Professional Documents
Culture Documents
Topic: Measurements
Section A: MCQ
1. A pupil used a micrometer screw gauge to
measure the thickness of a glass panel. The
diagram below shows part of the micrometer.
What is the thickness of the glass?
A 5.124 mm B 5.24 mm
C 6.24 mm D 6.74 mm
2. For YCKSS’s 40th anniversary, some students wanted to measure the thickness of the
cloth to make the flag and the internal diameter of the pole used by the wushu master.
Which instruments are most suitable for the accurate measurement of the thickness of
the cloth and the internal diameter of the pole?
5. The diagram below shows part of a pair of vernier callipers used to measure the diameter
of three identical ball bearings.
ball bearing
b. Spring balance
c. Stopclock
d. Ammeter
A
B
The bob of the pendulum was pulled to position A and then was released. The period of
the pendulum was found to be 1.2 s.
a. How long did it take the pendulum bob to swing from A to B? [1]
Suggested Answers
2
Section A
1. D 2. B 3. D 4. B 5. B 6. 7. 8. 9. 10.
11. 12. 13. 14. 15. 16. 17. 18. 19. 20.
Section B
1 What is measured by each of the following instruments? State the correct SI unit in each
case. The first example has been done for you. [3]
A
B
The bob of the pendulum was pulled to position A and then was released. The period of
the pendulum was found to be 1.2 s.
a. How long did it take the pendulum bob to swing from A to B? [1]
0.3 s
using a stopwatch to measure time taken for 20 oscillations and divide it by 20 to give
period.
Repeat procedure and calculate the average of these two measurements.