You are on page 1of 7

CJC 11997

SAA HB87 1997

This is a free 6 page sample. Access the full version at http://infostore.saiglobal.com.

JOINT USE OF POLES


The placement on poles of power lines and paired cable telecommunications lines
This Arrangement has been prepared jointly by Telstra Corporation Limited and the Electricity Supply Association of Australia Limited and has been approved by both these bodies

This Publication was prepared jointly by Telecom Australia, now Telstra Corporation Limited, and the Electricity Supply Association of Australia and has been approved by both these bodies. It was published by Standards Australia on 5 February 1997.

Review of this Publication Suggestions for improvement to this Publication, addressed to the head office of Standards Australia are welcomed. Notification of any inaccuracy or ambiguity found in this Publication should be made without delay in order that the matter may be investigated and appropriate action taken.
This is a free 6 page sample. Access the full version at http://infostore.saiglobal.com.

This is a free 6 page sample. Access the full version at http://infostore.saiglobal.com.

JOINT USE OF POLES


The placement on poles of power lines and paired cable telecommunications lines

First published by ESAA and PMG 1965. Reprinted 1970. Reprinted 1972. Reprinted 1975. Revised and redesignated SAA HB87 1997 (CJC 1).

PRINTED BY STANDARDS AUSTRALIA (STANDARDS ASSOCIATION OF AUSTRALIA) 1 THE CRESCENT, HOMEBUSH, NSW 2140
ISBN 0 7337 0929 X

ii

PREFACE This Arrangement has been prepared by Telecom Australia (now Telstra Corporation) and the Electricity Supply Association of Australia (ESAA) under the auspices of the Central Joint Committee for Co-ordination of Power and Telecommunications Systems (CJC), as a basis for co-ordination where the activities of these bodies co-exist. However Telstra and member bodies of ESAA are not bound to accept the contents of this Arrangement in their work practices or procedures. It is acknowledged that different practices from those described may be equally satisfactory depending on site circumstances. The Arrangement sets out the conditions as agreed between the Electricity Supply Association of Australia Limited and Telstra Corporation Limited whereby the poles of an Electricity Supply Utility or the Telstra Corporation may be jointly used by both parties. The Arrangement consists of two parts, A and B. PART A Explains the interpretation and scope of the Arrangement and sets out the general administrative and financial conditions and procedures which govern its application. PART B Sets out the engineering conditions in the form of a Code of Engineering Practice for Joint Use Construction. This Arrangement revises and succeeds the previous Arrangement for the Joint Use of Poles which was adopted by the Electricity Supply Association of Australia and the former Postmaster-Generals Department of the Commonwealth of Australia on 7th September 1965. This Arrangement makes reference to Publications prepared jointly by ESAA and the Australian Telecommunications Commission (ATC) (subsequently Telecom Australia, now Telstra Corporation). Enquiries concerning these publications should be directed to either: Electricity Supply Association of Australia Limited PO Box 2537 SYDNEY NSW 2001 National Power Coordination Telstra Corporation 1/355 Spencer Street WEST MELBOURNE VIC 3003

This is a free 6 page sample. Access the full version at http://infostore.saiglobal.com.

Copyri ght

Telstra and ESAA/STANDARDS AUSTRALIA

Copyri ght of the information in this publication is jointl y owned by Telstra Corporation Ltd and the Electr icit y Supply Association of Australi a. All ri ghts are reserved. No part of this work may be reproduced or copied in any form or by any means (graphic, electronic or mechanical, including photocopying or informati on retr ieval systems) wit hout the wri tt en permission of the publi sher.

iii
CONTENTS

Page
PART A SECTION A1 INTERPRETATION 1 3 3 GENERAL

A1.1 DEFINITIONS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . A1.2 SCOPE OF THE ARRANGEMENT . . . . . . . . . . . . . . . . . . . . . . . . . . . . A1.3 CLASSIFICATION OF JOINT USE . . . . . . . . . . . . . . . . . . . . . . . . . . . . SECTION A2
This is a free 6 page sample. Access the full version at http://infostore.saiglobal.com.

GENERAL CONDITIONS . . . . . . .. .. .. .. .. .. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .. .. .. .. .. .. . . . . . . . . . . . . . . . . . . . . . . . . 5 5 5 5 5 6

A2.1 A2.2 A2.3 A2.4 A2.5 A2.6

REVIEW . . . . . . . . . . . . . . . . . . . . . . . . . . PREVIOUS JOINT USE ARRANGEMENTS OBLIGATIONS UNDER ACTS . . . . . . . . . . RESPONSIBILITIES . . . . . . . . . . . . . . . . . ENTITLEMENTS . . . . . . . . . . . . . . . . . . . . INDEMNITY . . . . . . . . . . . . . . . . . . . . . . . FINANCIAL CONDITIONS ... ... .. .. . . . . . . . . . . . .

SECTION A3 A3.1 A3.2 A3.3 A3.4

GENERAL . . . . . . . . . . . . . . . . . CHARGING PRINCIPLES . . . . . . NORMAL JOINT USE PAYMENTS SPECIAL JOINT USE PAYMENTS PROCEDURE .. .. .. .. .. .. ..

.. .. .. ..

. . . .

.. .. .. ..

. . . .

. . . .

. . . .

.. .. .. ..

. . . .

.. .. .. ..

. . . .

. . . .

.. .. .. ..

.. .. .. ..

. . . .

.. 7 .. 7 . . 10 . . 11

SECTION A4 A4.1 A4.2 A4.3 A4.4 A4.5 A4.6 A4.7

GENERAL . . . . . . . . . . . . . . . ARRANGING JOINT USE . . . . RENEWING JOINT USE . . . . . WORK ON JOINT USE POLES TERMINATION OF JOINT USE RECORDS . . . . . . . . . . . . . . . BILLING AND PAYMENTS . . .

. . . . . . .

.. .. .. .. .. .. ..

. . . . . . .

. . . . . . .

. . . . . . .

.. .. .. .. .. .. ..

. . . . . . .

.. .. .. .. .. .. ..

. . . . . . .

. . . . . . .

. . . . . . .

.. .. .. .. .. .. ..

. . . . . . .

.. .. .. .. .. .. ..

. . . . . . .

. . . . . . .

.. .. .. .. .. .. ..

.. .. .. .. .. .. ..

. . . . . . .

.. .. .. .. .. .. ..

12 13 13 14 14 14 15

iv
Page
PART B CODE OF ENGINEERING PRACTICE FOR JOINT USE CONSTRUCTION SECTION B1 SECTION B2 B2.1 B2.2 B2.3 B2.4 B2.5 B2.6 INTRODUCTION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 17 NORMAL JOINT USE . . . . . . . . . . . . . . . . . . .. .. .. .. .. .. . . . . . . .. .. .. .. .. .. . . . . . . . . . . . . . . . . . . .. .. .. .. .. .. . . . . . . .. .. .. .. .. .. . . . . . . . . . . . . .. ... ..... ..... ..... . .. .. . .. .. .. .. .. .. .. . . 18 18 19 20 25 25

This is a free 6 page sample. Access the full version at http://infostore.saiglobal.com.

GENERAL . . . . . . . . . . . . . . . . . . . . NORMAL JOINT USE POLES . . . . . . POWER UTILITYS CONSTRUCTION TELSTRAS CONSTRUCTION . . . . . . CLEARANCES . . . . . . . . . . . . . . . . . DIAGRAMS . . . . . . . . . . . . . . . . . . . SPECIAL JOINT USE

SECTION B3 B3.1 B3.2 B3.3 B3.4

GENERAL . . . . . . . . . . . . . . . . . . . . SPECIAL JOINT USE POLES . . . . . . POWER UTILITYS CONSTRUCTION TELSTRAS CONSTRUCTION . . . . . . MAINTENANCE

. . . .

. . . .

. . . .

. . . .

. . . .

. . . .

.. .. .. ..

. . . .

. . . .

. . . .

. . . .

. . . .

. . . .

.. .. .. ..

. . . .

. . . .

.. .. .. ..

.. .. .. ..

. . . .

.. .. .. ..

27 27 28 31

SECTION B4

B4.1 POLES . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 33 B4.2 JOINT USE ATTACHMENTS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 33 B4.3 SAFE WORKING CONDITIONS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 33

APPENDIX TELSTRAS ATTACHMENTS ON NORMAL JOINT USE POLES . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 35

This is a free preview. Purchase the entire publication at the link below:

This is a free 6 page sample. Access the full version at http://infostore.saiglobal.com.

HB 87-1997 (CJC 1), Joint use of poles: The placement on poles of power lines and paired cable telecommunications lines

Looking for additional Standards? Visit SAI Global Infostore Subscribe to our Free Newsletters about Australian Standards in Legislation; ISO, IEC, BSI and more Do you need to Manage Standards Collections Online? Learn about LexConnect, All Jurisdictions, Standards referenced in Australian legislation Do you want to know when a Standard has changed? Want to become an SAI Global Standards Sales Affiliate? Learn about other SAI Global Services: LOGICOM Military Parts and Supplier Database Metals Infobase Database of Metal Grades, Standards and Manufacturers Materials Infobase Database of Materials, Standards and Suppliers Database of European Law, CELEX and Court Decisions

Need to speak with a Customer Service Representative - Contact Us

You might also like