Professional Documents
Culture Documents
PAPER - I REVISION
AIRCRAFT MANUAL (DGCA QUESTIONS)
2. Means of Aeronautical ground light visible as all azimuth either continuously or intermittently to
designate a particular point is known as
1. Aeronautical ground light 2. Aeronautical beacon 3.Landing light 4. Position light
4. The DGCA may debar permanently or temporarily a candidate from any flying test or examination if the
applicant has adopted unfair means during the test or examination
1. RULE 39A 2. RULE 41A (4) 3.RULE 38 4. RULE 31A
5. Means of Aeronautical ground light visible as all azimuth either continuously or intermittently to
designate a particular point is known as
1. Aeronautical ground light 2. Aeronautical beacon 3.Landing light 4. Position light
6. Fuelling operation to aircraft shall cease when a turbo prop jet aircraft maneuvers
1. Within 15 meters of fuelling equipment 2. Within 6 meters of fuelling equipment
3. Within 43 meters of fuelling equipment 4. Within 30 meters of fuelling equipment
9. The fees required for issue of temporary C of R an Aircraft of MAX. Takeoff Weight 62540kg is
1. 260000 2. 65000 3.120000 4. 22000
10. Weight and Balance control of an Aircraft is covered under____ of the Aircraft Rule 1937
1. RULE 58 2. RULE 48 3.RULE 46 4. RULE 55
11. Dropping of printed paper from an Aircraft in motion is possible only when permission is obtained from
1. District Magistrate 2. Commissioner of Police 3. AS in (1) & (2) also from DGCA
CAR UNNI
14. Rule 52 of Aircraft rule 1937 is
1. Indian Aircraft operating outside INDIA 2. Weight & Balance
3. Instruments & Equipments 4. None
16. Nationality & Registration marks shall be affixed on the Aircraft according to Rule of 1937
1. RULE 27 2. RULE 36 3. RULE 37A 4.RULE 37
19. MTCS during fuelling operation which may include filling or draining of fuel tanks
1. Fuelling of Aircraft not done at outdoor 2. Not less than 15m from any building
3. Electrical & radar, radio system shall be operated 4. All the above
24. When AME has not done proper maintenance his license is suspended/ cancelled under
1. RULE 61(11) 2. RULE 61(14) 3.RULE 61(4) 4. Rule 59
CAR UNNI
1. Used for remuneration purpose
2. Excluding public transport but including aerial work
3. Excluding public transport aircraft & including aerial work
4. Excluding aerial work but including public transport
35. An operator shall provide adequate number of cabin crew in accordance with
1. Rule 133B of Aircraft Rule 1937 2. Rule 49B of Aircraft Rule 1937
3. Rule 38B of Aircraft Rule 1937 4. Rule 133A of Aircraft Rule 1937
43. In case of spillage of fuel over an area greater than 5sq.mtr. fuelling should not stopped & all person
evacuated at placed at least
1. 15m from spillage 2. Not less than 6m spillage 3. 1km from spillage 4. All
CAR UNNI
1. Aerodrome control reporting office 2. Right hand traffic 3. Both 4. None
46.Aerodrome means
1. A definite or limited ground area 2. A definite or limited water are
3. Either (1) or (2) 4. As in (c) & used for landing & departure
47. Aerodrome Reference Point is relation to any aerodrome means a designed point established
1. in the vertical plane near the geometric center of the aerodrome
2. in the horizontal plane near the geometric center of the aerodrome
3. in the horizontal plane at or near the geometric center of the aerodrome
4. All the Above
48. The word Indian has been omitted from INDIAN AIRCRAFT ACT 1934 as per
1. Section 1 of the act (amendment) act 1960 2. Section 1 of the act (amendment) act 1934
3. Section 1 of the act (amendment) act 1937 4. None
49. For specify the radius of the land over which building cannot be constructed, the central government
may have to consider
1. The nature of aircraft operational
2. The international standards & recommended practices governing to operation of Aircraft
3. Both (1) & (2) 4. None of the above
51. In case any person aggrieved by an award of arbitrator then with in how many days he can appeal to
1. 30 days to supreme court 2. 60 days to high court 3. 6 days to supreme court
4. 30 days to high court
52. Which of the following power of civil court cannot be exercised by an arbitrator?
1. discovery& production of any document 2. Reception of evidence on affidavits
3. issuing commissions for examination of witness 4. None of the above
53. Penalty for failure to comply with direction issued under section 5A is
1. Imprisonment for a term which may extend to 6 months
2. a fine which may extended to two thousand rupees
3. Either (1) or (2) 4. Both (1) & (2)
54. Who among the following authority is having power to issue direction?
1. DGCA 2. Any officer empowered by Central Government
3. Either (1) or (2) 4. None
55. An aircraft used for an industrial or commercial purpose or any other remunerative purpose but does
not include public transport Aircraft is called
1. General Aviation aircraft 2. Aerial work aircraft 3.Private Aircraft 4. None
CAR UNNI
58. Aeronautical Beacon means
1. Aeronautical Light displayed on an Aircraft 2. Aeronautical Ground Light
3. Either (1) or (2) 4. None
59.Balloon is
1. Aerostat 2. Aerodyne 3.Aircraft 4. Both (1) & (3)
60. Air transport service means a service for the transport by air of person, mails or any other thing,
whether such service consist of
1. Single flight 2. Service of Flights 3. Either (1) or (2)
63. Flight Time during which a person is receiving flight instruction from pilot on board of Aircraft is called
1. Instructional Flight time 2. Dual Flight time 3. Pilot Flight time
66. What shall be the area of fuelling zone from the fuelling points
1. 15 meters 2. 30 meters 3. 6 meters
70. Under how many categories the Aircrafts are registered in India
1. one 2.Two 3.Three 4. Four
71. Under which of the category an Aircraft will be registered which is owned by an Indian Registered
company
1. Category A 2. Category B 3.Category C 4. Category D
72. If an Aircraft has been destroyed or permanently with drawn from use, then its C of R will be
1. Cancelled 2. Remain valid 3. Restricted 4. None
CAR UNNI
1. till the landing of aircraft at a customs aerodrome in India 2. 24 hours
3. 3 Days 4. 7 Days
75. If an aircraft in respect of which a temporary C of R has been issued, is imported otherwise then by
air, such temporarily certificate shall cease to be valid
1. Within a week from the date of Issue 2. On the date of Import of the Aircraft
3. Only after 1 month from date of issue 4. None of the above
84. During the takeoff & landing, the cabin attendants shall be located
1. in cockpit 2. At some suitable place in the Aircraft
3. AS near AS possible to the floor level exits 4. Any one the above
85. If a license holder has been debarred permanently then he has to surrender his license to the
licensing authority, & the authority shall
1. destroy that license immediately 2. Make relevant entries & return it to the license holder
3. Keep that license for around of 5 years 4. None
86. The validity of the Flight Radio Telephone operators license is for
1. 2 years 2.5 years 3.10 years 4. 1 years
87. Which of the following pilot cannot fly on aerial work Aircraft
1. A pilot holding a license of commercial pilot 2. A pilot holding a license of senior commercial pilot
3. A pilot holding a license of airline transport pilot 4. None of the Above
88. Who among the following shall impart instructions in pivoting the Aircraft?
1. a person having a flight instructors rating 2. a person having a assistant Flight instructor rating
CAR UNNI
3. Specially authorized by DGCA to import instruction 4. All the above
89. How many attendants are required by Ryle 38B for an aircraft having seating capacity of 55
passengers
1. one 2. Two 3.Three 4. Four
90. Under which of the following rule, the change in ownership of registered Aircraft is permitted
1. 31 2. 32 3. 33 4.34
91. The Rules of the Registration & marking of Aircraft can be framed by central government according to
1. Section 4 of the Aircraft act 1934 2. Section 7 of the Aircraft act 1934
3. Section 5 of the Aircraft act 1934 4. Section 6 of the Aircraft act 1934
93. DGCA, revalidation the TC in respect of engine/ propeller under the purviews of aircraft rule
1. 49 2. 49A 3.49B 4. 49C
96. An AME has not performed work in a careful & competent manner his licensed may be cancelled or
suspended under the aircraft rules
1. 61 sub rule 7 2. 54 3.57 4. 61 sub rule (14)
97. The least distance from aerodrome reference point where there is no any slaughtering
1. 20 km 2.10 km 3.Up to 5 Km & as required by aerodrome officer
CAR UNNI