You are on page 1of 3

G.

VENKATA RAMANAIAH
ROLL NO: M170537EE
POWER ELECTRONICS

DESIGN AND OPERATION OF BUCK-BOOST


CONVERTER

ABSTRACT:
The proposed Buck-Boost converter is a type of DC-DC Converter. This proposed converter has
an output voltage is either greater than (or) less than the input voltage magnitude. The output
voltage of this converter depends on the duty cycle .This advantages make the converter used in
self regulating power supplies, battery power systems and adaptive control system applications
.This proposed converter gives high output voltage with low voltage across the mosfet switch
.This converter has two different topologies are called buck-boost converter.

CIRCUIT DIAGRAM:

Fig. Circuit diagram of the Buck - Boost Converter


G.VENKATA RAMANAIAH
ROLL NO: M170537EE
POWER ELECTRONICS

OPERATING PRINCIPLE:
The circuit operations can be divided into two modes

Mode 1:

During this mode, the switch s1 is turned ON and the diode D is reverse biased. In this mode, the
input current rises flow through inductor L and switch S1

MODE 2:

During this mode, the switch s1 is off and the current, which was flowing through the
inductor, would flow through L, C, D and load. In this mode the energy stored in the inductor is
transferred to the load and the inductor current falls until the switch s1 is turned on again in the
next cycle
G.VENKATA RAMANAIAH
ROLL NO: M170537EE
POWER ELECTRONICS

You might also like