You are on page 1of 1

Chemical Engineering Basics

The softness or hardness of a grinding wheel depends upon the type & amount of bonding material used. For general purpose cutter
grinding aluminium oxide grinding wheel is normally used.
Tin based white metals are used, where bearings are subjected to high pressure & load.
Friction factor for fluid flow in pipe does not depend upon the pipe length.
All of the following alloying elements of steel increases hardness but sacrifice ductility, except
Nickel , vanadium, molybdenum, chromium
The following type of bonding is strongly directional in solids. Covalent.
Fog is an example of colloidal system of liquid dispersed in gas.
Chromium molybdenum steel can not be welded using electrical resistance welding.
Speisses is a mixture of the following: Arsenides of heavy metals.
Auto collimator is used to check angle.
In troposphere (the weather domain), the temperature 't' at height 'h' above the sea level in metres is given by (where, temperature
at sea level is 15°C and t is in °C.) t = 15 - 0.0065 h
A high pressure boiler generates steam at a pressure greater than 80 kg/cm2 .
Evaporative cooling process employs a combination of cooling and humidification in which the sensible heat is removed and the
latent heat is added.
Which of the following is not an explosive ?
TNT, CMC, RDX, Lead Azide
Maxwell's thermodynamic relations applies to the chemical systems in equilibrium.
Annealing of white cast iron produces malleable iron.
Resistance of an electrical conductor is proportional to its (where, l = length and A = cross-sectional area of the conductor). A & l
A solar cell converts the sunlight directly into electrical energy.
If a nuclear reactor produces more fissile nuclear fuel than it consumes, then it is called a breeder reactor.
Wrought iron is never shaped by
Casting, cold working, forging, welding
Powder metallurgy process does not make metal powder by
Atomization, grinding/milling, hammering, electrolytic deposition
In the blast furnace, incorporation of water vapour in the blast gives the following effect. Increases the reducing potential of the
gas.
The usual energy consumption in electric arc furnace steel making is 400 - 700 KWh/ton of steel.
Maximum permissible air velocity in pipelines is about 10 metre/second.
Area under the stress-strain curve upto the proportional limit is referred to as the modulus of resilience.
Alumina is the hardest oxide and is hence used where high wear resistance at high temperature is required.
Titanium alloys are welded using the Following process: TIG welding
An alloy of Fe - 0.4 % C is hypo-eutectoid steel.
A material in which the atoms are arranged regularly in some directions but not in others, is termed as 'mesomorphous material'; an
example of which is lead.
In extrusion of metals, which of the following statement is true ? Hollow ram is used for indirect extrusion.

You might also like