Professional Documents
Culture Documents
2 Gyroscope proofreading
Rise
上升
After the completion of the code, the aircraft
placed in the horizontal position,
Push the two joysticks at the same time to the
Turn right Turn left
lower right corner 45 ° for gyro calibration. LED
lights flash quickly, proofreading is complete.
Decline
Tips: Before the aircraft take off, be sure to place the aircraft in the When the left joystick (throttle) is pushed When the left joystick (throttle) is pushed
horizontal plane proofreading, to ensure that the aircraft after the smooth up or down, the aircraft rises or falls left or right, the aircraft turns left or right
accordingly. accordingly.
flight. When the aircraft by the impact or collision after the deviation, you can
also use this method to calibrate the gyroscope.
Forward
Battery
6. Rack cap screw hole 9
Fly to the right, fine-tune the left to adjust. 9.1 Headless mode switching
7. Forward rotation propeller Fly to the left, fine-tune the right to adjust.
9
1000TVL M7 Lens
Left
Right Start and set: After the completion of the aircraft frequency, the aircraft placed in the
8. Reversing the propeller 10 120°FOV H170° flat level, or hover in the air to ensure that the head of the aircraft and the remote
9. Propeller guardrail Wide angle camera Fly on Fly on control in front of the same direction, press the headless mode button (aircraft LED
Lipo battery the left the right lights flash) Start headless mode.
10. Body battery compartment
3.7V 200mAh 35C
11. Battery
11
01 (The bottom of the aircraft)
02 9 Exit the headless mode: Press the headless mode button again (the aircraft LED is 10
lit), then exit the headless mode.
Key functions:
2.0 parameters 3.0 Frequency method 9.2 One key return
1、Short press the button to adjust the frequency Press the button to return to the channel, you can correct the way through
FPV system :5.8G 40CH function, and at the frequency FR1-FR8 cycle Orientation Operating Before and after One key return
83.5 mm the right joystick to correct the channel (to the front of the frequency before
Craft parameter See Table 3 on the frequency table between the switch. F F the start in order to return to normal), the aircraft will automatically return.
Main wing length: 66mm 2、Long press the button for 2 seconds (LD1 During the return process, press the function key combination on the remote
flashing when the release button) for the control or push the right joystick "forward" to return the aircraft.
Size: 83.5*83.5*42.2mm L R
adjustment frequency group function, and in the
Weight: 20g(without battery)
83.5mm
Antenna frequency group CH1-CH5 cycle between the Tips: low alarm
Motor: 6015 1S brush motor When the aircraft appears tapping flashing, indicating that the aircraft is
42.2 mm
aircraft on the 3) Make sure the remote control is the 13.4 Aircraft can not take off the solution:
code, to promote original match. 1) Check that the screw is installed correctly.
the left joystick 13.2 Can not roll the solution: 2) whether the aircraft crash cover is loose, hinder
Unscrew the screw and Please use 3 "AAA 1.5V" Close the battery cover
throttle can start the propeller rotation. INSTRUCTION MANUAL
open the battery cover batteries and assemble and screw it on 1) Restart the rollover function key.
05 Red line Black line the aircraft. 06 3) whether the aircraft has electricity, 13 14
them in positive and (positive electrode) (negative ) 2) Check whether the lithium battery is too low, LiPo battery x1 Screwdriver x1 Manual x1
low power, the lights flashing.
re-charge.