You are on page 1of 6

NASKAH LOMBA KOMPETENSI SISWA (SMK)

TINGKAT PROPINSI KALIMANTAN SELATAN TAHUN 2016

Competitor Instructions Automobile Technology

Competitor Competitor
Task Petrol Engine
Name Number
Tune Up
A

Competitor Instructions

Familiarization Time 5 minutes


Task Duration 55 minutes
Total Time 60 minutes

Marking Summary

Possible
Section
Mark
1. Preparation. 100
2. Repair engine to start and run. 200
3. Correct and repair drivability problem. 200
4. Checks and measurements of fuel injectors. 200
5. Use of the exhaust gas analyser. 200
6. Checks and measurements of main Relay 100
Task Total 1000

You are required to


- Observe occupational health & safety standards
- Only ask necessary questions
- Not speak to the public while competing
- Comply with Experts instructions
- Ensure Name & Country Code on all forms
- Use appropriate tools and procedures
- Complete all instructions on the next page
Remark: Vehicle/model :Toyota Avanza 1.3 (Tahun 2012-2014)

LKS-Kalimantan Selatan-2016 1
D:Dok Sidik
NASKAH LOMBA KOMPETENSI SISWA (SMK)
TINGKAT PROPINSI KALIMANTAN SELATAN TAHUN 2016

The engine will not run! Before this problem the engine had rough operation
1.
and high fuel consumption.

2. The vehicle recently left the repair shop, and now it seems to be worse!

You may use tools and equipment you have, and is provide for you to
3.
diagnosis and repair problems found.

4. Ask the judge for repair-parts needed and show him what you have found.

After the engine is running satisfactory and no trouble codes are present,
5.
proceed to the items listed below:

Check the exhaust emission using the Emission Analyzer and record your
6.
findings.

7. Note: Do not try to repair a defective part! (Ask first)

LKS-Kalimantan Selatan-2016 2
D:Dok Sidik
NASKAH LOMBA KOMPETENSI SISWA (SMK)
TINGKAT PROPINSI KALIMANTAN SELATAN TAHUN 2016

Competitor Report Sheet Automobile Technology

Competitor Competitor
Task Petrol Engine
Name Number
Tune
A

Performance/
Condition of
S/No Items
Components
Good Bad

1. TROUBLE CODES ARE PRESENT


1. ________________________
2. ________________________
3. ________________________
4. ________________________

2. Fuel Injector Inspection Resistance


Injector No 1 __________ Ohms
Injector No 2 __________ Ohms
Injector No 3 __________ Ohms
Injector No 4 __________ Ohms

3 Exhaust Emission Test


Idling Speed ____________ Rpm
CO reading ________________ %
CO2 reading ________________ %
O2 reading ________________ %
HC reading ________________ ppm

MEASUREMENTS OF RESISTANCE MAIN RELAY

4 Resistance Main Relay ___________Ohm

Checked Function Main Relai OK NO

LKS-Kalimantan Selatan-2016 3
D:Dok Sidik
NASKAH LOMBA KOMPETENSI SISWA (SMK)
TINGKAT PROPINSI KALIMANTAN SELATAN TAHUN 2016

ASSESSMENT SHEET - AUTOMOBILE TECHNOLOGY

Competitor Comp. Task Marking


Name Number /Job Scale
PETROL ENGINE
A
TUNE UP EFI

Marking Summary

Possible Actual
Section
Mark Mark
1. Preparation. 100

2. Repair engine to start and run. 200

3. Correct and repair drivability problem 200

4. Check and measurements of fuel injectors. 200

5. Use of the exhaust gas analyser. 200

6. Check and measurements of Main Relay 100

Task Total 1000

Time Keeping

Competition Experts / Juri

Start Name

Stop Signatures

Experts Signatures
1 2 3 4

LKS-Kalimantan Selatan-2016 4
D:Dok Sidik
NASKAH LOMBA KOMPETENSI SISWA (SMK)
TINGKAT PROPINSI KALIMANTAN SELATAN TAHUN 2016

Section Details

1 Preparation & Finishing Yes No Actual Comments


1.1 Check all equipments first 5 0
1.2 Check all instructions 10 0
1.3 Select the correct test equipment 10 0
1.4 Use logical working procedure 10 0
1.5 Proper tools handling 10 0
1.6 Clean up the working area 10 0
1.7 Clean up tools and equipment 10 0
1.8 Clean up the test models 10 0
1.9 Used fender covers 10 0
1.10 Used seat covers 10 0
1.11 Used steering wheel cover 10 0
1.12 Used floor matt 5 0
Sub-Total 100 0

2 Service & repair Engine to Running Yes No Actual Comments


2.1 Checked power supply 100 0
2.2 Reinstal connector power supply (IB) 100 0
Sub-Total 200 0

3. Correct & Repair Drivability Problem Yes No Actual Comments


3.1 Check and find defect sensor 50 0
3.2 Diagnosis used scan tool 50 0
3.3 Instal loose connector 50 0
3.4 Clear the codes 25 0
3.5 Reinstall the removed parts 25 0
Sub-Total 200 0

4. Checks & Measurement of fuel injector Yes No Actual Comments


4.1 Using service manual correctly 50 0
4.2 Set test equipment to ohm 50 0
4.3 Correct measurement of injector 50 0
4.4 Checked Sekring EFI (15A) 50 0
Sub-Total 200 0

5. Use of the exhaust gas analyser Yes No Actual Comments


Using service manual correctly 50 0
Set test equipment exhaust gas analyser 50 0
Correct reading measurement of exhaust 100
gas analyser
Sub-Total 200 0

5. Check and measurements of Relay Yes No Actual Comments


Measurements of resistance main relay 50 0
Checked of function main relay 50
Sub-Total 100 0

LKS-Kalimantan Selatan-2016 5
D:Dok Sidik
NASKAH LOMBA KOMPETENSI SISWA (SMK)
TINGKAT PROPINSI KALIMANTAN SELATAN TAHUN 2016

LKS-Kalimantan Selatan-2016 6
D:Dok Sidik

You might also like