You are on page 1of 2

1# Which of the following describes this network. (Select two ) A. There are two broadcast domains in the network.

B. There are four broadcast domains in the network. C. There are six broadcast domains in the network. D. There are four collision domains in the network. E. There are five collision domains in the network. F. There are seven collision domains in the network. Answer: A, F 2# How many collision domains are present in the network? A. One B. Two C. Three D. Four E. Five F. Six G. Fourteen Answer: B 3# Which Layer 1 devices can be used to enlarge the area covered by a single LAN? (Select two) A. Switch B. Router C. NIC D. hub E. Repeater F. RJ-45 Answer: D, E 4# Which layer(s) of the reference model describes the operation of the following items?

A. Routers B. bridges 5# The MAC address for your PC NIC is: C9-3F-32-B4-DC-19. What is the address of the organizationally unique identifier (OUI) portion of this NIC card, expressed as a binary number? A. 11001100-00111111-00011000 B. 11000110-11000000-00011111 C. 11001110-00011111-01100000 D. 11001001-00111111-00110010 E. 11001100-01111000-00011000 F. 11111000-01100111-00011001 Answer: D
6# How would the number 231 be expressed as a binary number? A. 11011011 B. 11110011 C. 11100111 D. 11111001 E. 11010011 Answer: C 7 # In the ..mode: The switch reads the destination address before receiving the entire frame. The frame is then forwarded before the entire frame arrives. 8# The five components of a data communication system are the .., receiver, medium, .message, and protocol. 9# A ..protocol defines what is communicated, in what way and when. This provides accurate and timely transfer of information between different devices on a network.

10# The physical layer is responsible for transmitting a bit stream over a physical medium. While the .... layer is responsible for providing the physical addresses of the sender/receiver. 11# The ..Baseband transmission means sending a digital or an analog signal without modulation. While Broadband transmission means modulating a digital or an analog signal. 12# The wave length is the inverse of thefrequency if the propagation speed is fixed 13# In CSMA/CD, the protocol allows collisions to happen. If there is a collision, it will be detected, destroyed, and the frame will be resent. But .CSMA/CA uses a technique that prevents collision. 14# A .. forwarding port forwards a frame that it receives; a blocking port does not. 15# Crosstalk noise: It is commonly observed in telephones it has been able to hear other conversation 16# The three guided media used for data transmission are:.., .. and .. Twisted Pair Coaxial cable Optical fiber 17# The basic characteristics of switches and hubs for network connectivity. A. Switches take less time to process frames than hubs take. B. Switches do not forward broadcasts. C. Hubs can filter frames. D. Using hubs can increase the amount of bandwidth available to hosts. E. Switches increase the number of collision domains in the network. Answer E 18# What are the benefits of replacing a hub with a bridge and segmenting the network? A. It increases the number of collision domains. B. It decreases the number of collision domains. C. It increases the number of broadcast domains. D. It decreases the number of broadcast domains. Answer A 19# Which of the following about bridges and switches are true? (Choose three.) A. Switches are primarily software based while bridges are hardware based. B. Both bridges and switches forward Layer 2 broadcasts. C. Bridges are frequently faster than switches. D. Switches have a higher number of ports than most bridges. E. Bridges define broadcast domains while switches define collision domains. F. Both bridges and switches make forwarding decisions based on Layer 2 addresses. Answer B, D, F

You might also like