Ms-1 initial vertical velocity = 8ms-1 Horizontal velocity = 18ms-1 max height = 3. M Hints Average velocity = Remember to set initial vertical velocity = 0ms-1 acceleration is -9. Ms-2 Fuel is being used up - mass decreasing - acceleration increasing. Upthrust is due to a pressure difference between the top and bottom of the fish. Pressure at the bottom is greater than the top because P is directly proportional to the depth.
Ms-1 initial vertical velocity = 8ms-1 Horizontal velocity = 18ms-1 max height = 3. M Hints Average velocity = Remember to set initial vertical velocity = 0ms-1 acceleration is -9. Ms-2 Fuel is being used up - mass decreasing - acceleration increasing. Upthrust is due to a pressure difference between the top and bottom of the fish. Pressure at the bottom is greater than the top because P is directly proportional to the depth.
Ms-1 initial vertical velocity = 8ms-1 Horizontal velocity = 18ms-1 max height = 3. M Hints Average velocity = Remember to set initial vertical velocity = 0ms-1 acceleration is -9. Ms-2 Fuel is being used up - mass decreasing - acceleration increasing. Upthrust is due to a pressure difference between the top and bottom of the fish. Pressure at the bottom is greater than the top because P is directly proportional to the depth.
1 (a) i 50 metres 1 (a) ii 037O from North 1 (b) 2.5 ms-1 Average velocity =
2 (a) i Initial vertical velocity = 8ms-1
2 (a) ii Horizontal velocity = 18 ms-1 2 (b) Max height = 3.3 m Remember to set initial vertical velocity = 8 ms-1 Final vertical velocity at max height is 0ms-1 Acceleration is -9.8 ms-2 3 (a) 4.9 N 3 (b) 80.2 ms-2 3 (c) Fuel is being used up → mass decreasing → acceleration increasing. 4 (a) 6 ms-1 to the right 4 (b) i 12 kgms-1 Must draw the diagram to see the change in trolley B`s momentun 4 (b) ii 30 N
5 (a) 0.276 kg 1 cm3 = 1 x 10-6 m3
So 240 cm3 = 240 x 10-6 cm3 Just be careful of the conversion factor. 5 (c) Molecular spacing for a gas is ten times that for a liquid. So it will be 10 x 10 x 10 = 1000 for the volume. 6 (a)
Upthrust
Tension Weight
6 (b) Upthrust is due to a pressure difference between
the top and bottom of the fish. Pressure at the bottom is greater than the top because P is directly proportional to the depth. Because Force = Pressure x Area This gives rise to a force difference = upthrust 7 (a) Use and for each entry on the table gives a value of 0.07 This shows that = 0.07 = constant Provided T is in the Kelvin scale. 7 (b) The water should cover the air trapped by the mercury bead to ensure that the air is heated to the same temperature throughout.