You are on page 1of 4

GAS/SPEC A P P L I C AT I O N S

• Hydrogen Plants
• Cryogenic Systems
• Ammonia Plants
• Ethane Treating

CS-1110
P H YS I C A L P R O P E R T I E S 1,2

Specific Gravity @ 25/25° C _________________________ 1.04


Boiling Point @ 760 mmHg __________________________ 102.0 -170.0 °C
__________________________ 215.6 - 338.0 °F
Freezing Point (100 Wt%) ___________________________ < -25 °C

Specialty Amine ____________________________


Latent Heat of Vaporization @ normal boiling point _______
_________________________
< -13 °F
445.0 Btu/lb
247.2 Cal/g
Flash Point (PMCC) ________________________________ None to boiling
GAS/SPEC* CS-1110 is a methyldiethanolamine
(MDEA) based solvent formulated to provide 1
GAS/SPEC CS-1100 concentrate. Typical properties, not to be construed as specifications
deep removal of carbon dioxide (CO2) from gas 2
100 wt% indicate solvent concentrate as sold, and not a water-free solvent
processing applications. GAS/SPEC CS-1110
allows for greater CO2 removal capacity with
superior chemical stability, lower corrosion and
Viscosity
longer product life under extreme conditions
than MEA (monoethanolamine) or DEA Temperature, ºC
0 20 40 60 80 100 120
(diethanolamine). GAS/SPEC CS-1110 solvent 80
should be considered mainly for applications in 100 wt%
which the treated gas CO2 specification is less 70

than 1000 ppmv. GAS/SPEC CS-1110 can be 60


used to replace MDEA - Piperazine blends.
50
Viscosity, cP

.
40

* GAS/SPEC is a trademark and service mark of INEOS LLC. 30

20

10
40wt%
0
32 68 104 140 176 212 248
Temperature, ºF

Density

Temperature, ºC
0 20 40 60 80 100 120 140
8.8 1.054

8.7 1.042

8.6 1.031
Density, g/cm3
Density, lb/gal

8.5 1.019

8.4 1.007

8.3 0.995

8.2 0.983
40 wt%
8.1 0.971
100 wt%
8.0 0.959
32 68 104 140 176 212 248 284
Temperature, ºF
P R O D U C T S E RV I C E S Specific Heat
INEOS offers a broad line of services to our Temperature, ºC
specialty amine customers, including: 0 20 40 60 80 100 120 140
• superior simulation capabilities 1.1 1.1

• troubleshooting consultations 1.0 1.0


• on-site start-up and optimization 40 wt%

Specific Heat, Btu/lb•ºF


• solvent analysis and interpretation 0.9 0.9

Specific Heat, cal/g-K


• local stocking and supply
0.8 0.8

M AT E R I A L S O F C O N S T R U C T I O N 0.7 0.7
The preferred material for storage of GAS/SPEC
0.6 100 wt% 0.6
CS-1110 is 304L or 316L stainless steel.
Carbon steel tanks are also satisfactory, although 0.5 0.5
discoloration and iron in the amine may occur.
0.4 0.4
Nitrogen padding of the tanks is recommended 32 68 104 140 176 212 248 284
to prevent oxidation and discoloration of the Temperature, ºF
amine during extended storage. The amine can
also be stored in high-density polyethylene Thermal Conductivity
(HDPE) or polypropylene (HDPP).
Temperature, ºC
0 20 40 60 80 100 120 140
Materials to avoid include: .30 .52
• Aluminum • Copper
• Brass • Copper alloy
Thermal Conductivity, Btu/h-ft-ºF

.25 .43

Thermal Conductivity, W/m-ºC


S T O R AG E T E M P E R AT U R E .20 .35
40 wt%
• The recommended minimum temperature for
.15 .26
storing and pumping 100% GAS/SPEC CS-
1110 is 20 °F (-7 °C).
.10 .17
• Steam tracing and insulation may be required 100 wt%
in cold weather. .05 .09

HANDLING AND SAFETY 0 .0


32 68 104 140 176 212 248 284
• GAS/SPEC CS-1110 can cause serious injury
Temperature, ºF
to the eyes and may result in permanent eye
damage. If accidental contact with the eyes
occurs, flush eyes thoroughly for as long as Surface Tension
possible with plenty of water and seek
Temperature, ºC
medical attention. 20 40 60 80 100 120 140
• Swallowing of GAS/SPEC CS-1110 may cause 60
severe burns to the mouth, throat and
digestive tract. May cause allergic respiratory
Surface Tension dynes/cm

reaction. People with asthma or other long- 50


40wt%
standing respiratory conditions should be
protected from exposure to this product. In
40
case of accidental ingestion, seek medical 100 wt%
attention immediately.
• Brief contact may cause slight irritation to the 30
skin. Occasional brief contact with the skin
should be washed off immediately and should
have little adverse effects. May cause allergic 20
68 104 140 176 212 248 284
reaction in some individuals. Prolonged contact
Temperature, ºF
may result in severe irritation. Prolonged
contact may also result in absorption in
harmful amounts.
• Consult product Material Safety Data Sheet for
more details. Vapor Pressure
The following precautions should be observed Temperature, ºC
when the possibility of exposure exists: 10 38 66 93 121 149
10000
• A safety shower and eyewash facility
located nearby 1000 40 wt%
100 wt%

Vapor Pressure mmHg


• Chemical goggles 100
• Protective clothing, including chemically
resistant gloves 10
• A well-ventilated work area 1

Accidental Release 0.1

• Clear non emergency personnel from area. 0.01


• PROTECT THE ENVIRONMENT: Keep out of
0.001
sewers, storm drains, surface waters and soil. 50 100 150 200 250 300
• Contain spill, if possible. Clean up with a non- Temperature, ºF
combustible absorbent. Do not use sawdust.

R E G U L AT O RY
Regulatory requirements may vary for different
locations. Contact your INEOS representative for
more information.
• GAS/SPEC CS-1110 is corrosive to skin and is
considered hazardous according to the
guidelines of the US Department of
Transportation (DOT).
• GAS/SPEC CS-1110, as sold, contains no
chemical subject to SARA Title III Section 313
supplier notification requirements.
• The export of this product is regulated
under the provisions of the Chemical
Weapons Convention.
GAS/SPEC
Since 1982, the GAS/SPEC name has represented a special focus on The GAS/SPEC Technology Group is dedicated to achieving the
the products, technology and service to chemically remove acid gases highest degree of customer satisfaction globally through the applica-
from process streams. The GAS/SPEC business unit has been continu- tion of the best available technology through the supply of cost-effec-
ously headquartered in Houston, Texas, with its major technical facility tive products and services. Other companies offer MDEA based
in Freeport, Texas. products, some even attempting to emulate GAS/SPEC with similar
The family of specialty amines offered by the GAS/SPEC sounding names… But only products with the GAS/SPEC name bring
Technology Group, all based on MDEA technology, provides custom you the formulations, technology and service you are used to.
H2S and CO2 removal in amine treating operations. The GAS/SPEC INEOS LLC is a part of INEOS Oxide.
products and technology are exclusively offered by INEOS LLC and INEOS Oxide manufactures a full range of products based on its
its specialized distributors. production of ethylene oxide.

INEOS LLC
Head Office
2925 Briarpark Drive, Suite 870 • Houston, TX 77042
For more information on INEOS LLC products and services:
Phone: 713-243-6200 • Fax: 713-243-6220
Email us at: gastreating@ineos.com
www.gasspec.com
www.gastreating.com
Customer Service: 1-225-242-3005
or 866-865-4767 (toll free in USA and Canada).
Email us at: csr@ineos.com
NOTICE: No freedom from any patent owned by Seller or others is to be inferred. Because use conditions and applicable laws may differ from one location to
another and may change with time, Customer is responsible for determining whether products and the information in this document are appropriate for Customer’s
use and for ensuring that Customer’s workplace and disposal practices are in compliance with applicable laws and other governmental enactments. Seller assumes no
obligation or liability for the information in this document. NO WARRANTIES ARE GIVEN; ALL IMPLIED WARRANTIES OF MERCHANTABILITY OR FITNESS FOR
A PARTICULAR PURPOSE ARE EXPRESSLY EXCLUDED.
pg rev GSSS008-4/02

You might also like