Professional Documents
Culture Documents
Author: Rashmi
This document explains the steps to configure the Nordic readers to game network.
NORDIC READER CONFIGURATION FOR PARAFAIT 2017
Contents
Introduction ................................................................................................. 2
Nordic reader with RS485 : .......................................................................... 2
Trouble shooting:......................................................................................... 5
Nordic reader with POE: .............................................................................. 7
Trouble shooting:....................................................................................... 13
Introduction
This document explains the steps involved in Configuring the Nordic
readers.
Hardware requirements:
- Serial cables
- Cat5 cable
- Server computer
Connections:
Server side:
Reader side:
Setup:
1. Install ST Lab device in server computer and make sure 4 ports are
created under device manager.
5. Make sure Parafait server is not running and press configure button.
Press ‘Yes’ to configure the hub. You will get the message “Configuration
completed successfully”
Reader configuration:
Connect configuration PCB to redemption /Coin board using FRC cable and
configure the Hub Id (address), Mac Address (0-99) and Frequency in a
reader.
Run the Parafait Primary server. You can see the communication log with
status ‘OK’.
Trouble shooting:
Connection:
Server side:
Reader Side:
Setup:
Network:
Device IP address
Subnet mask
Gateway
DNS Server
Operation mode – TCP server
Serial:
Enable debug message output
Baud rate(R) – 19200
Data Bit (D) – 8
Parity(P) – None
Stop Bits(S) – 1
Flow control(F) – None
Time (T) – 0
Size(Z) – 32
Character(C) – 00
Network:
Inactivity Timer – 10
Reconnection interval – 1000
Enable Use row data transmission algorithms
7. Gemes -> Hubs -> Create the hubs as shown in below image.
Press ‘Yes’ to configure the hub. You will get the message “Configuration
completed successfully”
Reader configuration:
Connect configuration PCB game reader using FRC cable and configure the
Hub Id (address), Mac Address (0-99) and Frequency in a reader.
Run the Parafait Primary server. You can see the communication log with
status ‘OK’.
Trouble shooting:
Step 1: Login to wiznet config tool and search for POE Mac address.
Check whether you can see the Mac address of POE device.
If No, please check the LAN connectivity.
If yes, Go to next step.
Step 2: Shut down particular hub and check whether you are able to
configure the hub using configure option in hub setup.
- If you get an error as “unable to find access point with this Mac
Address. Please try again”-
Check the connectivity of hub to the POE device.
Check whether hub LED is glowing.
SEMNOX SOLUTIONS PVT LTD. Page 13
NORDIC READER CONFIGURATION FOR PARAFAIT 2017
3. Weak communication:
Disable the machines in management studio, machine setup
which are not in use.
Check the hub position and make sure it is fixed in a proper
location.
Check the hub antenna whether it is weak. If required, replace
the antenna.