You are on page 1of 8

Day 1

1)
2)
3)
4)
5)
6)
7)
8)
9)
10)
11)
12)

13)
14)
15)

16)
17)

18)
19)

20)

Number of carbon atoms in olvanil


Who discovered x-ray?
Amino acids in human protein
Definition of ozonolysis
Given dimensions of a peso bill (length & width). Assuming billion of gold atoms can be spread
across its length, determine total mass.
Freezing point depression
Boiling point rise
Evaluate given structural formulas (paraffins)
Center of an atom
Balancing chemical reactions
Given density of Sulfuric acid determine its molarity
Given a high-rating octane fuel
-mileage (mi/gal)
-density
-distance covered
Calculate CO2 produced
Blanket of pollutants
Pollutant produced from coal and petroleum
Nearest layer of atmosphere from earths surface
a) Troposphere
b) Stratosphere
c) Mesosphere
d) Thermosphere
pH problems (buffer)
pH problem:
Given NH4OH soln initially at 30 mL diluted to 400 mL then titrated with HCl. Compute pH
a) at the start
b) at the equiv point
c) after addition of 40 mL of HCl
Ksp problems (2)
Metabolic reactions
For 12 mold of ATP produced from every mole CH3COO- there are 7.4 kcal. For 1 gram of
CH3COO- determine
Edman Degradation (sequencing of amino acids)

Day 2
Problem 1.7 Coulson and Richardson
A cyclone separator, 0.3 m in diameter and 1.2 m long, has a circular inlet 75 mm in diameter and an
outlet of the same size. If the gas enters at a velocity of 1.5 m/s, at what particle size will the theoretical
cut occur? The viscosity of air is 0.018 mN s/m2, the density of air is 1.3 kg/m3 and the density of the
particles is 2700 kg/m3.
Using the data provided:
cross-sectional area at the gas inlet, Ai = (/4)(0.075)2 = 4.42 103 m2
gas outlet diameter, d0 = 0.075 m
gas density, = 1.30 kg/m3
height of separator, Z = 1.2 m, separator diameter, dt = 0.3 m.
Thus: mass flow of gas, G = (1.5 4.42 10 3 1.30) = 8.62 103 kg/s
The terminal velocity of the smallest particle retained by the separator,
u0 = 0.2Ai2d0g/(ZdtG)

(equation 1.54)

or: u0 = [0.2 (4.42 103)2 0.075 1.3 9.81]/[ 1.2 0.3 8.62 10 3]
= 3.83 104 m/s
Use is now made of Stokes law (Chapter 3) to find the particle diameter, as follows:
u0 = d2g(s )/18

(equation 3.24)

or: d = [u0 18/g(s )]0.5


= [(3.83 104 18 0.018 103)/(9.81(2700 1.30))]0.5
= 2.17 106 m or 2.17 m
Note tas may tanong pa na ano daw yung particle size na papasok sa cylone at yung mareretain sa
bottom something parang ganun.

PROBLEM 6.14 Coulson and Richardson


Glass spheres are fluidised by water at a velocity equal to one half of their terminal falling velocities.
Calculate:

(a) voidage
(b) the density of the fluidised bed,
(c) the pressure gradient in the bed attributable to the presence of the particles.
The particles are 2 mm in diameter and have a density of 2500 kg/m3. The density and viscosity of water
are 1000 kg/m3 and 1 mNs/m2 respectively. (sa original na tanong given naman yung galileo no.)
Solution
The Galileo number is given by:
Ga = d3(s )g/2
= [(2 103)3 1000(2500 1000) 9.81]/(1 103)2
= 117,720
From equation 5.79:
(4.8 n)/(n 2.4) = 0.043Ga0.57
= 0.043 117,7200.57 = 33.4
and: n = 2.47
u/u0 = 0.5 = e2.47
and hence: e = 0.755
The bed density is given by:
(1 e)s + e = (1 0.755) 2500 + (0.755 1000)
= 1367 kg/m3
The pressure gradient due to the solids is given by:
{[(1 e)s + e] }g = (1 e)(s )g
= (1 0.755)(2500 1000)9.81
= 3605 (N/m2)/m

PROBLEM 14.13 (Coulson and Richardson)


A liquid with no appreciable elevation of boiling-point is concentrated in a triple-effect evaporator. If the
temperature of the steam to the first effect is 395 K and vacuum is applied to the third effect so that the
boiling-point is 325 K, what are the approximate boiling-points in the three effects? The overall transfer
coefficients may be taken as 3.1, 2.3, and 1.1 kW/m2 K in the three effects respectively.
Solution
For equal thermal loads in each effect, that is Q1 = Q2 = Q3, then:
U1A1T1 = U2A2T2 = U3A3T3

(equation 14.7)

or, for equal areas in each effect:


U1T1 = U2T2 = U3T3

(equation 14.8)

In this case:
3.1T1 = 2.3T2 = 1.1T3
Thus: T1 = 0.742T2 and T3 = 2.091T2
T = T1 + T2 + T3 = (395 325) = 70 deg K
Thus: 0.742T2 + T2 + 2.091T2 = 70 deg K and T2 = 18.3 deg K
and: T1 = 13.5 deg K, T3 = 38.2 deg K
The temperatures in each effect are therefore:
T1 = (395 13.5) = 381.5 K
T2 = (381.5 18.3) = 363.2 K, and T3 = (363.2 38.2) = 325 K
Example 13.5 (Coulson and Richardson)
In order to extract acetic acid from dilute aqueous solution with isopropyl ether, the two immiscible
phases are passed countercurrently through a packed column 3 m in length and 75 mm in diameter.
It is found that, if 0.5 kg/m2s of the pure ether is used to extract 0.25 kg/m2s of 4.0 per cent acid
bymass, then the ether phase leaves the column with a concentration of 1.0 per cent acid by mass.
Calculate:
(a) the number of overall transfer units based on the raffinate phase, and
(b) the overall extraction coefficient based on the raffinate phase.

(pero ang tanong sa min eh, what daw ung conc. Ng acid sa raffinate, logarithmic driving force and no.
of transfer unit)
The equilibrium relationship is given by: (walang given na ganito)
(kg acid/kg isopropyl ether) = 0.3 (kg acid/kg water).

Note: Sa board exam di sinabi kung ilan yung retention na 2 kg insoluble matter/1kg solution
kenneth eto lang yun naaala ko
pero may mga ganito pa,
1.

super heated steam daw tas papasok sa nozzle, tapos may given na P1 P2 at T1, ang tinatanong eh
enthalpy at temp T2. (Over-all Energy Balance Problem)

2.

may lumabas ding fluid flow, sabi ni hero nasa mccabe daw xa, kaso nagulat xa kc iba ung sagot sa mccabe
eh same na same naman daw ang tanong pati given.
Example 4.6 (McCabe and Smith)
A pump draws a solution of specific gravity 1.84 from a storage tank through a 3 in. (75-mm) Schedule 40
steel pipe. The efficiency of the pump is 60 percent. The velocity in the suction line is 3 ft/s (0.914 m/s).
The pump discharges through a 2-in. (50-mm) Schedule 40 pipe to an overhead tank. The end of the
discharge pipe is 50 ft (15.2 m) above the level of the solution in the feed tank. Friction losses in the entire
piping system are 10 ft lbf/lbm (29.9 J/kg). What pressure must the pump develop? What is the power
delivered to the fluid by the pump?

3.

Yung TIo2 na tinuro mo Kenneth


TiCl4 can be formed by reacting titanium dioxide (TiO2) with hydrochloric acid. TiO2 is available as an ore
containing 78 % TiO2 and 22 % inerts. The HCl is available as 45 wt% solution (the balance is water). The per
pass conversion of TiO2 is 75 %. The HCl is fed into the reactor in 20 % excess based on the reaction. Pure
unreacted TiO2 is recycled back to mix with the TiO2 feed.
TiO2 + 4 HCl TiCl4 + 2 H2O
For 1 kg of TiCl4 produced, determine:
a. the kg of TiO2 ore fed.
b. the kg of 45 wt % HCl solution fed.
c. the ratio of recycle stream to fresh TiO2 ore (in kg).
(MW : TiO2 79.9; HCl 36.47; TiCl4 189.7)

4.

Yung production ng ammonia, ung sinabi ko sau Kenneth, may given given na mass nila, tas tinatanong
mga conversion something etc.
The synthesis of ammonia proceeds according to the following reaction
N2 + 3 H2 -----> 2 NH3
In a given plant, 4202 lb of nitrogen and 1046 lb of hydrogen are fed to the synthesis reactor
per hour. Production of pure ammonia from this reactor is 3060 lb per hour.
a. What is the limiting reactant.
b. What is the percent excess reactant.
c. What is the percent conversion obtained (based on the limiting reactant).

5.

Liquid fuel combustion, may given na 20% excess air, tas sa fuel eh binigay ang % w/w ng carbon,
hydrogen, oxygen at nitrogen. Tinatanong ang moles ng co2 sa fuel gas. 02 na issupply given na 20% xs
air. May given din mga calorific value something, ung pangatlong tanong gagamitin ung mga data ng
calorific value something

6.

Ang isa pang multi effect evap. Given naman xa maxado, kukunin mo lang yung V1 na mag eevaporate sa
unang evaporator. Tas amount na pasok sa evaporator 2 tas ang pangatlo eh area ang hinahanap

7.

Absorption ng sulfur something, may given na recovery. Water ang absorpption medium. Tapos ung water
with sulfur eh magrereact sa NaOH para marecover yung sulfur. May amount na given sa sulfur sa
product, tas ayun stoic stoic ata gagamitin ditto. (MATERIAL BALANCE)

8.

Thermo. 2 given na tanks, tas magkakonek cla sa pamamagitan ng isang tube something, tas initially ung
tank1 eh may given na pressure na given at temp. tapos ayun tanong eh wat temp at pressure pag equal
na volume dun sa tank 1 at 2. Parang ganun. (haha ang gulo)

9.

Simpleng PV=nRT (buti na lang meron neto,)

10. Conversion ng units, pero may halong pagkachecal xa


Conversion of units ng kinetic energy

11. 3 Heat of reaction na heat of formation yung given


12. Given eh 57.8 mole % hexane, 8.9 heptane, tas 33.3 steam. Tas may given na Antoine sa hexane at
heptane. Pero kakaiba ba xa kc A and B lang yung constant. Tas ayun ang tanong temp ng first liquid na
magcocondensed, tas temp ng 2nd liquid na mag cocondensed tas ano daw yung conc. Product after nun

You might also like