937
974
948
988
959
1003
1040
1076
1150
1189
1054
1095
1164
1206
1069
1113
1179
1224
1264
1283
36 - 51
Note B
36
37
38
39
40
41
41 - 50
Note C
42 - 51
Note D
36 - 51
Note B
36
37
38
39
40
41
41 - 50
Note C
42 - 51
Note D
1301
35 - 51
Note A
853
853
853
863
872
882
895
902
908
963
1036
1014
1047
1135
1135
1168
1246
1235
1279
1356
35 - 51
Note A
36 - 51
Note B
36
37
38
39
40
41
41 - 50
Note C
42 - 51
Note D
36
37
38
39
40
41
41 - 50
Note C
42 - 51
Note D
882
882
1069
908
1102
35 - 51 36 - 51
Note A Note B
35
882
908
959
992
992
NOTE A: Some P-Metric Light Load and Standard Load tires may be branded with a maximum inflation pressure of 35, 44 or 51 psi for high speed and handling optimization. However, there is no load increase above 35 psi.
NOTE B: Some European Metric tires may be branded with a maximum inflation pressure of 32, 36, 44 or 51 psi for high speed and handling optimization. However, there is no load increase above 36 psi.
NOTE C: Some P-Metric Extra Load tires may be branded with a maximum inflation pressure of 41 or 50 psi for high speed and handling optimization. However, there is no load increase above 41 psi.
NOTE D: Some European Metric Extra Load tires may be branded with a maximum inflation pressure of 42 or 51 psi for high speed and handling optimization. However, there is no load increase above 42 psi.
* Nominal Tire O. D. is a designated or theoretical size that may vary from the actual tire O. D.
IMPORTANT: Never exceed the maximum inflation pressure molded on the sidewall of the tire.
_____________________________________________________________________________
8/7/2006
889
937
937
B2
55 Series
P-Metric
Euro-Metric
185/55R13 (SL)
50 Series
P-Metric
Euro-Metric
175/50R13 (SL)
P175/50R13 (SL)
P175/50R13 (XL)
P215/50R13 (SL)
215/50R13 (SL)
215/50R13 (SL)
P235/50R13 (SL)
P245/50R13 (SL)
45 Series
P-Metric
Euro-Metric
235/45R13 (SL)
Tire Load Limits in Pounds (lbs.) at Various Cold Inflation Pressures in Pounds Per Square Inch (psi)
For Light Load and Standard Load Tires
83
86
86
89
Rim Width
Range
5.5 - 7.0
5.5 - 7.5
6.0 - 7.5
6.5 - 8.0
26
937
904
1014
1102
27
952
926
1032
1124
28
966
937
1051
1146
29
981
981
1069
1168
30
999
1014
1087
1187
31
1018
1025
1106
1205
32
1036
1058
1124
1224
33
1051
1091
1142
1242
34
1065
1113
1161
1261
35 - 51 36 - 51
35
Note A Note B
1080
1135
1168
1179
1279
Load
Index
77
Nominal
Tire O.D.*
21.0
Rim Width
Range
5.0 - 6.5
26
694
27
716
28
728
29
761
30
794
31
805
32
816
33
849
34
860
35 - 51
Note A
35
882
Load
Index
72
72
74
84
85
87
89
91
Nominal
Tire O.D.*
19.9
19.9
19.9
21.5
21.5
21.5
22.3
22.7
Rim Width
Range
5.0 - 6.0
5.0 - 6.0
5.0 - 6.0
6.0 - 7.5
6.0 - 7.5
6.0 - 7.5
6.5 - 8.5
7.0 - 8.5
26
606
672
672
948
871
926
1102
1179
27
617
683
683
963
893
948
1120
1201
28
628
694
694
977
915
970
1139
1224
29
650
705
705
992
948
1003
1157
1246
30
683
716
716
1010
992
1047
1176
1264
31
694
728
728
1029
1003
1058
1194
1283
32
705
739
739
1047
1025
1080
1213
1301
33
728
754
754
1062
1058
1124
1231
1323
34
739
768
768
1076
1080
1135
1250
1345
35 - 51 36 - 51
35
Note A Note B
761
783
783
783
1091
1102
1135
1157
1201
1268
1367
Load
Index
87
Nominal
Tire O.D.*
21.3
Rim Width
Range
7.5 - 9.0
26
926
27
948
28
970
29
1003
30
1047
31
1058
32
1080
33
1124
34
1135
35 - 51
Note A
35
1157
Load
Index
26
903
1014
1011
1113
1084
1213
1213
1174
1323
1323
1433
1554
27
931
1032
1042
1131
1117
1235
1235
1210
1349
1349
1462
1583
28
958
1051
1073
1150
1150
1257
1257
1246
1374
1374
1492
1613
29
986
1069
1104
1168
1183
1279
1279
1281
1400
1400
1521
1642
30
1013
1087
1134
1190
1215
1301
1301
1316
1422
1422
1543
1668
31
1040
1106
1164
1213
1247
1323
1323
1351
1444
1444
1565
1694
32
1066
1124
1194
1235
1280
1345
1345
1386
1466
1466
1587
1720
33
95
98
98
101
Rim Width
Range
4.0 - 5.5
4.5 - 6.0
4.5 - 6.0
4.5 - 6.0
4.5 - 6.0
5.0 - 6.5
5.0 - 6.5
5.0 - 6.5
5.0 - 7.0
5.0 - 7.0
5.5 - 7.0
6.0 - 7.5
Load
Index
84
84
87
87
88
90
91
93
95
96
96
Nominal
Tire O.D.*
23.7
23.7
24.3
24.3
24.3
24.8
24.8
25.4
25.4
25.9
25.9
Rim Width
Range
4.5 - 6.0
4.5 - 6.0
4.5 - 6.0
4.5 - 6.0
4.5 - 6.0
5.0 - 6.5
5.0 - 6.5
5.0 - 7.0
5.0 - 7.0
5.5 - 7.0
5.5 - 7.0
26
849
948
1036
926
948
1135
1047
1235
1168
1345
1201
27
871
966
1054
948
970
1157
1069
1257
1201
1367
1235
28
882
985
1073
970
992
1179
1091
1279
1224
1389
1257
29
926
1003
1091
1003
1036
1201
1135
1301
1268
1411
1312
30
959
1018
1109
1047
1069
1220
1179
1323
1323
1437
1367
31
970
1032
1128
1058
1080
1238
1190
1345
1345
1462
1378
32
992
1047
1146
1080
1113
1257
1224
1367
1378
1488
1411
86
175R14 (SL)
P185/75R14 (SL)
89
185R14 (SL)
P195/75R14 (SL)
P195/75R14 (XL)
92
95
195R14 (SL)
P205/75R14 (SL)
P205/75R14 (XL)
P215/75R14 (SL)
P225/75R14 (SL)
70 Series
P-Metric
Euro-Metric
175/70R14 (SL)
P175/70R14 (SL)
P185/70R14 (SL)
185/70R14 (SL)
185/70R14 (SL)
P195/70R14 (SL)
195/70R14 (SL)
P205/70R14 (SL)
205/70R14 (SL)
P215/70R14 (SL)
215/70R14 (SL)
36 - 51
Note B
1201
37
38
39
40
41
41 - 50
Note C
42 - 51
Note D
36
37
38
39
40
41
41 - 50
Note C
42 - 51
Note D
36
37
38
39
40
41
41 - 50
Note C
42 - 51
Note D
790
36
798
37
Nominal
Tire O.D.*
24.5
24.3
25.0
25.0
25.6
25.5
25.5
26.2
26.1
26.1
26.7
27.3
165R14 (SL)
P175/75R14 (SL)
36 - 51
Note B
908
36
805
38
812
39
820
40
827
41
41 - 50
Note C
42 - 51
Note D
Tire Load Limits in Pounds (lbs.) at Various Cold Inflation Pressures in Pounds Per Square Inch (psi)
Nominal
Tire O.D.*
22.2
22.7
22.7
23.2
34
35 - 51
Note A
1139
1153
1168
1253
1272
1290
1363
1363
1382
1382
1488
1488
1613
1746
1510
1510
1638
1771
33
1036
1065
1164
1124
1157
1275
1268
1389
1422
1510
1466
34
1047
1084
1183
1135
1168
1294
1290
1411
1444
1532
1488
36 - 51
Note B
36
37
38
40
41
41 - 50
Note C
42 - 51
Note D
1400
1400
1422
1444
1466
1484
1503
1521
1550
1569
1587
1609
1631
1653
1532
1532
1664
1797
35 - 51 36 - 51
35
Note A Note B
1069
1102
1102
1201
1157
1201
1190
1235
1312
1312
1356
1433
1477
1521
1554
1510
1565
36
37
38
NOTE A: Some P-Metric Light Load and Standard Load tires may be branded with a maximum inflation pressure of 35, 44 or 51 psi for high speed and handling optimization. However, there is no load increase above 35 psi.
NOTE B: Some European Metric tires may be branded with a maximum inflation pressure of 32, 36, 44 or 51 psi for high speed and handling optimization. However, there is no load increase above 36 psi.
NOTE C: Some P-Metric Extra Load tires may be branded with a maximum inflation pressure of 41 or 50 psi for high speed and handling optimization. However, there is no load increase above 41 psi.
NOTE D: Some European Metric Extra Load tires may be branded with a maximum inflation pressure of 42 or 51 psi for high speed and handling optimization. However, there is no load increase above 42 psi.
* Nominal Tire O. D. is a designated or theoretical size that may vary from the actual tire O. D.
IMPORTANT: Never exceed the maximum inflation pressure molded on the sidewall of the tire.
_____________________________________________________________________________
8/7/2006
39
B3
39
40
41
41 - 50
Note C
42 - 51
Note D
65 Series
P-Metric
Euro-Metric
P165/65R14 (SL)
P175/65R14 (SL)
P175/65R14 (XL)
175/65R14 (SL)
P185/65R14 (SL)
185/65R14 (SL)
185/65R14 (SL)
P195/65R14 (SL)
P195/65R14 (XL)
195/65R14 (SL)
205/65R14 (SL)
P215/65R14 (SL)
60 Series
P-Metric
Euro-Metric
P175/60R14 (SL)
185/60R14 (SL)
185/60R14 (XL)
P185/60R14 (SL)
P195/60R14 (SL)
195/60R14 (SL)
205/60R14 (SL)
P205/60R14 (SL)
P215/60R14 (SL)
215/60R14 (SL)
P225/60R14 (SL)
225/60R14 (SL)
P235/60R14 (SL)
P245/60R14 (SL)
P255/60R14 (SL)
P265/60R14 (SL)
P275/60R14 (SL)
55 Series
P-Metric
Euro-Metric
185/55R14 (SL)
195/55R14 (SL)
P205/55R14 (SL)
205/55R14 (SL)
P255/55R14 (SL)
50 Series
P-Metric
Euro-Metric
P205/50R14 (SL)
P225/50R14 (SL)
225/50R14 (SL)
P245/50R14 (SL)
P265/50R14 (SL)
Tire Load Limits in Pounds (lbs.) at Various Cold Inflation Pressures in Pounds Per Square Inch (psi)
For Light Load and Standard Load Tires
Rim Width
Range
6.0 - 7.5
6.0 - 8.0
6.5 - 8.0
26
1455
1565
1687
27
1481
1594
1716
28
1506
1624
1746
29
1532
1653
1775
30
1558
1679
1804
31
1583
1705
1834
32
1609
1731
1863
33
1631
1757
1889
34
1653
1782
1914
35
98
101
103
Nominal
Tire O.D.*
26.5
27.0
27.6
Load
Index
78
81
84
82
85
82
86
88
90
89
91
93
Nominal
Tire O.D.*
22.4
23.0
23.0
23.0
23.5
23.5
23.5
24.0
24.0
24.0
24.5
25.0
Rim Width
Range
4.5 - 6.0
5.0 - 6.0
5.0 - 6.0
5.0 - 6.0
5.0 - 6.5
5.0 - 6.5
5.0 - 6.5
5.5 - 7.0
5.5 - 7.0
5.5 - 7.0
5.5 - 7.5
6.0 - 7.5
26
805
882
882
805
970
805
904
1058
1058
981
1047
1257
27
820
900
900
827
988
827
926
1076
1076
1003
1069
1279
28
834
919
919
838
1007
838
937
1095
1095
1025
1091
1301
29
849
937
937
871
1025
871
981
1113
1113
1069
1135
1323
30
860
952
952
915
1040
915
1014
1131
1131
1113
1179
1345
31
871
966
966
926
1054
926
1025
1150
1150
1124
1190
1367
32
882
981
981
948
1069
948
1058
1168
1168
1157
1224
1389
33
900
994
994
981
1087
981
1091
1190
1190
1201
1268
1407
34
919
1006
1006
992
1106
992
1113
1213
1213
1213
1290
1426
35
Load
Index
79
82
86
82
85
86
88
88
91
91
94
94
96
98
101
103
105
Nominal
Tire O.D.*
22.3
22.8
22.8
22.8
23.2
23.2
23.7
23.7
24.2
24.2
24.7
24.6
25.1
25.6
26.1
26.5
27.0
Rim Width
Range
5.0 - 6.0
5.0 - 6.5
5.0 - 6.5
5.0 - 6.5
5.5 - 7.0
5.5 - 7.0
5.5 - 7.5
5.5 - 7.5
6.0 - 7.5
6.0 - 7.5
6.0 - 8.0
6.0 - 8.0
6.5 - 8.5
7.0 - 8.5
7.0 - 9.0
7.5 - 9.5
7.5 - 9.5
26
827
805
794
904
981
904
948
1069
1168
1047
1257
1135
1356
1455
1554
1664
1775
27
842
827
816
919
999
926
970
1091
1187
1069
1279
1168
1378
1481
1583
1694
1808
28
856
838
838
933
1018
937
992
1113
1205
1091
1301
1190
1400
1506
1613
1723
1841
29
871
871
871
948
1036
981
1036
1135
1224
1135
1323
1235
1422
1532
1642
1753
1874
30
886
915
904
966
1054
1014
1069
1153
1246
1179
1345
1290
1448
1558
1668
1782
1903
31
900
926
915
985
1073
1025
1080
1172
1268
1190
1367
1301
1473
1583
1694
1812
1933
32
915
948
937
1003
1091
1058
1113
1190
1290
1224
1389
1334
1499
1609
1720
1841
1962
33
931
981
970
1018
1106
1091
1157
1205
1308
1268
1411
1378
1521
1631
1746
1870
1991
34
947
992
981
1032
1120
1113
1168
1220
1327
1290
1433
1400
1543
1653
1771
1900
2021
35 - 51 36 - 51
35
Note A Note B
963
1014
1047
1003
1047
1135
1135
1168
1190
1235
1235
1345
1312
1356
1455
1433
1477
1565
1675
1797
1929
2050
Load
Index
Nominal
Tire O.D.*
Rim Width
Range
26
27
28
29
30
31
32
33
34
35
80
82
85
85
98
22.0
22.4
22.9
22.9
25.0
5.0 - 6.5
5.5 - 7.0
5.5 - 7.5
5.5 - 7.5
7.0 - 9.0
761
805
992
871
1444
783
827
1010
893
1470
794
838
1029
915
1495
827
871
1047
948
1521
860
915
1065
992
1547
871
926
1084
1003
1572
893
948
1102
1025
1598
926
981
1113
1058
1620
937
992
1124
1080
1642
Load
Index
83
88
89
93
98
Nominal
Tire O.D.*
22.1
22.9
22.9
23.7
24.5
Rim Width
Range
5.5 - 7.5
6.0 - 8.0
6.0 - 8.0
7.0 - 8.5
7.5 - 9.5
26
915
1069
981
1246
1422
27
933
1091
1003
1268
1448
28
952
1113
1025
1290
1473
29
970
1135
1069
1312
1499
30
985
1153
1113
1334
1525
31
999
1172
1124
1356
1550
32
1014
1190
1157
1378
1576
33
1034
1205
1201
1396
1598
34
1054
1220
1213
1415
1620
35 - 51 36 - 51
Note A Note B
1675
1808
1940
35 - 51 36 - 51
Note A Note B
937
1019
1019
1014
36
37
38
39
40
41
41 - 50
Note C
42 - 51
Note D
36
37
38
39
40
41
41 - 50
Note C
42 - 51
Note D
1032
1045
1058
1073
1087
1102
1250
1264
1279
1294
1308
1323
1047
1124
1014
1135
1047
1168
1235
1235
1235
1312
1279
1356
1444
35 - 51
Note A
959
1014
36 - 51
Note B
36
1036
37
1058
38
1069
1102
40
1124
41
41 - 50
Note C
1135
42 - 51
Note D
1168
36
37
38
39
40
41
41 - 50
Note C
42 - 51
Note D
36
37
38
39
40
41
41 - 50
Note C
42 - 51
Note D
992
1047
1135
1102
1135
1664
35 - 51 36 - 51
Note A Note B
1074
1235
1235
1279
1433
1642
35
NOTE A: Some P-Metric Light Load and Standard Load tires may be branded with a maximum inflation pressure of 35, 44 or 51 psi for high speed and handling optimization. However, there is no load increase above 35 psi.
NOTE B: Some European Metric tires may be branded with a maximum inflation pressure of 32, 36, 44 or 51 psi for high speed and handling optimization. However, there is no load increase above 36 psi.
NOTE C: Some P-Metric Extra Load tires may be branded with a maximum inflation pressure of 41 or 50 psi for high speed and handling optimization. However, there is no load increase above 41 psi.
NOTE D: Some European Metric Extra Load tires may be branded with a maximum inflation pressure of 42 or 51 psi for high speed and handling optimization. However, there is no load increase above 42 psi.
* Nominal Tire O. D. is a designated or theoretical size that may vary from the actual tire O. D.
IMPORTANT: Never exceed the maximum inflation pressure molded on the sidewall of the tire.
_____________________________________________________________________________
8/7/2006
39
B4
Tire Load Limits in Pounds (lbs.) at Various Cold Inflation Pressures in Pounds Per Square Inch (psi)
For Light Load and Standard Load Tires
(Continued)
45 Series
P-Metric
Euro-Metric
195/45R14 (SL)
P225/45R14 (LL)
P225/45R14 (SL)
Load
Index
77
79
86
Nominal
Tire O.D.*
20.9
22.0
22.0
Rim Width
Range
6.0 - 7.5
7.0 - 8.5
7.0 - 8.5
26
694
838
970
27
716
853
993
175/70R15 (SL)
P175/70R15 (SL)
185/70R15 (SL)
P185/70R15 (SL)
195/70R15 (SL)
P195/70R15 (SL)
P205/70R15 (SL)
205/70R15 (SL)
205/70R15 (SL)
P215/70R15 (SL)
215/70R15 (SL)
215/70R15 (SL)
P225/70R15 (SL)
225/70R15 (SL)
P235/70R15 (SL)
235/70R15 (SL)
235/70R15 (XL)
P245/70R15 (SL)
P245/70R15 (XL)
P255/70R15 (SL)
P255/70R15 (XL)
P265/70R15 (SL)
P275/70R15 (SL)
P285/70R15 (SL)
32
816
926
1104
33
849
938
1125
34
860
951
1147
35
882
36
37
38
39
40
41
41 - 50
Note C
42 - 51
Note D
963
1168
28
943
1016
1097
1323
1440
1440
1561
1561
1434
1690
1690
1819
1819
1949
2241
29
970
1045
1117
1345
1466
1466
1587
1587
1475
1720
1720
1852
1852
1984
2282
30
997
1073
1137
1367
1488
1488
1613
1613
1516
1746
1746
1881
1881
2017
2319
31
1023
1102
1156
1389
1510
1510
1638
1638
1556
1771
1771
1911
1911
2050
2355
32
1047
1130
1176
1411
1532
1532
1664
1664
1596
1797
1797
1940
1940
2083
2392
33
102
105
105
108
108
112
26
889
957
1058
1279
1389
1389
1510
1510
1352
1631
1631
1753
1753
1885
2160
1196
1433
1554
1554
1690
1690
1636
1823
1823
1969
1969
2141
2418
1215
1455
1576
1576
1716
1716
1675
1848
1848
1999
1999
2173
2443
Load
Index
86
85
89
89
92
92
95
95
96
97
97
98
100
100
102
103
107
105
108
108
110
110
112
115
Nominal
Tire O.D.*
24.7
24.7
25.2
25.2
25.8
25.8
26.3
26.3
26.3
26.9
26.9
26.9
27.4
27.4
28.0
28.0
28.0
28.5
28.5
29.1
29.1
29.7
30.2
30.8
Rim Width
Range
4.5 - 6.0
4.5 - 6.0
4.5 - 6.0
4.5 - 6.0
5.0 - 6.5
5.0 - 6.5
5.0 - 7.0
5.0 - 7.0
5.0 - 7.0
5.5 - 7.0
5.5 - 7.0
5.5 - 7.0
6.0 - 7.5
6.0 - 7.5
6.0 - 8.0
6.0 - 8.0
6.0 - 8.0
6.5 - 8.0
6.5 - 8.0
6.5 - 8.5
6.5 - 8.5
7.0 - 9.0
7.0 - 9.0
7.5 - 9.5
26
904
992
981
1091
1069
1190
1301
1168
1201
1411
1235
1268
1521
1356
1642
1488
1466
1764
1764
1885
1885
2017
2149
2293
27
926
1010
1003
1109
1091
1212
1323
1201
1235
1437
1268
1301
1547
1389
1672
1532
1510
1787
1787
1918
1918
2054
2190
2333
28
937
1029
1025
1128
1113
1235
1345
1224
1257
1462
1290
1323
1572
1411
1701
1554
1532
1820
1820
1951
1951
2090
2230
2374
29
981
1047
1069
1146
1157
1257
1367
1268
1312
1488
1345
1378
1598
1477
1731
1609
1598
1852
1852
1984
1984
2127
2271
2414
30
1014
1065
1113
1168
1213
1279
1389
1323
1367
1510
1400
1433
1624
1532
1757
1675
1664
1889
1889
2017
2017
2160
2308
2454
31
1025
1084
1124
1191
1224
1301
1411
1345
1378
1532
1422
1455
1649
1554
1782
1698
1687
1950
1950
2050
2050
2194
2344
2495
32
1058
1102
1157
1213
1257
1323
1433
1378
1411
1554
1455
1488
1675
1587
1808
1742
1720
1951
1951
2083
2083
2227
2381
2535
33
1091
1113
1201
1228
1301
1345
1455
1422
1466
1576
1510
1543
1701
1653
1837
1808
1786
1969
1969
2116
2116
2264
2410
2583
34
1113
1124
1213
1242
1323
1367
1477
1444
1488
1598
1532
1565
1727
1675
1867
1830
1819
1999
1999
2150
2150
2300
2440
2631
215R15 (SL)
70 Series
P-Metric
Euro-Metric
31
805
911
1082
Rim Width
Range
4.0 - 5.0
4.0 - 5.5
4.5 - 6.0
5.0 - 6.5
5.0 - 7.0
5.0 - 7.0
5.5 - 7.0
5.5 - 7.0
5.5 - 7.0
6.0 - 7.5
6.0 - 7.5
6.0 - 8.0
6.0 - 8.0
6.5 - 8.0
7.0 - 9.0
88
94
97
99
100
102
P225/75R15 (SL)
P225/75R15 (XL)
P235/75R15 (SL)
P235/75R15 (XL)
P245/75R15 (SL)
P265/75R15 (SL)
30
794
897
1060
Nominal
Tire O.D.*
24.8
25.4
25.3
26.5
27.1
27.1
27.7
27.7
28.5
28.3
28.3
28.9
28.9
29.5
30.7
Load
Index
155R15 (SL)
165R15 (SL)
P175/75R15 (SL)
P195/75R15 (SL)
P205/75R15 (SL)
P205/75R15 (XL)
P215/75R15 (SL)
P215/75R15 (XL)
29
761
882
1038
36 - 51
Note B
908
Tire Load Limits in Pounds (lbs.) at Various Cold Inflation Pressures in Pounds Per Square Inch (psi)
28
728
867
1015
34
35 - 51
Note A
36 - 51
Note B
36
37
38
40
41
41 - 50
Note C
42 - 51
Note D
1235
1477
1598
1598
1620
1642
1664
1679
1694
1709
1764
1786
1808
1830
1852
1874
1900
1925
1951
1977
2002
2028
2054
2079
2105
2131
2157
2183
37
38
1742
1742
1715
1754
1874
1874
2028
2028
2205
2469
35 - 51 36 - 51
35
Note A Note B
1135
1168
1135
1235
1279
1257
1345
1389
1389
1499
1477
1521
1510
1565
1620
1554
1609
1598
1653
1753
1709
1764
1896
1863
1929
1852
2028
2028
2183
2183
2337
2469
2679
36
39
40
41
41 - 50
Note C
1907
1940
1973
2028
2061
2057
2087
2116
2142
2168
2194
2212
2242
2271
2293
2315
2337
NOTE A: Some P-Metric Light Load and Standard Load tires may be branded with a maximum inflation pressure of 35, 44 or 51 psi for high speed and handling optimization. However, there is no load increase above 35 psi.
NOTE B: Some European Metric tires may be branded with a maximum inflation pressure of 32, 36, 44 or 51 psi for high speed and handling optimization. However, there is no load increase above 36 psi.
NOTE C: Some P-Metric Extra Load tires may be branded with a maximum inflation pressure of 41 or 50 psi for high speed and handling optimization. However, there is no load increase above 41 psi.
NOTE D: Some European Metric Extra Load tires may be branded with a maximum inflation pressure of 42 or 51 psi for high speed and handling optimization. However, there is no load increase above 42 psi.
* Nominal Tire O. D. is a designated or theoretical size that may vary from the actual tire O. D.
IMPORTANT: Never exceed the maximum inflation pressure molded on the sidewall of the tire.
_____________________________________________________________________________
8/7/2006
39
B5
2094
42 - 51
Note D
2149
Tire Load Limits in Pounds (lbs.) at Various Cold Inflation Pressures in Pounds Per Square Inch (psi)
For Light Load and Standard Load Tires
(Continued)
65 Series
P-Metric
Euro-Metric
145/65R15 (SL)
P185/65R15 (SL)
185/65R15 (SL)
185/65R15 (SL)
P195/65R15 (SL)
195/65R15 (SL)
P205/65R15 (SL)
P205/65R15 (XL)
205/65R15 (SL)
205/65R15 (SL)
205/65R15 (SL)
P215/65R15 (SL)
215/65R15 (SL)
225/65R15 (SL)
P235/65R15 (SL)
255/65R15 (SL)
P255/65R15 (SL)
P295/65R15 (SL)
60 Series
P-Metric
Euro-Metric
P185/60R15 (SL)
P195/60R15 (SL)
195/60R15 (SL)
195/60R15 (SL)
195/60R15 (SL)
P205/60R15 (SL)
205/60R15 (SL)
205/60R15 (SL)
P215/60R15 (SL)
215/60R15 (SL)
P225/60R15 (SL)
225/60R15 (SL)
225/60R15 (SL)
P235/60R15 (SL)
235/60R15 (SL)
P245/60R15 (SL)
255/60R15 (SL)
P255/60R15 (SL)
P255/60R15 (XL)
P265/60R15 (SL)
P275/60R15 (SL)
275/60R15 (SL)
P295/60R15 (SL)
P315/60R15 (SL)
55 Series
P-Metric
Euro-Metric
175/55R15 (SL)
185/55R15 (SL)
185/55R15 (SL)
P195/55R15 (SL)
Load
Index
Nominal
Tire O.D.*
Rim Width
Range
72
86
87
88
89
91
92
95
92
93
94
95
96
99
100
106
105
114
22.4
24.5
24.4
24.4
25.0
25.0
25.5
25.5
25.5
25.5
25.5
26.0
26.0
26.5
27.1
28.1
28.1
30.1
Load
Index
84
87
88
89
91
90
89
91
93
94
95
95
96
98
98
100
102
102
105
105
107
107
111
116
4.0 - 5.0
5.0 - 6.5
5.0 - 6.5
5.0 - 6.5
5.5 - 7.0
5.5 - 7.0
5.5 - 7.5
5.5 - 7.5
5.5 - 7.5
5.5 - 7.5
5.5 - 7.5
6.0 - 7.5
6.0 - 7.5
6.0 - 8.0
6.5 - 8.5
7.0 - 9.0
7.0 - 9.0
8.0 - 10.0
26
606
1014
926
948
1113
1047
1213
1213
1069
1102
1135
1312
1201
1312
1521
1609
1753
2271
27
617
1032
948
970
1131
1069
1235
1235
1091
1124
1168
1334
1235
1345
1550
1653
1786
2311
28
628
1051
970
992
1150
1091
1257
1257
1113
1146
1190
1356
1257
1367
1580
1687
1819
2351
29
650
1069
1003
1036
1168
1135
1279
1279
1157
1201
1235
1378
1312
1433
1609
1753
1852
2392
30
683
1087
1047
1069
1190
1179
1297
1297
1213
1246
1290
1404
1367
1488
1635
1819
1881
2428
31
694
1106
1058
1080
1213
1190
1316
1316
1224
1257
1301
1429
1378
1510
1661
1852
1911
2465
32
705
1124
1080
1113
1235
1224
1334
1334
1257
1290
1334
1455
1411
1543
1687
1896
1940
2502
33
728
1139
1124
1157
1250
1268
1356
1356
1301
1345
1378
1473
1466
1598
1713
1962
1969
2535
34
739
1153
1135
1168
1264
1290
1378
1378
1323
1367
1400
1492
1488
1620
1738
1995
1999
2568
35
761
Nominal
Tire O.D.*
23.7
24.2
24.2
24.2
24.2
24.7
24.7
24.7
25.2
25.2
25.6
25.6
25.6
26.1
26.1
26.6
27.0
27.1
27.1
27.5
28.0
28.0
28.9
29.9
Rim Width
Range
5.0 - 6.5
5.5 - 7.0
5.5 - 7.0
5.5 - 7.0
5.5 - 7.0
5.5 - 7.5
5.5 - 7.5
5.5 - 7.5
6.0 - 7.5
6.0 - 7.5
6.0 - 8.0
6.0 - 8.0
6.0 - 8.0
6.5 - 8.5
6.5 - 8.5
7.0 - 8.5
7.0 - 9.0
7.0 - 9.0
7.0 - 9.0
7.5 - 9.5
7.5 - 9.5
7.5 - 9.5
8.0 - 10.0
8.5 - 11.0
26
948
1036
948
981
1047
1124
981
1047
1224
1135
1312
1168
1201
1422
1268
1521
1444
1631
1631
1742
1863
1653
2105
2359
27
966
1054
970
1003
1069
1146
1003
1069
1246
1168
1338
1201
1235
1448
1301
1550
1477
1661
1661
1775
1896
1698
2142
2399
28
985
1073
992
1025
1091
1168
1025
1091
1268
1190
1363
1224
1257
1473
1323
1580
1499
1690
1690
1808
1929
1731
2179
2439
29
1003
1091
1036
1069
1135
1190
1069
1135
1290
1235
1389
1268
1312
1499
1378
1609
1565
1720
1720
1841
1962
1797
2216
2480
30
1018
1109
1069
1113
1179
1209
1113
1179
1308
1290
1411
1323
1367
1521
1433
1635
1631
1749
1749
1870
1991
1874
2253
2520
31
1032
1128
1080
1124
1190
1227
1124
1190
1327
1301
1433
1345
1378
1543
1455
1661
1653
1779
1779
1900
2021
1896
2289
2560
32
1047
1146
1113
1157
1224
1246
1157
1224
1345
1334
1455
1378
1411
1565
1488
1687
1687
1808
1808
1929
2050
1940
2326
2601
33
1065
1161
1157
1201
1268
1264
1201
1268
1367
1378
1477
1422
1466
1591
1543
1709
1753
1834
1834
1958
2083
2006
2352
2652
34
1084
1175
1168
1213
1290
1283
1213
1290
1389
1400
1499
1444
1488
1616
1565
1731
1786
1859
1859
1988
2116
2039
2377
2704
35
Load
Index
Nominal
Tire O.D.*
Rim Width
Range
77
81
82
84
22.6
23.0
23.0
23.4
5.0 - 6.0
5.0 - 6.5
5.0 - 6.5
5.5 - 7.0
26
694
783
805
959
27
716
805
827
977
28
728
816
838
996
29
761
849
871
1014
30
794
882
915
1029
31
805
893
926
1043
32
816
915
948
1058
33
849
948
981
1073
34
860
959
992
1087
35 - 51
Note A
36 - 51
Note B
783
36
37
38
1418
1437
1455
36
37
38
40
41
41 - 50
Note C
42 - 51
Note D
1168
1157
1190
1201
1235
1279
1312
1356
1400
1400
1345
1389
1433
1477
1499
1521
1389
1433
1477
1510
1510
1653
1565
1709
1764
2028
2094
2028
2601
1190
1235
1312
1235
1312
1433
1477
1510
1598
1819
35 - 51 36 - 51
Note A Note B
1102
1190
1235
1279
1356
1301
1279
1356
1411
1477
1521
1521
1565
1642
1653
1753
1874
1885
1885
1911
1936
1962
39
1988
40
41
2013
41 - 50
Note C
42 - 51
Note D
2039
2017
2149
2083
2149
2403
2756
35 - 51 36 - 51
35
Note A Note B
882
908
981
1019
1014
1047
1102
36
37
38
NOTE A: Some P-Metric Light Load and Standard Load tires may be branded with a maximum inflation pressure of 35, 44 or 51 psi for high speed and handling optimization. However, there is no load increase above 35 psi.
NOTE B: Some European Metric tires may be branded with a maximum inflation pressure of 32, 36, 44 or 51 psi for high speed and handling optimization. However, there is no load increase above 36 psi.
NOTE C: Some P-Metric Extra Load tires may be branded with a maximum inflation pressure of 41 or 50 psi for high speed and handling optimization. However, there is no load increase above 41 psi.
NOTE D: Some European Metric Extra Load tires may be branded with a maximum inflation pressure of 42 or 51 psi for high speed and handling optimization. However, there is no load increase above 42 psi.
* Nominal Tire O. D. is a designated or theoretical size that may vary from the actual tire O. D.
IMPORTANT: Never exceed the maximum inflation pressure molded on the sidewall of the tire.
_____________________________________________________________________________
8/7/2006
39
B6
39
40
41
41 - 50
Note C
42 - 51
Note D
50 Series
P-Metric
Euro-Metric
P195/50R15 (SL)
195/50R15 (SL)
P205/50R15 (SL)
205/50R15 (SL)
205/50R15 (SL)
205/50R15 (XL)
215/50R15 (SL)
P215/50R15 (SL)
P225/50R15 (SL)
225/50R15 (SL)
P245/50R15 (SL)
P245/50R15 (XL)
245/50R15 (SL)
P265/50R15 (SL)
P275/50R15 (SL)
P295/50R15 (SL)
295/50R15 (SL)
P305/50R15 (SL)
P305/50R15 (XL)
305/50R15 (SL)
P325/50R15 (SL)
45 Series
P-Metric
Euro-Metric
195/45R15 (SL)
215/45R15 (SL)
215/45R15 (XL)
225/45R15 (SL)
Tire Load Limits in Pounds (lbs.) at Various Cold Inflation Pressures in Pounds Per Square Inch (psi)
For Light Load and Standard Load Tires
82
83
84
85
87
87
88
91
89
92
92
100
104
118
Rim Width
Range
5.5 - 7.0
5.5 - 7.0
5.5 - 7.0
5.5 - 7.0
5.5 - 7.5
5.5 - 7.5
5.5 - 7.5
5.5 - 7.5
6.0 - 7.5
6.0 - 8.0
6.0 - 8.0
7.0 - 9.0
7.5 - 9.5
10.0 - 12.0
26
805
827
849
871
1047
926
948
1047
981
1069
1224
1510
1521
2557
27
827
849
871
893
1065
948
970
1069
1003
1091
1246
1536
1565
2605
28
838
860
882
915
1084
970
992
1091
1025
1113
1268
1561
1598
2653
29
871
893
926
948
1102
1003
1036
1135
1069
1157
1290
1587
1664
2701
30
915
937
959
992
1120
1047
1069
1179
1113
1213
1308
1613
1731
2745
31
926
948
970
1003
1139
1058
1080
1190
1124
1224
1327
1638
1753
2789
32
948
970
992
1025
1157
1080
1113
1224
1157
1257
1345
1664
1797
2833
33
981
1003
1036
1058
1172
1124
1157
1268
1201
1301
1360
1690
1852
2858
34
992
1014
1047
1080
1186
1135
1168
1290
1213
1323
1374
1716
1885
2884
35
1014
1036
1069
1102
Load
Index
81
82
84
85
86
89
88
87
90
91
95
97
96
99
101
105
105
108
110
110
112
Nominal
Tire O.D.*
22.7
22.7
23.1
23.1
23.1
23.1
23.5
23.5
23.9
23.9
24.7
24.7
24.7
25.5
25.9
26.7
26.7
27.1
27.1
27.0
27.8
Rim Width
Range
5.5 - 7.0
5.5 - 7.0
5.5 - 7.5
5.5 - 7.5
5.5 - 7.5
5.5 - 7.5
6.0 - 7.5
6.0 - 7.5
6.0 - 8.0
6.0 - 8.0
7.0 - 8.5
7.0 - 8.5
7.0 - 8.5
7.5 - 9.5
7.5 - 9.5
8.0 - 10.0
8.0 - 10.5
8.5 - 11.0
8.5 - 11.0
8.5 - 11.0
9.0 - 12.0
26
893
805
970
871
904
849
948
1047
1124
1047
1301
1301
1201
1488
1587
1786
1565
1896
1896
1797
2116
27
908
827
985
893
926
893
970
1065
1146
1069
1323
1323
1235
1514
1616
1819
1609
1929
1929
1841
2156
28
922
838
999
915
937
915
992
1084
1168
1091
1345
1345
1257
1539
1646
1852
1642
1962
1962
1874
2197
29
937
871
1014
948
981
948
1036
1102
1190
1135
1367
1367
1312
1565
1675
1885
1709
1995
1995
1951
2238
30
952
915
1032
992
1014
992
1069
1120
1209
1179
1393
1393
1367
1591
1701
1914
1775
2028
2028
2028
2271
31
966
926
1051
1003
1025
1003
1080
1139
1227
1190
1418
1418
1378
1616
1727
1944
1797
2061
2061
2061
2304
32
981
948
1069
1025
1058
1025
1113
1157
1246
1224
1444
1444
1411
1642
1753
1973
1841
2094
2094
2105
2337
33
994
981
1084
1058
1091
1058
1157
1172
1264
1268
1462
1462
1466
1668
1779
2002
1907
2127
2127
2183
2373
34
1006
992
1098
1080
1113
1080
1168
1186
1283
1290
1481
1481
1488
1694
1804
2032
1940
2161
2161
2216
2410
35
Load
Index
Nominal
Tire O.D.*
Rim Width
Range
26
27
28
29
30
31
32
33
34
35
78
84
87
87
21.9
22.6
22.6
22.9
6.0 - 7.5
7.0 - 8.0
7.0 - 8.0
7.0 - 8.5
716
948
816
926
739
970
838
948
195/80R16 (SL)
Load
Index
97
Nominal
Tire O.D.*
27.9
750
992
860
970
783
1036
893
1003
816
1069
926
1047
827
1080
937
1058
849
1113
959
1080
882
1157
1003
1124
893
1168
1014
1135
35 - 51
Note A
36 - 51
Note B
1047
1074
1102
1135
36
37
38
39
40
41
41 - 50
Note C
42 - 51
Note D
36
37
38
39
40
41
41 - 50
Note C
42 - 51
Note D
1201
1157
1190
1312
1235
1345
1201
1235
1356
1279
1389
1389
1742
1918
1984
2910
35 - 51 36 - 51
Note A Note B
1019
1014
1047
1113
1102
1135
1135
1168
1102
1190
1235
1201
1301
1312
1356
1499
1499
1510
1565
1720
1830
2061
1973
2039
2194
2194
2260
2337
2447
35 - 51
Note A
904
1190
1036
1157
36 - 51
Note B
1135
1157
1168
1213
1235
1521
1543
1565
1580
1594
1609
2223
2253
2282
2300
2319
2337
36
37
38
39
40
1246
41
1279
41 - 50
Note C
42 - 51
Note D
937
1235
1069
1091
1102
1135
1157
1168
1201
1201
Tire Load Limits in Pounds (lbs.) at Various Cold Inflation Pressures in Pounds Per Square Inch (psi)
Nominal
Tire O.D.*
23.4
23.4
23.4
23.4
23.9
23.9
23.9
23.9
24.3
24.8
24.8
26.0
26.9
30.0
26
1235
27
1268
28
1290
29
1345
30
1400
31
1422
32
1455
33
1510
34
1532
35 - 51
Note A
36 - 51
Note B
1609
36
37
38
NOTE A: Some P-Metric Light Load and Standard Load tires may be branded with a maximum inflation pressure of 35, 44 or 51 psi for high speed and handling optimization. However, there is no load increase above 35 psi.
NOTE B: Some European Metric tires may be branded with a maximum inflation pressure of 32, 36, 44 or 51 psi for high speed and handling optimization. However, there is no load increase above 36 psi.
NOTE C: Some P-Metric Extra Load tires may be branded with a maximum inflation pressure of 41 or 50 psi for high speed and handling optimization. However, there is no load increase above 41 psi.
NOTE D: Some European Metric Extra Load tires may be branded with a maximum inflation pressure of 42 or 51 psi for high speed and handling optimization. However, there is no load increase above 42 psi.
* Nominal Tire O. D. is a designated or theoretical size that may vary from the actual tire O. D.
IMPORTANT: Never exceed the maximum inflation pressure molded on the sidewall of the tire.
_____________________________________________________________________________
8/7/2006
B7
39
40
41
41 - 50
Note C
42 - 51
Note D
Tire Load Limits in Pounds (lbs.) at Various Cold Inflation Pressures in Pounds Per Square Inch (psi)
For Light Load and Standard Load Tires
(Continued)
75 Series
P-Metric
Euro-Metric
P215/75R16 (SL)
P225/75R16 (SL)
P225/75R16 (XL)
P235/75R16 (SL)
P235/75R16 (XL)
P245/75R16 (SL)
P265/75R16 (SL)
265/75R16 (SL)
70 Series
P-Metric
Euro-Metric
P215/70R16 (SL)
215/70R16 (SL)
215/70R16 (SL)
P225/70R16 (SL)
225/70R16 (SL)
P235/70R16 (SL)
P235/70R16 (XL)
235/70R16 (SL)
235/70R16 (SL)
P245/70R16 (SL)
245/70R16 (SL)
P255/70R16 (SL)
P255/70R16 (XL)
P265/70R16 (SL)
265/70R16 (SL)
P275/70R16 (SL)
275/70R16 (SL)
P285/70R16 (SL)
65 Series
P-Metric
Euro-Metric
P205/65R16 (SL)
P215/65R16 (SL)
215/65R16 (SL)
P225/65R16 (SL)
P235/65R16 (SL)
235/65R16 (SL)
255/65R16 (SL)
P255/65R16 (SL)
P265/65R16 (SL)
P275/65R16 (SL)
P285/65R16 (SL)
P295/65R16 (SL)
60 Series
P-Metric
Euro-Metric
P205/60R16 (SL)
P205/60R16 (XL)
205/60R16 (SL)
P215/60R16 (SL)
215/60R16 (SL)
Load
Index
101
104
106
106
109
109
114
116
Nominal
Tire O.D.*
28.7
29.3
29.3
29.8
29.8
30.5
31.7
31.7
Rim Width
Range
5.5 - 7.0
6.0 - 7.5
6.0 - 7.5
6.0 - 8.0
6.0 - 8.0
6.5 - 8.0
7.0 - 9.0
7.0 - 9.0
Load
Index
99
99
100
101
102
104
107
105
106
106
107
109
112
111
112
Nominal
Tire O.D.*
27.9
27.9
27.9
28.4
28.4
29.0
29.0
29.0
29.0
29.5
29.5
30.1
30.1
30.6
30.6
Rim Width
Range
5.5 - 7.0
5.5 - 7.0
5.5 - 7.0
6.0 - 7.5
6.0 - 7.5
6.0 - 8.0
6.0 - 8.0
6.0 - 8.0
6.0 - 8.0
6.5 - 8.0
6.5 - 8.0
6.5 - 8.5
6.5 - 8.5
7.0 - 9.0
7.0 - 9.0
26
1466
1312
1356
1587
1444
1709
1709
1565
1609
1841
1653
1962
1962
2105
1896
27
1467
1345
1389
1616
1477
1745
1745
1609
1653
1874
1698
1999
1999
2138
1951
28
1492
1367
1411
1646
1499
1777
1777
1642
1687
1907
1731
2036
2036
2177
1984
29
1554
1433
1477
1675
1565
1808
1808
1709
1753
1940
1797
2072
2072
2216
2061
30
1540
1488
1532
1697
1631
1825
1825
1775
1819
1969
1874
2103
2103
2252
2149
31
1562
1510
1554
1725
1653
1855
1855
1797
1852
1999
1896
2138
2138
2289
2183
32
1620
1543
1587
1753
1687
1885
1885
1841
1896
2028
1940
2172
2172
2326
2227
33
1606
1598
1653
1766
1753
1926
1926
1907
1962
2050
2006
2205
2205
2333
2315
34
1628
1620
1675
1793
1786
1955
1955
1940
1995
2072
2039
2238
2238
2368
2348
114
114
116
31.2
31.2
31.8
7.0 - 9.0
7.0 - 9.0
7.5 - 9.5
2238
1995
2116
2278
2050
2183
2319
2083
2216
2359
2172
2304
2399
2260
2392
2440
2293
2425
2480
2348
2491
2520
2436
2579
2561
2469
2623
Load
Index
Nominal
Tire O.D.*
Rim Width
Range
94
96
98
99
101
103
109
106
109
111
113
116
26.5
27.0
27.0
27.5
28.0
28.0
29.1
29.1
29.5
30.1
30.6
31.1
5.5 - 7.5
6.0 - 7.5
6.0 - 7.5
6.0 - 8.0
6.5 - 8.5
6.5 - 8.5
7.0 - 9.0
7.0 - 9.0
7.5 - 9.5
7.5 - 9.5
8.0 - 10.0
8.0 - 10.0
1268
1367
1268
1477
1598
1488
1742
1830
1962
2083
2216
2359
1290
1393
1301
1506
1624
1532
1786
1863
1995
2128
2256
2403
Load
Index
91
94
92
94
95
Nominal
Tire O.D.*
25.7
25.7
25.7
26.1
26.1
Rim Width
Range
5.5 - 7.5
5.5 - 7.5
5.5 - 7.5
6.0 - 7.5
6.0 - 7.5
26
1179
1179
1069
1279
1168
27
1199
1199
1091
1301
1201
26
1576
1698
1698
1830
1830
1962
2249
2116
26
27
1602
1727
1727
1863
1863
1999
2287
2183
27
28
1627
1757
1757
1896
1896
2035
2329
2216
28
29
1653
1786
1786
1929
1929
2072
2370
2304
30
1683
1815
1815
1962
1962
2105
2412
2392
31
1712
1845
1845
1995
1995
2139
2452
2425
32
1742
1874
1874
2028
2028
2172
2491
2491
33
1768
1911
1911
2050
2050
2205
2526
2579
34
1793
1947
1947
2072
2072
2238
2564
2623
29
30
31
32
33
34
1312
1418
1323
1536
1649
1554
1819
1896
2028
2167
2297
2447
1334
1444
1378
1565
1675
1609
1896
1929
2061
2205
2337
2491
1356
1470
1433
1591
1705
1675
1973
1962
2094
2231
2377
2531
1378
1495
1455
1616
1734
1698
2006
1995
2127
2268
2418
2572
1400
1521
1488
1642
1764
1742
2050
2028
2160
2304
2458
2612
1426
1536
1543
1664
1782
1808
2127
2050
2197
2333
2484
2660
1451
1550
1565
1687
1801
1830
2160
2072
2234
2368
2509
2708
28
1218
1218
1113
1323
1224
29
1246
1246
1157
1345
1268
30
1258
1258
1213
1367
1323
31
1277
1277
1224
1389
1345
32
1301
1301
1257
1411
1378
33
1317
1317
1301
1433
1422
34
1336
1336
1323
1455
1444
35 - 51 36 - 51
Note A Note B
1819
1984
1984
36
37
38
40
41
41 - 50
Note C
2002
2021
2039
2057
2076
2094
2131
2168
2205
2227
2249
2271
42 - 51
Note D
2094
2094
2271
2601
2668
2756
35 - 51 36 - 51
35
Note A Note B
1709
1653
1709
1709
1764
1819
1819
1874
1984
1984
1973
2039
2028
2094
2094
2083
2149
2271
2271
2403
2392
2469
36
37
38
39
40
41
41 - 50
Note C
2006
2028
2050
2083
2116
2149
2300
2330
2359
2396
2432
2469
42 - 51
Note D
2601
2513
2668
35
2601
2756
35 - 51
Note A
36 - 51
Note B
36
37
38
39
40
41
41 - 50
Note C
42 - 51
Note D
36
37
38
39
40
41
41 - 50
Note C
42 - 51
Note D
1477
1565
1598
1653
1709
1819
1863
2194
1929
2271
2094
2271
2403
2535
2756
35
35 - 51 36 - 51
Note A Note B
1356
1356
1345
1378
1400
1422
1389
1477
1477
1521
NOTE A: Some P-Metric Light Load and Standard Load tires may be branded with a maximum inflation pressure of 35, 44 or 51 psi for high speed and handling optimization. However, there is no load increase above 35 psi.
NOTE B: Some European Metric tires may be branded with a maximum inflation pressure of 32, 36, 44 or 51 psi for high speed and handling optimization. However, there is no load increase above 36 psi.
NOTE C: Some P-Metric Extra Load tires may be branded with a maximum inflation pressure of 41 or 50 psi for high speed and handling optimization. However, there is no load increase above 41 psi.
NOTE D: Some European Metric Extra Load tires may be branded with a maximum inflation pressure of 42 or 51 psi for high speed and handling optimization. However, there is no load increase above 42 psi.
* Nominal Tire O. D. is a designated or theoretical size that may vary from the actual tire O. D.
IMPORTANT: Never exceed the maximum inflation pressure molded on the sidewall of the tire.
_____________________________________________________________________________
8/7/2006
39
B8
1440
1459
1477
55 Series
P-Metric
Euro-Metric
P195/55R16 (SL)
P205/55R16 (SL)
205/55R16 (SL)
205/55R16 (SL)
205/55R16 (SL)
205/55R16 (XL)
205/55R16 (XL)
P215/55R16 (SL)
215/55R16 (SL)
215/55R16 (SL)
215/55R16 (XL)
P225/55R16 (SL)
225/55R16 (SL)
225/55R16 (SL)
225/55R16 (SL)
225/55R16 (SL)
P235/55R16 (SL)
235/55R16 (SL)
P245/55R16 (SL)
245/55R16 (SL)
255/55R16(SL)
50 Series
P-Metric
Euro-Metric
185/50R16 (SL)
195/50R16 (SL)
195/50R16 (SL)
P195/50R16 (SL)
P205/50R16 (SL)
P205/50R16 (XL)
205/50R16 (SL)
P215/50R16 (SL)
215/50R16 (SL)
P225/50R16 (SL)
225/50R16 (SL)
225/50R16 (XL)
Tire Load Limits in Pounds (lbs.) at Various Cold Inflation Pressures in Pounds Per Square Inch (psi)
For Light Load and Standard Load Tires
97
97
98
102
99
100
104
104
103
106
109
111
Nominal
Tire O.D.*
26.6
26.6
26.6
26.6
27.1
27.1
27.1
28.0
28.0
28.5
29.0
29.5
Rim Width
Range
6.0 - 8.0
6.0 - 8.0
6.0 - 8.0
6.0 - 8.0
6.5 - 8.5
6.5 - 8.5
6.5 - 8.5
7.0 - 9.0
7.0 - 9.0
7.5 - 9.5
7.5 - 9.5
8.0 - 10.0
26
1378
1235
1268
1279
1477
1356
1356
1698
1488
1819
1742
2061
27
1404
1268
1301
1312
1510
1389
1389
1731
1532
1852
1786
2098
28
1429
1290
1323
1334
1537
1411
1411
1764
1554
1885
1819
2135
29
1455
1345
1378
1389
1565
1477
1477
1797
1609
1918
1896
2172
30
1477
1400
1433
1444
1589
1532
1532
1826
1675
1947
1973
2209
31
1499
1422
1455
1466
1616
1554
1554
1856
1698
1977
2006
2245
32
1521
1455
1488
1499
1642
1587
1587
1885
1742
2006
2050
2282
33
1550
1510
1543
1554
1659
1653
1653
1918
1808
2035
2127
2322
34
1580
1532
1565
1576
1684
1675
1675
1951
1830
2065
2160
2363
Load
Index
86
89
89
90
91
94
97
91
91
93
97
94
93
94
95
96
96
96
99
100
103
Nominal
Tire O.D.*
24.4
24.9
24.9
24.9
24.9
24.9
24.9
25.3
25.3
25.3
25.3
25.8
25.7
25.7
25.7
25.7
26.1
26.1
26.6
26.6
27.0
Rim Width
Range
5.5 - 7.0
5.5 - 7.5
5.5 - 7.5
5.5 - 7.5
5.5 - 7.5
5.5 - 7.5
5.5 - 7.5
6.0 - 7.5
6.0 - 7.5
6.0 - 7.5
6.0 - 7.5
6.0 - 8.0
6.0 - 8.0
6.0 - 8.0
6.0 - 8.0
6.0 - 8.0
6.5 - 8.5
6.5 - 8.5
7.0 - 8.5
7.0 - 8.5
7.0 - 9.0
26
1003
1091
981
1014
1047
1003
1102
1179
1047
1102
1102
1279
1102
1135
1168
1201
1378
1201
1477
1356
1488
27
1021
1113
1003
1036
1069
1036
1124
1201
1069
1124
1124
1301
1124
1168
1201
1235
1400
1235
1503
1389
1532
28
1040
1135
1025
1058
1091
1058
1146
1224
1091
1146
1146
1323
1146
1190
1224
1257
1422
1257
1529
1411
1554
29
1058
1157
1069
1102
1135
1102
1190
1246
1135
1201
1190
1345
1201
1235
1268
1312
1444
1312
1554
1477
1609
30
1076
1176
1113
1146
1179
1146
1246
1268
1179
1246
1246
1367
1246
1290
1323
1367
1470
1367
1580
1532
1675
31
1095
1194
1124
1157
1190
1157
1257
1290
1190
1257
1257
1389
1257
1301
1345
1378
1495
1378
1606
1554
1698
32
1113
1213
1157
1190
1224
1179
1290
1312
1224
1290
1290
1411
1290
1334
1378
1411
1521
1411
1632
1587
1742
33
1131
1235
1201
1235
1268
1224
1334
1327
1268
1345
1334
1433
1345
1378
1422
1466
1536
1466
1657
1653
1808
34
1150
1257
1213
1257
1290
1246
1356
1341
1290
1367
1356
1455
1367
1400
1444
1488
1550
1488
1683
1675
1830
Load
Index
81
83
84
83
86
89
87
89
90
91
92
95
Nominal
Tire O.D.*
23.3
23.7
23.7
23.7
24.1
24.1
24.1
24.5
24.5
24.9
24.9
24.9
Rim Width
Range
5.0 - 6.5
5.5 - 7.0
5.5 - 7.0
5.5 - 7.0
5.5 - 7.5
5.5 - 7.5
5.5 - 7.5
6.0 - 7.5
6.0 - 7.5
6.0 - 8.0
6.0 - 8.0
6.0 - 8.0
26
783
827
849
937
1014
1014
926
1091
1014
1179
1069
1036
27
805
849
871
947
1031
1031
948
1113
1036
1201
1091
1058
28
816
860
882
964
1050
1050
970
1135
1058
1224
1113
1080
29
849
893
926
981
1069
1069
1003
1157
1102
1246
1157
1135
30
882
937
959
1003
1088
1088
1047
1175
1146
1264
1213
1179
31
893
948
970
1020
1106
1106
1058
1194
1157
1283
1224
1190
32
915
970
992
1036
1124
1124
1080
1213
1190
1301
1257
1224
33
948
1003
1036
1043
1134
1134
1124
1235
1235
1323
1301
1268
34
959
1014
1047
1059
1151
1151
1135
1257
1257
1345
1323
1290
35
35 - 51 36 - 51
Note A Note B
35
981
1019
1036
1074
1069
1102
1074
1168
1168
1157
1201
1279
1279
1323
1367
1345
1389
1312
42 - 51
Note D
38
39
40
41
1664
1698
1720
1775
1797
1819
1874
1764
1797
1819
1874
1907
1929
1984
38
39
40
41
36
37
41 - 50
Note C
42 - 51
Note D
1312
1433
1334
1455
1356
1477
1400
1521
1422
1543
1433
1565
1477
1609
1433
1455
1477
1521
1543
1565
1609
36
37
38
39
40
1183
1198
1213
1235
1257
1356
1378
1389
1433
1455
NOTE A: Some P-Metric Light Load and Standard Load tires may be branded with a maximum inflation pressure of 35, 44 or 51 psi for high speed and handling optimization. However, there is no load increase above 35 psi.
NOTE B: Some European Metric tires may be branded with a maximum inflation pressure of 32, 36, 44 or 51 psi for high speed and handling optimization. However, there is no load increase above 36 psi.
NOTE C: Some P-Metric Extra Load tires may be branded with a maximum inflation pressure of 41 or 50 psi for high speed and handling optimization. However, there is no load increase above 41 psi.
NOTE D: Some European Metric Extra Load tires may be branded with a maximum inflation pressure of 42 or 51 psi for high speed and handling optimization. However, there is no load increase above 42 psi.
* Nominal Tire O. D. is a designated or theoretical size that may vary from the actual tire O. D.
IMPORTANT: Never exceed the maximum inflation pressure molded on the sidewall of the tire.
_____________________________________________________________________________
8/7/2006
41 - 50
Note C
37
36
B9
41
41 - 50
Note C
42 - 51
Note D
1279
1477
1521
45 Series
P-Metric
Euro-Metric
195/45R16 (SL)
P205/45R16 (LL)
205/45R16 (SL)
205/45R16 (XL)
215/45R16 (SL)
225/45R16 (SL)
225/45R16 (XL)
P245/45R16 (LL)
P245/45R16 (SL)
245/45R16 (SL)
P265/45R16 (LL)
265/45R16 (SL)
40 Series
P-Metric
Euro-Metric
P205/40R16 (LL)
P205/40R16 (SL)
P205/40R16 (XL)
205/40R16 (SL)
205/40R16 (XL)
215/40R16 (SL)
215/40R16 (XL)
225/40R16 (SL)
225/40R16 (XL)
Tire Load Limits in Pounds (lbs.) at Various Cold Inflation Pressures in Pounds Per Square Inch (psi)
For Light Load and Standard Load Tires
94
95
96
97
99
99
101
103
107
Rim Width
Range
6.5 - 8.5
6.5 - 8.5
7.0 - 8.5
7.0 - 8.5
7.0 - 9.0
7.0 - 9.0
7.5 - 9.5
7.5 - 9.5
8.0 - 10.0
26
1268
1168
1356
1235
1455
1312
1554
1653
1863
27
1290
1201
1382
1268
1481
1345
1583
1683
1893
28
1312
1224
1407
1290
1506
1367
1613
1712
1928
29
1334
1268
1433
1345
1532
1433
1642
1742
1962
30
1356
1323
1459
1400
1558
1488
1668
1771
1996
31
1378
1345
1484
1422
1583
1510
1694
1801
2029
32
1400
1378
1510
1455
1609
1543
1720
1830
2061
33
1426
1422
1532
1510
1635
1598
1746
1863
2087
34
1451
1444
1554
1532
1661
1620
1771
1896
2118
35 - 51 36 - 51
35
Note A Note B
1477
1477
1521
1576
1554
1609
1687
1653
1709
1797
1929
2149
Load
Index
80
77
83
87
86
89
93
88
94
94
92
92
Nominal
Tire O.D.*
22.9
23.2
23.2
23.2
23.6
23.9
23.9
24.7
24.7
24.6
25.4
25.4
Rim Width
Range
6.0 - 7.5
6.5 - 7.5
6.5 - 7.5
6.5 - 7.5
7.0 - 8.0
7.0 - 8.5
7.0 - 8.5
7.5 - 9.0
7.5 - 9.0
7.5 - 9.0
8.5 - 10.0
8.5 - 10.0
26
761
794
827
816
904
981
981
1069
1226
1135
1213
1069
27
783
809
849
838
926
1003
1003
1085
1255
1168
1235
1091
28
794
823
860
860
937
1025
1025
1104
1283
1190
1257
1113
29
827
838
893
893
981
1069
1069
1124
1312
1235
1279
1157
30
860
853
937
926
1014
1113
1102
1142
1340
1290
1301
1213
31
871
867
948
937
1025
1124
1113
1160
1368
1301
1323
1224
32
893
882
970
959
1058
1157
1146
1179
1396
1334
1345
1257
33
926
891
1003
1003
1091
1201
1190
1199
1423
1378
1360
1301
34
937
899
1014
1014
1113
1213
1213
1217
1450
1400
1374
1323
35 - 51 36 - 51
Note A Note B
35
959
992
908
1036
1074
1036
1135
1168
1235
1279
1235
1235
1477
1433
1477
1389
1345
1389
Load
Index
75
79
83
78
83
82
86
85
89
Nominal
Tire O.D.*
22.4
22.4
22.4
22.4
22.4
22.8
22.8
23.1
23.1
Rim Width
Range
7.0 - 8.0
7.0 - 8.0
7.0 - 8.0
7.0 - 8.0
7.0 - 8.0
7.0 - 8.5
7.0 - 8.5
7.5 - 9.0
7.5 - 9.0
26
728
798
798
716
739
805
794
871
849
27
743
817
817
739
750
827
816
893
893
28
757
836
836
750
761
838
838
915
915
29
772
855
855
783
794
871
871
948
948
30
783
873
873
816
827
915
904
992
992
31
794
892
892
827
838
926
915
1003
1003
32
805
910
910
849
860
948
937
1025
1025
33
821
928
928
882
893
981
970
1058
1058
34
837
945
945
893
904
992
981
1080
1080
P235/75R17 (SL)
P245/75R17 (SL)
P255/75R17 (SL)
70 Series
P-Metric
Euro-Metric
P235/70R17 (SL)
P235/70R17 (XL)
P245/70R17 (SL)
P255/70R17 (SL)
35
35 - 51 36 - 51
Note A Note B
853
963
963
904
926
1014
1003
1102
1102
36
37
38
39
40
41
41 - 50
Note C
42 - 51
Note D
36
37
38
39
40
41
41 - 50
Note C
42 - 51
Note D
1069
1091
1102
1135
1157
1168
1201
1268
1290
1312
1356
1378
1389
1433
36
37
38
39
40
983
1003
1023
1040
1057
948
970
981
1014
1036
41
41 - 50
Note C
42 - 51
Note D
1074
937
1047
1074
1047
1036
1058
1069
1102
1124
1135
1168
1135
1157
1168
1213
1235
1246
1279
1135
Tire Load Limits in Pounds (lbs.) at Various Cold Inflation Pressures in Pounds Per Square Inch (psi)
Nominal
Tire O.D.*
25.3
25.3
25.7
25.7
26.1
26.1
26.5
26.9
27.6
Load
Index
Nominal
Tire O.D.*
Rim Width
Range
108
110
113
30.9
31.5
32.1
Load
Index
105
108
108
110
Nominal
Tire O.D.*
30.0
30.0
30.6
31.1
27
1944
2087
2234
28
1980
2123
2275
29
2017
2160
2315
30
2046
2197
2352
31
2076
2234
2388
32
2105
2271
2425
33
2138
2293
2462
34
2172
2315
2498
35
6.0 - 8.0
6.5 - 8.0
6.5 - 8.5
26
1907
2050
2194
Rim Width
Range
6.0 - 8.0
6.0 - 8.0
6.5 - 8.0
6.5 - 8.5
26
1786
1786
1918
2050
27
1819
1819
1951
2087
28
1852
1852
1984
2123
29
1885
1885
2017
2160
30
1914
1914
2050
2197
31
1944
1944
2083
2234
32
1973
1973
2116
2271
33
1995
1995
2146
2293
34
2017
2017
2175
2315
35
35 - 51 36 - 51
Note A Note B
2205
2337
2535
35 - 51 36 - 51
Note A Note B
2039
2039
36
37
38
39
40
41
41 - 50
Note C
42 - 51
Note D
36
37
38
39
40
41
41 - 50
Note C
42 - 51
Note D
2076
2112
2149
2205
2337
NOTE A: Some P-Metric Light Load and Standard Load tires may be branded with a maximum inflation pressure of 35, 44 or 51 psi for high speed and handling optimization. However, there is no load increase above 35 psi.
NOTE B: Some European Metric tires may be branded with a maximum inflation pressure of 32, 36, 44 or 51 psi for high speed and handling optimization. However, there is no load increase above 36 psi.
NOTE C: Some P-Metric Extra Load tires may be branded with a maximum inflation pressure of 41 or 50 psi for high speed and handling optimization. However, there is no load increase above 41 psi.
NOTE D: Some European Metric Extra Load tires may be branded with a maximum inflation pressure of 42 or 51 psi for high speed and handling optimization. However, there is no load increase above 42 psi.
* Nominal Tire O. D. is a designated or theoretical size that may vary from the actual tire O. D.
IMPORTANT: Never exceed the maximum inflation pressure molded on the sidewall of the tire.
_____________________________________________________________________________
8/7/2006
B10
2168
2186
2205
Tire Load Limits in Pounds (lbs.) at Various Cold Inflation Pressures in Pounds Per Square Inch (psi)
For Light Load and Standard Load Tires
113
115
117
31.7
31.7
32.8
Rim Width
Range
7.0 - 9.0
7.0 - 9.0
7.5 - 9.5
Load
Index
98
100
101
102
103
104
108
109
105
108
110
112
113
115
Nominal
Tire O.D.*
28.0
28.5
28.5
28.5
29.1
29.1
29.1
29.1
29.5
30.1
30.6
30.6
31.1
31.6
Rim Width
Range
6.0 - 7.5
6.0 - 8.0
6.0 - 8.0
6.0 - 8.0
6.5 - 8.5
6.5 - 8.5
6.5 - 8.5
6.5 - 8.5
7.0 - 8.5
7.0 - 9.0
7.5 - 9.5
7.5 - 9.5
7.5 - 9.5
8.0 - 10.0
26
1433
1543
1400
1444
1664
1521
1510
1554
1786
1907
2039
1896
2172
2315
27
1459
1569
1433
1477
1694
1565
1554
1598
1819
1944
2076
1951
2212
2355
28
1484
1594
1455
1499
1723
1598
1576
1620
1852
1980
2112
1984
2253
2396
29
1510
1631
1521
1565
1753
1664
1642
1687
1885
2017
2149
2061
2293
2436
30
1536
1657
1587
1631
1782
1731
1698
1753
1914
2050
2186
2149
2330
2476
31
1561
1682
1609
1653
1812
1753
1720
1775
1944
2083
2223
2183
2366
2517
32
1587
1709
1642
1687
1841
1797
1764
1819
1973
2116
2260
2227
2403
2557
33
1609
1731
1698
1753
1870
1852
1830
1885
1995
2146
2286
2315
2447
2598
34
1631
1753
1731
1786
1900
1885
1863
1918
2017
2175
2311
2348
2491
2638
35
Nominal
Tire O.D.*
27.2
27.2
27.6
28.1
28.1
29.1
29.1
29.5
29.5
Rim Width
Range
6.0 - 7.5
6.0 - 7.5
6.0 - 8.0
6.5 - 8.5
6.5 - 8.5
7.0 - 9.0
7.0 - 9.0
7.5 - 9.5
7.5 - 9.5
26
1334
1201
1444
1543
1543
1775
1598
1698
1698
27
1360
1235
1470
1572
1572
1808
1642
1742
1742
28
1385
1257
1495
1602
1602
1841
1664
1775
1775
29
1411
1312
1521
1631
1631
1874
1731
1841
1841
30
1433
1367
1543
1657
1657
1899
1808
1918
1918
31
1455
1378
1565
1683
1683
1931
1830
1951
1951
32
1477
1411
1587
1709
1709
1962
1874
1995
1995
33
1492
1466
1609
1727
1727
1979
1940
2061
2061
34
1506
1488
1631
1746
1746
2009
1973
2094
2094
35
265/60R17(SL)
Load
Index
95
96
98
100
103
105
110
108
108
275/60R17 (SL)
285/60R17(SL)
110
110
114
30.0
30.0
30.5
7.5 - 9.5
7.5 - 9.5
8.0 - 10.0
2017
1797
1995
2054
1841
2050
2090
1874
2083
2127
1951
2172
2164
2028
2260
2201
2061
2293
2238
2105
2348
2271
2183
2436
2304
2216
2469
Load
Index
93
94
95
97
101
98
99
102
102
105
Nominal
Tire O.D.*
26.3
26.3
26.8
26.8
26.8
27.2
27.2
28.0
28.0
28.5
Rim Width
Range
6.0 - 7.5
6.0 - 7.5
6.0 - 8.0
6.0 - 8.0
6.0 - 8.0
6.5 - 8.5
6.5 - 8.5
7.0 - 9.0
7.0 - 9.0
7.5 - 9.5
26
1235
1135
1334
1235
1246
1433
1312
1642
1444
1753
27
1257
1168
1360
1268
1279
1459
1345
1670
1477
1786
28
1279
1190
1385
1290
1301
1484
1367
1701
1499
1819
29
1301
1235
1411
1345
1356
1510
1433
1731
1565
1852
30
1323
1290
1433
1400
1400
1536
1488
1761
1631
1881
31
1345
1301
1455
1422
1422
1561
1510
1790
1653
1911
32
1367
1334
1477
1455
1455
1587
1543
1819
1687
1940
33
1389
1378
1492
1510
1510
1609
1598
1837
1753
1973
34
1411
1400
1506
1532
1532
1631
1620
1855
1786
2006
107
109
28.9
28.9
7.5 - 9.5
7.5 - 9.5
1874
1742
1907
1786
1940
1819
1973
1896
2006
1973
2039
2006
2072
2050
2098
2127
2123
2160
P265/70R17 (SL)
265/70R17 (SL)
P285/70R17 (SL)
65 Series
P-Metric
Euro-Metric
P215/65R17 (SL)
P225/65R17 (SL)
225/65R17 (SL)
225/65R17 (SL)
P235/65R17 (SL)
235/65R17 (SL)
235/65R17 (XL)
235/65R17 (XL)
P245/65R17 (SL)
P255/65R17 (SL)
P265/65R17 (SL)
265/65R17 (SL)
P275/65R17 (SL)
P285/65R17 (SL)
60 Series
P-Metric
Euro-Metric
P215/60R17 (SL)
215/60R17 (SL)
P225/60R17 (SL)
P235/60R17 (SL)
P235/60R17 (XL)
P255/60R17 (SL)
255/60R17 (XL)
P265/60R17 (SL)
P275/60R17 (SL)
55 Series
P-Metric
Euro-Metric
P215/55R17 (SL)
215/55R17 (SL)
P225/55R17 (SL)
225/55R17 (SL)
225/55R17 (XL)
P235/55R17 (SL)
235/55R17 (SL)
P255/55R17 (SL)
255/55R17 (SL)
P265/55R17 (SL)
P275/55R17 (SL)
275/55R17 (SL)
26
2194
2061
2480
27
2234
2116
2528
28
2275
2149
2575
29
2315
2238
2623
30
2352
2326
2664
31
2388
2359
2704
32
2425
2414
2745
33
2462
2502
2789
34
2498
2546
35 - 51 36 - 51
35
Note A Note B
2535
2590
2679
2833
35 - 51 36 - 51
Note A Note B
1653
1764
1764
1819
1819
1874
1929
1918
1984
1896
1951
2039
2205
2337
2392
2469
2535
2679
35 - 51 36 - 51
Note A Note B
1521
1510
1565
1653
1764
1764
2039
2006
2138
2205
2138
2205
36
37
38
39
40
41
41 - 50
Note C
42 - 51
Note D
36
37
38
39
40
41
41 - 50
Note C
42 - 51
Note D
1962
2017
1995
2050
2017
2083
2083
2149
2116
2183
2138
2205
36
37
38
39
40
41
1797
1830
1863
1885
1907
2072
2105
2138
2205
2238
2271
36
37
38
39
40
41
1620
1642
1664
1720
1742
1764
41 - 50
Note C
42 - 51
Note D
1929
2337
2337
2260
2513
2337
2601
35 - 51 36 - 51
Note A Note B
1433
1433
1477
1521
1554
1609
1565
1653
1653
1709
1874
1819
1874
2039
35
2149
2194
2271
NOTE A: Some P-Metric Light Load and Standard Load tires may be branded with a maximum inflation pressure of 35, 44 or 51 psi for high speed and handling optimization. However, there is no load increase above 35 psi.
NOTE B: Some European Metric tires may be branded with a maximum inflation pressure of 32, 36, 44 or 51 psi for high speed and handling optimization. However, there is no load increase above 36 psi.
NOTE C: Some P-Metric Extra Load tires may be branded with a maximum inflation pressure of 41 or 50 psi for high speed and handling optimization. However, there is no load increase above 41 psi.
NOTE D: Some European Metric Extra Load tires may be branded with a maximum inflation pressure of 42 or 51 psi for high speed and handling optimization. However, there is no load increase above 42 psi.
* Nominal Tire O. D. is a designated or theoretical size that may vary from the actual tire O. D.
IMPORTANT: Never exceed the maximum inflation pressure molded on the sidewall of the tire.
_____________________________________________________________________________
8/7/2006
2205
2271
B11
41 - 50
Note C
42 - 51
Note D
1819
Tire Load Limits in Pounds (lbs.) at Various Cold Inflation Pressures in Pounds Per Square Inch (psi)
For Light Load and Standard Load Tires
(Continued)
50 Series
P-Metric
Euro-Metric
P205/50R17 (SL)
205/50R17 (SL)
205/50R17 (SL)
205/50R17 (XL)
P215/50R17 (SL)
P215/50R17 (XL)
215/50R17 (SL)
215/50R17 (XL)
P225/50R17 (SL)
225/50R17 (SL)
P235/50R17 (SL)
235/50R17 (SL)
P245/50R17 (SL)
245/50R17 (SL)
245/50R17 (SL)
P255/50R17 (SL)
255/50R17 (SL)
45 Series
P-Metric
Euro-Metric
205/45R17 (SL)
205/45R17 (XL)
P215/45R17 (SL)
215/45R17 (SL)
215/45R17 (SL)
215/45R17 (XL)
P225/45R17 (LL)
P225/45R17 (SL)
225/45R17 (SL)
225/45R17 (SL)
225/45R17 (XL)
P235/45R17 (LL)
P235/45R17 (SL)
235/45R17 (SL)
235/45R17 (SL)
235/45R17 (XL)
P245/45R17 (LL)
P245/45R17 (SL)
245/45R17 (SL)
245/45R17 (XL)
P255/45R17 (LL)
P255/45R17 (SL)
255/45R17 (SL)
P305/45R17 (LL)
P305/45R17 (SL)
P315/45R17 (LL)
40 Series
P-Metric
Euro-Metric
P205/40R17 (LL)
P205/40R17 (SL)
205/40R17 (SL)
205/40R17 (XL)
Load
Index
88
89
91
93
90
93
91
95
93
94
95
96
98
98
99
100
101
Nominal
Tire O.D.*
25.1
25.1
25.1
25.1
25.5
25.5
25.5
25.5
25.9
25.9
26.3
26.3
26.7
26.7
26.7
27.1
27.1
Rim Width
Range
5.5 - 7.5
5.5 - 7.5
5.5 - 7.5
5.5 - 7.5
6.0 - 7.5
6.0 - 7.5
6.0 - 7.5
6.0 - 7.5
6.0 - 8.0
6.0 - 8.0
6.5 - 8.5
6.5 - 8.5
7.0 - 8.5
7.0 - 8.5
7.0 - 8.5
7.0 - 9.0
7.0 - 9.0
26
1058
981
1047
981
1146
1146
1047
1036
1235
1135
1323
1201
1422
1268
1312
1521
1400
27
1076
1003
1069
1003
1170
1170
1069
1058
1257
1168
1349
1235
1446
1301
1345
1547
1433
28
1095
1025
1091
1025
1192
1192
1091
1080
1279
1190
1374
1257
1473
1323
1367
1572
1455
29
1113
1069
1135
1069
1213
1213
1135
1135
1301
1235
1400
1312
1499
1378
1433
1598
1521
30
1131
1113
1179
1102
1228
1228
1179
1179
1323
1290
1422
1367
1526
1433
1488
1628
1587
31
1150
1124
1190
1113
1248
1248
1190
1190
1345
1301
1444
1378
1551
1455
1510
1657
1609
32
1168
1157
1224
1146
1268
1268
1224
1224
1367
1334
1466
1411
1576
1488
1543
1687
1642
33
1190
1201
1268
1190
1285
1285
1268
1268
1389
1378
1484
1466
1605
1543
1598
1713
1698
34
1213
1213
1290
1213
1304
1304
1290
1290
1411
1400
1503
1488
1629
1565
1620
1738
1731
35 - 51 36 - 51
35
Note A Note B
1235
1235
1279
1312
1356
1235
1323
1323
1312
1356
1312
1433
1433
1477
1521
1510
1565
1653
1598
1653
1653
1709
1764
1764
1819
Load
Index
84
88
87
87
88
91
84
90
90
91
94
87
93
93
94
97
89
95
95
99
92
98
98
102
109
104
Nominal
Tire O.D.*
24.3
24.3
24.7
24.6
24.6
24.6
25.0
25.0
25.0
25.0
25.0
25.4
25.4
25.4
25.4
25.4
25.7
25.7
25.7
25.7
26.1
26.1
26.1
27.8
27.8
28.2
Rim Width
Range
6.5 - 7.5
6.5 - 7.5
7.0 - 8.0
7.0 - 8.0
7.0 - 8.0
7.0 - 8.0
7.0 - 8.5
7.0 - 8.5
7.0 - 8.5
7.0 - 8.5
7.0 - 8.5
7.5 - 9.0
7.5 - 9.0
7.5 - 9.0
7.5 - 9.0
7.5 - 9.0
7.5 - 9.0
7.5 - 9.0
7.5 - 9.0
7.5 - 9.0
8.0 - 9.5
8.0 - 9.5
8.0 - 9.5
9.0 - 11.0
9.0 - 11.0
10.0 - 12.0
26
849
838
996
926
948
926
970
1098
1014
1047
1003
1036
1188
1102
1135
1102
1113
1261
1168
1168
1190
1371
1268
1609
1883
1698
27
871
860
1022
948
970
948
988
1124
1036
1069
1036
1053
1216
1124
1168
1124
1135
1291
1201
1201
1212
1403
1301
1638
1928
1731
28
882
882
1047
970
992
970
1006
1149
1058
1091
1058
1072
1244
1146
1190
1146
1157
1321
1224
1224
1235
1436
1323
1668
1972
1764
29
926
915
1067
1003
1036
1003
1025
1175
1102
1135
1102
1091
1272
1201
1235
1190
1179
1351
1268
1268
1257
1468
1378
1698
2017
1797
30
959
959
1089
1047
1069
1047
1039
1200
1146
1179
1146
1110
1299
1246
1290
1246
1198
1380
1323
1323
1275
1500
1433
1719
2060
1826
31
970
970
1111
1058
1080
1058
1054
1225
1157
1190
1157
1128
1327
1257
1301
1257
1216
1408
1345
1334
1294
1531
1455
1747
2102
1856
32
992
992
1135
1080
1113
1091
1069
1250
1190
1224
1179
1146
1354
1290
1334
1290
1235
1437
1378
1367
1312
1563
1488
1775
2145
1885
33
1036
1025
1172
1124
1157
1124
1080
1274
1235
1268
1224
1166
1380
1345
1378
1334
1250
1465
1422
1422
1338
1593
1543
1820
2187
1918
34
1047
1036
1208
1135
1168
1146
1091
1299
1257
1290
1246
1184
1407
1367
1400
1356
1264
1493
1444
1444
1363
1623
1565
1847
2229
1951
35 - 51 36 - 51
35
Note A Note B
1069
1102
1058
1201
1157
1201
1190
1235
1168
1102
1323
1279
1323
1312
1356
1268
1201
1433
1389
1433
1433
1477
1378
1279
1521
1477
1521
1466
1389
1653
1598
1653
1874
2271
1984
Load
Index
76
80
80
84
Nominal
Tire O.D.*
23.5
23.5
23.5
23.5
Rim Width
Range
7.0 - 8.0
7.0 - 8.0
7.0 - 8.0
7.0 - 8.0
26
761
822
761
750
27
776
842
783
772
28
790
862
794
783
29
805
882
827
816
30
820
900
860
849
31
834
919
871
860
32
849
937
893
882
33
860
955
926
915
34
871
974
937
926
35 - 51 36 - 51
Note A Note B
882
992
959
992
948
35
36
37
38
40
1268
1290
1312
1356
1378
1341
1360
1378
1396
1415
1356
1378
1389
1433
1455
36
37
38
39
40
41
41 - 50
Note C
1389
42 - 51
Note D
1433
1433
1477
41
1521
41 - 50
Note C
42 - 51
Note D
1091
1113
1135
1168
1190
1201
1235
1201
1224
1246
1279
1301
1323
1356
1312
1334
1356
1400
1422
1433
1477
1433
1455
1477
1521
1543
1565
1609
1521
1543
1565
1609
1642
1664
1709
36
981
37
1003
38
1014
NOTE A: Some P-Metric Light Load and Standard Load tires may be branded with a maximum inflation pressure of 35, 44 or 51 psi for high speed and handling optimization. However, there is no load increase above 35 psi.
NOTE B: Some European Metric tires may be branded with a maximum inflation pressure of 32, 36, 44 or 51 psi for high speed and handling optimization. However, there is no load increase above 36 psi.
NOTE C: Some P-Metric Extra Load tires may be branded with a maximum inflation pressure of 41 or 50 psi for high speed and handling optimization. However, there is no load increase above 41 psi.
NOTE D: Some European Metric Extra Load tires may be branded with a maximum inflation pressure of 42 or 51 psi for high speed and handling optimization. However, there is no load increase above 42 psi.
* Nominal Tire O. D. is a designated or theoretical size that may vary from the actual tire O. D.
IMPORTANT: Never exceed the maximum inflation pressure molded on the sidewall of the tire.
_____________________________________________________________________________
8/7/2006
39
B12
39
1036
40
1058
41
1069
41 - 50
Note C
42 - 51
Note D
1102
Tire Load Limits in Pounds (lbs.) at Various Cold Inflation Pressures in Pounds Per Square Inch (psi)
(Continued)
40 Series (continued)
Load
Nominal Rim Width
Range
P-Metric
Euro-Metric Index Tire O.D.*
P215/40R17 (LL)
215/40R17 (SL)
215/40R17 (XL)
P235/40R17 (LL)
235/40R17 (SL)
235/40R17 (XL)
P245/40R17 (LL)
245/40R17 (SL)
245/40R17 (XL)
P255/40R17 (LL)
P255/40R17 (SL)
255/40R17 (SL)
255/40R17 (SL)
255/40R17 (XL)
P265/40R17 (LL)
265/40R17 (SL)
P275/40R17 (LL)
P275/40R17 (SL)
275/40R17 (SL)
P285/40R17 (LL)
P285/40R17 (SL)
285/40R17 (SL)
285/40R17 (SL)
295/40R17 (SL)
35 Series
P-Metric
Euro-Metric
245/35R17
P285/35R17 (LL)
P315/35R17 (LL)
P315/35R17 (SL)
315/35R17 (SL)
P335/35R17 (LL)
335/35R17 (LL)
335/35R17 (SL)
28
856
860
860
988
1058
1058
1062
1091
1080
1128
1283
1146
1190
1179
1205
1257
1279
1436
1323
1363
1533
29
871
893
893
1003
1102
1102
1080
1135
1135
1146
1312
1201
1235
1224
1224
1312
1301
1468
1378
1389
1567
30
886
937
926
1021
1146
1146
1098
1179
1179
1168
1340
1246
1290
1279
1246
1367
1323
1500
1433
1411
1600
31
900
948
937
1040
1157
1157
1117
1190
1190
1191
1368
1257
1301
1290
1268
1378
1345
1531
1455
1433
1634
32
915
970
959
1058
1190
1179
1135
1224
1224
1213
1396
1290
1334
1323
1290
1411
1367
1563
1488
1455
1667
33
931
1003
1003
1073
1235
1224
1146
1268
1268
1235
1423
1345
1378
1378
1312
1466
1389
1593
1543
1477
1699
34
947
1014
1014
1087
1257
1246
1157
1290
1290
1257
1450
1367
1400
1400
1334
1488
1411
1623
1565
1499
1732
79
83
87
84
90
94
86
91
95
89
94
93
94
98
91
96
93
98
98
95
100
23.8
23.8
23.8
24.4
24.4
24.4
24.7
24.7
24.7
25.0
25.0
25.0
25.0
25.0
25.4
25.4
25.7
25.7
25.7
26.0
26.0
7.0 - 8.5
7.0 - 8.5
7.0 - 8.5
8.0 - 9.5
8.0 - 9.5
8.0 - 9.5
8.0 - 9.5
8.0 - 9.5
8.0 - 9.5
8.5 - 10.0
8.5 - 10.0
8.5 - 10.0
8.5 - 10.0
8.5 - 10.0
9.0 - 10.0
9.0 - 10.5
9.0 - 11.0
9.0 - 11.0
9.0 - 11.0
9.5 - 11.0
9.5 - 11.0
26
827
827
816
959
1014
1003
1025
1047
1036
1091
1226
1102
1135
1124
1168
1201
1235
1371
1268
1312
1464
100
101
102
26.0
26.0
26.3
9.5 - 11.0
9.5 - 11.0
10.0 - 11.5
1356
1400
1444
1389
1433
1477
1411
1455
1499
1477
1521
1565
1532
1587
1631
1554
1609
1653
1587
1642
1687
1653
1698
1753
1675
1731
1786
Load
Index
87
88
93
102
102
97
97
106
Nominal
Tire O.D.*
23.8
24.9
25.7
25.7
25.7
26.2
26.2
26.2
Rim Width
Range
8.0 - 9.5
9.5 - 11.0
11.0 - 12.0
11.0 - 12.0
10.5 - 12.5
11.0 - 13.0
11.0 - 13.0
11.0 - 13.0
26
926
1058
1246
1554
1444
1389
1235
1609
27
948
1076
1272
1591
1477
1415
1268
1653
28
970
1095
1297
1627
1499
1440
1290
1687
29
1003
1113
1323
1664
1565
1466
1345
1753
30
1047
1131
1341
1699
1631
1488
1400
1819
31
1058
1150
1360
1735
1653
1510
1422
1852
32
1080
1168
1378
1770
1687
1532
1455
1896
33
1124
1190
1396
1805
1753
1558
1510
1962
34
1135
1213
1415
1839
1786
1583
1532
1995
P255/70R18 (SL)
P265/70R18 (SL)
65 Series
P-Metric
Euro-Metric
P235/65R18 (SL)
P265/65R18 (SL)
P275/65R18 (SL)
1709
1764
1819
41 - 50
Note C
42 - 51
Note D
36
37
38
39
40
41
1069
1091
1102
1135
1157
1168
1201
1312
1334
1356
1400
1422
1433
1477
1356
1378
1389
1433
1455
1477
1521
1466
1488
1510
1565
1587
1609
1653
1764
1819
1874
35 - 51 36 - 51
35
Note A Note B
1157
1201
1235
1433
1874
1819
1874
1609
1554
1609
2028
2094
36
37
38
39
40
41
41 - 50
Note C
42 - 51
Note D
Tire Load Limits in Pounds (lbs.) at Various Cold Inflation Pressures in Pounds Per Square Inch (psi)
Load
Index
Nominal
Tire O.D.*
Rim Width
Range
112
114
32.1
32.6
Load
Index
104
112
114
Nominal
Tire O.D.*
30.0
31.5
32.1
27
2168
2315
28
2208
2359
29
2249
2403
30
2286
2440
31
2322
2476
32
2359
2513
33
2396
2542
34
2432
2572
35
6.5 - 8.5
7.0 - 9.0
26
2127
2271
Rim Width
Range
6.5 - 8.5
7.5 - 9.5
7.5 - 9.5
26
1731
2116
2260
27
1764
2157
2300
28
1797
2197
2341
29
1830
2238
2381
30
1859
2275
2421
31
1889
2311
2462
32
1918
2348
2502
33
1940
2388
2535
34
1962
2429
2568
35
35 - 51 36 - 51
Note A Note B
2469
2601
35 - 51 36 - 51
Note A Note B
1984
2469
2601
36
37
38
39
40
41
41 - 50
Note C
42 - 51
Note D
36
37
38
39
40
41
41 - 50
Note C
42 - 51
Note D
NOTE A: Some P-Metric Light Load and Standard Load tires may be branded with a maximum inflation pressure of 35, 44 or 51 psi for high speed and handling optimization. However, there is no load increase above 35 psi.
NOTE B: Some European Metric tires may be branded with a maximum inflation pressure of 32, 36, 44 or 51 psi for high speed and handling optimization. However, there is no load increase above 36 psi.
NOTE C: Some P-Metric Extra Load tires may be branded with a maximum inflation pressure of 41 or 50 psi for high speed and handling optimization. However, there is no load increase above 41 psi.
NOTE D: Some European Metric Extra Load tires may be branded with a maximum inflation pressure of 42 or 51 psi for high speed and handling optimization. However, there is no load increase above 42 psi.
* Nominal Tire O. D. is a designated or theoretical size that may vary from the actual tire O. D.
IMPORTANT: Never exceed the maximum inflation pressure molded on the sidewall of the tire.
_____________________________________________________________________________
8/7/2006
B13
Tire Load Limits in Pounds (lbs.) at Various Cold Inflation Pressures in Pounds Per Square Inch (psi)
For Light Load and Standard Load Tires
(Continued)
60 Series
P-Metric
Euro-Metric
285/60R18 (SL)
285/60R18 (XL)
305/60R18 (SL)
Load
Index
99
102
103
104
112
109
110
111
114
116
120
120
Nominal
Tire O.D.*
28.6
29.1
29.1
29.6
30.0
30.5
30.5
31.0
31.5
31.5
31.5
32.4
Rim Width
Range
6.0 - 8.0
6.5 - 8.5
6.5 - 8.5
7.0 - 8.5
7.0 - 9.0
7.0 - 9.5
7.5 - 9.5
7.5 - 9.5
8.0 - 10.0
8.0 - 10.0
8.0 - 10.0
8.5 - 11.5
26
1499
1609
1488
1731
1687
1973
1797
2094
2227
2116
2105
2370
27
1525
1639
1532
1760
1731
2010
1841
2135
2267
2183
2172
2436
28
1550
1668
1554
1790
1764
2046
1874
2175
2308
2216
2205
2480
29
1576
1698
1609
1819
1830
2083
1951
2216
2348
2304
2293
2579
30
1602
1727
1675
1848
1907
2116
2028
2253
2388
2392
2381
2690
31
1627
1757
1698
1878
1940
2150
2061
2289
2429
2425
2414
2723
32
1653
1786
1742
1907
1984
2183
2105
2326
2469
2491
2469
2789
33
1672
1815
1808
1933
2050
2212
2183
2352
2513
2579
2568
2888
34
1690
1845
1830
1958
2083
2242
2216
2377
2557
2623
2612
2932
35 - 51 36 - 51
35
Note A Note B
1709
1874
1863
1929
1984
2127
2271
2260
2337
2403
2601
2668
2756
2657
2987
3086
55 Series
P-Metric
Euro-Metric
Load
Index
Nominal
Tire O.D.*
Rim Width
Range
26
27
28
29
30
31
32
33
34
35
97
99
100
104
105
109
106
109
114
111
27.8
28.2
28.1
29.0
29.0
29.0
29.5
29.9
29.9
30.4
6.0 - 8.0
6.5 - 8.5
6.5 - 8.5
7.0 - 9.0
7.0 - 9.0
7.0 - 9.0
7.5 - 9.5
7.5 - 9.5
7.5 - 9.5
8.0 - 10.0
Load
Index
Nominal
Tire O.D.*
Rim Width
Range
94
97
96
97
101
99
100
102
106
101
109
26.9
27.3
27.3
27.3
27.3
27.7
27.7
28.1
28.1
28.1
29.3
6.0 - 8.0
6.5 - 8.5
6.5 - 8.5
6.5 - 8.5
6.5 - 8.5
7.0 - 8.5
7.0 - 8.5
7.0 - 9.0
7.0 - 9.0
7.0 - 9.0
8.0 - 10.0
Load
Index
89
93
91
91
95
88
94
94
96
96
100
Nominal
Tire O.D.*
25.6
25.6
25.9
25.9
25.9
26.3
26.3
26.3
26.7
26.7
26.7
Rim Width
Range
7.0 - 8.0
7.0 - 8.0
7.0 - 8.5
7.0 - 8.5
7.0 - 8.5
7.5 - 9.0
7.5 - 9.0
7.5 - 9.0
7.5 - 9.0
7.5 - 9.0
7.5 - 9.0
P225/60R18 (SL)
P235/60R18 (SL)
235/60R18 (SL)
P245/60R18 (SL)
255/60R18 (XL)
P265/60R18 (SL)
265/60R18 (SL)
P275/60R18 (SL)
P285/60R18 (SL)
P225/55R18 (SL)
P235/55R18 (SL)
235/55R18 (SL)
P255/55R18 (SL)
255/55R18 (SL)
255/55R18 (XL)
P265/55R18 (SL)
P275/55R18 (SL)
275/55R18 (XL)
P285/55R18 (SL)
50 Series
P-Metric
Euro-Metric
P225/50R18 (SL)
P235/50R18 (SL)
235/50R18 (SL)
235/50R18 (SL)
235/50R18 (XL)
P245/50R18 (SL)
245/50R18 (SL)
255/50R18 (SL)
255/50R18 (XL)
P255/50R18 (SL)
285/50R18 (SL)
45 Series
P-Metric
Euro-Metric
215/45R18 (SL)
215/45R18 (XL)
P225/45R18 (SL)
225/45R18 (SL)
225/45R18 (XL)
P235/45R18 (LL)
P235/45R18 (SL)
235/45R18 (SL)
P245/45R18 (SL)
245/45R18 (SL)
245/45R18 (XL)
1389
1499
1356
1709
1565
1554
1830
1951
1775
2072
26
1290
1389
1201
1235
1246
1488
1356
1444
1433
1587
1742
26
981
981
1124
1047
1036
1080
1226
1135
1299
1201
1201
1415
1525
1389
1742
1609
1598
1863
1984
1819
2109
27
1312
1411
1235
1268
1279
1514
1389
1477
1466
1616
1786
27
1003
1003
1151
1069
1058
1102
1255
1168
1330
1235
1235
1440
1550
1411
1775
1642
1620
1896
2017
1852
2146
28
1334
1433
1257
1290
1301
1539
1411
1499
1488
1646
1819
28
1025
1025
1177
1091
1080
1124
1283
1190
1360
1257
1257
1466
1576
1477
1808
1709
1687
1929
2050
1929
2183
29
1356
1455
1312
1345
1356
1565
1477
1565
1554
1675
1896
29
1069
1069
1204
1135
1135
1146
1312
1235
1391
1312
1312
1492
1602
1532
1837
1775
1753
1958
2083
2006
2216
30
1378
1481
1367
1400
1400
1591
1532
1631
1620
1701
1973
30
1113
1102
1230
1179
1179
1164
1340
1290
1420
1367
1367
1517
1627
1554
1867
1797
1775
1988
2116
2039
2249
31
1400
1506
1378
1422
1422
1616
1554
1653
1642
1727
2006
31
1124
1113
1255
1190
1190
1183
1368
1301
1450
1378
1378
1543
1653
1587
1896
1841
1819
2017
2149
2083
2282
32
1422
1532
1411
1455
1455
1642
1587
1687
1675
1753
2050
32
1157
1146
1281
1224
1224
1201
1396
1334
1479
1411
1411
1565
1672
1653
1925
1907
1885
2043
2190
2160
2322
33
1440
1558
1466
1510
1510
1664
1653
1753
1742
1775
2127
33
1201
1190
1306
1268
1268
1212
1423
1378
1508
1466
1466
1587
1690
1675
1955
1940
1918
2068
2230
2194
2363
34
1459
1583
1488
1532
1532
1687
1675
1786
1764
1797
2160
34
1213
1213
1331
1290
1290
1224
1450
1400
1536
1488
1488
35 - 51
Note A
36 - 51
Note B
36
37
38
40
41
41 - 50
Note C
42 - 51
Note D
2194
2227
2260
2337
2370
2403
2469
2745
2789
2833
2910
2965
2998
3086
36
37
38
39
40
41
41 - 50
Note C
42 - 51
Note D
1609
1709
1709
1764
1984
1973
1951
2039
2017
2050
2083
2149
2183
2205
2271
2315
2348
2381
2458
2491
2524
2601
2094
2271
2238
2403
35
35 - 51
Note A
36 - 51
Note B
36
37
38
39
40
41
41 - 50
Note C
42 - 51
Note D
1477
1609
1510
1554
1565
1565
1609
1620
1642
1664
1720
1742
1764
1819
1863
1896
1918
1973
2006
2039
2094
1709
1709
1819
1797
1764
1874
1819
2194
35
1235
1235
2271
35 - 51
Note A
36 - 51
Note B
1279
36
37
38
39
40
41
41 - 50
Note C
42 - 51
Note D
1268
1290
1312
1356
1378
1389
1433
1356
1378
1389
1433
1455
1477
1521
1565
1598
1620
1664
1698
1720
1764
1356
1312
1312
1356
1235
1477
1433
1477
1565
1510
1521
1565
NOTE A: Some P-Metric Light Load and Standard Load tires may be branded with a maximum inflation pressure of 35, 44 or 51 psi for high speed and handling optimization. However, there is no load increase above 35 psi.
NOTE B: Some European Metric tires may be branded with a maximum inflation pressure of 32, 36, 44 or 51 psi for high speed and handling optimization. However, there is no load increase above 36 psi.
NOTE C: Some P-Metric Extra Load tires may be branded with a maximum inflation pressure of 41 or 50 psi for high speed and handling optimization. However, there is no load increase above 41 psi.
NOTE D: Some European Metric Extra Load tires may be branded with a maximum inflation pressure of 42 or 51 psi for high speed and handling optimization. However, there is no load increase above 42 psi.
* Nominal Tire O. D. is a designated or theoretical size that may vary from the actual tire O. D.
IMPORTANT: Never exceed the maximum inflation pressure molded on the sidewall of the tire.
_____________________________________________________________________________
8/7/2006
39
B14
40 Series
P-Metric
Euro-Metric
P215/40R18 (LL)
P225/40R18 (LL)
P225/40R18 (SL)
P235/40R18 (LL)
225/40R18 (SL)
225/40R18 (XL)
P245/40R18 (LL)
P245/40R18 (SL)
P255/40R18 (LL)
235/40R18 (SL)
235/40R18 (XL)
245/40R18 (SL)
245/40R18 (XL)
255/40R18 (SL)
255/40R18 (XL)
P265/40R18 (LL)
265/40R18 (SL)
265/40R18(XL)
P275/40R18 (LL)
275/40R18 (SL)
P285/40R18 (LL)
285/40R18 (SL)
P315/40R18 (LL)
35 Series
P-Metric
Euro-Metric
P215/35R18 (LL)
215/35R18 (SL)
215/35R18 (XL)
225/35R18 (SL)
225/35R18 (XL)
P245/35R18 (LL)
245/35R18 (SL)
P255/35R18 (LL)
255/35R18 (SL)
255/35R18 (XL)
P265/35R18 (LL)
265/35R18 (SL)
265/35R18 (XL)
P275/35R18 (LL)
275/35R18 (SL)
Tire Load Limits in Pounds (lbs.) at Various Cold Inflation Pressures in Pounds Per Square Inch (psi)
For Light Load and Standard Load Tires
Nominal
Tire O.D.*
27.0
27.0
27.1
27.1
28.5
28.5
28.1
28.5
Rim Width
Range
8.0 - 9.5
8.0 - 9.5
8.0 - 9.5
8.0 - 9.5
9.5 - 11.0
9.5 - 11.0
9.0 - 10.5
9.5 - 11.0
26
1312
1312
1246
1418
1587
1828
1488
1698
27
1345
1356
1268
1451
1613
1871
1532
1742
28
1367
1378
1290
1484
1638
1915
1554
1775
29
1433
1433
1312
1517
1664
1958
1609
1841
30
1488
1488
1330
1549
1694
2000
1675
1918
31
1510
1510
1349
1582
1723
2041
1698
1951
32
1543
1543
1367
1614
1753
2083
1742
1995
33
1598
1598
1389
1646
1775
2124
1808
2061
34
1620
1620
1411
1677
1797
2164
1830
2094
35
1653
1653
Rim Width
Range
7.0 - 8.5
7.5 - 9.0
7.5 - 9.0
8.0 - 9.5
7.5 - 9.0
7.5 - 9.0
8.0 - 9.5
8.0 - 9.5
8.5 - 10.0
8.0 - 9.5
8.0 - 9.5
8.0 - 9.5
8.0 - 9.5
8.5 - 10.0
8.5 - 10.0
9.0 - 10.0
9.0 - 10.5
9.0 - 10.5
9.0 - 11.0
9.0 - 11.0
9.5 - 11.0
9.5 - 11.0
11.0 - 12.0
26
860
926
1023
992
948
948
1069
1023
1135
1047
1036
1102
1102
1168
1168
1213
1235
1246
1290
1312
1367
1400
1620
27
875
944
1047
1010
970
970
1085
1038
1159
1069
1058
1124
1124
1201
1201
1235
1268
1279
1308
1345
1393
1433
1650
28
889
963
1072
1029
992
992
1104
1054
1180
1091
1080
1146
1146
1224
1224
1257
1290
1301
1332
1367
1418
1455
1679
29
904
981
1096
1047
1036
1036
1124
1069
1201
1135
1135
1201
1190
1268
1268
1279
1345
1356
1356
1433
1444
1521
1709
30
922
996
1119
1065
1069
1069
1142
1101
1217
1179
1179
1246
1246
1323
1323
1301
1400
1400
1377
1488
1466
1587
1735
31
941
1010
1143
1084
1080
1080
1160
1134
1237
1190
1190
1257
1257
1345
1334
1323
1422
1422
1400
1510
1488
1609
1760
32
959
1025
1166
1102
1113
1113
1179
1166
1257
1224
1224
1290
1290
1378
1367
1345
1455
1455
1422
1543
1510
1642
1786
33
970
1041
1189
1113
1157
1157
1199
1189
1285
1268
1268
1345
1334
1422
1422
1360
1510
1510
1434
1598
1528
1698
1815
34
981
1058
1212
1124
1168
1168
1217
1212
1304
1290
1290
1367
1356
1444
1444
1374
1532
1532
1456
1620
1547
1731
1845
35
80
83
88
85
88
92
88
93
90
91
95
93
97
95
99
92
97
101
94
99
96
101
102
Nominal
Tire O.D.*
24.8
25.1
25.1
25.4
25.1
25.1
25.7
25.7
26.0
25.4
25.4
25.7
25.7
26.0
26.0
26.3
26.3
26.3
26.7
26.7
27.0
27.0
27.9
Load
Index
73
80
84
83
87
80
88
82
90
94
85
93
97
87
95
Nominal
Tire O.D.*
23.9
23.9
23.9
24.2
24.2
24.8
24.8
25.0
25.0
25.0
25.3
25.3
25.3
25.6
25.6
Rim Width
Range
7.0 - 8.5
7.0 - 8.5
7.0 - 8.5
7.5 - 9.0
7.5 - 9.0
8.0 - 9.5
8.0 - 9.5
8.5 - 10.0
8.5 - 10.0
8.5 - 10.0
9.0 - 10.0
9.0 - 10.5
9.0 - 10.5
9.0 - 11.0
9.0 - 11.0
26
694
761
750
827
816
860
948
915
1014
1003
981
1102
1102
1036
1168
27
709
783
772
849
838
875
970
933
1036
1036
996
1124
1124
1054
1201
28
724
794
783
860
860
889
992
952
1058
1058
1010
1146
1146
1073
1224
29
739
827
816
893
893
904
1036
970
1102
1102
1025
1201
1190
1091
1268
30
750
860
849
937
926
919
1069
985
1146
1146
1043
1246
1246
1109
1323
31
761
871
860
948
937
933
1080
999
1157
1157
1062
1257
1257
1128
1345
32
772
893
882
970
959
948
1113
1014
1190
1179
1080
1290
1290
1146
1378
33
783
926
915
1003
1003
963
1157
1025
1235
1224
1098
1345
1334
1164
1422
34
794
937
926
1014
1014
977
1168
1036
1257
1246
1117
1367
1356
1183
1444
35
99
103
93
99
101
108
103
108
Load
Index
35 - 51
Note A
36 - 51
Note B
1709
36
1709
37
1742
38
1764
1819
40
1852
41
41 - 50
Note C
1874
42 - 51
Note D
1929
1433
1709
1819
2205
1863
2138
1929
2205
35 - 51 36 - 51
Note A Note B
992
1074
1235
1135
1190
1235
1190
1235
1235
1323
1312
1356
1312
1389
1433
1378
1477
1521
1466
1389
1554
1609
1565
1477
1653
1709
1565
1764
1819
1874
35 - 51 36 - 51
Note A Note B
805
959
992
948
1036
1074
1036
992
1190
1235
1047
1279
1323
1268
1135
1389
1433
1378
1201
1477
1521
36
37
38
39
40
41
41 - 50
Note C
42 - 51
Note D
1235
1257
1268
1312
1334
1356
1389
1356
1378
1389
1433
1455
1477
1521
1433
1455
1477
1521
1543
1565
1609
1521
1543
1565
1609
1642
1664
1709
1620
1642
1664
1720
1742
1764
1819
36
37
38
39
40
41
41 - 50
Note C
42 - 51
Note D
981
1003
1014
1036
1058
1069
1102
1069
1091
1102
1135
1157
1168
1201
1312
1334
1356
1400
1422
1433
1477
1433
1455
1477
1521
1543
1565
1609
NOTE A: Some P-Metric Light Load and Standard Load tires may be branded with a maximum inflation pressure of 35, 44 or 51 psi for high speed and handling optimization. However, there is no load increase above 35 psi.
NOTE B: Some European Metric tires may be branded with a maximum inflation pressure of 32, 36, 44 or 51 psi for high speed and handling optimization. However, there is no load increase above 36 psi.
NOTE C: Some P-Metric Extra Load tires may be branded with a maximum inflation pressure of 41 or 50 psi for high speed and handling optimization. However, there is no load increase above 41 psi.
NOTE D: Some European Metric Extra Load tires may be branded with a maximum inflation pressure of 42 or 51 psi for high speed and handling optimization. However, there is no load increase above 42 psi.
* Nominal Tire O. D. is a designated or theoretical size that may vary from the actual tire O. D.
IMPORTANT: Never exceed the maximum inflation pressure molded on the sidewall of the tire.
_____________________________________________________________________________
8/7/2006
39
B15
Tire Load Limits in Pounds (lbs.) at Various Cold Inflation Pressures in Pounds Per Square Inch (psi)
For Light Load and Standard Load Tires
285/35R18 (SL)
89
97
91
Nominal
Tire O.D.*
25.9
25.9
26.1
295/35R18 (SL)
315/35R18 (SL)
99
101
26.1
26.7
10.0 - 11.5
10.5 - 12.5
1312
1400
1345
1433
1367
1455
1433
1521
1488
1587
1510
1609
1543
1642
1598
1698
1620
1731
Load
Index
93
94
91
98
100
102
95
97
Nominal
Tire O.D.*
24.8
25.0
25.5
25.3
25.7
25.9
25.9
26.2
Rim Width
Range
9.5 - 10.5
10.0 - 11.0
11.0 - 12.0
10.5 - 11.5
11.0 - 12.0
11.5 - 12.5
12.0 - 13.0
12.0 - 14.0
26
1102
1135
1179
1268
1356
1444
1312
1378
27
1124
1168
1201
1301
1389
1477
1334
1404
28
1146
1190
1224
1323
1411
1499
1356
1429
29
1201
1235
1246
1378
1477
1565
1378
1455
30
1246
1290
1268
1433
1532
1631
1400
1477
31
1257
1301
1290
1455
1554
1653
1422
1499
32
1290
1334
1312
1488
1587
1687
1444
1521
33
1345
1378
1327
1543
1653
1753
1470
1550
34
1367
1400
1341
1565
1675
1786
1495
1580
P285/35R18 (LL)
P295/35R18 (LL)
30 Series
P-Metric
Euro-Metric
285/30R18 (SL)
295/30R18 (SL)
P315/30R18 (LL)
305/30R18 (SL)
325/30R18 (SL)
335/30R18 (SL)
P335/30R18 (LL)
P345/30R18 (LL)
Rim Width
Range
9.5 - 11.0
9.5 - 11.0
10.0 - 12.0
26
1102
1235
1168
27
1116
1268
1190
28
1137
1290
1213
29
1157
1345
1235
30
1185
1400
1253
31
1205
1422
1272
32
1224
1455
1290
33
1242
1510
1312
34
1261
1532
1334
Nominal
Tire O.D.*
Rim Width
Range
255/50R19 (SL)
101
Load
Index
103
29.2
Nominal
Tire O.D.*
29.1
45 Series
P-Metric
Euro-Metric
Load
Index
98
94
Nominal
Tire O.D.*
27.7
28.1
100
108
107
40 Series
P-Metric
Euro-Metric
225/40R19 (SL)
235/40R19(SL)
245/40R19 (SL)
245/40R19 (XL)
50 Series
P-Metric
Euro-Metric
245/45R19 (SL)
P255/45R19 (LL)
P255/45R19 (SL)
275/45R19 (XL)
285/45R19 (SL)
P255/40R19 (LL)
255/40R19 (SL)
255/40R19 (XL)
255/40R19 (XL)
P315/40R19 (LL)
P315/40R19 (SL)
35 Series
P-Metric
Euro-Metric
P215/35R19 (LL)
215/35R19(XL)
37
38
39
40
41
41 - 50
Note C
42 - 51
Note D
36
37
38
39
40
41
41 - 50
Note C
42 - 51
Note D
1709
1819
35 - 51 36 - 51
35
Note A Note B
1389
1433
1433
1477
1356
1598
1653
1709
1764
1819
1874
1521
1609
Load
Index
P235/55R19 (SL)
1653
1764
36
Tire Load Limits in Pounds (lbs.) at Various Cold Inflation Pressures in Pounds Per Square Inch (psi)
6.5 - 8.5
Rim Width
Range
7.0 - 9.0
26
1554
27
1583
28
1613
29
1642
30
1668
31
1694
32
1720
33
1753
34
1786
26
1488
27
1532
28
1554
29
1609
30
1675
31
1698
32
1742
33
1808
34
1830
35 - 51
35
Note A
1863
Rim Width
Range
7.5 - 9.0
8.0 - 9.5
26
1268
1290
27
1301
1316
28
1323
1341
29
1378
1367
30
1433
1389
31
1455
1411
32
1488
1433
33
1543
1448
34
1565
1462
35 - 51 36 - 51
Note A Note B
35
1598
1653
1477
28.1
8.0 - 9.5
1464
1498
1533
1567
1600
1634
1667
1699
1732
28.7
29.1
8.5 - 10.5
9.0 - 10.0
1510
1653
1554
1698
1576
1731
1642
1797
1698
1874
1720
1896
1764
1940
1830
2006
1863
2039
Load
Index
Nominal
Tire O.D.*
Rim Width
Range
89
92
94
98
91
96
100
103
103
109
Load
Index
26.1
26.4
26.7
26.7
27.1
27.0
27.0
27.0
28.9
28.9
Nominal
Tire O.D.*
7.5 - 9.0
8.0 - 9.5
8.0 - 9.5
8.0 - 9.5
8.5 - 10.0
8.5 - 10.0
8.5 - 10.0
8.5 - 10.0
11.0 - 12.0
11.0 - 12.0
Rim Width
Range
26
981
1069
1135
1124
1190
1201
1201
1312
1687
1883
27
1003
1091
1168
1157
1213
1235
1235
1356
1716
1928
28
1025
1113
1190
1179
1235
1257
1257
1378
1746
1972
29
1069
1157
1235
1224
1257
1312
1312
1433
1775
2017
30
1113
1213
1290
1279
1270
1367
1367
1488
1804
2060
31
1124
1224
1301
1290
1291
1378
1378
1510
1834
2102
32
1157
1257
1334
1323
1312
1411
1411
1543
1863
2145
33
1201
1301
1378
1378
1317
1466
1466
1598
1885
2187
34
1213
1323
1400
1400
1336
1488
1488
1620
1907
2229
75
85
24.9
24.9
7.0 - 8.5
7.0 - 8.5
26
728
772
27
743
794
28
757
805
29
772
849
30
783
882
31
794
893
32
805
915
33
821
948
34
837
959
35
36 - 51
Note B
1929
36
37
38
39
40
41
41 - 50
Note C
42 - 51
Note D
36
37
38
39
40
41
41 - 50
Note C
42 - 51
Note D
36
37
38
39
40
41
41 - 50
Note C
42 - 51
Note D
1764
1896
2083
1962
35 - 51 36 - 51
35
Note A Note B
1235
1279
1345
1389
1433
1477
1422
1356
1510
1565
1521
1653
1929
2271
35
981
1995
2017
35 - 51 36 - 51
Note A Note B
853
36
37
38
2116
2138
2205
39
40
41
41 - 50
Note C
42 - 51
Note D
1466
1488
1510
1565
1587
1609
1653
1565
1709
1598
1742
1620
1764
1664
1819
1698
1852
1720
1874
1764
1929
36
1003
37
1025
38
1036
NOTE A: Some P-Metric Light Load and Standard Load tires may be branded with a maximum inflation pressure of 35, 44 or 51 psi for high speed and handling optimization. However, there is no load increase above 35 psi.
NOTE B: Some European Metric tires may be branded with a maximum inflation pressure of 32, 36, 44 or 51 psi for high speed and handling optimization. However, there is no load increase above 36 psi.
NOTE C: Some P-Metric Extra Load tires may be branded with a maximum inflation pressure of 41 or 50 psi for high speed and handling optimization. However, there is no load increase above 41 psi.
NOTE D: Some European Metric Extra Load tires may be branded with a maximum inflation pressure of 42 or 51 psi for high speed and handling optimization. However, there is no load increase above 42 psi.
* Nominal Tire O. D. is a designated or theoretical size that may vary from the actual tire O. D.
IMPORTANT: Never exceed the maximum inflation pressure molded on the sidewall of the tire.
_____________________________________________________________________________
8/7/2006
2083
2149
B16
39
1069
40
1091
41
1102
41 - 50
Note C
42 - 51
Note D
1135
30 Series
P-Metric
Euro-Metric
265/30R19 (XL)
275/30R19 (SL)
275/30R19 (XL)
285/30R19 (SL)
285/30R19(XL)
305/30R19 (SL)
305/30R19 (XL)
P345/30R19 (LL)
Tire Load Limits in Pounds (lbs.) at Various Cold Inflation Pressures in Pounds Per Square Inch (psi)
For Light Load and Standard Load Tires
Nominal
Tire O.D.*
Rim Width
Range
84
88
86
87
91
89
89
93
92
96
94
96
99
110
25.2
25.2
25.5
25.5
25.5
25.8
25.8
25.8
26.0
26.0
26.6
26.6
26.9
28.5
7.5 - 9.0
7.5 - 9.0
8.0 - 9.5
8.0 - 9.5
8.0 - 9.5
8.0 - 9.5
8.0 - 9.5
8.0 - 9.5
8.5 - 10.0
8.5 - 10.0
9.0 - 10.5
9.0 - 11.0
9.5 - 11.0
11.5 - 13.5
Load
Index
Nominal
Tire O.D.*
Rim Width
Range
93
92
96
94
98
98
102
98
25.3
25.6
25.6
25.8
25.8
26.3
26.3
27.2
9.0 - 10.0
9.0 - 10.0
9.0 - 10.0
9.5 - 10.5
9.5 - 10.5
10.5 - 11.5
10.5 - 11.5
12.0 - 14.0
26
849
838
904
926
926
1060
981
981
1069
1069
1135
1201
1312
1797
27
871
860
926
948
948
1085
1003
1003
1091
1091
1168
1235
1345
1841
28
882
882
937
970
970
1110
1025
1025
1113
1113
1190
1257
1367
1874
29
926
915
981
1003
1003
1135
1069
1069
1157
1157
1235
1312
1433
1951
30
959
959
1014
1047
1047
1159
1113
1102
1213
1213
1290
1367
1488
2028
31
970
970
1025
1058
1058
1184
1124
1113
1224
1224
1301
1378
1510
2061
32
992
992
1058
1080
1091
1208
1157
1146
1257
1257
1334
1411
1543
2105
33
1036
1025
1091
1124
1124
1232
1201
1190
1301
1301
1378
1466
1598
2183
34
1047
1036
1113
1135
1146
1255
1213
1213
1323
1323
1400
1488
1620
2216
26
981
1069
1069
1135
1124
1268
1279
1433
27
1003
1091
1091
1168
1157
1301
1312
1459
28
1025
1113
1113
1190
1179
1323
1334
1484
29
1069
1157
1157
1235
1224
1378
1389
1510
30
1102
1213
1213
1290
1279
1433
1444
1536
31
1113
1224
1224
1301
1290
1455
1466
1561
32
1146
1257
1257
1334
1323
1488
1499
1587
33
1190
1301
1301
1378
1378
1543
1554
1609
34
1213
1323
1323
1400
1400
1565
1576
1631
P275/60R20 (SL)
55 Series
P-Metric
Euro-Metric
P275/55R20 (SL)
285/55R20 (SL)
50 Series
P-Metric
Euro-Metric
255/50R20 (XL)
P265/50R20 (SL)
265/50R20 (XL)
P285/50R20 (SL)
285/50R20 (SL)
305/50R20 (SL)
305/50R20 (XL)
325/50R20 (SL)
45 Series
P-Metric
Euro-Metric
P235/45R20 (SL)
255/45R20 (XL)
Load
Index
Nominal
Tire O.D.*
35
1069
1058
1135
1157
1168
36 - 51
Note B
1102
36
37
38
39
40
41
41 - 50
Note C
42 - 51
Note D
1091
1113
1135
1168
1190
1201
1235
1201
1224
1246
1279
1301
1323
1356
1268
1290
1312
1356
1378
1389
1433
1389
1411
1433
1477
1499
1521
1565
36
1268
37
1290
38
1312
39
1356
40
1378
1389
1411
1433
1477
1499
1521
1565
1466
1488
1510
1565
1587
1609
1653
1664
1698
1720
1775
1797
1819
1874
1168
1201
1279
1235
1235
1345
1345
1433
1510
1653
2260
1279
1389
1477
1565
1709
2337
35 - 51 36 - 51
35
Note A Note B
1235
1345
1389
1345
1433
1477
1422
1598
1653
1609
1653
41 - 50
41
Note C
1389
42 - 51
Note D
1433
Tire Load Limits in Pounds (lbs.) at Various Cold Inflation Pressures in Pounds Per Square Inch (psi)
26
2260
27
2300
28
2341
29
2381
30
2421
31
2462
32
2502
33
2535
34
2568
35
27
2135
2116
28
2175
2149
29
2216
2238
30
2249
2326
31
2282
2359
32
2315
2414
33
2344
2502
34
2374
2546
35
35 - 51 36 - 51
Note A Note B
2601
114
33.0
7.5 - 9.5
Load
Index
Nominal
Tire O.D.*
Rim Width
Range
111
115
31.9
32.4
7.5 - 9.5
8.0 - 10.0
26
2094
2061
Load
Index
109
106
112
111
112
116
120
120
Load
Index
Nominal
Tire O.D.*
30.1
30.5
30.5
31.3
31.3
32.0
32.0
32.8
Rim Width
Range
7.0 - 9.0
7.5 - 9.5
7.5 - 9.5
8.0 - 10.0
8.0 - 10.0
8.5 - 11.0
8.5 - 11.0
9.0 - 11.5
26
1554
1830
1687
2061
1896
2116
2105
2370
27
1598
1863
1731
2098
1951
2183
2172
2436
28
1620
1896
1764
2135
1984
2216
2205
2480
29
1687
1929
1830
2172
2061
2304
2293
2579
30
1753
1958
1907
2205
2149
2392
2381
2690
31
1775
1988
1940
2238
2183
2425
2414
2723
32
1819
2017
1984
2271
2227
2491
2469
2789
33
1885
2043
2050
2315
2315
2579
2568
2888
34
1918
2068
2083
2359
2348
2623
2612
2932
35 - 51 36 - 51
35
Note A Note B
1951
2094
2127
2403
2392
2469
2668
2756
2657
2987
3086
Nominal
Tire O.D.*
Rim Width
Range
26
27
28
29
30
31
32
33
34
35
96
105
28.4
29.1
7.5 - 9.0
8.0 - 9.5
1299
1389
1330
1411
1360
1433
1391
1510
1420
1576
1450
1598
1479
1631
1508
1698
1536
1720
35 - 51 36 - 51
Note A Note B
2403
2590
2679
1753
35 - 51 36 - 51
Note A Note B
1565
36
37
38
39
40
41
41 - 50
Note C
42 - 51
Note D
36
37
38
39
40
41
41 - 50
Note C
42 - 51
Note D
36
2017
37
2050
38
2083
39
2149
40
2183
41 - 50
Note C
41
2205
2194
2227
2260
2337
2370
2403
2469
2745
2789
2833
2910
2965
2998
3086
36
1808
37
1841
38
1874
NOTE A: Some P-Metric Light Load and Standard Load tires may be branded with a maximum inflation pressure of 35, 44 or 51 psi for high speed and handling optimization. However, there is no load increase above 35 psi.
NOTE B: Some European Metric tires may be branded with a maximum inflation pressure of 32, 36, 44 or 51 psi for high speed and handling optimization. However, there is no load increase above 36 psi.
NOTE C: Some P-Metric Extra Load tires may be branded with a maximum inflation pressure of 41 or 50 psi for high speed and handling optimization. However, there is no load increase above 41 psi.
NOTE D: Some European Metric Extra Load tires may be branded with a maximum inflation pressure of 42 or 51 psi for high speed and handling optimization. However, there is no load increase above 42 psi.
* Nominal Tire O. D. is a designated or theoretical size that may vary from the actual tire O. D.
IMPORTANT: Never exceed the maximum inflation pressure molded on the sidewall of the tire.
_____________________________________________________________________________
8/7/2006
B17
39
1929
40
1962
41
1984
41 - 50
Note C
42 - 51
Note D
2271
42 - 51
Note D
2039
Tire Load Limits in Pounds (lbs.) at Various Cold Inflation Pressures in Pounds Per Square Inch (psi)
For Light Load and Standard Load Tires
Nominal
Tire O.D.*
Rim Width
Range
295/45R20 (SL)
295/45R20 (XL)
108
106
106
114
110
114
29.4
29.8
29.8
30.5
30.5
30.5
305/45R20 (SL)
305/45R20 (XL)
112
116
36 - 51
Note B
8.5 - 10.0
8.5 - 10.0
8.5 - 10.5
9.5 - 11.0
9.5 - 11.0
9.5 - 11.0
26
1510
1737
1609
1938
1797
1775
27
1554
1778
1653
1984
1841
1819
28
1576
1820
1687
2031
1874
1852
29
1642
1861
1753
2077
1951
1929
30
1698
1901
1819
2121
2028
2006
31
1720
1940
1852
2165
2061
2039
32
1764
1980
1896
2209
2105
2083
33
1830
2018
1962
2252
2183
2160
34
1863
2056
1995
2294
2216
2194
35
1896
2028
2337
2260
2238
2094
30.8
30.8
9.5 - 11.5
9.5 - 11.5
1896
1885
1951
1929
1984
1962
2061
2050
2149
2127
2183
2160
2227
2205
2315
2293
2348
2326
2392
2370
2469
Load
Index
90
95
106
102
106
104
101
106
106
Nominal
Tire O.D.*
Rim Width
Range
8.0 - 9.5
8.0 - 9.5
9.0 - 11.0
9.0 - 11.0
9.0 - 11.0
9.5 - 11.0
10.0 - 12.0
10.0 - 12.0
10.0 - 11.5
26
1157
1168
1737
1444
1433
1521
1565
1737
1609
27
1181
1201
1778
1477
1466
1565
1594
1778
1653
28
1203
1224
1820
1499
1488
1598
1623
1820
1687
29
1224
1268
1861
1565
1554
1664
1653
1861
1753
30
1238
1323
1901
1631
1620
1731
1679
1901
1819
31
1259
1345
1940
1653
1642
1753
1705
1940
1852
32
1279
1378
1980
1687
1675
1797
1731
1980
1896
33
1285
1422
2018
1753
1742
1852
1760
2018
1962
34
1304
1444
2056
1786
1764
1885
1789
2056
1995
35 - 51 36 - 51
Note A Note B
35
1323
1477
1521
2094
1819
1874
1797
1918
1984
1819
2094
2028
2094
Nominal
Tire O.D.*
265/35R20 (SL)
275/35R20 (SL)
Load
Index
91
95
93
93
97
89
95
98
26.8
26.8
27.0
27.0
27.0
27.6
27.3
27.6
Rim Width
Range
8.0 - 9.5
8.0 - 9.5
8.5 - 10.0
8.5 - 10.0
8.5 - 10.0
9.0 - 11.0
9.0 - 10.5
9.0 - 11.0
26
1047
1036
1188
1102
1102
1124
1168
1268
27
1069
1058
1216
1124
1124
1148
1201
1301
28
1091
1080
1244
1146
1146
1169
1224
1323
29
1135
1135
1272
1201
1190
1190
1268
1378
30
1179
1179
1299
1246
1246
1206
1323
1433
31
1190
1190
1327
1257
1257
1226
1345
1455
32
1224
1224
1354
1290
1290
1246
1378
1488
33
1268
1268
1380
1345
1334
1242
1422
1543
34
1290
1290
1407
1367
1356
1261
1444
1565
35 - 51 36 - 51
35
Note A Note B
1312
1356
1312
1433
1389
1433
1378
1279
1477
1521
1598
1653
315/35R20 (SL)
315/35R20 (SL)
106
108
28.7
28.7
10.5 - 12.5
10.5 - 12.5
1609
1698
1653
1742
1687
1775
1753
1841
1819
1918
1852
1951
1896
1995
1962
2061
1995
2094
2028
2138
Load
Index
97
95
104
Nominal
Tire O.D.*
26.5
26.8
28.0
Rim Width
Range
9.0 - 10.0
9.5 - 10.5
11.5 - 12.5
26
1102
1168
1521
27
1124
1201
1565
28
1146
1224
1598
29
1190
1268
1664
30
1246
1323
1731
31
1257
1345
1753
32
1290
1378
1797
33
1334
1422
1852
34
1356
1444
1885
35 - 51
Note A
35
1378
1477
1918
36 - 51
Note B
Load
Index
100
Nominal
Tire O.D.*
26.8
Rim Width
Range
12.0 - 13.0
26
1356
27
1389
28
1411
29
1477
30
1532
31
1554
32
1587
33
1653
34
1675
35 - 51
35
Note A
1709
36 - 51
Note B
1764
265/45R20 (XL)
P275/45R20 (SL)
275/45R20 (SL)
P295/45R20 (XL)
40 Series
P-Metric
Euro-Metric
P245/40R20 (LL)
245/40R20 (SL)
P275/40R20 (SL)
275/40R20 (SL)
275/40R20 (XL)
285/40R20 (SL)
P295/40R20 (LL)
P295/40R20 (SL)
295/40R20 (SL)
35 Series
P-Metric
Euro-Metric
245/35R20 (SL)
245/35R20 (XL)
P255/35R20 (SL)
255/35R20 (SL)
255/35R20 (XL)
P275/35R20 (LL)
30 Series
P-Metric
Euro-Metric
275/30R20 (XL)
285/30R20 (SL)
335/30R20 (SL)
25 Series
P-Metric
Euro-Metric
345/25R20 (SL)
27.7
27.7
28.7
28.7
28.7
29.0
29.3
29.3
29.3
245/35R21 (XL)
255/35R21 (XL)
285/35R21 (SL)
Load
Index
96
98
101
Nominal
Tire O.D.*
27.8
28.0
28.9
37
1995
38
2017
39
2083
40
2116
41 - 50
41
Note C
2138
42 - 51
Note D
2205
2094
2385
2432
2480
2520
2561
2315
2348
2381
2458
2491
2524
2447
2491
2524
2601
2646
2679
2601
2337
36
1863
36
37
38
1896
37
1918
38
39
1973
39
40
2006
40
41
2601
2756
41 - 50
Note C
2039
41
42 - 51
Note D
2094
41 - 50
Note C
42 - 51
Note D
1356
1378
1389
1433
1455
1477
1521
1433
1455
1477
1521
1543
1565
1609
36
1433
37
1455
38
1477
39
1521
40
1543
41 - 50
41
Note C
1565
36
37
38
39
40
41
2094
2205
42 - 51
Note D
1609
1521
1984
41 - 50
Note C
42 - 51
Note D
Tire Load Limits in Pounds (lbs.) at Various Cold Inflation Pressures in Pounds Per Square Inch (psi)
36
1962
26
1069
1124
1395
27
1091
1157
1434
28
1113
1179
1475
29
1157
1224
1521
30
1213
1279
1566
31
1224
1290
1608
32
1257
1323
1646
33
1301
1378
1684
34
1323
1400
1727
35 - 51
Note A
36 - 51
Note B
36
1389
1466
37
1411
1488
38
1433
1510
1819
NOTE A: Some P-Metric Light Load and Standard Load tires may be branded with a maximum inflation pressure of 35, 44 or 51 psi for high speed and handling optimization. However, there is no load increase above 35 psi.
NOTE B: Some European Metric tires may be branded with a maximum inflation pressure of 32, 36, 44 or 51 psi for high speed and handling optimization. However, there is no load increase above 36 psi.
NOTE C: Some P-Metric Extra Load tires may be branded with a maximum inflation pressure of 41 or 50 psi for high speed and handling optimization. However, there is no load increase above 41 psi.
NOTE D: Some European Metric Extra Load tires may be branded with a maximum inflation pressure of 42 or 51 psi for high speed and handling optimization. However, there is no load increase above 42 psi.
* Nominal Tire O. D. is a designated or theoretical size that may vary from the actual tire O. D.
IMPORTANT: Never exceed the maximum inflation pressure molded on the sidewall of the tire.
_____________________________________________________________________________
8/7/2006
B18
39
1477
1565
40
1499
1587
41 - 50
Note C
41
1521
1609
42 - 51
Note D
1565
1653
Tire Load Limits in Pounds (lbs.) at Various Cold Inflation Pressures in Pounds Per Square Inch (psi)
For Light Load and Standard Load Tires
(Continued)
30 Series
P-Metric
Euro-Metric
325/30R21 (SL)
Load
Index
104
Nominal
Tire O.D.*
28.7
Rim Width
Range
11.0 - 12.0
26
1521
27
1565
Nominal
Tire O.D.*
Rim Width
Range
265/40R22 (SL)
305/40R22 (SL)
110
114
118
118
Load
Index
106
110
11.2
32.8
32.8
32.8
Nominal
Tire O.D.*
30.3
31.6
9.0 - 11.0
9.5 - 11.5
9.5 - 11.0
9.5 - 11.5
Rim Width
Range
9.0 - 10.5
10.0 - 12.0
305/40R22 (XL)
325/40R22 (XL)
114
118
31.6
32.2
Load
Index
98
102
102
305/45R22 (SL)
P305/45R22 (XL)
305/45R22 (XL)
40 Series
P-Metric
Euro-Metric
35 Series
P-Metric
Euro-Metric
265/35R22 (SL)
265/35R22 (XL)
285/35R22 (SL)
30 Series
P-Metric
Euro-Metric
285/30R22 (XL)
295/30R22 (SL)
295/30R22 (XL)
25 Series
P-Metric
Euro-Metric
295/25R22 (XL)
26
1938
1995
2158
1984
27
1984
2050
2209
2039
P305/40R23 (XL)
305/40R23 (XL)
35 Series
P-Metric
Euro-Metric
285/35R23 (XL)
305/35R23 (SL)
305/35R23 (XL)
31
1753
32
1797
33
1852
34
1885
35
1918
36
38
37
39
40
41
41 - 50
Note C
42 - 51
Note D
28
2031
2083
2259
2072
29
2077
2172
2310
2160
30
2121
2260
2359
2249
31
2165
2293
2409
2282
32
2209
2348
2458
2337
33
2252
2436
2506
2414
34
2294
2469
2553
2458
35 - 51
Note A
36 - 51
Note B
35 - 51
Note A
36 - 51
Note B
2094
2337
27
1653
1841
28
1687
1874
29
1753
1951
30
1819
2028
31
1852
2061
32
1896
2105
33
1962
2183
34
1995
2216
35
2028
2260
10.0 - 12.0
11.0 - 13.0
1775
1984
1819
2039
1852
2072
1929
2160
2006
2249
2039
2282
2083
2337
2160
2414
2194
2458
2238
2502
Nominal
Tire O.D.*
29.3
29.3
29.9
Rim Width
Range
9.0 - 10.5
9.0 - 10.5
9.5 - 11.0
26
1268
1279
1444
27
1301
1312
1477
28
1323
1334
1499
29
1378
1389
1565
30
1433
1444
1631
31
1455
1466
1653
32
1488
1499
1687
33
1543
1554
1753
34
1565
1576
1786
35 - 51
35
Note A
1598
1609
1819
36 - 51
Note B
1653
Load
Index
101
99
103
Nominal
Tire O.D.*
28.8
29.0
29.0
Rim Width
Range
9.5 - 10.5
10.0 - 11.0
10.0 - 11.0
26
1246
1312
1312
27
1279
1345
1356
28
1301
1367
1378
29
1356
1433
1433
30
1400
1488
1488
31
1422
1510
1510
32
1455
1543
1543
33
1510
1598
1598
34
1532
1620
1620
35 - 51
Note A
35
1565
1653
1653
36 - 51
Note B
Load
Index
97
Nominal
Tire O.D.*
27.8
Rim Width
Range
10.0 - 11.0
35 - 51
Note A
36 - 51
Note B
26
1102
27
1124
28
1146
29
1190
30
1246
31
1257
32
1290
33
1334
34
1356
35
1378
36
37
38
39
40
41
2658
2579
2716
2623
2773
2668
2819
2745
2864
2800
2833
41 - 50
Note C
42 - 51
Note D
2601
26
1609
1797
2910
36
37
38
39
40
41
2315
2579
2348
2623
2381
2668
2458
2745
2491
2800
2524
2833
36
37
38
39
40
41
2910
41 - 50
Note C
42 - 51
Note D
2601
2910
41 - 50
Note C
1664
1698
1720
1775
1797
1819
36
1620
37
1642
38
1664
39
1720
40
1742
41 - 50
41
Note C
1764
1709
1742
1764
1819
1852
1874
42 - 51
Note D
1874
1874
42 - 51
Note D
1819
1709
36
1433
37
1455
38
1477
39
1521
40
1543
41
1565
1929
41 - 50
Note C
42 - 51
Note D
1609
Tire Load Limits in Pounds (lbs.) at Various Cold Inflation Pressures in Pounds Per Square Inch (psi)
30
1731
Load
Index
P285/45R22 (SL)
29
1664
36 - 51
Note B
1984
Tire Load Limits in Pounds (lbs.) at Various Cold Inflation Pressures in Pounds Per Square Inch (psi)
28
1598
Load
Index
115
115
Nominal
Tire O.D.*
32.6
32.6
Rim Width
Range
10.0 - 12.0
10.0 - 12.0
26
1993
1830
27
2040
1874
28
2087
1907
29
2134
1995
30
2180
2072
31
2225
2105
32
2271
2149
33
2315
2227
Load
Index
107
107
111
Nominal
Tire O.D.*
30.9
31.4
31.4
Rim Width
Range
9.5 - 11.0
10.0 - 12.0
10.0 - 12.0
26
1466
1653
1642
27
1510
1698
1687
28
1532
1731
1709
29
1598
1797
1786
30
1664
1874
1852
31
1687
1896
1885
32
1720
1940
1929
33
1786
2006
1995
34
2359
2260
35
2403
2304
35 - 51
Note A
36 - 51
Note B
34
1819
2039
2028
35 - 51
35
Note A
1852
2083
2061
36 - 51
Note B
37
2503
2425
38
2553
2458
39
2595
2524
40
2637
2568
36
1907
37
1940
38
1973
39
2028
40
2061
41 - 50
41
Note C
2094
2138
2172
2205
2271
2304
2337
42 - 51
Note D
2149
2149
NOTE A: Some P-Metric Light Load and Standard Load tires may be branded with a maximum inflation pressure of 35, 44 or 51 psi for high speed and handling optimization. However, there is no load increase above 35 psi.
NOTE B: Some European Metric tires may be branded with a maximum inflation pressure of 32, 36, 44 or 51 psi for high speed and handling optimization. However, there is no load increase above 36 psi.
NOTE C: Some P-Metric Extra Load tires may be branded with a maximum inflation pressure of 41 or 50 psi for high speed and handling optimization. However, there is no load increase above 41 psi.
NOTE D: Some European Metric Extra Load tires may be branded with a maximum inflation pressure of 42 or 51 psi for high speed and handling optimization. However, there is no load increase above 42 psi.
* Nominal Tire O. D. is a designated or theoretical size that may vary from the actual tire O. D.
IMPORTANT: Never exceed the maximum inflation pressure molded on the sidewall of the tire.
_____________________________________________________________________________
8/7/2006
41 - 50 42 - 51
Note C Note D
2679
2601
2679
41
36
2453
2381
B19
2403
Load
Index
114
Nominal
Tire O.D.*
32.4
26
1775
27
1819
305/30R26
Load
Index
108
Nominal
Tire O.D.*
33.2
325/35R28
Load
Index
120
Nominal
Tire O.D.*
37.0
30
2006
31
2039
32
2083
33
2160
34
2194
35
2238
36
2315
37
2348
26
1698
27
1742
38
2381
39
2458
40
2491
41 - 50
41
Note C
2524
42 - 51
Note D
2601
28
1775
29
1841
30
1918
31
1951
32
1995
33
2061
34
2094
35 - 51
Note A
36 - 51
Note B
2205
36
37
38
39
40
41
41 - 50
Note C
42 - 51
Note D
Tire Load Limits in Pounds (lbs.) at Various Cold Inflation Pressures in Pounds Per Square Inch (psi)
29
1929
36 - 51
Note B
Tire Load Limits in Pounds (lbs.) at Various Cold Inflation Pressures in Pounds Per Square Inch (psi)
28
1852
26
2370
27
2436
28
2480
29
2579
30
2690
31
2723
32
2789
33
2888
34
2932
35 - 51
Note A
36 - 51
Note B
3086
36
37
38
NOTE A: Some P-Metric Light Load and Standard Load tires may be branded with a maximum inflation pressure of 35, 44 or 51 psi for high speed and handling optimization. However, there is no load increase above 35 psi.
NOTE B: Some European Metric tires may be branded with a maximum inflation pressure of 32, 36, 44 or 51 psi for high speed and handling optimization. However, there is no load increase above 36 psi.
NOTE C: Some P-Metric Extra Load tires may be branded with a maximum inflation pressure of 41 or 50 psi for high speed and handling optimization. However, there is no load increase above 41 psi.
NOTE D: Some European Metric Extra Load tires may be branded with a maximum inflation pressure of 42 or 51 psi for high speed and handling optimization. However, there is no load increase above 42 psi.
* Nominal Tire O. D. is a designated or theoretical size that may vary from the actual tire O. D.
IMPORTANT: Never exceed the maximum inflation pressure molded on the sidewall of the tire.
_____________________________________________________________________________
8/7/2006
B20
39
40
41
41 - 50
Note C
42 - 51
Note D
LT-Metric
85 Series
30.4
5.5 - 7.0
LT235/85R16
31.7
6.0 - 7.5
LT255/85R16
33.1
6.5 - 8.0
80 Series
DUAL
SINGLE
DUAL
SINGLE
DUAL
SINGLE
28.5
5.5 - 7.0
LT235/80R16
36.5
8.5 - 11.0
LT235/80R17
31.8
6.0 - 7.5
75 Series
DUAL
SINGLE
DUAL
SINGLE
DUAL
SINGLE
24.3
4.5 - 5.5
LT185/75R14
25.0
4.5 - 6.0
LT195/75R14
25.5
5.0 - 6.0
DUAL
SINGLE
DUAL
SINGLE
DUAL
SINGLE
35
40
45
50
55
60
65
70
75
80
1360
1495
1545
1700
1745
1920
1490
1640
1700
1870
1920
2110
1625
1785
1845
2030
2085
2290
1765 (C)
1940 (C)
2006 (C)
2205 (C)
2270 (C)
2470 (C)
1865
2050
2125
2335
2400
2635
1985
2180
2260
2485
2550
2800
2150 (D)
2335 (D)
2381 (D)
2623 (D)
2755 (D)
3000 (D)
2210
2430
2515
2765
2320
2550
2645
2905
2470 (E)
2680 (E)
2778 (E)
3042 (E)
35
40
45
50
55
60
65
70
75
80
1275
1400
2535
2755
1570
1725
1395
1535
2705
2970
1725
1895
1515
1665
2935
3225
1870
2055
1655
1820
3195 (D)
3525 (D)
2040
2270
1745
1920
1855
2040
1930 (D)
2150 (D)
2190
2405
2315
2545
2470
2680
2560
2815
2685
2950
2835 (E)
3085 (E)
35
40
45
50
55
60
65
70
75
80
870
955
945
1040
1015
1115
955
1050
1035
1140
1115
1225
1035
1140
1130
1240
1210
1330
1135 (C)
1235 (C)
1235 (C)
1355 (C)
1325 (C)
1435 (C)
1390
1530
1480
1630
1565 (D)
1710 (D)
Note: Letters in parentheses denote Load Range for which Bold Face loads are maximum.
Note: Due to the increased stress factors associated with light truck tires with a section width greater than 295 millimeters, higher load range constructions
are required at lower inflation pressures.
* Nominal Tire O. D. is a designated or theoretical size that may vary from the actual tire O. D.
ALWAYS USE APPROVED TIRE AND RIM COMBINATIONS FOR DIAMETERS AND CONTOURS.
_____________________________________________________________________________
8/7/2006
B21
LT-Metric
(continued)
75 Series
26.7
5.5 - 7.0
LT195/75R15
26.5
5.5 - 6.0
LT205/75R15
27.1
5.5 - 6.5
LT215/75R15
27.7
5.5 - 7.0
LT225/75R15
28.3
6.0 - 7.0
LT235/75R15
28.9
6.0 - 7.0
LT245/75R15
29.5
6.5 - 7.5
LT255/75R15
30.0
6.5 - 8.0
LT265/75R15
30.7
7.0 - 8.5
LT225/75R16
29.3
6.0 - 7.0
LT245/75R16
30.5
6.5 - 8.0
LT265/75R16
31.7
7.0 - 8.0
DUAL
SINGLE
DUAL
SINGLE
DUAL
SINGLE
DUAL
SINGLE
DUAL
SINGLE
DUAL
SINGLE
DUAL
SINGLE
DUAL
SINGLE
DUAL
SINGLE
DUAL
SINGLE
DUAL
SINGLE
DUAL
SINGLE
35
40
45
50
55
60
65
70
75
80
1170
1285
1060
1165
1145
1260
1225
1345
1315
1445
1390
1530
1490
1635
1575
1730
1675
1840
1365
1500
1545
1700
1740
1910
1290
1415
1165
1280
1260
1385
1340
1475
1440
1585
1530
1680
1635
1795
1730
1900
1840
2020
1500
1650
1695
1865
1910
2100
1395
1535
1265
1390
1365
1500
1460
1605
1565
1720
1660
1825
1775
1950
1880
2065
1995
2195
1630
1790
1845
2030
2075
2280
1520 (C)
1655 (C)
1390 (C)
1520 (C)
1520 (C)
1655 (C)
1610 (C)
1765 (C)
1710 (C)
1875 (C)
1820 (C)
1985 (C)
1930 (C)
2150 (C)
2040 (C)
2270 (C)
2205 (C)
2405 (C)
1765 (C)
1940 (C)
2006 (C)
2205 (C)
2270 (C)
2470 (C)
1605
1765
1710
1880
1820 (D)
1985 (D)
1575
1730
1680
1845
1800
1980
1910
2100
1675
1840
1785
1960
1910
2100
2035
2235
1765 (D)
1930 (D)
1930 (D)
2095 (D)
1985 (D)
2205 (D)
2150 (D)
2335 (D)
2265
2490
2375
2610
2535 (E)
2755 (E)
1875
2060
2125
2335
2390
2625
1995
2190
2255
2480
2540
2790
2150 (D)
2335 (D)
2381 (D)
2623 (D)
2755 (D)
3000 (D)
2220
2440
2515
2765
2825
3105
2330
2560
2640
2900
2965
3260
2470 (E)
2680 (E)
2778 (E)
3042 (E)
3085 (E)
3415 (E)
Note: Letters in parentheses denote Load Range for which Bold Face loads are maximum.
Note: Due to the increased stress factors associated with light truck tires with a section width greater than 295 millimeters, higher load range constructions
are required at lower inflation pressures.
* Nominal Tire O. D. is a designated or theoretical size that may vary from the actual tire O. D.
ALWAYS USE APPROVED TIRE AND RIM COMBINATIONS FOR DIAMETERS AND CONTOURS.
_____________________________________________________________________________
8/7/2006
B22
LT-Metric
(continued)
75 Series
32.8
7.5 - 9.0
LT295/75R16
33.4
7.5 - 9.5
LT315/75R16
34.6
8.0 - 10.0
LT245/75R17
31.5
6.5 - 7.5
LT285/75R17
34.1
7.5 - 9.5
LT325/75R20
39.2
8.5 - 11.0
70 Series
25.4
5.0 - 6.5
LT215/70R14
25.9
5.5 - 7.0
LT235/70R15
28.0
6.0 - 8.0
LT245/70R15
28.5
6.5 - 7.5
LT255/70R15
29.1
6.5 - 8.0
LT265/70R15
29.7
7.0 - 8.5
LT285/70R15
30.8
7.5 - 9.0
LT315/70R15
32.4
8.0 - 10.0
USAGE
35
40
45
50
55
60
65
70
75
80
DUAL
SINGLE
DUAL
SINGLE
SINGLE
DUAL
SINGLE
DUAL
SINGLE
DUAL
SINGLE
1940
2130
2040
2240
2535 (C)
1610
1770
2010
2210
2835
3085
2130
2340
2240
2460
2715
1770
1945
2210
2430
2965
3260
2310
2540
2430
2670
2950
1920
2110
2400
2640
3220
3540
2535 (C)
2755 (C)
2680 (C)
2910 (C)
3195 (D)
2040
2270
2600
2835
3525 (D)
3860 (D)
2660
2925
2795
3070
2830
3110
2965
3260
3000 (D)
3305 (D)
3085 (D)
3415 (D)
2210
2430
2690
2955
2360
2595
2800
3075
2535
2755
2910 (D)
3195 (D)
2640
2900
2775
3050
2910 (E)
3195 (E)
USAGE
35
40
45
50
55
60
65
70
75
80
DUAL
SINGLE
DUAL
SINGLE
DUAL
SINGLE
DUAL
SINGLE
DUAL
SINGLE
DUAL
SINGLE
DUAL
SINGLE
DUAL
SINGLE
1045
1150
1125
1235
1335
1465
1420
1560
1505
1655
1595
1750
1780
1955
2150(C)
2335(C)
1150
1265
1235
1355
1465
1610
1555
1710
1650
1815
1750
1925
1950
2145
2275
2500
1245
1370
1340
1470
1595
1750
1695
1860
1795
1970
1900
2090
2120
2330
2470
2715
1355 (C)
1475 (C)
1475 (C)
1610 (C)
1710 (C)
1875 (C)
1875 (C)
2040 (C)
1930 (C)
2150 (C)
2040 (C)
2270 (C)
2335 (C)
2535 (C)
2680 (D)
2910 (D)
1440
1580
1525
1675
1610 (D)
1765 (D)
1700
1870
1785
1960
1875 (E)
2040 (E)
1830
2010
1945
2140
2040 (D)
2270 (D)
2165
2380
2275
2500
2335 (E)
2600 (E)
2440
2680
2595
2850
2755 (D)
3000 (D)
Note: Letters in parentheses denote Load Range for which Bold Face loads are maximum.
Note: Due to the increased stress factors associated with light truck tires with a section width greater than 295 millimeters, higher load range constructions
are required at lower inflation pressures.
* Nominal Tire O. D. is a designated or theoretical size that may vary from the actual tire O. D.
ALWAYS USE APPROVED TIRE AND RIM COMBINATIONS FOR DIAMETERS AND CONTOURS.
_____________________________________________________________________________
8/7/2006
B23
LT-Metric
(continued)
70 Series
27.9
5.5 - 7.0
LT225/70R16
28.4
6.0 - 7.0
LT235/70R16
29.0
6.0 - 7.5
LT245/70R16
29.5
6.5 - 7.5
LT255/70R16
30.1
6.5 - 8.0
LT265/70R16
30.6
7.0 - 8.5
LT275/70R16
31.2
7.0 - 8.5
LT305/70R16
32.8
8.0 - 9.5
LT315/70R16
33.4
8.5 - 10.0
LT355/70R16
35.6
9.0 - 12.0
LT365/70R16
36.1
9.5 - 11.0
LT395/70R16
37.8
10.0 - 12.0
LT245/70R17
30.6
6.5 - 8.0
LT265/70R17
31.7
7.0 - 8.5
USAGE
35
40
45
50
DUAL
SINGLE
DUAL
SINGLE
DUAL
SINGLE
DUAL
SINGLE
DUAL
SINGLE
DUAL
SINGLE
DUAL
SINGLE
DUAL
SINGLE
DUAL
SINGLE
DUAL
SINGLE
DUAL
SINGLE
DUAL
SINGLE
DUAL
SINGLE
DUAL
SINGLE
1220
1340
1305
1435
1390
1525
1540
1690
1565
1720
1655
1820
1750
1925
2040
2270
2205
2405
2680
2910
2755
3000
3085 (C)
3415 (C)
1540
1690
1720
1890
1340
1475
1435
1575
1525
1675
1690
1855
1720
1890
1820
2000
1920
2110
2245
2465
2355
2590
2835
3115
2960
3250
1455
1600
1555
1710
1655
1820
1830
2010
1865
2050
1975
2170
2090
2295
2440
2680
2560
2815
3975
3380
3210
3530
1610 (C)
1765 (C)
1710 (C)
1875 (C)
1820 (C)
1985 (C)
1985
2205
1985 (C)
2205 (C)
2150 (C)
2335 (C)
2270 (C)
2470 (C)
2680 (D)
2910 (D)
2835 (D)
3085 (D)
3305 (D)
3640 (D)
3525 (D)
3860 (D)
1690
1855
1890
2075
1830
2010
2050
2255
1985
2205
2270 (C)
2470 (C)
55
60
65
1905
2095
2105
2315
2150
2360
2275
2500
2400
2640
2805
3085
2030
2230
2240
2460
2285
2510
2415
2655
2555
2805
2980
3275
2150 (D)
2335 (D)
2335 (D)
2600 (D)
2470 (D)
2680 (D)
2600 (D)
2835 (D)
2755 (D)
3000 (D)
3195 (E)
3525 (E)
2105
2315
2360
2595
2240
2460
2570
2760
2335 (D)
2600 (D)
2680 (D)
2910 (D)
Note: Letters in parentheses denote Load Range for which Bold Face loads are maximum.
Note: Due to the increased stress factors associated with light truck tires with a section width greater than 295 millimeters, higher load range constructions
are required at lower inflation pressures.
* Nominal Tire O. D. is a designated or theoretical size that may vary from the actual tire O. D.
ALWAYS USE APPROVED TIRE AND RIM COMBINATIONS FOR DIAMETERS AND CONTOURS.
_____________________________________________________________________________
8/7/2006
B24
70
75
80
2495
2740
2615
2875
2755 (E)
3000 (E)
3320
3650
3485
3830
3640 (F)
3970 (F)
2495
2740
2735
3005
2615
2875
2820
3100
2755 (E)
3000 (E)
2910 (E)
3195 (E)
LT-Metric
(continued)
70 Series
32.2
7.0 - 8.5
LT285/70R17
32.8
7.5 - 9.0
LT305/70R17
33.9
8.0 - 9.5
LT315/70R17
34.4
8.5 - 10.0
LT355/70R17
36.6
9.0 - 12.0
LT275/70R18
33.2
7.0 - 8.5
65 Series
27.5
7.0 - 8.0
LT375/65R16
35.2
10.0 - 13.0
LT 245/65R17
29.5
7.0 - 8.0
LT305/65R17
32.6
8.5 - 11.0
LT 275/65R18
32.1
7.5 - 9.0
LT285/65R18
32.6
8.0 - 10.0
LT325/65R18
34.6
9.0 - 12.0
LT395/65R18
38.2
11.0 - 14.0
LT275/65R20
34.1
7.5 - 9.5
USAGE
35
40
45
50
55
60
65
DUAL
SINGLE
DUAL
SINGLE
DUAL
SINGLE
DUAL
SINGLE
DUAL
SINGLE
DUAL
SINGLE
1820
2000
1915
2105
2205
2405
2335
2535
2755
3000
1885
2070
1995
2195
2105
2315
2390
2605
2445
2685
2805
3065
2065
2270
2165
2380
2285
2510
2570
2800
2665
2915
2855
3130
2250
2470
2335 (C)
2600 (C)
2535
2755
2755 (D)
3000 (D)
2910 (D)
3195 (D)
2910 (D)
3195 (D)
2470
2680
2630
2890
2795
3070
2910 (D)
3195 (D)
2585
2840
2750
3020
USAGE
35
40
45
50
55
SINGLE
DUAL
SINGLE
DUAL
SINGLE
DUAL
SINGLE
DUAL
SINGLE
DUAL
SINGLE
DUAL
SINGLE
DUAL
SINGLE
DUAL
SINGLE
1450
2680
2910
1435
1575
1595
2880
3165
1575
1730
1730
3125
3435
1705
1875
1875 (C)
3415 (D)
3750 (D)
1875 (C)
2040 (C)
1765
1940
1850
2035
2335
2535
3085 (C)
3415 (C)
1895
2080
1940
2130
2035
2235
2470
2715
2100
2310
2205
2425
2680
2945
2335 (C)
2535 (C)
2335
2600
2910
3195
2075
2280
2250
2475
2470
2680
70
75
80
2910
3195
3060
3360
3210
3530
3305 (E)
3640 (E)
60
65
70
75
80
2420
2660
2540
2790
3085
3390
2570
2825
2700
2965
3275
3600
2755
3000
2910 (D)
3195 (D)
3525 (D)
3860 (D)
2865
3150
3010
3305
3085 (E)
3415 (E)
2595
2850
2755
3030
2910
3195
3070
3375
3220
3540
3415 (E)
3750 (E)
Note: Letters in parentheses denote Load Range for which Bold Face loads are maximum.
Note: Due to the increased stress factors associated with light truck tires with a section width greater than 295 millimeters, higher load range constructions
are required at lower inflation pressures.
* Nominal Tire O. D. is a designated or theoretical size that may vary from the actual tire O. D.
ALWAYS USE APPROVED TIRE AND RIM COMBINATIONS FOR DIAMETERS AND CONTOURS.
_____________________________________________________________________________
8/7/2006
B25
LT-Metric
60 Series
30.4
29.5
9.0 - 11.0
8.0 - 9.5
LT235/60R17
28.1
8.0
LT285/60R17
30.5
8.0 - 9.0
LT325/60R18
33.4
9.0 - 12.0
LT375/60R18
35.7
10.0 - 13.0
LT325/60R20
35.4
9.0 - 12.0
55 Series
29.6
30.9
8.0 - 10.0
10.0 - 12.0
LT375/55R16
32.2
10.0 - 13.0
LT345/55R17
32.0
10.0 - 12.0
LT285/55R20
32.4
8.0 - 10.0
LT325/55R22
36.1
9.0 - 12.0
LT335/55R22
36.5
9.0 - 12.0
50 Series
32.8
10.0 - 13.0
LT325/50R20
32.8
9.0 - 12.0
45 Series
35.5
9.0 - 12.0
55
60
65
70
75
80
1720
1890
1825
2005
1930 (D)
2150 (D)
2035
2235
2135
2345
2270 (E)
2470 (E)
2855
3135
3030
3330
3195 (E)
3525 (E)
55
60
65
70
75
80
2990
3285
3175
3490
3415 (E)
3750 (E)
2305
2535
2455
2700
2600 (D)
2835 (D)
50
55
60
65
70
75
80
2500
2745
2390
2755
3000
2600
2875
3160
2750
3060
3365
2920
3195 (E)
3525 (E)
3085 (E)
40
45
50
55
60
65
70
75
80
2190
2380
2600
2735
2910
3085 (E)
USAGE
35
40
45
50
SINGLE
SINGLE
DUAL
SINGLE
SINGLE
DUAL
SINGLE
DUAL
SINGLE
DUAL
SINGLE
2095 (C)
1750
1250
1375
1820
2150
2335
2680
2910
2335
2535
1920
1375
1510
1995
2285
2510
2830
3110
2440
2680
2085
1490
1640
2170
2480
2725
3070
3375
2655
2915
2270 (C)
1610 (C)
1765 (C)
2335 (C)
2755
3000
3305 (D)
3640 (D)
2910 (D)
3195 (D)
USAGE
35
40
45
50
SINGLE
SINGLE
DUAL
SINGLE
SINGLE
DUAL
SINGLE
DUAL
SINGLE
SINGLE
1875
2150
2270
2470
2270
1685
1850
2270
2470
2535
2020
2325
2395
2630
2410
1845
2030
2375
2610
2715
2195
2525
2600
2855
2620
2005
2205
2580
2835
2950
2405 (D)
2755 (D)
2835
3085
2835 (D)
2205
2405
2835 (D)
3085 (D)
3195 (D)
USAGE
35
40
45
DUAL
SINGLE
SINGLE
2150
2335
2040
2300
2530
2200
USAGE
35
SINGLE
2040
Note: Letters in parentheses denote Load Range for which Bold Face loads are maximum.
Note: Due to the increased stress factors associated with light truck tires with a section width greater than 295 millimeters, higher load range constructions
are required at lower inflation pressures.
* Nominal Tire O. D. is a designated or theoretical size that may vary from the actual tire O. D.
ALWAYS USE APPROVED TIRE AND RIM COMBINATIONS FOR DIAMETERS AND CONTOURS.
_____________________________________________________________________________
8/7/2006
B26
Flotation
TIRE SIZE
DESIGNATION
14" Rim Diameter
27X8.50R14LT
15" Rim Diameter
29X9.50R15LT
30X9.50R15LT
31X10.50R15LT
31X11.50R15LT
31X12.50R15LT
32X11.50R15LT
33X9.50R15LT
33X10.50R15LT
33X12.50R15LT
33X15.50R15LT
35X12.50R15LT
35X13.50R15LT
36X14.50R15LT
36X15.50R15LT
37X12.50R15LT
37X13.50R15LT
38X15.50R15LT
25
30
35
40
45
50
26.5
6.0 - 7.5
SINGLE
940
1075
1200 (B)
1305
1415
1520 (C)
28.5
29.5
30.5
30.5
30.5
31.5
32.5
32.5
32.5
32.5
34.5
34.5
35.5
35.5
36.5
36.5
37.5
6.5 - 8.5
6.5 - 8.5
7.0 - 9.0
8.0 - 10.0
8.5 - 11.0
8.0 - 10.0
6.5 - 8.5
7.0 - 9.0
8.0 - 11.0
11.0 - 13.0
8.0 - 11.0
8.5 - 11.0
10.0 - 12.0
11.0 - 13.0
8.5 - 11.0
8.5 - 11.0
11.0 - 13.0
SINGLE
SINGLE
SINGLE
SINGLE
SINGLE
SINGLE
SINGLE
SINGLE
SINGLE
SINGLE
SINGLE
SINGLE
SINGLE
SINGLE
SINGLE
SINGLE
SINGLE
1135
1240
1400
1455
1520
1575
1565
1630
1765 (B)
1930
2040
2095
2270
2335
2270 (B)
2335
2680
1290
1410
1595
1660
1715
1795
1780
1855
2000
2185
2295
2370
2610
2690
2600
2690
3040
1435 (B)
1565 (B)
1765 (B)
1820 (B)
1913 (C)
1985 (B)
1980
2040 (B)
2205 (C)
2405 (C)
2535 (C)
2600 (C)
2910 (C)
3000 (C)
2910 (C)
3000 (C)
3415 (C)
1575
1715
1945
2020
1700
1855
2100
2185
1820 (C)
1985 (C)
2270 (C)
2335 (C)
2185
2170
2260
2360
2345
2445
2535 (C)
2535 (C)
2600 (C)
Note: Letters in parentheses denote Load Range for which Bold Face loads are maximum.
Note: Due to the increased stress factors associated with light truck tires with a section width greater than 295 millimeters, higher load range constructions
are required at lower inflation pressures.
* Nominal Tire O. D. is a designated or theoretical size that may vary from the actual tire O. D.
ALWAYS USE APPROVED TIRE AND RIM COMBINATIONS FOR DIAMETERS AND CONTOURS.
_____________________________________________________________________________
8/7/2006
B27
Flotation
TIRE SIZE
DESIGNATION
17" Rim Diameter
33X12.50R17LT
35X12.50R17LT
36X14.50R17LT
37X12.50R17LT
37X13.50R17LT
38X13.50R17LT
38X15.50R17LT
40X13.50R17LT
18" Rim Diameter
35X12.50R18LT
35X13.50R18LT
36X14.50R18LT
37X12.50R18LT
37X13.50R18LT
38X15.50R18LT
20" Rim Diameter
37X12.50R20LT
40X13.50R20LT
25
30
35
40
45
50
32.5
34.5
35.5
36.5
36.5
37.5
37.5
39.5
8.5 - 11.0
8.0 - 11.0
10.0 - 12.0
8.5 - 11.0
8.5 - 11.0
8.5 - 11.0
11.0 - 13.0
8.5 - 11.0
SINGLE
SINGLE
SINGLE
SINGLE
SINGLE
SINGLE
SINGLE
SINGLE
1625
1875
2150
2150
2205
2405
2535
2680
1850
2155
2455
2470
2550
2715
2885
3055
2040 (C)
2405 (C)
2755
2755 (C)
2835
3000 (C)
3195 (C)
3195 (C)
2255
2625
2900
3005
2955
2440
2840
3050
3250
3075
2600 (D)
3000 (D)
3195 (D)
3525 (D)
3195 (D)
34.5
34.5
35.5
36.5
36.5
37.5
8.5 - 11.0
8.5 - 11.0
10.0 - 12.0
8.5 - 11.0
8.5 - 11.0
11.0 - 13.0
SINGLE
SINGLE
SINGLE
SINGLE
SINGLE
SINGLE
1820
1875
2095
2095
2150
2470
2075
2140
2370
2395
2470
2800
2335
2405
2600
2680
2755
3085
2530
2605
2885
2915
3005
3405
2735
2815
3115
3150
3250
3685
2910 (D)
3000 (D)
3305 (D)
3415 (D)
3525 (D)
3970 (D)
36.5
39.5
8.5 - 11.0
8.5 - 11.0
SINGLE
SINGLE
1930
2470
2225
2815
2470
3085
2705
3425
2925
3705
3085 (D)
3705 (D)
Note: Letters in parentheses denote Load Range for which Bold Face loads are maximum.
Note: Due to the increased stress factors associated with light truck tires with a section width greater than 295 millimeters, higher load range constructions
are required at lower inflation pressures.
* Nominal Tire O. D. is a designated or theoretical size that may vary from the actual tire O. D.
ALWAYS USE APPROVED TIRE AND RIM COMBINATIONS FOR DIAMETERS AND CONTOURS.
_____________________________________________________________________________
8/7/2006
B28
Numeric
Nominal Rim Width
Tire O.D. *
Range
7.00*15LT
29.6
5.0 - 6.5
7.50*16LT
31.8
5.5 - 7.0
8.00*16.5LT
28.3
6.00 - 6.75
8.75*16.5LT
29.5
6.00 - 6.75
9.50*16.5LT
30.6
6.75 - 8.25
8*17.5LT
31.0
5.25
USAGE
35
40
45
Radial Ply
55
60
50
65
70
75
80
60
1820 (D)
2040 (D)
2150 (D)
2470 (D)
1825 (D)
2040 (D)
2095 (D)
2405 (D)
2470 (D)
2835 (D)
2150 (D)
2470 (D)
65
1870
2130
2245
2560
70
1960
2220
2345
2670
75
2040 (E)
2335 (E)
2470 (E)
2755 (E)
2175
2470
2570
2920
2260
2575
2260
2570
2685
3050
2360
2685
2405
2680
2835
3195
2470
2835
30
1190
1350
1430
1620
1195
1360
1380
1570
1635
1860
35
1310
1480
1565
1770
1310
1490
1515
1720
1785
2030
1575
1790
40
1420
1610
1690
1930
1415
1610
1630
1850
1925
2190
1700
1940
45
1520 (C)
1710 (C)
1820 (C)
2040 (C)
1520 (C)
1765 (C)
1765 (C)
1985 (C)
2095 (C)
2405 (C)
1820 (C)
2095 (C)
50
1620
1830
1930
2190
1620
1840
1855
2110
2200
2500
1935
2205
55
1715
1940
2040
2310
1710
1945
1970
2240
2330
2650
2050
2335
(E)
(E)
(E)
(E)
(E)
(E)
* Tire size design will include "R" (Radial Ply) or (Diagonal or Bias Ply)
Note: Letters in parentheses denote Load Range for which Bold Face loads are maximum.
Note: Due to the increased stress factors associated with light truck tires with a section width greater than 295 millimeters, higher load range constructions
are required at lower inflation pressures.
* Nominal Tire O. D. is a designated or theoretical size that may vary from the actual tire O. D.
ALWAYS USE APPROVED TIRE AND RIM COMBINATIONS FOR DIAMETERS AND CONTOURS.
6/05
LTP-Metric
TIRE SIZE DESIGNATION
LTP215/70R14
LTP205/75R15
LTP215/75R15
LTP235/75R15
LTP255/70R15
5.5
5.0
5.5
6.0
6.5
7.0
7.0
7.0
8.0
8.5
USAGE
LOAD
INDEX
SINGLE
SINGLE
SINGLE
SINGLE
SINGLE
93
94
97
102
105
26
1220
1260
1370
1595
1715
29
1285
1330
1440
1680
1810
32
1350
1395
1510
1765
1895
35
1435 (B)
1475 (B)
1610 (B)
1875 (B)
2040 (B)
Note: Letters in parentheses denote Load Range for which Bold Face loads are maximum.
* Nominal Tire O. D. is a designated or theoretical size that may vary from the actual tire O. D.
_____________________________________________________________________________
8/7/2006
B29
38
2040 (B)
41
2040 (B)