Professional Documents
Culture Documents
www.andhracolleges.com
⋆⋆⋆⋆⋆
www.andhracolleges.com
Figure 1:
3. (a) Explain how to obtain the B-H curve of a magnetic material. What does that
curve indicate?
(b) A steel magnetic circuit has an uniform cross sectional area of 6 cm2 and
length 60cm. A coil of 300 turns is wound uniformly over the magnetic circuit
When the current in the coil is 1A, the total flux is 0.3 mwb. and when the
current is 5A, the flux, is 0.6m wbs. Calculate The magnetic field strength
and relative permeability in each case. [8+8]
www.andhracolleges.com
ii. the voltage across the coil, Draw the phasor diagram. [8+8]
8. With a neat sketch explain in detail moving iron attraction type instrument. [16]
⋆⋆⋆⋆⋆
www.andhracolleges.com
Seminar Topics - Scholarships - Admission/Entrance Exam Notifications
2 ofUSA-UK-Australia-Germany-France-NewZealand
2 Universities List
www.andhracolleges.com
⋆⋆⋆⋆⋆
www.andhracolleges.com
calculate the mean value of the EMF induced in the coil. [4+3+3+6]
4. (a) Derive an expression for the EMF generated by a two pole alternator.
(b) What is the difference between electrical and mechanical degrees? What is
the relation between them.
(c) Give the polar form of the expression 8+J2
J2
. [8+4+4]
5. What are the different losses occuring in a transformer on load. How can these
losses be determined experimentallty. [16]
Seminar Topics - Scholarships - Admission/Entrance Exam Notifications
USA-UK-Australia-Germany-France-NewZealand Universities List
1 of 2
www.andhracolleges.com Engineering-MBA-MCA-Medical-Pharmacy-B.Ed-Law Colleges Information
www.andhracolleges.com The Complete Information About Colleges in Andhra Pradesh
7. Explain with the help of suitable diagrams how rotating magnetic field is produced
in a three phase induction motor. [16]
www.andhracolleges.com
8. (a) Discusss the classification of electrical instruments.
(b) Explain the significance of controlling torque and damping torque relevant to
the operation of indicating instruments. [8+8]
⋆⋆⋆⋆⋆
www.andhracolleges.com
Seminar Topics - Scholarships - Admission/Entrance Exam Notifications
2 ofUSA-UK-Australia-Germany-France-NewZealand
2 Universities List
www.andhracolleges.com
⋆⋆⋆⋆⋆
1. A Wheatstone Bridge consists of AB=4 ohms, BC=3 ohms, CD= 6 ohms and
DA= 5 ohms. A 2v cell is connected between A and C. Find the current through
galvanometer connected between B and D. as shown in figure 1 [16]
Figure 1:
www.andhracolleges.com
2. (a) Three equal resistances of value R ohms are connected in a delta (mesh)
fashion. as shown in figure 2 If this is to be replaced by an equivalent star
connected resistances R1 R2 and R3 . what are the values of R1 , R2 , & R3 in
the terms of R.
(b) Calculate the equivalent delta connected resistances values for the following
star connected resistances. [8+8]
Figure 2:
3. (a) What do you understand by the terms “ Hysteresis loss” and derive an ex-
pression for the same in a magnetic material.
Seminar Topics - Scholarships - Admission/Entrance Exam Notifications
1 ofUSA-UK-Australia-Germany-France-NewZealand
2 Universities List
www.andhracolleges.com
iii. Average value
iv. Form factor.
(b) A coil having a resistance of 10 ohms and an inductance of 0.2H is connected
in series with a 100×10−6 F capacitor across a 230V, 50Hz supply, Calculate
i. The active and reactive components of the current
ii. the voltage across the coil, Draw the phasor diagram. [8+8]
5. Draw the phasor diagrams of a transformer at no load and full load lagging power
factor conditions and explain the operation of a transformer. [16]
8. With a neat sketch explain in detail moving iron repulsion type instrument. [16]
www.andhracolleges.com
⋆⋆⋆⋆⋆
www.andhracolleges.com
⋆⋆⋆⋆⋆
Figure 1:
www.andhracolleges.com
3. (a) Derive an expression for the energy stored in a magnetic field
(b) Two coils with self inductance L1 and L2 Henrys are connected in series aiding,
and the net inductance is found to be 6 henrys and in series opposition (differ-
ential) the net inductance is found to be 2 henrys. If the coefficient of coupling
between the two coils is 0.5, Calculate the self and mutual inductances. [8+8]
5. (a) Define voltage regulation of a transformer. Deduce the expression for the
voltage regulation.
(b) The number of turns on the primary and secondary windings of a single phase
transformer are 350 and 35 respectively. If the primary is connected to a 2.2
KV 50 HZ supply determine the secondary voltage. [8+8]
www.andhracolleges.com
8. Explain the following with reference to the indicating instruments
⋆⋆⋆⋆⋆
www.andhracolleges.com
Seminar Topics - Scholarships - Admission/Entrance Exam Notifications
2 ofUSA-UK-Australia-Germany-France-NewZealand
2 Universities List