Professional Documents
Culture Documents
1 2 3
If you have a design in mind, you can draw it Alternatively, trace an existing design using a Place your traced design, pencil side down,
directly using a soft pencil. Wash under the soft pencil, 3b or similar. onto the block and rub firmly to transfer the
tap with detergent if the pencil lines smudge soft pencil onto the surface to be cut. The
or fail to take. cutter handle or the Baren is ideal for this.
4 5 6
Using a Safety Cutter and Hand Guard, begin Roll the ink evenly onto a flat, non porous sur- Gently roll the ink onto the surface of the
to cut your design. Always cut towards the face lifting the roller occasionally. A ceramic block. Avoid excessive pressure or the ink will
Hand Guard, turning your block as you work. tile or glass is ideal. Do not use too much ink. fill the cut lines.
A Bench Hook could also be used. See below
7 8 9
Carefully place a sheet of paper onto the Using the Baren, apply even pressure to Carefully peel the paper from the block to
inked block. Use drawing pins to ensure a transfer the ink from the block onto the reveal your print. Wash away water based ink
good register. paper. under the tap.
Hand Guard