Professional Documents
Culture Documents
Agent:
Datum: 11.01.2018
Initial Sample Test
Date: Report
Werk / Jandelsbrunn No.: 000462_00 (Tele)Fon.: 08583/21-779
Factory / E-Mail: : m.kroneder@knaustabbert.de
Weitere Erstmusterprüfung erforderlich / Check-over initial saple test from: Ja / Yes Nein / No
Nachprüfung der Auflagen erforderlich / Check-over the conditions necessary Ja / Yes Nein / No
Cut out is to less and not in the right angle Check Cut out, dimensional specifications Markos ASAP
(see the cut line on the photos) must be follow in drawing, it’s a very
Measure Deviation, not in Tolerance important Measure,
Actual Value: 2240
Setpoint: 2242 +3 -0
Result: Collision with sidewall, stress
Fractures, Hutze cannot be mounted
Falsches Kompriband (geht bis zu 3 cm Anderes Dichtungsband (Höhe bis max Grünberger Max 20.12.17
auf) 15mm und in schwarz) bei würth Erledigt
Bei Hutzenmontage verdrückt es das anfragen und in Zeichnung abändern
Kompriband nach aussen
Wrong Rubber, Height is 3cm, Use Würth Sealing tape VKP PLUS-15/3- Markos ASAP
Hutze cannot be mounted with this foam BLACK Art.-no .: 087501153 (Follow also
Tape Basic Specifications from tecnology)
Sheet Inserts for mounting (Screw to fiat) Sheet Insert implement after drawing/3D Markos ASAP
missing in Hutze on both sides Data
Sheet insert on exterior surface (for These Sheet insert change to Aluminium Markos ASAP
Roofconnectionrail) are in Steel 1mm (See Email Basic specifications for all
hutzen 15.12.17 Mr. Grünberger)
Pre drill of SteelSheetinsert is necessary
With Automatic screw driver not get
through the Steel sheet insert
Surface mistake, stripes at the Gel Coat Surface without stripes, Optimize Markos ASAP
Surface Finishing
Dirtiness Surface, GFK dust from cut out Surface finishing optimize Markos ASAP
at the surface of Hutze