Professional Documents
Culture Documents
System Wiring
Connect DTM and the computer. Refer to System Wiring Diagram for Configuration.
3. Select “Install the software automatically (Recommended)” and then click Next button.
5. After the USB-RS converter driver was installed, the computer will begin to install COM port. And the
From the root folder of DVD-ROM, open “DTMCFG-Setup” folder and double click Setup.exe to install
2. Run DTM-CFG software, and then type the right ID of the connected DTM. Refer to Start DTM-CFG
3. On main window of standard edition, click STEP1 Get connected button. If the connection failed, go to
step4.
4. Mark “Check communication cable connection” and “Check power supply with correct voltage”, and then
5. Click First diagnosis (Two minutes) button. If the connection failed click Second diagnosis (Twenty
minutes) button. If failed yet, click Third diagnosis (Two hours) button.
Click STEP2 Configuration button on main window of standard edition. On configuration window, click
Upload (From DTM) button to upload the default configuration information from DTM device. And then click