Professional Documents
Culture Documents
Module is prepared for a CAN BUS connection in motor vehicles with 12 volt and ground
battery poles. The module converts digital signals to analogue, for connecting to input
terminals of car alarms like Athos, Nestor and so on..
Program numbers in the tables are valid the MCB-01 module with firmware version 5S
Numbers included after slash symbol are valid for the MCB-02 module.
Produces
JABLOTRON ALARMS a.s. Pod Skalkou 33, Jablonec n.N.
www.jablotron.com
Brera, 159
A3,TT
A4, A6, Q7
A8
3 Serie 2005< 26/251 H..orange/green CAS unit, left side of steering coloumn, 41
L..green pin black connector, position 26,35
1 Serie
7 Serie
5 Serie, X5
Jumper
Charger
Ducato 2006-2011 19/171 H..pink/black 36 pin blue connector at the back of BSI
L..pink/white unit, position 5 and 6
Ducato 2006-2011
Ducato 2011<
Freemont
Scudo
Mondeo 2007< 36/136 H..grey/orange bunch from the front passengers door
L..violet/orange
S-Max 2006< 36/136 H..grey/orange green connector on central unit under front
L..violet/orange passenger glove compartment, position
24,25 or 32,33 (41,42)
Fiesta,
Fusion
S-Max
Accord
Accord 2008<
CR_V 2013<
i30
ix35
Cruze, Orlando
Captiva
300 C
PT Cruiser
Daily
Wrangler
Carnival 2006< 32B H..green bunch from the front pasengers door
L..orange
Optima 2012< 75 / 276 H.. white/red connector on the back side of fuse box on
L.. yellow/red the drivers side
Rio 2011< 75 / 277 H.. brown connector on the left side of fuse box on
L.. white the drivers side
Sportage 2011< 75 / 278 H.. blue connector on the right side of fuse box on
L.. red the drivers side
Carens
Optima
Sportage
CX-5
Outlander
Viano 2004< 24/411 H..brown/red black connector on the unit behind front
L..brown passenger glove compartment
C-class
<2001
E-class
G-class
S 350
Vito
Caution: some X-Trail model modules dont send lock and unlock signals. This signal is
connected to the orange (2), violet (4), or green (8) wire on the black connector. Confirmation
by direct light is on the brown (7) and grey (8) wire on the brown connector. Both connectors
are situated on the same unit as the CAN BUS connection point.
Micra
X-Trail
Ampera 2012< --/221 H..green blue connector on unit under fuses, lower
L..GND wires on the very right
Insignia 2009< 93/221 H..green blue connector on unit under fuses, lower
L..GND wires on the very right
Antara
Astra, Zafira
208 2011< 81* white connector PB1 on BSI unit, 3(H) 5(L)
301 2013< --/182 H..brown blue connector on BSI unit, 16(H), 18(L)
L..green
308 2007< 81/181* white connector PB1 on BSI unit, 3(H) 5(L)
3008 2009< 81* white connector PB1 on BSI unit, 3(H) 5(L)
Boxer 2006< 19/171 H..violet/black 36 pin blue connector at the back of BSI
L..violet/white unit, position 5 and 6
Partner 2008< 81/181* white connector PB1 on BSI unit, 3(H) 5(L)
Expert 2007< 81/181* white connector PB1 on BSI unit, 3(H) 5(L)
if the alarm isnt enabled in the car unit, the module signals only key on
Programming:
407
Boxer 2006<
911,
Carrera,
Cayman
Evoque
Captur, Clio
Fluence, Megane
9.5 2004< 96B H..green cable bunch next to the relay box - see
L..white picture
9.3
9.5
Ibiza 2002< 11/112 H..orange/green 18 pin black connector, on unit over clutch
L..orange/brown pedal, position 9 and 12
Cordoba,Ibiza
Impreza 2007< 39B/372 H..pink on the unit next to the steering rod
L..green/red
Legacy 2004< 18 H..pink L..violet on the unit next to the steering rod
Tribeca 2005< 18 H..pink L..violet on the unit next to the steering rod
Outback 2004< 18/371 H..pink L..violet on the unit next to the steering rod
Forester, Impreza
Outback
Grand Vitara
Superb II 2008< 11/111 H..orange/green 52 pin brown connector on the BCM unit,
L..orange/brown position 15 and 16
Octavia II 2004-2008 11/111 H..orange/green 12 pin black connector (G), on the unit
L..orange/brown above clutch pedal, position 7 and 8
Octavia II 2009< 11/111 H..orange/green 52 pin brown connector on the BCM unit,
L..orange/brown position 15 and 16
CitiGo (62)
Yeti
Avensis 2009< 45B H..blue on white diagnostics connector (pin 6 and 14)
L..white
Verso 2009< 17/381 H..green on white diagnostics connector (pin 6 and 14)
L..white
Yaris 2005< 17/381 H..blue on grey connector behind front passenger glove
L..white compartment
Yaris
S 60 V 70;
XC 90
XC 60
Golf 5 2004< 11/111 H..orange/green 12 pin black connector (G), on the unit
L..orange/brown above pedals, position 7 and 8
Tiguan 2007< 11/111 H..orange/green 12 pin black connector (G), on the unit
L..orange/brown above pedals, position 7 and 8
Touran 2003< 11/111 H..orange/green 12 pin black connector (G), on the unit
L..orange/brown above pedals, position 7 and 8
Golf 4
T 5 2011<