Professional Documents
Culture Documents
Unlead. Gas.
JFA
MTBE
Gasoil
Slops
Custom 1
Custom 2
Custom 3
Custom 4
Custom 5
U
J
M
GO
SL
C1
C2
C3
C4
C5
0.7499
0.8203
0.7471
0.8524
0.9130
1.0000
1.0000
1.0000
1.0000
1.0000
FF007F007F00
7F007F00FF00
F600FA00C900
FF00FF007F00
FF006F00FF00
D6000300D600
D600D6000300
0300D600D600
D60003000300
DF00DF00DF00
If you make an error, you can always reset the densities to their default values in the
Densities dialog.
Also see:
Windows Registry on page 16
Waveform
Page 152
Once a wavelength has been set, the wave height may be modified.
The phase offset governs the position of the wave crest aft of the forward end of the
DWL, as a proportion of the wavelength. The phase offset varies between 0 and 1, both
of which correspond to a wave crest at the forward end of the DWL.
For example, a phase offset of 0.5, with a wavelength equal to the waterline length, will
give a single wave crest at amidships.
Grounding
Page 153
Note:
Grounding points are considered to span the transverse extents of the hull
and therefore constrain the heel to zero. The length of the grounding points
is only used when considering the load distribution for Longitudinal
Strength analysis and not to determine the pivot point. The vessel is
considered to pivot at the centre of the grounding point.
When two grounding points are entered, the first point (edit boxes on the
left) must refer to the forward grounding point; the second grounding point
is the aft grounding point.
Stability criteria may be seen as the environment of authorities that the ship will be
deployed in.
For more information see Chapter 4 Stability Criteria starting at page 163.
Damage
You can specify whether the model is to be analysed in intact or damaged condition
using the Analysis Toolbar.
Also see:
Damage Case Definition on page 71
Page 154