You are on page 1of 3

Magic Cube Rose

by Valerie Vann
Diagrammed by Joel Sampson

Part 1: Leaf Modules x3

1. Start with the white 2. Fold the outside 3. Fold the top right 4. Fold the bottom
side up. Fold in half edges into the centre corner down to the left corner up to the
and then unfold. crease then unfold. crease shown, then unfold. crease shown.

5. Bring Point A down to point B, 6. Rotate model 180 , o


7. fold top triangle
folding along the crease shown. Then then fold top left corner down along crease shown.
fold left side in, along crease shown down along crease shown.

8. Fold point A 9. Fold top layer along the creases 10. Turn over and fold 11. Fold the bottom and
up to point B inside shown, bringing point A down to the bottom triangle upwards the top along the creases
of the model. point B and bringing the left side along crease shown. shown, then unfold.
inwards at the same time.

A
B

B
A

You will need to make 3 of these modules


Magic Cube Rose
by Valerie Vann
Diagrammed by Joel Sampson

Part 2: Petal Modules x3

1. Start with the white 2. Fold the outside 3. Fold the top right 4. Fold the bottom
side up. Fold in half edges into the centre corner down to the left corner up to the
and then unfold. crease then unfold. crease shown, then unfold. crease shown.

5. Bring Point A down to point B, 6. Rotate model 180 , and fold left side of
o

folding along the crease shown. Then model along crease shown. Then bring point A
fold left side in, along crease shown. up to point B inside the model.

A
B

7. Fold top layer along

9.
the creases shown, bringing
point A down to point B
and bringing the left side
8. Turn over and fold the Fold the bottom and the
top along the creases shown,
two white triangles along
inwards at the same time. the creases shown. then unfold.

You will need to make 3 of these modules


Magic Cube Rose
by Valerie Vann
Diagrammed by Joel Sampson

Part 3: Joining the 6 modules

1. Insert the triangular end of 2. Join the other module to 3. Inside View of the joined
one module into the opening the other 2 by inserting the modules. They should look like they
of another as shown triangular end, and then inserting form the corner of a cube...
the end of the 1st module
into the last. Follow the arrows

Inside View

4. For the pink modules: Insert the 5. Join the other module to the 6. Outside view of
triangular end of one module into other 2 by inserting the triangular the joined pink modules.
the opening of another as shown end, and then inserting the end
of the 1st module into the last

Outside View

7. Now insert the pink group into the green group. 8. It’s Magic!!
Follow the arrows. To open up the rose, slowly work the pink petals out
from the 3 diagonal joins and the centre, and you can
open up the leaves too if you wish.

You might also like