You are on page 1of 4

INDIAN AEROSPACE & ENGINEERING

Class Test - PAPER-1 SERIES-X


1.

4-3-16

When a flame is applied for a limited period and removed, the material shall self extinguish within a specified time is known as:
a.
flame resistant
b.
flame retardant
c.
self extinguishing
d.
any one of above

2.

Flame resistant means


a.
not susceptible to combustion
b.
as in (a) and to the point of propagating a flame after ignition source is removed
c.
as in (a) and after ignition source is removed after 10 minutes
d.
none of the above

3.

Each receptacle for towels, paper or waste in toilets of a/c should be constructed
a.
of material resistant to fire
b.
of material like steel which does not catch fire
c.
of material which are self extinguishing type
d.
any of the above

4.

Concession approval should be preserved for future reference for


a.
as long as period as the log books are kept
b.
c.
a period of 2 years from the date of approval
d

a period of 5 years
a period of 6 months

5.

Whenever materials/parts (covered under concession) are used


a.
the related documents like log books, procedure sheets etc. must make a mention of the same
b.
no requirement of mentioning the concession
c.
parts must be replaced when concession period is over
d.
any one of above

6.

Which of the following statements is/are correct?


a.
contents of every page of FRB are required to be approved by RAO
b.
FRB is always not required to be carried on board for all flights
c.
it is an equivalent document to A/c log book
d.
all of the above

7.

In respect of each newly manufactured aircraft, engine or propeller, log book is issued by
a.
manufacture along with the release documents
b.
as in (a) and if not issued, owner operator may raise a log book on his own
c.
as in (b) and each log book shall be in three section
d.
as in (b) and each log book shall be in triplicate

8.

The routine inspection mentioned on the log book may be identified by


a.
identification number mentioned on the front page of log book
b.
identification code mention on the preface of log book
c.
identification number mentioned on the routine inspection schedule

9.

d.

Which of the following statement is/are correct?


a.
in an approved firm operator is responsible for proper maintenance of log book
b.
in case of private aircraft QCM is responsible for proper maintenance of log book
c.
omission in log book entries shall render aircraft un-airworthy
d.

any one of the above

all are correct

10.

Flight time of helicopter means total time from the movement


a.
the rotor blade start turning until the moment it finally comes to rest at the end of flight and rotor blades are stopped
b.
the rotor blade is set for collective pitch to take off and till it is set to neutral at touch down
c.
hovering to touch town
d.
any one of above

11.

Which of the following statement is correct in case of log book preservation?


a.
it is preserved till cancellation of C of A
b.
in case aircraft meeting accident and it is beyond economical repair the log books are preserved for a period of two year from
the date of completion of investigation
c.
both (a) and (b) are correct
d.
none of the above

12.

Mark the correct statement


a.
the content of JLB is approved Board of Officers
c.
1st page of JLB will be issued by manufacturer

13.

b.
d.

1st page of JLB will be issued by DGCA


1st page of JLB is issued by QCM

State the correct statement/s


a.
in case a document has been submitted to a competent authority for renewal, that fact shall be deemed as valid excuse for not
carried on board
b.
in any case document to be procured and to be kept in aircraft as a photocopy, if original is submitted to authority
c.
original documents need not be sent to authority can be renewed by producing a certificate from operator
d.
none of the above

14.

15.

Mark the correct statement (Passenger safety information card)


a.
make use of symbols to convey instruction
b.
c.
as in (b) and also show restrictions on smoking d.

as in (a) and included use of evacuation slides


none of the above

Number of flight crew to be carried for test flight is given in


a.
operation manual
b.
flight manual

c.

M.S. manual

d.

all of the above

16.

Which of the following statement/s are correct?


a.
taxi permit is issued to the person holding valid licence in Cat. C covering the type of engine installed
b.
taxi permit is issued to person holding valid RT licence
c.
taxi permit is issued to the person holding Cat. B licence d.
both (a) and (b) are correct

17.

Damage caused to the aircraft during taxing operation shall be intimated promptly to
a.
owner/operator
b.
as in (a) and owner should intimate such damage to concerned Regional Airworthiness Office
c.
as in (b) and owner should give a copy to manufacturer for remedial action
d.
none of the above

18.

Standard weight of crew is


a.
85 kg

b.

75 kg

c.

(85 + 5) 90 kg

d.

19.

Which aircraft rule requires that every aircraft shall be weighted and its CG determined?
a.
Aircraft Rule 36 of 1937
b.
Rule 58 of Aircraft Rule, 1937
c.
Rule 15 of Aircraft Rule 1937
d.
Rule 25 of Aircraft Rule 1937

20.

Weight schedule shall be prepared by


a.
by appropriately licensed AME in Cat. R
c.
by a person approved for the purpose

21.
22.
23.
24.
25.

26

b.
d.

none of above

by appropriately licensed AME in Cat. B


both (b) and (c) are correct

Which of the following is included in empty weight of aircraft?


a.
fixed ballast
b.
engine coolant
c.

hydraulic fluid

d.

all of the above are correct

Standard weight of Infant


a.
10 kg

15 kg

d.

none of above

3 FAK

d.

4 FAK

b.

12 kg

c.

An aircraft passenger carrying capacity 160 shall be equipped with


a.
1 FAK (First Aid Kit)b.
2 FAK
c.

A material not susceptible to combustion, the point of propagating a flame after ignition source is removed:
a.
self extinguishing
b.
flame resistance c.
fire resistant
d.
Which rule requires that all aircraft registered in India must have Nationality &
Registration markings
a)
Rule 133 A
b)
Rule 60
c)

Rule 15

d)

all the above

Rule 37

Rule 58 of Aircraft rules 1937 requires that


a) All Indian registered aircraft should affix identification plate with nationality marking
b) Every aircraft shall be weighed and its CG determined
c) Deals with size and location of nationality and registration makings
d) Every aircraft shall be fitted with instruments and equipments.

27.

Empty weight means


a) Measured or computed weight of an aircraft with weight of all items of fixed operating equipment or other equipment which
are mandatory.
b) Weight of an aircraft excluding the weight of all removable equipment and other items of disposable load.
c) Both a & b
d) Lot of an aircraft which is empty of all pay load.

28.

Maximum take-off weight (MTOW)


a) Is the maximum weight with which the aircraft can take-off
b) Is the maximum permitted take off weight as per C of A or flight manual
c) Is the maximum weight of total load or passengers which can be carried on board
d) None of the above

29.

Aircraft of weights below 2000 kgs


a)
Should be reweighed during C of A renewal
c)
Should be reweighed yearly once

b.
d.

Need not be reweighed on routine basis


None.

30

Mark the correct sentence regarding reweighing of aircraft of AUW above 2000kgs
a)
Reweighing every year during C of A renewal
b)
Extension of 4 months or below can be granted by regional Airworthiness office for reweighing periods
c)
Extension up to 3 months for reweighing can be granted by Sub-RAO.
d)
Shall be reweighed every five years.

31.

An aircraft shall be required to be reweighed if


a)
It has under gone major repair
c)
A major alteration has been done

32.
33.

34.

35.
36.
37.
38
39
40

b.
d.

Major changes in cargo compartments effecting weight and balance


All above

The weight schedule will be prepared by a appropriately licensed AME in


a)
Cat A
b)
Cat B
c)
Cat X
Weight schedule should contain
a)
Registration marking and serial no. of aircraft
b)
Maximum usable fuel capacity
c.

category
d)

Type of aircraft

d.

Mark the correct sentence regarding weight schedule


a) It will have date of weighment with signature of licensed AME/approved person
b) Maximum number of passengers
The weight schedule will be approved by
a)
RAO
b)
DGCA Hqs

Cat D

All above

b. It will record empty weight CG


d. All above

c. QCM of schedule airlines

d)

Director of Airworthiness

Rule requires that every aircraft shall be fitted and equipped with instruments and equipments.
a)
Rule 58
b)
Rule 57
c)
Rule 60
d)

Rule 37

Transport aircrafts are type certificated to


a)
FAR 25/JAR 25 standard b)

d)

Major modifications affect


c) Weight of aircraft

b)

FAR 33 standard

c)

Change in design c.

Major repair if improperly carried out will affect


a) Weight of aircraft
b)
Centre of gravity

c.

FAR 23 standard

Change in flight characteristics


Change in design

None.
d) All above

d. Flight characteristics

Requests for grant of concessions relating to use of materials/parts in cockpit door will be given by
a)
DGCA Hqs. Though RAO
b.
DGCA Hqs. Directly
b) QCM of organization approved in category A & B

c.

RAO

41.

Mark the correct sentence


a) Requests for concessions relating to fuel system will be disposed of by RAO
b) Requests for concessions relating to hydraulic power system will be disposed of by RAO
c) Concessions relating to landing gear system will be authorized by QCM of approved firms with specific approval for such
delegations, under intimation to RAO
d) None of there.

42.

All aircraft registered in India shall have aircraft log book is mandated in
a) Rule 57
b)
Rule 67
c)
Rule 47

43. The third section of Radio apparatus log book will have
a)
Modification status
b)
c)
Flight release inspection records
d)
44

When an engine is removed from the aircraft


a)
Entry should be made in Aircraft log book
b)
Entry should be made in Engine log book

d)

Rule 77

Major repair records


Replacement records.
b)Entry should be made in Journey logbook
d)Both a and c are correct

45. When a component, not having an individual log book, is removed


a)
Entry should be made in Aircraft log book
b.
Entry should be made in journey log book
c)
Entry should be made in Flight log book
d)
A new log book is to be made and removal entry should be entered such book.
46. If aircraft log book is not maintained in the manner and from prescribed, then
a.
The operators license will be cancelled
b.
The QCM/Accountable Manager will be warned by DGCA to maintain the records.
c.
The aircraft shall be deemed un airworthy.
d.
The license of the AME/AMEs who are expected to make entry will be suspended.

47

Rule 7 of aircraft rules 1937 demands that


a) All aircraft registered in India shall carry instruments and equipments an specified
b) All Indian registered aircraft shall carry valid documents as specified.
c) All Indian registered aircraft shall not carry any explosive material onboard when in passenger transportation.
d) All Indian registered aircraft should have nationality & registration markings.

48.

Passenger safety information briefing card contains


a)
Places of tourist attraction in the route
c)
Restrictions on smoking

49.

b.
d.

Evils of drinking liquor and taking drug


All above

Mark the correct sentence


a) Person wishing to obtain taxi permit will be assessed for his taxiing ability by RAO
b) Person wishing to obtain taxi permit must mandatorily hold RT license
c) Taxi permit will be renewed for one year provided the holder has taxied at least once during preceding year.
d) All true.

50.

The log books in respect of newly manufactured aircraft will be issued by


a)
The manufacturer or owner/operator
b)
DGCA during first C of A check
c)
The RAO
d)
None.

51.

Mark the correct sentence


a)
Width of letter of markings shall be 2/3rd of height of letter
b)
Thickness of markings shall be 1/4th of height
c)
The space between two letters in the markings shall be at least 1/4 th of height of the letter
d)
Both a & c are true

52.

The second section of propeller log book will contain


a)
Hours flown date wise
b)
repairs

53.

54.
55.

56.

The third section of Radio apparatus log book will have


a)
Modification status
b)
c)
Flight release inspection records
d)

Test flights

c)

When an engine is removed from the aircraft


a)
Entry should be made in Aircraft log book
c)
Entry should be made in Engine log book

Minor

Major repair records


Replacement records.

The contents of journey log book in case of scheduled operators will be Approved by
a)
QCM
b) Accountable Manager
c)
RAO
d)
The entries in the log books shall be completed with in
a)
24 hours of completion of work
c)
24 working hours of the RAO
d)

Overhaul records d)

English Book Stores, New Delhi.

b)
48 hours of completion of work
2 working days of RAO
b.
d.

Entry should be made in Journey log book


Both a and c are correct

57.

When a component, not having an individual log book, is removed


a) Entry should be made in Aircraft log book
b.
Entry should be made in journey log book
c)
Entry should be made in Flight log book
d.
A new log book is to be made and removal entry should be entered in such a book

58.

Mark the correct sentence


a) Aircraft log books shall be preserved till aircraft is permanently withdrawn from use
b) In case an aircraft is damaged beyond economical repair the log book will be preserved for 1 year from the date
of accident
c) Engine log book will be preserved for a period of 2 years after engine
is permanently withdrawn from use
d) All of the above

59.

If aircraft log book is not maintained in the manner and from prescribed, then
a.
The operators license will be cancelled
b.
The QCM/Accountable Manager will be warned by DGCA to maintain the records.
c.
The aircraft shall be deemed un airworthy.
d.
The license of the AME/AMEs who are expected to make entry will be suspended.

60.

Rule 7 of aircraft rules 1937 demands that


a) All aircraft registered in India shall carry instruments and equipments an specified.
b) All Indian registered aircraft shall carry valid documents as specified.
c) All Indian registered aircraft shall not carry any explosive material on board when in passenger transportation.
d) All Indian registered aircraft should have nationality & registration markings.

You might also like