Problem
What is the equivalent head of a fluid that has a’ velocity of 18 m/s? 46 54 m
Problem
The length of pipe is 168 meters. If the pressure drop is 50 kPa for
every 30 m, what is the total pressure drop? 280
Problem
Find the volume flow rate of water in L/s if the power developed under a
head of 320 mis 10,600 kW and the hydraulic efficiency is 85% 3,935 Us
Problem z
‘Water flows in a pipe with a velocity of 10 mis. Determine the velocity
head of the water. ze woe $.10m
Problem
A cylindrical pipe with water flowing downward at 0.02 m/s having top
diameter of 0.08, bottom diameter of 0.04 m and height of 1.5 m. Find
the pressure between the pipe. 104 kPa
™m room is flooded to a depth of 15
.0x 10° Pa.s), a pump is used that oes
Problem
If the velocity of the flow in a 7:
is the power avalabla in a d0-mm Sere
attached at the end of the pipe?
Problem
noes Us 30 imin) of water is flowing in a round pipe such that
rat et a gsm
umber o be 2000, what is ter of the pipe necessary to
a ¥ flow? (Note: kinematic viscosity of water is 475 x 10% 33.50 ft,
i ire hose is 25 cm/s,
siameter jot issuing from > nosat 1.34
Probleat
Water is flowing in a pipe of varying cross-sectional area, and at ali
points the water completely fills the pipe. The cross-sectional area at
point D is 0.080 m’, and the velocity is 3.5 m/s. Compute the fluid’s
velocity at point @ where the cross-sectional area is 0.060 m’. 467 misProblem
A sealed tank containing seawater to a height of 12 m also contains air
above the water at gage pressure of 5 atm. Water flows out from the,
bottom through a small hole. Catculate the efflux speed of the water.
Note: pew = 1.03 x 10° kg/m?
Problem
A cylindrical bucket, open at the top, 0.200 m high and 0.100 m in
diameter. A circular hole with cross-section area 1.0 cm? is cut in the
‘center of the bottom of the bucket. Water flows into the bucket from a
tube above it at the rate of 1.30 x 10% m’¥s, How high will the water in
the bucket rise? -
Problem
Modem airplane design calls for a lift due to the net force of the moving
air on the wing of about 2000 Nim? of wing area. Assume that air
density (density = 1.2 kg/m*) flows past the wing of an air-craft with
streamline flow. If the speed of flow put the lower wing surface is 140
m/s, what is the required speed over the upper surface to give a lif of
2000 Nim??
Problem
Water leaves a faucet with a downward velocity of 3 m/s. As the water
falls below the faucet it accelerates with acceleration g. The cross
‘sectional area of the water stream leaving the faucet is 1.0 cm?. What is
‘the cross-sectional area of the stream 0.50 m below the faucet?
Problem
A hose shoots water straight up a distance of 2.5 m. The end opening
on the hose has an area of 0.75 cm? How much water comes out in
min
Problem
‘What is the force.acting on one side of the tank moving upward with an
acceleration of 4.7 m/s" when it is filed with oil whose specific gravity is
0.752 and a height of 1.3 m for the bottom of the tank?
Problem
A conical reducing sections connects an existent 10.16 cm diameter
Pipeline with a new 5.08 cm diameter line. At 689.30 kPa static
pressure under no-flow conditions, what is the tensile force is exerted
‘on the connectors at joint A assuming no end restraint from the pipe.
Problem
‘An oil flowing at the rate of 0.001 m’/s through an 8 cm diameter pipe
has a kinematic viscosity cf 2 x 10° m’/s and an specific gravity of 0.85.
‘What is the centerline velocity?
34.92 mis
8.62 cm
151 mis.
0.69 cm?
31.S'liters
11.986 KN
4.19 Kn
0.398 misProblem
Water at 20°C is flowing in a pipe of radius 1.0 cm. The viscosity of
water at 20°C is 1.005 centipoise. If the flow speed at the center is
0.200 m/s and the flow is laminar, find the pressure drop due to
viscosity along a 5 m section pipe. 40.2 Pa
Problem
‘Assmall block of wood of density 0.4 x 10° kg/m’ is submerged in water
at a depth of 2.9 m. Find the acceleration of the block toward the
‘surface when the block is released in a water whose viscosity is to be
negligible. 14.7 mis?
Problem «ak
A submarine is 100 m long. The shape of its: hullis roughly cylindrical
‘with a diameter of 15 m. When it is submerged, it cruises at a speed of
about 40 knots or approximately 20 m/s. Compute the Reynolds 5
number, if the viscosity is 1.0 x 10° Pa.s. 3x10!
Problem
A hose shoots water straight up for a distance of 2.5 m. The end
‘opening on the hose has an area of 0.75 cm”, How much water come
3
‘out in 1 hour? 1.89 m
Problem
The jet discharges water at the rate of 0.10 ms and at a speed of 18
tis fo stationary plate. Determine the force on ihe plate 1800 N
Problem
A 150 mm diameter pipe carries 81.3 Ls of water. The pipe branches,
into two pipes one is 50 mm in diameter and the other is 75 mm. What
is the velocity in 75 mm pipe if the velocity of th
isthe veo pipe city of the flow in the 50 mm pipe 43 96 mig
Problem
A gas flows through a square conduit, at the entrance the conduit sides
are 10 om, the velocity is 7.55 mis, and the gas mass density is 1.09
kgim’. At the exit, the conduit sides are 25 om, and the velocty of the
flow is 2.02 mvs. Find the density of the gas at the exit section weg
considering that the gas is compressible. 0.6518 kg/m
Problem
‘What is the expected head loss per mile of a closed cicular pipe with
in. inside diameter friction factor of 0.03 when 3300 gai/min of water
flow under pressure? s 37.7 ft
Problem
A pipe has a diameter of 4 in, at section XX a diameter of 2 in. at
section YY. An ideal fluid flow, the velocity is given as 2 f/s at section
XX. Determine the flow velocity at section YY. 8 fs
Problem
What is the hydraulic radius of a semi-circular channel of radius 8? 4 ft