You are on page 1of 7

AIRCRAFT LEGISLATION (A)

CASR Part 21
1. An application for a type certificate is :
a. Made on a form and in a manner prescribed by the DGCA
b. Is submitted to the DGCA office
c. Both answer are correct
2. A type certificate :
a. May be transferred to or made available to third person by licensing agreement
b. Simultaneously be transferred to the owner
c. May not be transferred
3. A class I provisional type certificate is effective :
a. For twenty four months after the date of issue
b. For twelve months after the date of issue
c. For one year
4. Any person shall apply to the DGCA for a supplemental type certificate :
a. Who alter a product by introducing minor change in type design, not great enough
to require a new application for type certificate
b. Who alter a product by introducing major change in type design, not great enough to
require a new application for type certificate
c. Both answer are correct
5. Airworthiness certificates issued for acrobatic category aircraft is :
a. Special airworthiness certificates
b. Special flight permits
c. Standard airworthiness certificates
6. Special flight permit is effective for :
a. One year
b. The period of time specified in the permit
c. Both answer are correct
7. A special flight permit may be issued for an aircraft, for the following purposes :
a. Delivering or exporting the aircraft
b. Evacuating aircraft from areas of impending danger
c. Both answer are correct
8. Wings, fuselage, and landing gear are :
a. A class I product
b. A class II product
c. A class III product

BASIC AIRCRAFT MAINTENANCE 4 Page 1


CASR Part 121
9. An air carrier whose operations specifications authorize operations outside Indonesia is
referred to as :
a. Flag air carrier
b. Supplemental air carrier
c. Domestic air carrier
10. No air operator certificate holder may operate an aircraft unless there has been issued with
respect to and carried on board that aircraft :
a. A valid certificate of airworthiness
b. A valid aircraft maintenance manual
c. Both answer are correct

CASR Part 145


11. For the purpose of part 145, line maintenance means :
a. Any unscheduled maintenance resulting from unforeseen events
b. Scheduled checks that contain servicing and/or inspections that do not require
specialized training, equipment, or facilities
c. Both answer are correct
12. A certificate or rating issued to an AMO in the Republic of Indonesia shall remain in force
for :
a. One year
b. Shall not exceed one year
c. Both answer are correct
13. Airframe rating class I is :
a. Reciprocating engine of 400 horsepower or less
b. Composite construction of small aircraft
c. Both answer are correct
14. Radio rating class 2 is :
a. A radio system used in aircraft for en route or approach navigation
b. Equipment operated on radar or pulsed radio frequency principles
c. Both answer are correct
15. Instrument ratings class 3 is :
a. Bourdon tube
b. Electrical
c. Gyroscopic
16. Aircraft wheel brakes is :
a. Accessory rating class 1
b. Accessory rating class 2
c. Accessory rating class 3

BASIC AIRCRAFT MAINTENANCE 4 Page 2


17. Non destructive inspection, testing, and processing is :
a. Accessory rating class 1
b. Limited ratings
c. Airframe ratings
18. Each certifying personnel employed by certificated AMO located inside the Republic of
Indonesia must be :
a. Trained in inspection techniques and procedures
b. Trained in English
c. Licensed under CASR Part 65
19. A certificated AMO may :
a. Approve for return to service any article for which it is rated after it has performed
maintenance, preventive maintenance, or an alteration in accordance with CASR
Part 21
b. Approve for return to service any article for which it is rated after it has performed
maintenance, preventive maintenance, or an alteration in accordance with CASR
Part 43
c. Approve for return to service any article for which it is rated after it has performed
maintenance, preventive maintenance, or an alteration in accordance with CASR
Part 121
20. A certificated AMO must retain the record for at least :
a. 1 year from the date the article was approved for return to service
b. 90 days from the date the article was approved for return to service
c. 2 years from the date the article was approved for return to service
21. A certificated AMO must report to the DGCA after it discovers any failures, malfunction,
or defect or an article, within :
a. 96 hours
b. 90 days
c. 24 hours
22. Hazardous material means :
a. A substance or material that is capable of posing an reasonable risk to health, safety,
and property when transported in commerce
b. A substance or material that is capable of posing an reasonable risk to health, safety,
and property when transported in aviation
c. Both answer are correct
23. A service provider shall have in place a Safety Management System that is acceptable to :
a. The Accountable Manager
b. The DGCA
c. Both answer are correct

BASIC AIRCRAFT MAINTENANCE 4 Page 3


24. Condition, object or activity with the potential of causing injuries to personnel, damage to
equipment or structures, loss of material, or reduction of ability to perform a prescribed
function is :
a. Consequence
b. Mitigation
c. Hazard

CASR Part 45
25. Registration mark shall be assigned by the DGCA and :
a. Shall be two letters
b. Shall be the letter PK
c. Shall be close letters
26. Type and size of marks :
a. The letters shall be capital letters in Roman character without ornamentation.
Numbers shall be Arabic number without ornamentation.
b. The letters shall be capital letters in Arabic character without ornamentation.
Numbers shall be Roman number without ornamentation.
c. The letters shall be capital letters in Roman character without ornamentation.
Numbers shall be Roman number without ornamentation.
27. Fixed wing aircraft :
a. The height of the identification marks on the wings shall be at least 5 cm
b. The height of the identification marks on the wings shall be at least 50 cm
c. The height of the identification marks on the wings shall be at least 10 cm

CASR Part 23
28. The commuter category is :
a. Limited to propeller driven, multiengine airplanes that have a seating configuration,
excluding pilot seats, of 19 or less
b. And a maximum certificated take off weight of 19,000 pounds or more
c. Both answer are correct

CASR Part 25
29. The empty weight of the airplane include :
a. Usable fuel
b. Full operating fluids
c. Both answer are correct

BASIC AIRCRAFT MAINTENANCE 4 Page 4


30. The airplane must be protected against catastrophic effect from lightning :
a. For metallic component, may be shown by designing the components to minimizing
the effect of a strike
b. For nonmetallic component, may be shown by bonding the components properly to
the airframe
c. For metallic component, may be shown by bonding the components properly to the
airframe
31. Cable system :
a. No cable smaller than 1/8 inch in diameter may be used in the aileron, elevator, or
rudder
b. Fairlead must be installed so they do not cause a change in cable direction of more
than three degrees
c. Both answer are correct
32. Take off warning system including any of the following, that would not allow a safe take
off :
a. The wing flap
b. The landing gear
c. Both answer are correct
33. Aerodynamic controls :
a. Aileron; right for right aileron down
b. Aileron; right for right wing down
c. Aileron; right for nose down
34. The ventilation system must be designed to provide each occupant with an airflow
containing at least :
a. 0.55 cubic feet of fresh air per minute
b. 0.55 pounds of fresh air per minute
c. Both answer are correct
35. For passenger capacity 61 to 200, the minimum number of hand fire extinguishers is :
a. 3
b. 4
c. 5
36. Each lavatory must be equipped with :
a. A fire detection system
b. A heat detection system
c. A smoke detector system
37. For all airplane, the following are required powerplant instruments :
a. A fuel quantity indicator for each fuel tank
b. A manifold pressure indicator for each engine
c. Both answer are correct

BASIC AIRCRAFT MAINTENANCE 4 Page 5


38. Each landing light must be approved, and must be installed so that :
a. Provide sufficient illumination to make each instrument easily readable
b. It provide enough light for night landing
c. Both answer are correct
39. Rear position light :
a. Must consist of a red and a green light
b. Must consist of a red light
c. Must be a white light
40. The flight crew compartment bulkhead and door shall be designed to :
a. Be able to be locked from passenger compartment
b. Minimize penetration by small arm fire and grenade shrapnel
c. Provide enough light for night landing

CASR Part 43
41. Alternation of the following parts are airframe major alterations :
a. Installation of propeller deicing system
b. Change in blade design
c. Landing gear

CASR Part 65
42. A basic certificate is :
a. Equivalent to a license without rating
b. Equivalent to a license
c. Both answer are correct
43. A license, but the group or type rating may be limited in respect to validity and scope, is :
a. A COMA
b. A type rating
c. A group rating
44. Basic certificates is one or more the following category :
a. Airframe
b. C1 radio
c. Both answer are correct
45. License is one or more of the following category :
a. Turbine engine
b. Airframe helicopter
c. Engines

BASIC AIRCRAFT MAINTENANCE 4 Page 6


46. The holder of a valid license shall not exercise the privileges of the document unless,
within the immediately 24 months :
a. At least 6 months exercise the privileges of the license
b. Has for periods totaling at least 6 months exercise the privileges of the license
c. Exercise the privileges of the license
47. The holder of a license shall notify the appropriate office of the Director General, in
writing, of the new address, within :
a. 30 days after any change to a permanent mailing address
b. 6 months after any change to a permanent mailing address
c. 24 months after any change to a permanent mailing address
48. A basic certificate may be issued to a person who is :
a. Not less than 21 year of age
b. Not less than 18 year of age
c. Not less than 19 year of age
49. Rating may be issued in the following groups :
a. Airframe, Group 5; piston engine helicopter
b. Engine, Group 2; turbine powerplants
c. Both answer are correct
50. Type rating for individual aircraft or component types :
a. Airframes, Group 6; turbine engine helicopters
b. Engines, Turbine powerplants
c. Both answer are correct

END

BASIC AIRCRAFT MAINTENANCE 4 Page 7

You might also like