You are on page 1of 2

Errata Sheet

Y. A. Cengel, Heat Transfer: A Practical Approach, 2nd ed., McGraw-Hill, 2003. ISBN 0072458933
(Last update: May 2005)

Page Location Error Correction


8 Header THERMODYNAMICS HEAT TRANSFER
54 Fig. P1-93 60C 55C
56 Prob. 1-114 0.0113 0.113
76 Eq. 2-43, second term T T
kr k

113-125 Header CHAPTER 1 CHAPTER 2
115 Prob. 2-33, 1st term of equation r 2 T r 2 T

t r
118 Prob. 2-59, 1st line A 800-W An 800-W
122 Prob. 2-92, 5th line g0 g 0
131 Eq. 3-15 T T 2 T1 T 2
189 Prob. 3-29, 1st line 3-cm-thick 15-cm-thick
199 Fig. P3-119 8C 12C
231 1st equation of Solution 0.36 0.38
The result of (a) changes to 0.82 m.
270 6th line same result. same result when rounded to the second
decimal place for cents.
344-360 The same symbol is used to represent velocity component v and the kinematic viscosity . Change the following s to
the velocity component vee v [the lower case v for the y-component of velocity; see Fluids book for proper symbol]:

p. 344: All except the one in Eq. 6-16.


p. 345: 11th line of Sec. 6-7 (all 3 of them); Fig. 6-20 (all 3 of them).
p. 346-351: All
p. 352: All, except the one in last term of Eq. 6-40. (Always including the figure).
p. 353: 1st term v = of Eq. 6-47, and the line that follows.
p. 354: None.
p. 355: 2nd term of 6-56,
p. 356: All.
p. 357: 2nd line of Sec. 6-10.
p. 358: None
p. 359: Eqs. 6-76 and 6-77.
p. 360: None
p. 361: Right column, the 4 equations in the middle of page [continuity, x-momentum, energy, and = eqs]
343-345 Sec. 6-6: In next edition, revise using Sec. 8-5 of Cengel-Cimbala FM, including new and upgraded figures.
372 11th line from bottom detennined determined
373 Fig. 7-9 V V
373, 374 Figs. 7-9 and 7-10 The Cf and hx curves touch the The curves should not touch the vertical
vertical axis. axis since Cf and hx should approach
infinity at x = 0.
376 Fig. 7-12 A As
376-377 Example 7-1, Properties = 24210 -6
= 2.48510-4
Example 7-1, Properties Table A-14 Table A-13
711 Prob. 13-94E, 1st line double-pipe heat exchanger double-pipe counterflow heat
exchanger

1
The first part of Analysis (first 9 lines): Replace by

Also, at bottom of p. 376 snd top of p. 377, replace 18 kg by 6 kg. [2 occurrences].


On p. 377, the 3 equations on the top:
In Nu= relation, replace 4.13 by 4.024. Also replace 1918 by 1913.
In h= relation: Replace 1918 by 1913. Also replace 55.2 by 55.24.
In Q= relation: Replace 55.2 by 55.24. Also replace 11,040 W by 11.0 kW.
429 13th line from bottom NUT > 5 NTU > 5
430 top line Eq. 8-17 Eq. 8-15
433 Eq. 8-45
433 5th line after Eq. 8-45 Cf = s ( V 2
/ 2) Cf = s/ ( V 2
/ 2)
m m
435 Eq. 8-56 r 2
r 4
r2 2
r2
4R 4R 2
444 Fig. 8-26, labels Di and D0 Di should be the outer diameter of inner pipe, and
D0 is the inner diameter of outer pipe.
452 Prob. 8-5 Missing information at the end Add: D?
before the ?
454 Prob. 8-45 Missing information at the end After the last sentence, add: Assume
fully developed flow and disregard any
changes in Tln.
471 8th line Eq. 9-26 Eq. 9-25
471 9th line Eq. 9-27 Eq. 9-26
477 4th line of Section 9-5 Insulting insulating
485 12th line of Analysis 100F 110F
524 The line after Eq. 10-4 Berenson Berensen
525 Eq. 10-5, numerator Closing bracket ] is missing
630 2nd and 3rd lines from the bottom 0.68 0.62
630 2nd line from the bottom 0.28 0.38
655 Prob 12-9 Is twice equals [to match SM]
890, 891, Top row (with units) of Table A-5E Btu-in./ftF Btu-in./hft2F
892

You might also like