You are on page 1of 3

NAME ____________________________

Skill Module Number: 18 Subject: DAS

Objective: The student will be able to access the Drive authorization and explain the listed values

Vehicle and tools required: 220 vehicle SDS

Required material: NONE

Instructions: 1. Follow the instructions and answer the questions. 2. Ask your instructor if assistance is needed. 3. Stop at Instructor checkpoints for sign-off. 508 Mod 18 DAS (WJB) 10-02-02 1

Drive authorization and Tip start function Using the SDS function menu, select Body >EIS > Actual values> Drive authorization 1. What value is listed for the EIS test counter? ____________________________ 2. What does that value mean to you? ___________________________________ 3. What is the actual value for: a. EIS control module receives the start message of key. _________________ b. Key data are being entered. ______________________________________ Insert a key from another vehicle. What is the actual value now? a. EIS control module receives the start message of key. _________________ b. Key data are being entered. ______________________________________ c. Insert proper key. 4. What is the current Key number inserted in EIS? ________________________ 5. Is there an actual value shown that indicates if the starter circuit (Circuit 50) is activated? _______________________________________________________ 6. In the Adaptations menu, select Activate EIS. What message do you get when you try to activate the EIS? _________________________________________

Instructor checkpoint ______


Using the Control unit groups, select Drive > ME-SFI > Actual values > Check drive Authorization. 7. How many actual values are listed? ___________________________________ 8. What would It mean if Start enable actual value was no? ________________________________________________________________ ________________________________________________________________ Go to: Drive > ESM > Actual Values > Drive Authorization. 9. What value is listed for the ESM test counter? ___________________________ 508 Mod 18 DAS (WJB) 10-02-02 2

10. If the transport protection of control module ESM is deactivated reads no what is the corrective action that the technician should take? ________________________________________________________________ ________________________________________________________________ Instructor checkpoint ____________ Match the following terms with the correct definition: 8. Authentication Test A. - Same as marrying the component to the vehicle. Cannot be personalized to another vehicle. B. Second and third set of keys available for the vehicle with rolling codes: 20,001-400,000 and 400,001-600,000 C. First keys available with vehicle containing rolling codes 1-200,000. D. Limits the duration of test mode when count reaches 0. E. The EIS is reading the key checking codes. The key is released for turning coil power then turned off. F. Second part of code sent out by key changes with each authentication test. G. Special tool for personalizing EIS to the vehicle. H. Must be deactivated for the EIS to have long term function. I. Storage of security-relevant vehicle specific data which allows part to be used in vehicle.

9. Green Key

10. Personalization 11. Activated 12. Transport Protection

13. First Generation Key 14. Replacement Key 15. Rolling code 16. Test counter

If you have noticed any parts that need to be replaced on this vehicle, please inform your instructor now. Instructor check point ______________ 3

508 Mod 18 DAS (WJB) 10-02-02

You might also like