Professional Documents
Culture Documents
FAULT CODE 15
PROTECTIVE PERIOD ELAPSED PREVIOUS NON-OPERATING AREA
The protection period has
elapsed. The table in the
non-operating area is the
previous (old) table.
FAULT CODE 16
PROTECTIVE PERIOD ELAPSED ZEROIZED NON-OPERATING AREA
The protection period has
elapsed. The non-operating
area is zeroized.
FAULT CODE 17
PROTECTIVE PERIOD ELAPSED EQUAL AREAS
The protection period has
elapsed. The operating and
non-operating areas are
equal.
FAULT CODE 18
PROTECTIVE PERIOD ELAPSED MODIFIED NON-OPERATING AREA
The protection period has
elapsed. The non-operating
area is modified.
-----------------------------------------------------------------------------------
---------------------------------------------------------------
ANBZI;
anbsi
1.1.2 Format 2
/ \ / \
| / \| | / \|
| |F=f|| | |CS ||
| | || | | ||
ANBSI:B=b|,+N=n+| |,+CC=cc+|,RC=rc
| | || | | ||
| |NE || | |IS ||
| \ /| | \ /|
\ / \ /
[,A=a][,BICA=bica][,BNT=bnt][,CCDA=ccda][,CCL=ccl]
[,CCR=ccr][,CIC=cic][,CTI][,CW][,D=d][,DNT=dnt]
[,DT][,EAP=eap][,EMC][,FGB][,ISK=isk][,L=l][,LAD]
[,LAT=lat][,M=m][,MD][,NAPI=napi][,NSI=nsi][,NT]
[,NW][,OAMS=oams...][,PR=pr][,RI=ri][,SATW][,SD]
[,SIC=sic][,SII=sii][,SIO=sio][,SSC=ssc]
[,STATUS=status][,TI=ti][,TRD=trd][,TS][,TSAC=tsac]
[,TTA=tta];
2.2 Format 2
This command specifies the result of a B-Number analysis with a routing case for
a number series and is used for changing the B-Number analysis tables.
-----------------------------------------------------------------------------------
-----------------------------------------
ANBSE:B=b[,STATUS=status];
This command sets number series in a non-operating table for B-number analysis to
vacant.
The command cannot be used if other than normal vacancy information is desired.
-----------------------------------------------------------------------------------
------------------------------------------------------
ANBAI;
If the operating and the non-operating areas are equal when the command is given,
the printout will be:
NOT ACCEPTED
FAULT CODE 47
STATUS=EQUAL
(EQUAL AREAS)
Now the switch takes place though the areas are equal.
The previous area will also in this case is protected against changes, until the
protective period has elapsed.