You are on page 1of 1

On Fluorocarbon Coating Aluminium

ver the years, the aluminum surface treatment is anodized. As Oxidation production is in the process of putting the aluminum into the oxidation bath to clean, color and seal. The oxidation bath is prepared from a variety of chemical elements. It oxides each batch of aluminum, the chemical composition of the bath are changing, so the bath is a variable value and the color of the oxided aluminum always has chromatic aberration. So aluminum curtain wall can never use anodic oxidation to do the treatment. This treatment problem has been bothering aluminium profile suppliers until the generation of electrostatic spraying which solves the problem of the surface treatment of aluminum curtain walls, not only making the color difference become small and aluminum with a variety of colors available. Electrostatic spraying is divided into two kinds: powder coating and fluorocarbon coating. Fluorocarbon coating is high-end with higher price. It is widely used in aluminum curtain walls. Due to its excellent features, it is getting more and more construction users attention and favor. fluorocarbon coating aluminium is with excellent resistance, fade resistance, frost resistance, air pollution (acid rain) corrosive, strong anti-UV ability and crack resistance which can withstand harsh weather conditions. Fluorocarbon aluminum plates have Fluorocarbon coating aluminum and fluorocarbon coating pre-roll. The following is the introduction of fluorocarbon coating plate. Fluorocarbon coating board is divided into two-coat paint system, three-coat paint system and the four-coat systems. General speaking, the multi-layer coating system should be adopted. Two-coat system: composited by 5 ~ 10m fluorocarbon primer and 20 ~ 30m fluorocarbon finish, the total film thickness is not less than 35m. It can only be used for the general environment. Three-coat system: composited by 5 ~ 10m fluorocarbon primer, 20 ~ 30m fluorocarbon paint and 10 ~ 20m fluorocarbon varnish and the total film thickness is not less than 45m. It is for air pollution, industrial areas and harsh environments such as coastal areas. Four-coat systems: There are two kinds of four-coat system. When large particles of aluminum pigments are used, it requires 20m fluorocarbon intermediate coat paint between the primer and the creation. The other is added in a coat between the primer and the polyurethane blends of polyamide dense coating to improve corrosion resistance, increasing the life of fluorocarbon aluminum. Because the general fluorocarbon sponge structure, porosity, cannot prevent the free positive and negative ions in the air to penetrate to the metal plate grassroots. Therefore, this coating system is more suitable for air pollution, harsh industrial areas and coastal zone environment. aluminium curtain wall suppliers, Fluorocarbon Coating Aluminium, Aluminium Alloy Window

You might also like