Professional Documents
Culture Documents
constructive solutions
Dosage
Advantages
Properties
Appearance:
Specific gravity:
Chloride content:
Air entrainment:
Alkali content:
Standard compliance
Conplast P510M complies with BS5075 Part 1 and with
ASTM C494 as Type A and Type D, depending on dosage
used.
Conplast P510M complies with the requirements of the
United Kingdom Water Fittings Byelaws Scheme and is
listed in the Directory of Materials as suitable for use in
contact with potable water.
Description
Conplast P510M is a chloride free water reducing admixture
based on a blend of selected lignosulphonate and
hydrolysed carbohydrate materials. It is supplied as a
brown solution which instantly disperses in water.
Brown liquid
o
Typically 1.230 at 20 C
Nil to BS5075
Typically less than 2% additional
air is entrained at normal
dosages
Typically less than 4.0 g. Na2O
equivalent per litre of admixture.
A fact sheet on this subject is
available
Page 1
Conplast P510M
b) Low temperatures will give higher levels of retardation
for the same admixture dosage. This is particularly
noticeable if cement replacement materials are used.
Precautions
Dispensing
The correct quantity of Conplast P510M should be
measured by means of a recommended dispenser. The
admixture should then be added to the concrete with the
mixing water to obtain the best results. Contact Fosroc for
advice regarding suitable equipment and its installation.
Fire
Effects of overdosing
Estimating - Packaging
Conplast P510M is available in drum or bulk supply. For
larger users, storage tanks can be supplied.
Storage
Conplast P510M has a minimum shelf life of 12 months
o
provided the temperature is kept within the range of 2 C to
o
50 C. Should the temperature of the product fall outside
this range then the Fosroc Sales Support Department
should be contacted for advice.
Important note:
Fosroc products are guaranteed against defective materials and manufacture and are sold subject to its standard Conditions
for the Supply of Goods and Services, copies of which may be obtained on request. Whilst Fosroc endeavours to ensure that
any advice, recommendation, specification of information it may give is accurate and correct, it cannot, because it has no direct
or continuous control over where or how its products are applied, accept any liability either directly or indirectly arising from the
use of its products, whether or not in accordance with any advice, specification, recommendation of information given by it.
www.fosroc.com
email: fosam@fosroc.com
Regional Offices
Jeddah Sales Office
Jeddah Showroom
Riyadh
Dammam
Khamis Mushayt
Registered Office: Industrial Area, Phase 4, Road No. 414, Street No. 407
Page 2
FO SA/CONPLAST P510M/05/A