Professional Documents
Culture Documents
Revision description
Issued for Use
Table of Contents
1 DESCRIPTION ................................................................................................................................................2
2 RESPONSIBILITIES AND INTERFACES .......................................................................................................9
3 DEFINITIONS ..................................................................................................................................................9
4 REFERENCES ................................................................................................................................................9
Attachments
1 Description
This guideline outlines basic requirements for bracing of small bore connections to pipes (i.e. vent-, drain-,
instrument- or sample-connections).
The Piping Detail Standard; 37-1A-KST-P52-00002 PDS-509 provides general
guidelines for bracing. PDS-509 Sheet 5 Plate type bracing shall not be used.
This guideline will provide additional details to what, where and how to brace the connections.
Requirements for bracing stated below is applicable for branches 2" and below which terminates with a valve or
an instrument. Connections requiring bracing is stated on the specific PDS details, - typically, instrument
pressure connection, etc.
Reference is made to Sheet 1 of PDS 509 which gives recommendation regarding scope for bracing.
BRACING TYPES
Main bracing type to be used should minimize length of bracing for stiffness, i.e valve should be routed as close
as possible to header pipe. Some examples (welded to branch-flange and header pipe) shown below.
Alt 1 Alt 2
The PDMS software, Cap Support Pipe Bracing, shall be used by the piping designer to model pipe bracing
where required.
Notes:
st
Dig 1: Always the 1 flange closest to header branch connection
Dig 2: In most cases dig on the side you want the brace to come
3 Definitions
4 References
Piping Detail Standard : 37-1A-KST-P52-00002