You are on page 1of 5

NONDESTRUCTIVE

TESTING MANUAL

TASK 71-21-00-213-802-B
EFFECTIVITY: ALL
ENGINE AFT MOUNT ASSEMBLY - INTERNAL

1. General

A. This task gives the procedure to do a detailed inspection of the engine-aft-mount assembly. The
inspection is applicable to the yoke, links, clevises, lugs and attachment hardware, and the LH/RH
internal side of the nacelle.

B. This inspection is applicable to zones 416 and 426.

C. This inspection is applicable to the SSI 71-21-002.

HARD COPY IS UNCONTROLLED. ONCE PRINTED, THIS PAGE MUST NOT BE RETAINED FOR FUTURE REFERENCE.
D. Structural Significant Item(s): 71-21-002 - ENGINE AFT MOUNT ASSEMBLY.

2. References

BEFORE USING, MAKE SURE THIS HARD COPY IS THE LATEST ISSUE.
REFERENCE DESIGNATION

Aircraft Maintenance Safety Procedures - Standard Proce-


AMM TASK 20-00-00-910-801-A/200
dures
Connection of the external AC power supply to the aircraft -
AMM TASK 24-42-02-860-801-A/200
Aircraft/System Configuration
Disconnection of the external AC power supply from the air-
AMM TASK 24-42-02-860-802-A/200
craft - Aircraft/System Configuration
AMM TASK 52-46-00-000-801-A/400 Middle Avionics-Compartment Access-Door - Removal
AMM TASK 52-46-00-400-801-A/400 Middle Avionics-Compartment Access-Door - Installation
AMM TASK 71-11-00-910-801-A/200 Fan Cowl - Open
AMM TASK 71-11-00-910-802-A/200 Fan Cowl - Close
AMM TASK 78-30-01-910-801-A/200 Thrust Reverser - Open
AMM TASK 78-30-01-910-802-A/200 Thrust Reverser - Close
AMM TASK 78-33-01-040-801-A/200 Isolation Control Unit (ICU) - Deactivation
AMM TASK 78-33-01-440-801-A/200 Isolation Control Unit (ICU) - Reactivation
AMM SDS 34-61-00/1 FLIGHT MANAGEMENT SYSTEM
Filtered Serial Nº contained in this publication: 178

3. Zones and Accesses

ZONES
LOCATION REFERENCE
ACCESS

LH Center Fuselage II Bottom - Middle Avionics Com-


147AL AMM TASK 06-41-00-800-801-A/100
partment
199AL Wing-to-Fuselage Fairing LH Aft Panel AMM TASK 06-41-00-800-801-A/100
412AR RH Fan Cowl - LH Powerplant AMM TASK 06-43-00-800-801-A/100
413AL LH Fan Cowl - LH Powerplant AMM TASK 06-43-00-800-801-A/100
414AR RH Thrust Reverser - LH Powerplant AMM TASK 06-43-00-800-801-A/100
415AL LH Thrust Reverser - LH Powerplant AMM TASK 06-43-00-800-801-A/100

Embraer 190 - NDT 3214 213-802-B


Printed by FlyEmbraer Part 5 71-21-00 Page 1 of 5
Mar 07/19 - 15:06:33 Rev 14 - Nov 14/14
User: bamainte
NONDESTRUCTIVE
TESTING MANUAL

(Continued)

ZONES
LOCATION REFERENCE
ACCESS

416 Engine - LH Powerplant AMM TASK 06-30-00-800-802-A/100


422AR RH Fan Cowl - RH Powerplant AMM TASK 06-43-00-800-801-A/100
423AL LH Fan Cowl - RH Powerplant AMM TASK 06-43-00-800-801-A/100
424AR RH Thrust Reverser - RH Powerplant AMM TASK 06-43-00-800-801-A/100
425AL LH Thrust Reverser - RH Powerplant AMM TASK 06-43-00-800-801-A/100
426 Engine - RH Powerplant AMM TASK 06-30-00-800-802-A/100

HARD COPY IS UNCONTROLLED. ONCE PRINTED, THIS PAGE MUST NOT BE RETAINED FOR FUTURE REFERENCE.
4. Tools and Equipment

REFERENCE DESIGNATION

Commercially available Hand - Held 10X Minimum Magnifying Lens

BEFORE USING, MAKE SURE THIS HARD COPY IS THE LATEST ISSUE.
Commercially available Wiper cloth, lint-free
Commercially available Workstand - Engine/Pylon
Commercially available Circuit Breaker Ring and Tag (Inoperative - Do Not Operate)

5. Circuit Breakers List

MCDU
TYPE DESIGNATION LOCATION BUS LOCATION TIP
PAGE

CB E1 REVERSER LICC DC BUS 1 - -


DC ESS BUS EN-
SSPC E1 START VLV SPDA2 SPDA2-M4
1 GINE
CB E2 REVERSER RICC DC BUS 2 - -
DC ESS BUS EN-
SSPC E2 START VLV SPDA2 SPDA2-M5
2 GINE
CB SLAT ACE 1 LHCBP DC BUS 1 FLIGHT CONTROLS -
DC ESS BUS
CB SLAT ACE 2 RHCBP FLIGHT CONTROLS -
2
Filtered Serial Nº contained in this publication: 178

6. Job Set-Up

WARNING: MAKE SURE THAT THE AIRCRAFT IS IN A SAFE CONDITION BEFORE YOU DO THE
MAINTENANCE PROCEDURES. THIS IS TO PREVENT INJURY TO PERSONS AND/OR
DAMAGE TO THE EQUIPMENT.

A. Do the procedure to make the aircraft safe for maintenance (AMM TASK 20-00-00-910-801-A/200).

B. Connect the external AC power supply to the aircraft (AMM TASK 24-42-02-860-801-A/200).

C. Open these circuit breakers and put a circuit breaker ring and tag (inoperative - do not operate) on
each one of them:

• SLAT ACE 1-LHCBP (DC BUS 1 FLIGHT CONTROLS)

Embraer 190 - NDT 3214 213-802-B


Printed by FlyEmbraer Part 5 71-21-00 Page 2 of 5
Mar 07/19 - 15:06:33 Rev 14 - Nov 14/14
User: bamainte
NONDESTRUCTIVE
TESTING MANUAL

• SLAT ACE 2-RHCBP (DC ESS BUS 2 FLIGHT CONTROLS)

D. On the MCDU (AMM SDS 34-61-00/1), use the sequence in parentheses to open these SSPCs:

• E1 START VLV-SPDA2 (CBMENU/CB BY SYS/ENGINE)

• E2 START VLV-SPDA2 (CBMENU/CB BY SYS/ENGINE)

E. Get access to the middle avionics compartment as follows:

(1) Open access door 199AL.

(2) Open and remove access door 147AL (AMM TASK 52-46-00-000-801-A/400).

HARD COPY IS UNCONTROLLED. ONCE PRINTED, THIS PAGE MUST NOT BE RETAINED FOR FUTURE REFERENCE.
F. Open these circuit breakers and put a circuit breaker ring and tag (inoperative - do not operate) on
each one of them:

• E1 REVERSER-LICC (DC BUS 1)

BEFORE USING, MAKE SURE THIS HARD COPY IS THE LATEST ISSUE.
• E2 REVERSER-RICC (DC BUS 2)

G. Deactivate the ICU (AMM TASK 78-33-01-040-801-A/200).

H. Use a workstand (engine and pylon) to get access to the area that you will examine.

I. Open access doors 413AL, 412AR, 423AL, and 422AR (AMM TASK 71-11-00-910-801-A/200).

J. Open access doors 415AL, 414AR, 425AL, and 424AR (AMM TASK 78-30-01-910-801-A/200).

K. Before you do the inspection, clean the area with a lint-free wiper cloth soaked in water.

7. Procedure (Figure 1)

A. Use a flashlight or mirror, if necessary, to make the inspection easier.

B. Use a 10X magnifying lens to do the detailed inspection of the engine-aft-mount assembly. The
inspection is applicable to the yoke, links, clevises, lug and attachment hardware, and the LH/RH
internal sides of the nacelle. Make sure that:

• There are no loose or missing rivets and bolts.


Filtered Serial Nº contained in this publication: 178

• There are no nicks, scratches, gouges, dents, corrosion and other signs of damage.

• The condition of the protection system or sealant is satisfactory.

8. Indication Evaluation

A. Record the location of the damage indication.

9. Acceptance and Rejection Criteria

A. If there are signs of damage, tell Embraer.

Embraer 190 - NDT 3214 213-802-B


Printed by FlyEmbraer Part 5 71-21-00 Page 3 of 5
Mar 07/19 - 15:06:33 Rev 14 - Nov 14/14
User: bamainte
NONDESTRUCTIVE
TESTING MANUAL

10. Job Close-Up

A. Close the access to the middle avionics compartment as follows:

(1) Install and close access door 147AL (AMM TASK 52-46-00-400-801-A/400).

(2) Close access door 199AL.

B. Close access doors 413AL, 412AR, 423AL, and 422AR (AMM TASK 71-11-00-910-802-A/200).

C. Close access doors 415AL, 414AR, 425AL, and 424AR (AMM TASK 78-30-01-910-802-A/200).

HARD COPY IS UNCONTROLLED. ONCE PRINTED, THIS PAGE MUST NOT BE RETAINED FOR FUTURE REFERENCE.
D. Remove the workstand (engine and pylon) and all tools, equipment and unwanted materials from the
worked area.

E. Start the ICU (AMM TASK 78-33-01-440-801-A/200).

F. Remove the circuit breaker ring and tag (inoperative - do not operate) from each of these circuit

BEFORE USING, MAKE SURE THIS HARD COPY IS THE LATEST ISSUE.
breakers and close them:

• E1 REVERSER-LICC (DC BUS 1)

• E2 REVERSER-RICC (DC BUS 2)

G. Close the access to the middle avionics compartment as follows:

(1) Install and close access door 147AL (AMM TASK 52-46-00-400-801-A/400).

(2) Close access door 199AL.

H. On the MCDU (AMM SDS 34-61-00/1), use the sequence in parentheses to close these SSPCs:

• E1 START VLV-SPDA2 (CBMENU/CB BY SYS/ENGINE)

• E2 START VLV-SPDA2 (CBMENU/CB BY SYS/ENGINE)

I. Remove the circuit breaker ring and tag (inoperative - do not operate) from each one of these circuit
breakers and close them:

• SLAT ACE 1-LHCBP (DC BUS 1 FLIGHT CONTROLS)


Filtered Serial Nº contained in this publication: 178

• SLAT ACE 2-RHCBP (DC ESS BUS 2 FLIGHT CONTROLS)

J. Disconnect the external AC power supply from the aircraft (AMM TASK 24-42-02-860-802-A/200).

K. Put the aircraft back to its initial condition.

Embraer 190 - NDT 3214 213-802-B


Printed by FlyEmbraer Part 5 71-21-00 Page 4 of 5
Mar 07/19 - 15:06:33 Rev 14 - Nov 14/14
User: bamainte
NONDESTRUCTIVE
TESTING MANUAL

EFFECTIVITY: ALL
Engine-Aft-Mount Assembly - Inspection
Figure 1

HARD COPY IS UNCONTROLLED. ONCE PRINTED, THIS PAGE MUST NOT BE RETAINED FOR FUTURE REFERENCE.
B
A

BEFORE USING, MAKE SURE THIS HARD COPY IS THE LATEST ISSUE.
ZONES
416
426

SSI 71−21−002 ENGINE AFT


MOUNT ASSEMBLY

FIXED LINK

FIXED LINK

THRUST LINK CLEVIS


Filtered Serial Nº contained in this publication: 178

THRUST YOKE ENGINE LUG


NK170NDT710011B.DGN

LEGEND:

INSPECTION AREA.

Embraer 190 - NDT 3214 213-802-B


Printed by FlyEmbraer Part 5 71-21-00 Page 5 of 5
Mar 07/19 - 15:06:33 Rev 14 - Nov 14/14
User: bamainte

You might also like