You are on page 1of 8

TO

VESSEL DETAILS REQUIREMENT PRIOR TO LIFTING : Murphy Sabah Oil Co., Ltd. Production Manager (603) 7490 8787

ATTENTION : FAX NO FROM DATE : : :

The following vessel details are required prior to acceptance to lift from the Kikeh Production Tanker. NOTES: 1)A legible copy of the forecastle deck arrangement plan must be supplied showing the proposed lead from the Panama fairlead to the winch drum. The plan shall be signed, stamped with the company name and dated to acknowledge that the plan is accurate and that all equipment shown is in service. 2) For YES or NO answers, tick the box that applies.

3) A copy of the completed Questionnaire and the forecastle plan must be sent to the Master of the Offtake Vessel. 4) NOTE: If the offtake tanker has a current OCIMF SIRE form this can be sent in place of the following questionnaire. SECTION 1.0 GENERAL VESSEL DETAILS 1. Name of vessel: .. 2. Previous Names, if any: .. 3. Port of Registry and/or Flag: .. 4. Name of Owner: ... 5. Registered Address: 6. Nationality of Officers and Crew: .. 7. Vessel Classification society / classed as: .. 8. Year of build: 9. Type of vessel. Crude Oil Tanker, Product Oil Tanker, Oil/Bulk Ore Carrier, etc..

If the vessel is an Oil/Bulk/Oil Carrier answer questions 9.1 and 9.2 9.1 What were the last three cargoes? ............................................................................................. 9.2 Are the following personnel familiar with oil carrying operations?

Master YES NO 1st Mate YES NO 2nd Mate YES NO Chief Engineer YES NO Second Engineer YES NO 9.3 Do the following personnel who are familiar with oil carrying operations have the appropriate endorsements to their certificates? Master YES NO 1st Mate YES NO 2nd Mate YES NO Chief Engineer YES NO Second Engineer YES NO 9.4 9.5 9.6 Is all equipment used on deck intrinsically safe in preventing ignition sources? YES NO Is there a permit-to-work system in place? YES NO Are there NO SMOKING regulations in place? YES NO

9.7 Are there at least two certified personnel on board to undertake Crude Oil Washing operations? YES NO 10. Call sign: 11. INMARSAT No. 12. Length overall (m): ... 13. Breadth (m): ...

14. Distance, bow to manifold (m): 15. Distance, ship side to manifold (m): .. 16. Diameter of manifold (m): ... 17. Diameters of available manifold reducers (mm): 18. Does the manifold and associated equipment comply with the latest edition of OCIMFs Standards for Oil Tanker Manifolds and Associated Equipment? .YES NO If NO, what does not comply .. 19. 19.1 Safe working load of manifold crane/derrick: .. Is the manifold crane/derrick positioned on the vessels centre line? YES NO

20. Are the vessels main engines capable of being run astern for prolonged Period of time at low engine revolutions YES NO 21. Summer/Tropical/Winter dead weight : .. 22. Cargo capacity at 98% full: 23. Maximum loading rate (m3/hr): .. 24. Arrival draughts (m): FWD/AFT 25. Has vessel Segregated Ballast Tanks (SBT)? .. YES NO 26. Has the vessel Clean Ballast Tanks (CBT)? . YES NO If YES, complete 26.1 and 26.2 26.1Does the vessel monitor ballast discharges from CBT using the oil in Water monitor that complies with the latest IMO (MARPOL) regulations? YES NO 26.2 Can vessel load and deballast simultaneously with two valve separation? YES NO

27. Has the vessel a panama lead on the forecastle head for acceptance of the mooring hawser? YES NO 28. Dimensions of the forward Panama lead that shall be Used for the mooring hawser .(mm) 29. Has vessel a chain stopper that complies with the latest edition of OCIMFs Recommendations for Equipment employed in the mooring of Ships at a single point mooring? YES NO

30.

Can chain stopper accept 76 mm diameter chain? YES NO

31. Distance, panama lead to chain stopper (m): .. 32. What is the lifting capability of the Mooring Winch? ... 33. Does the lead of the mooring hawser allow it to be hauled from the panama lead Via the chain stopper onto an empty drum? (Not the warping drum end) YES NO 34. Do the Senior Personnel speak English? .. YES NO

35. Does the vessel comply with the requirements of the International Transport Federation (ITF) Agreement? YES NO 36. Does the vessel have in place a Drug and Alcohol Policy complying with (as a minimum) the statement issued in the latest edition of the OCIMFs Guidelines for the Control of Drugs and Alcohol Onboard YES NO 37. 38. 39. 40. 41. Vessels last port of call? Protection and Indemnity (P & I) Club insuring the vessel? . What is the Pollution Liability Insurance limit? At which port may the Vessel be inspected by MSOCL representative? Is there a MSOCL Kikeh Berthing and Terminal Handbook(s) on board? YES NO

If YES what revision numbers? Revision number . 42. Does the vessel operate a management system certified to ISO 9002 Or equivalent? YES NO 43. Does the vessel have a dedicated helicopter winching area? YES NO

If YES complete Section 1.1 and Section 2.0 If NO, complete Section 2.0

SECTION 1.1 PUBLIC TRANSPORT HELICOPTER WINCHING DETAILS

1.

Where is the winching area located?: a) Bow / Forward / Amidships / Aft / Poop Deck b) Port / Starboard / Centre

2. What is the size of the winching area?: (Refer to Figure 1) a) What is the diameter of the Clear Zone?: (m) b) What is the diameter of the Intermediate Zone?: (m)

c) What is the diameter of the Maneuvering Zone?: (m)

3. Are the Clear Zone and the Maneuvering Zone circles marked and is WINCH ONLY marked?: YES NO If YES, what are the: Circle Diameters (m) Circle Colour Colour of the WINCH ONLY letters .. If NO, what is marked? . 4. Obstructions (Refer to figure 1) a) Plot all obstructions within the Maneuvering Zone on Figure 1 and state their heights. b) Are obstructions in the Maneuvering Zone marked with bright contrasting colours? YES NO

5. Fire Fighting Equipment Is the following fire fighting equipment or its equivalent available for all helicopter operations? a) At least 2 dry powder extinguishers with Aggregate capacity of not less than 45kg; YES NO b) Foam application system (fixed or portable) capable of delivering a foam solution at a rate of 6 litres per minute for each square meter of clear zone with sufficient foam compound to enable the rate to be maintained for at least five minutes; YES NO c) Carbon dioxide (CO2) extinguishers with an Aggregate capacity of not less than 18kg; YES NO d)Deck water system capable of delivering at least two jets of water to any part of the helicopter Operating area; YES NO e) At least two fire hose nozzles of the dual purpose type: YES NO f) Fire resistant blankets and gloves; YES NO g)At least two fire protective suits; YES NO h) Is all fire fighting equipment inspected, tested and in serviceable condition? YES NO

6. Rescue and Medical Equipment Is the following rescue and medical equipment in serviceable condition close to the helicopter operating area?: a) Large axe YES NO b) Crowbar YES NO c) Wire Cutters (Bolt Cutters) YES NO

d) First aid equipment YES NO

7. Is the following communication equipment available for all helicopter operations?: a) Marine VHF FM radio capable of transmission and Reception on Channel 16 and two other simplex working frequencies YES NO b) Portable radio transceiver (walkie talkie) capable of communication between deck and bridge. YES NO c) VHF AM Aeronautical radio 118-136 MHz YES NO If YES, specify the authorized frequency MHz

8. Is the following level of manning available for all helicopter operations?: a) Deck party officer-in-charge YES NO b) At least one person wearing a fire protective suit and two persons to attend fire fighting equipment and to act as a rescue party. YES NO

9. Is the ships rescue boat or lifeboat be capable of immediate lowering or launch? YES NO 10. Are ships personnel familiar with shipboard helicopter operations? YES NO If YES how many helicopter operations has the vessel handled in the last 12 months? 11. Does the vessel have the ICS (International Chamber of Shipping) Guide to Helicopter/Ship Operations Third Edition, May 1989 on board? YES NO 12. Does the P&I Club insurance in Section 1 Question 40 cover Aviation operations? YES NO

You might also like