Professional Documents
Culture Documents
BO. 8 (MA-8)
SPACECRAFT HO. 16
CLASSIFICATION CHAHG1
TO - f^DNCLASSIFll
~By authority
/r.
Changed by^-
MEDQNNEIi
IT. lOUII.MO.
DATE 30?,
V
AVAILABLE 10 U.S. GOVERKSEKT AGENCIES ONLY
(Title Unclassified)
SPACECRAFT NO. l6
DATA H1SPORT
REF9RT- 93Qi») COPY NO.
PREPARED
A. A. Aden
Data Engineer Assistant Engineer
APPROVED BY JLL
' M. A. Leone
APPROVED BY
H. V. Walden
Senior Data Engineer Group Flight Test Engr.
APPROVED BY
J. McOroarty /
APPROVED BY J. J.e.C.VJ
Waldner
Orop Data^EngineJer . Fligtt
APPROVED BY_ APPROVED BY
C. E. M&theny
Chief, Data Analyi
DATE
25 March 1963 ST. LOUIS. MISSOURI PAC.E
INDEX OF REVISIONS
PAGES AFFECTED
DATE REMARKS REVISED BY APPROVED i
'REVISED | ADDED REMOVED
None-
LIST OF PAGES
Title
i
ii
. iii
1.0
2.0
2-3
3.0
3-9
4.0
4.17
5-0
\'
5.270
CONTENTS •
Page Number
INDEX OF REVISIONS i
LIST OF PAGES ii
1.0 INTRODUCTION 1.0
REVISED MODEL .
1.0 INTRODUCTION
^HHM|MaiMMHi^^^ 133
REVISED '
• •••••••••••i MODEL . _ . ^
2.1 Data Records - Data records obtained, during the MA-8 mission include
(a) the magnetic tape recorded on-board the spacecraft, (b) magnetic tapes re-
corded at the ground telemetry stations, (c) motion picture film from,the astro- -
naut observer camera, and (d) transcriptions of voice communications. Data con-
i ./ • .• • .
tained on these records include the individual parameters listed in the data
summary tabulation on Pages 5«1 through.5.6. "•
REVISED MODEL .
133
2.3 Data Quality - The quality of the duplicate on-board magnetic tape
record was good. Variations in the data were exhibited during the high-"q." exit
environment between 00:00:50 aa<l 00:01:20 mission time. Recorder transients or
drop-outs of several seconds duration occurred at the following times from launch:
Time From Launch
Hr:Min:Sec
", .
: 00:32:5^
. 01:01:35
01:3^:21
05:14:50
06:28:12
07:07:11
08:51:23
These recorder drop-outs are not reflected in the presented data because they were
sldlpped when periodic data sampling was applied for presentation. Other voids
evidenced in the presentations were PDM data points that were refused because the
recorded signals violated conditions established for commutated data. In the case
of ttuj iat. -.r voids, a bad area existed between- 07:2^:00 and 07:27:00 mission time*
The mission instrumentation references (Z/R calibrations) were consistent
within one percent between the pre-flight and in-flight records and between the
high and low-frequency tracks, except for the high-frequency conmutated body
temperature discussed in Paragraph 4.5»8. All instrumentation reference deflec-
tions recorded during the mission were in reasonable agreement with those of the
original instrument calibration.
Segment 19, Heat Shield Temperature, of the low-frequency commutator was
the only parameter not acceptable for presentation, it being inoperative.
During the flight the satellite clock (the clock aboard the spacecraft
from which the time is recorded) gained approximately five seconds when related to
AMKTi This error was slowly accumulated, throughout the mission. No effort was
made to account in the data processing for this relatively insignificant '
discrepancy*
The tabulations on Pages 5»1 through 5.6 contain general information con-
cerning the MA-8 data acquisition, processing, and presentation. Specific data
processing procedures are covered in the following discussion.
3.1. Correlation
•v n T
" ~ ^~ "" ~ ' ~
- •The data presented in Section
_ . '
5*0
• •
are
. ,
plotted
• .
as
variations against elapsed time from launch which occurred at 1215:34- GMT. The
procedures used for correlating these data are outlined in the sub-sections that
follow.
. 133
REVISED J*BBMMBBBB«iM^^ MODEL _ ±±-
special teinperature data were plotted .against the time interpreted at the beginning
of each block, whereas the multiplexed data vere continuously interpreted. j
3.1.4 Event Elapsed Time - The elapsed times for the sequen-
tial events were established as the biased satellite clock times indicated during
the blocks in which the events transpired. The elapsed times for non-instrumented
events were an interpretation of the processed data, ground telemetry station re-
cords, and/or the communication logs.
MAC 2 3 1C ( R£ V I .. •' -; 1 j
DATE 25 March 1963 ST. LOUIS, MISSOURI PAGE
REVISED REPORT.
MAC 23 1C ( R E V I . AUG •« I)
DATE _25_Marchl963 ST. LOUIS, MISSOURI PAGE
was a controlled measurement of the spacecraft ^gOg supply pressures and the
supplies at ground conditions.
(c) Oxygen Supplies in Pounds - The OQ supply pressures
were related to the remaining 02 poundage values using the Gas Law pV = KWRT.
vhere: K = constant obtained from NASA ' . . . . . •
generalized compressibility curves, .
V = 198 in?, and
R = 579.6 in/°R.
(The temperature variations of the primary and secondary 02 supplies were
assumed to be the same.)
The weight (W) of secondary oxygen at launch was determined -assuming the tempera-
ture of the bottle = 7Q°F. Using this computed oxygen quantity in the secondary
supply as the amount retained in that bottle for the entire mission (indicated by
the pressure data), the oxygen temperatures were then determined throughout the
mission by reverse application of the gas law. These theoretical secondary oxygen
temperatures were then applied with the gas law to the primary bottle pressures for
the temperature compensated 02 supplies (pounds) used in the data presentation.
REVISED REPORT.
REVISED MOOEL .
consecutive valleys. Peaks and valleys related to respiratory cycles were differ-
entiated from noise, physical and vocal exercises, and other oscillations. This
• ' ' / • ' • ' • „ '•
'; • ' "!''
Peak
Valley
ically conditioned and reshaped to that having a constant base and equal pulse .;
amplitudes. The conditioned and reshaped signal vas interpreted by a rate meter
which were sampled every nine minutes of the first and. last orbits. These . analyses
were made from the original recorded ECG signal and are presented as a plot on
Page 5.158. . . . .'.'-.:'
linear interpretation between the upper and lower transducer limits was fitted to
the oscillograph records for presentation. The limits were established by the
3'5 Bata Presentations - Pages 5'1 through 5«6 index the data included/
in this report and identify the functional parameter groupings, the plot number;
indexing, the presentation formats, accuracies and limits, and the specific
M A C . Z 3 I C (REV ) A U 6 - 6 1 )
DATE 25 March 1963 ST. LOUIS, MISSOURI PAGE . : 2±?
REVISED : . • REPORT 9^0^"
^AMMMMM^UIU^^I^L^y^g^m^^^Jl^^^^ , 1^^
REVISED ' ^i^^^M^^HBBH^^^HB MODEL ,' ^^^
processing procedures that were applied to the data of this Mercury-Atlas mission.
General details of the data presentations are discussed in the following sub-
sections* ,
of additional data recorded by the Mercury Ketwork ground stations and by the ' ''
astronaut. The normal operating limits of some parameters were also Identified on
the presentations.
MAC 2 3 1 C M R E V I A U G - 6 1 )
DATE _ 25 March 1963 ST. LOUIS, MISSOURI PAGE 3.9
REVISED REPORT.
REVISED . ^VBHH^HHBBIBBHMRP-
^^a^fiaEEK^^^^^2^^2Mfftted0j0BM||^^
MODEL ~>2P
1 OO
4.1 Event Times - The fcUcwins event tiaes, shotm as mission elapsed
tine,, were obtained from the sources noted in Sub-section 3.1.4.
Hr:Min:Sec .
00:00:00 (1215:11 GMT) Launch; Gyros Horiaal.
00:02:07.8 BECO (Booster Engine Cutoff)
00:02:10.8 Staging
00:02:33 Tower SSC&PS Socket Fire
00:02:33 Tower Jettison
00:05:15 SECO (Sustainer Engine Cutoff)
00:05:18 Spacecraft Separation; Start
. Damping. .
00:05:19 Periscope Extended
00:05:21 Start Fly-By-Wire (FEW)
00:07:11 2ad FEW; Start Orbit Mode
C<):10:51 End Orbit Mode; Start FEW
00:11:10 to 00:11:45 Sustainer Tracking
00:12:09 End FEW; Start Manual Proportional.
(MP)
00:12:51 End MP; Start Orbit
MAC 2 3 I C ( R E V I A U G 6 1 )
DATE >5 March 1963 ST. LOUIS, MISSOURI PAGE 4.2
REVISED REPORT. 93Q4.
REVISED MODEL . .
133
REVISED REPORT.
U.3 Reliable Limits - Some of the data that are presented were Inter-
preted beyond the ranges for vhich the parameters were calibrated* The valid
ranges (Calibration Limits) in vhich the presented data may be analyzed are
established in the data summary tabulations on Pages 5.1 through 5.6. Since the
calibrated limits of referenced temperatures are not directly Indicative of their
reliable limits, the valid^ranges of these paramters vere Investigated and are
discussed In Section 4.5.
The voltage drops indicated on the plots resulted from presentation of a three
point average every 25th data point and are, therefore, an approximate average of
the transient magnitudes.
' . =' (c) Static Pressure (Segment 22H) - The increase of the
static pressure shortly after landing vas verified to exist in the data recording.
The static pressures exhibited at the lover levels were somewhat higher in noise
level than indicated "by the other environmental pressures. , . •••'.:'
REVISED REPORT.
REVISED MODEL .
plot presented) and the low-frequency commutated body temperature revealed (l)
the pre -launch instrumentation reference produced an adjustment of approximately
9% in the high-frequency commutator and very little change in the low-frequency
commutator; (2) the high-frequency commutator instrumentation reference adjustment
was in the proper direction but of an insufficient magnitude to produce compatible
values between the high and low-frequency commutators; (3) the high-frequency •
commutator mission instrumentation calibrations exhibited approximately a 5$ drift
between the first and last calibration, whereas the low-frequency commutator
calibrations were consistent; and (k) tlie high-frequency commutator body tempera-
tures were lower than those of the low-frequency commutator ranging between 0.2°P
at the beginning of the mission to 0.4°F at the end. A nominal instrumentation
t
calibration from the pre-launch was used. If the high-frequency commutator body'
temperature had been adjusted for the calibration drift, the two body temperature
measurements would have been in closer agreement.
(b) Cabin and Suit Inlet Temperatures _(Segments 10HL
and IIHL) - The cabin and suit inlet temperatures from the high and low-frequency
commutators were not redundant, employing individual instrumentation circuits.
' . . . . . The cabin temperature probe utilized for the meter
observed by the astronaut was located in an area removed from the cabin inlet
temperature (Segments 10HL) thermocouples. This area was one in which air circula-
tion is poor. .
. The suit inlet temperature variations exhibited between
the high and low-frequency commutators at the elevated levels were validated. A
post-mission investigation revealed that the astronaut's meter for the suit inlet
temperature vas indicating temperatures apprcsdunately 6°? cooler than should "be
expected.
MAC 2 3 1 C ( R E V I A U G 6 1 )
DATE 25 March 1963 ST. LOUIS, MISSOURI PACE
4.14
REVISED REPORT. 9304
REVISED MODEL 133
the 2400 Series above, and consistently were below the lover calibration limits,
each varying as much as 120°F below the limit. The upper limits vere not exceeded.
All differential temperatures of Segment 9 vere within the
calibrated range.
page. These vere attributed to composite inaccuracies introduced in the plotting '
and assembly of the plots for photographic treatment.
.'(b) Scanner Ignores (Segments 59H, 8gS) - These
parameters indicated + 10$ noise vhen in ths On position.
(c) Scanner Out-out:; (Segments 86H, 88H) - The pitch
scanner outputs (Segment 88H) vere biased dorci 14.5°, and the biased outputs that
exceeded a maxiTfmw of 26.5° or a m-tn-tTmwn of -56° vere not plotted. The roll scan-
ner outputs (Segment 86) exceeded their calibrated range. The data recorded be-
yond a maximum of 32.4° and a minimum of -36.20 are plotted, but are not reliable.
(d) RCS High Solenoids and Scanner Ignores (Segments
59H, 65H, 66H, 69H,; 70S, ?8H, 79H and 85H) - The recorded signals of the ECS h
solenoids and the scanner ignores exhibited momentary increases of about 2$. . This
occurred throughout the mission approximately every 2 minutes vhen the parameters
vere in the Off position. '
(e) gyro Outputs (Segments IgH, 17H and 18H) - !Bae
outputs of the gyros are presented, uncorrected for interaction.
REVISED REPORT.
REVISED MODEL .
Acceleration, Ay k
Acceleration,^^^
Az X$L T Acceleration
PARAMETER POLAHZDI33
(Positive Directions ai-e Shovni)
REVISED 9304
REVISED MODEL
Time history plots of the data processed from the, MA-8 mission are pre-
sented in this section, preceded on Pages 5»1 through 5*6 by a summary tabulation
which indexes the plots and contains general information concerning the acquisition,
processing, and presentation of the data. Explanatory notes relative to the
summary tabulation follow.
1\ . Recorder location
xxH = Eigh-Frequency Coissutator (PDl-l)
xxL = Lew-Frequency Commutator (PDM)
= High and Low-Frequency Commutators
xxkc H =. ELgh-Frequency . Multiplex
xxkc: L = Low-Frequency Ifiiltiplex
xxkciHL = ELgh and Low-Frequency Multiplexes
Calc » Data obtained from data interpretations and/ or
special computations
P = Data obtained from the astronaut
Rg = Data obtained from Mercury Ketxrork range stations
c
lOH RCS supply pressure, manual 3.3.2 A 20 psig 1060/2150 1-8 Analysis Ail ! lh 10m 3 avg/25 3 avg/5C 3 avg/2 5.7
39H A 20 psig 815/2150 1
11
RCS supply pressure, automatic
Calc RCS H202 manual supply, Ibs - 3.k.l(b] 0.5 lb 0/25. k ^
- 5.lU
Calc RCS H202 automatic supply, Ibs ' -
3.iui(a: 0.5 lb 0/32.9 1
18H ASCS yaw gyro output 3.3,* 2ocli 180° B 5/1.3° -60/230 1-8 Analysis Ail lh 10m 1 20th 1 5.17
15H ASCS pitch gyro output 1 90° A 5/1.3° -120/130 1
17H ASCS roil gyro output r 0° A 5A.3° -70/71.5 1fol
63H Gyro switch position On-Off •- .2k
- - -
600 ELECTRICAL NO. 1
3I4H Main DC bus current 3.3.1^3 . A 0.5 amp 5Ao 1-8 Analysis All lh 10m 3 avg/25 3 avg/5( 3 avg/25 5. *->
-.
REVISED MODEL
133
9H 02 supply pressure, primary 3.3.2 A 100 psig 500/7500 1-8 Analysis All \ Ih 10m 3 avg/25 3 avg/50 3 avg/25 5.58
12H 02 supply pressure, secondary 3.3.2 A 100 psig 500/7500
Calc
Calc
02
02
primary supply, Ibs
secondary supply, Ibs
3.U.l(c)
3J4.1(c)
-
5.65
\
Calc, Rg 02 primary supply, Ibs 10-11 Report All ; 5h 3 avg/25 3 avg/15C 3 avg/25 5.66
Calc, Rg 02 secondary supply, Ibs Itfti -
- - -
5.67
1000 ENVIRONMENTAL PRESSURES
6HL Cabin 02 partial pressure 3.3 .25:3 A 0.15 psia 3.1/15.5 1-8 Analysis All • Ih 10m 3 avg/25 3 avg/50 3 avg/25 5.68
8H Suit pressure 3.3,,2 A .075 psia .25/1)4.76 10-11 Report All 5h 3 avg/25 3 avgA5C 3 avg/25
22H Static pressure 3.3. lJ4.73psia A 0.15 psia ,25A*4.76 12-13 Analysis Exit km 20s 1 2nd 1
82H Cabin pressure 3.3,',2 A .075 psia^ 0.5/114.76 lii-19 Analysis Re-entry km 20s 1 2nd 1 5.85
1100 RCS TEMPERATURES
19HL Heat shield temperature 3.3.2&3 A 10°F -55/970 1-8 Analysis All Ih 10m 3 avg/25 3 avg/50 3 avg/25 5.96
Retro-rocket temperature 3.3.2&3 A l.5°F 0/118 10-11 Report All 3 avg/25 3 avgA5C 3 avg/25
- - 5lio5
MODEI
133
REVISED
21H "250 VA main inverter temperature 3.3 .2^3 "- A 2°F 51/251 1-8 Analysis All Ih 10m 3 avg/25 3 avg/50 3 avg/25 5.106
35H 150 VA main inverter temperature A 2°F hh/239 t 5hl3
21H, Rg 250 VA main inverter temperature A 2°F 51/251 10-11 Report All 5h 3 avg/25 3 avgA50 3 avg/25 5.11U
35H, Rg 150 VA main inverter temperature i — A 2°F Uii/239
i
i 5.115
lUOO ENVIRONMENTAL TEMPERATURES i
10HL Cabin temperature 3.3 .2&3 A 2°F 37/197 1-6 Analysis All , Ih 10m 3 avg/25 3 avg/50 3 avg/25 5.116
11HL Suit inlet temperature B 0.6°F U5/86
hH Body Temperature - A 0.02°F 95/106
P Comfort control positions i
5.123
10HL Cabin temperature A 2°F 37/197 10-11 Report All 5h 3 avg/25 3 avg/150 3 avg/25 5.121*
11HL Suit inlet temperature -
B U.6°F U5/86
UH Body temperature A 0.02°F 95/106 I
5.125
LlHL,P,Rg Suit inlet temperature B 2°F 37/197 12-13 Report All 5h 3 avg/25 3 avg/150 3 avg/25 5.126
UH,P Body temperature A U.02°F 95Ac'6
P Comfort control position i
P Suit heat exchanger dome temperature -
5.127
LOHL,P,Rg Cabin temperature A 2°F 37/197 11-15 Report All 5h 3 avg/25 3 avg/150 3 avg/25 5.128
UH,P Body temperature A 0.15°F 95Ao6 i
P Comfort control position -
P
P
Cabin heat exchanger dome temp.
Cabin heat exchanger outlet temp. f i i
5.129
1500 ACCELERATIONS
16H Acceleration, Az 3.3.2&li lg B 0.6g -20/30 10-11 Analysis Exit km 20s 1 2nd 1 5.130
81H Acceleration, Ax 3.3.1iU Og A O.OSg -k/k 12-17 Analysis re-entry Urn 20s 1 2nd 1
80H Acceleration, Ay 3.3.2&I* Og A 0.08g -k/k 5.137
1700 BODY FUNCTIONS
/
1.3kc H Respiration rate 3.h.2(a) 1-20 Analysis All 28m 5.138
1.7kc H Heart rate, EGG (chest) - t - -
3.»4.2(b)
UH Body temperature 3.3.2&3 A U.15°F 95/106 Line faired 5.157
•
i
-
i
18
«^^WPWw<^B?^M J I /At-
DATE 25 March MMNELL J. PAGE.
REPORT. 930ll
REVISED. ST. LOUIS 3, MISSOURI
133
REVISED MODEL_
\
\
7000 RE-ENTRY COMPARISONS \ •
- \
,56kc L Yaw rate and RCS yaw solenoid, low 3.l.3(b) ?• -. 1 Special Re-entrj 30s 5.270
Dynamic pressure _
- - -
Rg - -
Calc RCS H202 Supply (automatic) . » —
Calc RCS H202 supply (manual) . • . . i
.UOkc L Pitch rate and RCS pitch solenoid, ' - X
low - -
- - -
*
'
/ i
•
V
•—» '
s § s
3)sd 'sjnssaJd Xiddns SDH
S S
Bqj 'Xiddns
D$TE__ PAGE
MODEL 133 REPORT 9304
o
S
Ta
• •
_
§
Is
.*
1
s
I
s
s
s
Hill s
§
s
1 1 |
Sjsd 'a-inssajd Xfddns gOH
mmmmmm*immmmmmttmnammmmmmmm»mmmmmm
mmmmmmlmmammmtmmmmmmmmmmmmmmmmmm f
I
•••l!?55K5j!5SS!S55S!:55!SSr5S"
••••••••••••••••••••••••.•••••••••••••^••••••^•••••••!
•ft'j ••••••*«••
, . . - - . .. , . • •!!•••• ••!!••
• vi» • • • • • all • •
•i ••••••••••• • • • • •••••• ••••••• •
mm •*••••••••• • • • • •••••• ••••••• • ••^••••••^•M
---------- -•(•••••••liai
• •14«•••••?!••
eqa '
25 M&gch 1963 PAGE 5.13
133 REPOKT 930**
:::::::::::::::::::::::L::::::I;:
«
E 8
S S
«
** ^ ^
Sjsd 'ajnssajd Xpfdns goa
V&TE a? March 1963 PAGE
;
ll,f
'!>,'-,-
v&
1$'
|i» .'-. .
i.{?<•
?:fi'
i i.
-Jl
S i E
8 §
g «
§ I
S •'•'
' ,"i
8 t:
S Y'
,,
ertrt
HI
EDO sI••
§ .8
Sop -jmUno outS ipud 808V
25 March 1963 PAGE i 5.18
MODEL
L . . 133 REPORT 9304
"o
i
O
irt • • "i - J' r' =
* 'J 'r ': *—'"*T""*°
> - i i :'**r'-'-' '.~' -- r' =
' .-'-.''z. r' :.B
. ' i -' r - - S' y - - "-
~l_
Imf l
J lii
li ::::::::::: :::::::::::::::: ::::::::&:
s ;:;:;;E;;;;i;E:E;iEEE;E;EE;;EE;EEEEfc;
:::::::::::jj:::::::::::::::::::::::|:
• ••• -a l-2- = -
&r" i' 'i "
s
m BTI
iiEiiiiiiiiiiiiiiiiiEHiEiiiiiiiiiijjilii ffl^
- ? I o
g Jj S
h-^K'^^B^I^ i
c . .... ^ - ... co |- .... S . . . . os . . '
WO e MI
|ffl|||ira i
££•-•
i i i i i j i i i i - j L .iiiilljjiiiiiiJiiiijiii:! '
t OT re •?•s
tl t t t It! ftM 1IlitiiilH^iiliifHI
i||Hi»
:::::::::::::&::::::::::::::::::::::$::
, rt \t ••
| 1 |Mj ij | 1 ,^ffl
I::::::::::::::::::::-::::::::::::;:::::::::: «
| ?.
* .-,...?.... :::::::::::::::::::::i!:::::::::::::j|::::::3 §
!Hi!!i!HH!!!;!H!!!lii!;H!!!!}!!!!i!;!! !
s
:::::::::::::::::::::$:::::::::::::: i:::::::: »
[I J
I 1
3ap "indjno OJXS ipnd SOSV
uopisod
1
DATE
[
March 1963 PAGE
:0
:: ?. s
- ° ft
£
s 3»p ipjjd SOSV
MTE 25 .March 1963 PAGE _ 5.21.
o S
I
S § 8
Sap *}nd)no ojX3 ABJ! SOSV Sap "jratino oiM no-1 SOSV
O!
o
irt
i
T?f
Sap 'jndino ojAS «EX SOSV Sap 'jndino ojX3 n°J SDSV
n
uoftisod
Sap ^ndino oaX3 tpjjd SDSV
DATE ;March 1963 PAGE
MODEL REPORT 9301*
g
**
u
ftl
8
'S
o
8
8
§ •
8
8
S
S 8 S'S
8HB* «j(MU>d smq SIIOA 'aSBjiOA Bnq oa BTBW
sdme
25 arch 16 PAGE 5.26
MODEL 133 REPORT
•S. 8 SS
*J8Aod
sdnre *)U3Jjna
snq QQ
DATE 25 196 PAGE 5.27
MODEL 133 REPORT 930^
S
s
1
8
?• °i
o
C4
snq
snq QQ U^BJIJ
2 £ March 1^63 PAGE ' 5.28
MODEL
L : 133 REPORT 930U
" ' » M
3* ..;,..:. ...3 - -
to | „
i :::::• - - - J . - : --- : ^ ^
O, ; -
[ .....c «
i::::::::::::::::::::;!::::::;:::::::::::::: 3
_ _ ! i
[ P« 5 -
i 1
t i « -
:::::::::::§ ::::::::>: :::::J:::: ::::::::::
SJ !..._>-_.. o
A
•° Lt 1 M. 1 ' '
i ' - - -j • • • : ; : «
.._.._ i
llll Illllll i |||||.[i[i|i||ifi^^-y^Mj ^
-..- :.:... j
-IP
o
2
" : ! r :::;•::: t :•;•:•::::
£j • ;;
» mmE E E i i i E E E E E E E E E i E E E ^ E E E i E E E ^ . E E E E E E ! : : : 8 i
: : ' ::::::
»• -•-
1 II III! II 1 s HfGIIIBi ? II II § P.
i ...... n . .r. ......... _ (n - - , - ...... it::::::::::::::::: » :::;::::;: «,:::::::::: S §
:::::::::::::::::::JB :::!::::!: B:::::::::: 3 |
T 0 --' J' 0 - 1
u
II 1 1 1 1 1 II 1 1 1 1 1 1 1 1 1 1 1 1 1* 1 1 1 1 tl 1 D 1111111 111 '
I : : : : : : = ::[::::::::::::::::::::= ::!:::::::
* -.1. __.!£..-. _ . . . . _ 2 ..j.. . 1
r-- -•* >- - •* T5
:::::: a
. ::
..ii :::::::: :::::
.; :::::::< .:_ !i ::::::::::::::::::::::::::: o :i: ;::::;:>:::::::::: ° g.
...j...._.
-... .i , L o
1 , i E;;;;;;;;;;;E;;;;E;;;;;;;, ;:;;;;;;;;;;;;;;;;; i
::l:::::::::::::::::::::::::::::::i:::::::::j 8
- - < • • •• ...-,,.. g o
_ - 4 . . -i »- 1
rtl . ~ -- •- - - ' • - -
c i :::::::::..::::::::::::::::::::::::::::::::::_.l
EEIE;;EEEEEEEE;;EEEEEEEEE;EEE!EE
c :-••[: j
— ...1.
:. — ! o
O
-1 - [ • -; [ o
s s ss
snq SHOA «a2ntOA snq 30 npw
*panddnB £3J3aa
i 25 March 1963 PAGE 5.29
MODEL
IL 133 REPORT 9304
1
S ::::::::::::::::::::::::::::::::::::::::::::
! i i E E E i l i j i i E E E I E E i E iE i E
s - .
luiii
iiiiiiiiiiiiiiiiiiiiiiiiiiiiiiini!^
iiiHiiiiiiHiiiiHimifiiiiiiiim?.
BI 1 _^
r
,•
><< • M< • » -
05:35
E „
05:SOrfX)
, I ! ^ » « , , !,.,!,,. ,| « . [ , , - , , i
05:25KK»
. \
n^anilflme~ hour»:mlnute«:«econd«
05:20:00
CO ffM •• & 3
..,.. titi ' 1"
05:15:00
3 : : : g ::l : : : : : : : : : : : : : : : : : : : : : : : : : : : : : : : g :
• 5 ; ;; « ; ;] ::::;::::::::::::;::;;:;;;;;;;;a ;
•. >i. , , .. ..s3 : : , ; : : : : : : sa -.
• ! 1 • i'i , !| * i
OSdOtfO
'riilillilllllHI !
: . 0
OSrfHrfW
M
:00:00
r II
:::::::::::::::::::::::::::::::::!-::::::::: 8
I II 1 1 11111441 I-H *•
:;;E;;EEEE;;E:;;:;E:EEEi;i:E!EEEE;
8
00
o
!•
ID
in
s
g
s
8
S
S
i!
s i'
8 6
ii
2S
awn* *J9*od »IOA '
°
«,BM.nu,
ffeirch 196^ PAGE
MODKL 133 REPORT
I; J
§
. 00
9
6 ;: bo
o c
u T*
- 3s
'.'. fc> ~
Artter
H
——
!+
Ili >!i
""
8 S
s e
S S g . S
• • mrt MI
• r ••,• • !•-
• • «rt «dau
• r ••_• • ••*.
• i •?• a«Bu
r *«.i ••»..
S• •
r
•••
«M
»«ft--
•••»
* 1 1"
I.
DATE 25 March 1963 PAfiE
Si
8
a.«
*§
B?IOA
admc snq
PAGE 5.36
MODEL 133 REPORT 9304
I I
8
8
adore
DATE 25 March _ PAGE 5.37
MODEL 133 REPORT 9304
snq
DATE, 25 March 1963 PAGE
MODEL 133 REPORT 9304
sdmc 'juajjno
DATE £5 March 1963 PAGE 5-39
MODEL_ ; 133 REPORT 9304
a" Bp
!i
••••{•••••••••••••••
§
DATS 25 March 1963 PAGE
MODEL 133 REPORT 930^
?.
1
I.
i'i'i'i
o
M
sitq 30 umxi
DAIS 25 March 196l PAGE 5.41
MODEL 133 REPORT 9301*
g
DATE 2$ March 1963 PAGE 5,42
MODEL 133 .REPORT 9304
8
s
8
••••••••••'••••••••••••••••••••••••••••••••••••••••••••••••••'••••••••••'•••=)?••••
•••••••••••••••••••••••••••••• •••••••••••••••• •••••••••••••••• •••••••••••%•••• •a
S j o/o '^i<Mns
S»IOA
oonc)naaiiU)SDt ov A 1
o
i
§
8
3
g
11
8 |
§ 1
1 1
• •••••••••••••••••""•••"••""•-'••iM
o
eo
S & o/o '^lAfos jaood saq py
AA
o
SS
t
*a9e)pA snq 30 snq 0V
S 25 March 1963 PAGE 5.^5
a*
MODEL 133 REPORT 9?^''
r- ' ...» .. ( .-
^ IE ---t ...r.
; : : : : : : : : : ; : : : : : : : : : : : :i : : : : : : : : : : : : : : : : : : ::
S ::::::::::::i:::::::::::!l:::::::::::::::::;::
n
n
::::::::::::::::::::::::::;:::::: ::::::::: 3
: '..._.
i i .
, . - - » 3 - - ::::::::::::::: ::::::::: :s ::::::| ::::::::: 3
i ...I ,!...
\ 3
::::::::::::::::::::::::::!:::::: ::::::::: §
, O
. .. r ... | < j --
.1 i , --
: : : : : : : : : : : : : : : : : : : : : : : : : : :! ! : : : : : : : : : : : : : : : : : 8
i ..... »
1 .t -
1
:::::::::::::::::::::::::::E:::::::::::!I:::: 3
. . I ... - „-
gt i|i Ml •si
8
;| ;;;;;;;;:;;;;;;| ;;;;;;;:;;};;!:;;;; -?
- * a ...1 *5 is
* :::::* :: :|::::::::1 :::!:::::::::::::::;:: s
: *m* § gmfl ? I II rfffffffflgTMti-
tiiiiiSii iijiiiiilBiiiiiiiiiiiiiiiiiiii!! :o ii : ii : ; :i ; : :: :i« ::::::::::« n;::::: *
S | -- •;;! >. t..< ,.-
- < a . ..'. u o «
a
:::i: : : :ii::::::=I ':'::<:':': \ : : : : : \ \ \ \ \ ' : \ i :
-1 -.;-••• • • • - - -
i. ..... L 1 [ -. ::::::::::::::::::::::::::;::::::::::::;::::: g
, . ., , ! ..
. . :: i ..
. .1 ,k ,..
::::::::::::::::::::::::::::::::::::::::::::: 3
I:::::::::::::::::::::::::::::::::::::::::::] 8
::::::::::::::::::::::::::!:::::::::::::!:::: 3 ,
I::::::::::::::::::::::::::;:::::::::::;!:::: 8
i::::::::::::::::::::::::::;::::::::::::!:::: 3
:::::::::::::::::::::::::::!::::::::::::!:::: §
" s s g g
*4
S
*4
38
^1
S i. o/o 'SjOOaa .
UUm|lfl^«nJ^fllH ^ JV A i
a SS
«« so «o
*• S 8 S
sjfOA 'a88)|oA snq 30
DATE 25 March 196^ PAGE 5.U6
MODEL, 133 REPORT
D
•
g S S 8 Sw
**
g
S j o/o 'XjAlnB jaood
snq ay K>W
S
snq OQ 'aSejiOA gnq oy
DATE 25 Marc
MODEL
DATE g.3 March 1963 PAGE
MODEL 133 REPORT 530
S S S S S
S
«»1<U ajpu
DATE 2$ March 1963 PAGE
S
*a8e)ioA snq oa Bjp)A
?
I.
r escape rocket fire
§ : :::::::::::::::::::::::::::::::: g
3 :S - :::::::::::::::::::
"o
i*
; a,::::::::::::::::::ii:::i:::::::±:
eo - - _._...... !iiiiii!!::!!!!!!:!!:!!!!!jli!j!! S
«
:::::::{• EiE:ii!i?i:=Ei=EEEiE!=ii=iE=iEE=! 8
:
:::::::( 1 :::::::::ji:::::::i::i:::i:i:iii: g
|JlJlJlJiJl]'iJlJ]JlJiJ|J|Ji| j I* • [ ; ";z;^;i!;r; ! • i • z; i ; z
I;;;;;;;:];;;;;;;;;;;;;;;;;;;;;;; g
Illllllmllllllllliiiiiiiiiiiiiii g
S
r i
DATE 25 March 1963 PAGE 5.^U
IllllllllllllllllllllllllllllilHtf^i8 |
1 1 1 1 1 1 1 1 1 1:1 1 I 1 1 1 1 1 1 1 1 1 1 1 1 1 1- !!llilllll!ll:ii!!!i!l!!iiJ!![!!!li!!!!!li i. I?. 1
s 1 1 1 1 1 1 IB \l\\\ 1:::: a
i :::::: .§ :::: : :::::: ::: ::::::::::::::::::::::::::::::::::::::::::::::::::::::::: : S :
g :Eiiii!!i!^: ! v^
:::::: a :::::::::::::::::::::::::::::::::: ;iii;;;;;;;:; ; s
— . ,. . _i
:::::::::::: : §
:::::::::::: !::! s
i ---• g
1 Q §
.1 3 o
;;;;;!;j;;;; ; s i ,
|
i „•; iiiiii;;;;:;;;:;!;;:;;;:;;;;!;;;;;;:
illllll 1 li i
:ii:!:iiii:i:iii::ij i i i i E E i i - i i i ii:!j:: ii | J .
ill •
ji •• ••
::::::::::::::::::l| :::::::::::!:::::!! : I
Oii :::::::::::::::::::::::::::::::::::::3 Illlllll Illl llr 9 "! Ill III III Illllll I s
;;i;i;;;j!!i!ijijii!jlijl!!!!!!ll!l!!!ii 1-
i
8
Illlllll | 1 III II II 1 Illi s
:::::::::::::::::::::::::::::::::::::::::::: 8
o
:::::::::::::::::::::::::::::::::::::::::!;s: 3
flB
::::::::::::::::::::::::::::::5i:::;:::::: ::
::::::::::::::::::::::::::::::::::::::::ij::: 8
Illl 1 II II Hill g s
:::::::::::::::::::::::::::::::::::r:::H!j S
8 1 g
/ (PATE sfc March 1963 • PAGE 5.35
[MODEL 133 REPORT 930^
?.
S
*
l
§
s
5
'
Q
9.
'
§
-.?.
3
''
J9A|909J .
POBUXCDOQ 'uVii iflSn^qB pra8|B jaAjaoaj pmtoraoo
DATE 25 March 1963 PAGE
MODEL 133 REPORT 930^
s;
Si
•••••••••••• & «•
mmmmmmmmmmmmjffmm
'uVu
DATE 25 March 1963 PAGE
8 S 8 '•!
_ tionim
'uVu *n**"i* i«o8|o JOAIOOAI pmramuo
DATE 25 March 1963 PAGE_ 5.58
•I^BI^M
?. 5
?. 8
:§
Q) *"•
II
H^
8
§
f
DATE 25 March 1963 PAGE 5.59
MODEL 133 REPORT 9304
.&-
8
o
V*
3
8
8
I
8
g
8
m
s
s
8
:00:00
02:55:00
I
ed ti
sqi '
DATE 25 March 1963 PAGE 3.61
f
§o
I
§
(A
3
O
o
o
«
s
§
iT)
s
25 March 196? PAGE ' 5 . 6 2
«» p ;
••••••••••••••••••••••:••••• «•••••••••••••••••
T5" " •••••••••••••••••••••••••••a •••••••••••••••••a
•••••••••••••••••••••«••••• • •••••••••••••••••
iiiiii ** ^M
EiiiiiiiiiiiijiiS I
::::::::::::::::« 9
••;• 1
S i ...
g
B. fft B: u mfl
: . ..
£c :
•
:
•
: ::
• •• : : : : : : ::::::::; S
1 : : :::
•• • • • •• S
•: • • • ••
^ i.... K
•:
B
•
•
•
••••
••••
• ••- • m mm mm •••• Eiiiiiiiiiiiiiiil '
!::!!!:!!!::!!:!ii::!!:!!!:[!!::ii:!iS!:!!!:i!:!Ei;:n:i!i:
:::::::::::::::! S
\'::.\::':\:.\':\\:.\
- is8
AjBiui-id 'aJnsBajd Xtddns «o :::::: :::::::: g
V 'ON strnv-A-inajan
;>* .; .. : . . ,. • JJIJIIIIIIIJIIIJ 8 |
- M • - 1 3* • | | ? - §
- >, • • ' •
: : : : : : : : : : : : : : j, ::: :::: > - : : : : : : : : . : : : : : :
:::::: : : : : : : : : : 8 1
(lltllillllHHI i
£npOO338
:::::: : : : : : : : : : 8
W:55.-00
1 L ....
1 1 i 1 li IHI8IIIIIHHIHHIHH 04:50:00
04:4SK»
40gO
eqt 'j
DATE 25 Mac
i
8 «
? !*i
:cf i
I
?.
I
to
•p.
S : : : : : : ; : : : :::::::::: :::::::::;:::::::::::::::
^ i E
> • i
g ::::::;::::::::::::::::::::::|:::::::::::::::
::::-::::::: ::::::::::::::::::::::::::::::: S
:-
07:55
. . . . . - . ! " . " ! , . : . ! . . t ! . . E ! . E : " . . ! 3 - L ! : . . !...!:.[:::[! I..!:..::. . " ! . i E ! . . . _
:!..T!.'....-l.':'.£iS.!B2.L[l.Lii..|ijLEi-iM-E|4.Ml
::::::::::•;:::::•':::
; ; : ;
:: ::;
07:50:00
-i i Li.LLi 1 1 1 1 i.i i i LI 1 1 1 i LI rmu..
07:45:00
Oj supply pressure, primary -
: : : : : : . . : : . ^ Pi primary supply
07:35:00
:::::: secondary
07:30:00
©
• ; ; :
07:25:00
..!..-'....•
:: :::
: : : ; :
7:20:00
;
k a
:::::::::::: :::::::::::::::::::::::::::::] §
• i ...... 1 i! i
H i l t ' fttl t ls
::::;::::::: :::::::::::::::::::::::::::::::: S
••'••"
m » ... 1.. ,
d • i •• ::::-::::::: :::::::::::::::::::::::::::::::: S
c ::::: :|::: :::::::::::::::::;:::::::::::..:::: E l ! ! : ! : ; ; ; ! ! i i i i E E E i E E E i i i E E E i E E i i E E E E E E E E ! 8 -
:::::::::::: ::::::::::::::::::::::::::::: S
:::::::::::: : ::::::::::::::::::::::::::: 8 :
::::;::::::: i::::::::::::::::::::;::::::::: g
n
§ 9 a a g » " ~ ° S .
;!;;;;;;!;;H;:;;;;;i;;;;;l;;;;;;;;;;;;;;;;;;:;l
^^^^^^^^^^^^^^^^^^••••••r«B> •••••••••••»!•••••• •••••••FIB mmm
- 0 - 1 - - £-5 •-•
, £ >. h'O.'0:. * _ * . . . 8
8
: : : : : : : : : : : : : : : : :::* : = Ss: SfE •? E: :::
iiiiiiijl tilllilllll 1 H § §
ffmnJ
;;;;;;::;;;;;; :i;;;ii:;;;;;; •§ 1 ;iffl*
ml m ml f" F ;;; ^
I;;;;:;;;;;;;;; :;;;;:;;;;;;;;;: 1 ;§ ;* ;;; § |
111
P= mmf mm
!!^ p.i hi
if •
}. * o 0
E,;;;:;;;;;;; :, ;;; i a «;;;8
r|:;;:i;;;;;;
-••-•
;;|E;;
- §• w;;;;;;;;;;; i» «
E| ill i
E g ; ; ; : ; ; ; ; ; ; ; iliEiiiiiiiiiiiiiiiiiiiiii!: •
I
Ecr;;ii;;;i;;: iEd-:;;;;;;:;:;;;;;;;;;;;;;;; |
8
^llllllillllllllllllllllllllllllllllllHmttta?.
j tin
:::::;:::::::: ::::::::::::::::::::::::::::::: 3
:::::::::::::: :::::::::::::::::::::::::::::: 8
;;;;;I;;;;;E;;
i
;;;;;;;;;;;;;;;;;;;;;;;;;;;;;; ?.a
:::::;:::::::: ::::::::::::::::::::::::::::::: 3
:::::;:::::::: :::::::::::::::::::::::::::::: §
^ 99 « <^ O G9
O
PATE 25 March 1963 PAGE
REPORT 930*
K3DEL 133
DATE 25 March 1963 PAGE ..67.
32
.??
3 *
g
© to
'/Cjddns 'o
DAlE 25 March 1963 PAGE ,-68
MODEL 133 REPORT 930^
Bjsd '
DATE 25 'March 1963 PAGE V • 5.69
MODEL RETORT 9304
8
"
"s g
DATE 2* March 1963 PAGE 5.70-
MODEL 133 REPORT
I
B
E
DATE 25 March PAGE 5.71
MODEL 133 REPORT 930^
s
3 i;;;;;;;;;;:;;:::;;;;;;;:;;;;;;;::;;;;;;;;;: i;:;;;;;;;:;;;;;;;:;; ! ;;|;;:;;:EEE;;:;E;:;;!;
3 '• -
s
s
i m ml E
i!i!!i!!!!!!ii!ii!iil|!!!!i
::::::::::::::::::::;•::; :::::g
-!!!!!!i.
::::::::;: S
Hi gfl .5 Li s .,
o
a, . ' " " ... -. : ; : : : " : : : : :— | ! •• ;3 a ° • •; • g : 9.
i)..s3 § -J3 «- i'.
o- - -' *• a t- 5
lmfffTilBI-8 •
:,, (. «
:;;;:;:;;;:;;;;;;;:;i!;;i;;;;;:^:;;;;;;;;;:!; s
- i r - - k
a-
SS'is ± S- <=>
::::::::::::::::. :::';;|:::::::::::::::::::::: S
s
I fff m --^M lH
||||||||||||||||||||i||M| s i fH||[fiiH|^ 1
::::::::::::::::::::;;::•::•& g ::::::::::::•: «
- - - ! ! . -i. .2 ° -j- ,[. o c
:::::::::::::::::::::;;:•- ^±:: ::::::::: 9. S
T : - - T - - : - - M : - E - £ §•-::::•-::::•• 2 S
CO --- > i - *> - g g -— » - y D
>•--.- S S >- o a
§. ;;;;;J;;;;;I;;E;;:;;;;:;;;;;;;;;;:E;;:;;;;;E
3 ;!J;;;J;:J;:;;E;;;;;:;:IE;;;:;I;;::;;;;;;;;:
£• : ::••• ± :::::::::: S g::::ii|::::5 *:::::::£ ::3: * *
1 3 ....|[.,..-3 o f - - : . - I - - J - g a
::::::::::::::::::::!!::«:::::::::::::::::::;: g S
:::::::::::::::::::: E i ::::::::::::::::::::: B : 9.
-(•-:• 1• n
j•••< *• o
;;;;i;;;;;:;;E:;;;;i!;;i;;;;:E;;E:;;;:i:;;;E!; §
!..: 3. m
;;;;;;;;;;;;;E;;;:;;J;J! ;;;;;;:;:;;;;;;;;;;:•; s
;;:;;;;;;;;:;E;;;;;;!;i|;:;;M:;E;;;;;;;:;;;s; i
• I••;'•• ( o
::::::::::::::::::::j::!j:::::::::::::::::::!3 g
J a- - ' e- «
9--nS e- o
£ i;;;;:;;;;;::;;;;;;;;;;;;:;:;;;;;;:;;;;;;::: 3 - - - 1
nB--><
T 1-
a-
0
9
m
j||| | ||[ [IIIJII 1 1 1 1 1 1 1 1 1 1 1 II II 1 1 i 1 i°i •
1 |||||||||||jj||j: H I M
- • j r" ' ~ $' O
:::::::::::::::::::H:i!:::::::::::::::::i:i §
s s s s eo <D ^r ca On
O
I
VIE
DATE 25
2j> >i
March 1963 PAGE 5*72
03
09:39:00
e -s ,
s 'S '
O O
§°
» s.
*• «
§
DATE_ PAGE
•••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••El
I *
I I
..... m.
I.
I •P.
a
3
25 March 1963 PAGE 5.74
jj : : : : : : : : : : : : : : : : : : : : : : : : : : : : : : : : : : : : : : : : : : : :
? :::::::::: : : : : : : : : : : : : : : : : : : : : :::::::::::::.
°- 1 1 1 1 1! 1 1 1 1 1 i 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 It'll
g i H8
||.|||.|j|.|-)|[||.|f||(.||^^.fj||f|||.f||.|^^ g . .
II \ijjmt
:::::::::::::::::::::!i::: ;:§-:::::::::::£: 8
=ii!ii!iiiii|i=ii:iiliii!ii!g g-iiiiiiiiili ?
:::::::::::::::::::::;;:::!:: g I E : : : : : : : : ; : S
:::::: : : : : : : : : : : : : : • • ! [ : : • ' : : .= ° ::::::::: E: ^
<' g 5 •• g §
|:::::. ::::::. ..::::,,::: i: « «^. ..:::::,: o |
m . . . . r - . . . .
;;;;;;:;;;;;| § = ; ; ; ; ; ; ; * & ; ; ; ; § : ; : g i •
£ ::::::::::::::::::::::::::::::::::::::::::::
5 ^iiiUMcr °"ffia^-^ ! i
i L . .i i . JJ
: :•• i r •• i ••::;::::::::: — r • «.
:::::: ::::::::: ::: - j ! - - | ••::::::::::::--•-!• B
:::::; : ;;;:;;::;:;;;;i!;;i ;;;;:::::;!:;;;;:;•; g
;;;;;;;;;;;;;;;E;:;;;!t;;!;::;i :;;:;;;;;;;!; i
::::::::::::::::::::! ::!::::! :::::::::::!: 8
:::::::::::::::::::::; ::| ;::: S :::::::::::;: g
1 - • [ • - • - -:::::::::::: S
pU- 4-1- t-t •l-t'U i *i" i -.1 L.
S 21 « o oo <D ^ eg ° E*
DATE 2!> March 196j
PAGE 5.75
MODEL 133
REPORT 9304
a
•o
DATE
i ' :i 25 •March.
- -J-J -_ - - - . .
1963
- -- ^ ---• - L_-
PAGE 5.76
s.
8
5
?.
?.
S
8
S
8 1
i: s
s i
If 1 I
r. I
S a
O ~ i!
a. o. iL
rf
=
s
2. a. a
• £ • 3 0
C C C
f
§
Bisd 'a
DATE 25 March 1963 PAGE 3.77
MODEL 133 REPORT . 9304
o
o--
eisd
£5 March 1Q PAGE 5.78
MODEL .133 REPORT
JBSii
DATE 2S March 1963 PAGE
o B
a o
rf
S
§
Hs- R
*I
8
DATE 2^ March 1963 PAGE
MODEL 133 REPORT 930*1
f f t""t;J.IJ.IJ.Ij.lJ.lj:^l:+ IjlUJJi
o - - - -
:::::::::::::::::::S::;j::::::::::::::::-j: g
EiiEiiEEEEEEEEiiEEEiEEJiEEEEEEEEEiEEEEEE^i; s
I;:::::!:!!!!!!::-':::::!!!:!:!!::::!!:!!!;!:
= 6
5 :::::::::::::::: g :::::::::: :::::::::::::::E i E E i l E E i E E E E l i E l E l l p J E l E i E l J E i i l p
1 BllliPiftl II ;!i;;;;;;;!!;;;;;;;p!;;;;;;;!;;!;i;;;;i; i
j ; r ;.-;'•;
' --
rt
:::::::::.".:::: S .::::::::::::::::::::::::
i 1 1 1 1 i i i 1 1 i i i 1 1 1 i i i i ri i 1 1 1 i j i j i j i j 1 1 j i j - - - -
: :::::::::::::::::::!:::•:::::: :::::::::::!: i'
0
aSH^n^>«^^i2j-iaL.iB..!!..9t..»8
:
'.'.'
08:50:20
- + Cabin O2 partial pressure (h'gh comm) [:
08:50:00
^>- Cabin O, partial pressure (low comm) b
08:49:40
CO _
I ::::::::::::EEE::::::E:EEEEEE::EEEEEEEEE;;EEE
e f l e ' i f l « UJtUUiij
08:49:20
Static pressure
3 i::::::::::::::::::::::::---::::::::--- S «
>, - g a
L
r iB t
t, - - - - - - - - - . . . - - - - . _ _ . 2 IDQ
?, tttttilrh a :S
c ! fUikKWn
| :::::::::::::::::::::::::::::::::::::::: 0 :6
08:49:00
:
1 '•[ 1 i " f ' i ' ' " • > > L '"' r r i
'.' '. :::::::::•::::::•; * 5
O
::::::::: ::::: o<
-tM!fi!.OfS-!o Uil
08:48:40
L L i ! e ? LiBJffjJ4il]J.4il
--
08:48:20
1111
mSiMf
EEEEEEEEEEEEEEEEEEEElEEEiiEEEEEEEEEEEEEEEEil! |
:i:i:::::;:::i::ii::!;::j::iiii::::::::::::c: g
lllllllillilnmiiiarrHilillnllllinlBI *
!!!NH!!!!!HilH!!i!H|jHH!!!!!!HHHii!i
^ • ;• • ; - : : ::::
. . _ _ . . .. M i - > . - "
L 1
c ) I:::::::::::::::::::::::::::::::::::::::::..-
1 : ::::::::::::::::::::::::::::::::::::::±:::::E E E E i E E E E E E E E E i E E E E- gi S E E E| I' j E E E E E E -i i E E E E E E i EJJ-E- g
c > HI---*
c ---• j
:Jr: 8
t. o
CD ^ CM o GO Q> V C3 O QQ
DATE 2!> March 1963 pAGE 5.51
-i --<•>-
----- .. J .. 2 .j-
O _
8 :::::::::::::::::::::::::: I vl-
i ::::::::::: ::
O .---_. _ . _ . _ _ _.
- o *" ~"
a, ::::
- (O
: f
: 8
- . .: . I. : 8
:
§ .:
i-
;: S9.
:
S
- --..(-
: :::::::::::::
§^g ifm : E -g::: :| - =!
" a . *.-
-: :* '• ^
... .. ... . _ j= i-i _ .__i_- W"
3' ^S
81
« S
::::::::::: ::::::::::T£ £ --: : : ; • « : "*-- " i' eo m
0
;i!::!>-^;:!!i;!!!Ji<n!;:j!i]H!g^!!^^
08:54:00
3 :-.::::-.::: :: .-.::: :::-." .::::::::::::::::::::.::
,
* « 3::: ::: !-
<
Static pressure
::: :: ::::::::-: ::::: g S t S --: ::: :s:
g- ;::;;;;;;;;;§ ;: ; ™ :E;;;;:IEI:;;;;;;II;EIE: l -°"°";;: ;;;;{;
g
:::::::::::::::::::::::: | i a &::: ::3:|:
,5 illllillili
o. e c c j . !-
08:53:40
J
^ 'w
a 5 S 3: ' < :
-a • -r-
$'
:::: e
... • a; ' :::::::::::::::::::::::: < o •»•-<>•::: : : : : < -
-. D
.-..:::::::: : a :::::::::: - --i i-
08:53:20
e tttttttftn
:::::::::::::§ ::::::::::
08:53:00
±
::::::::::::::::::::::r
--
S
-i bj
:::::::::::::::::::::::: g :::::::::::::::: ?.
— 6 J. m
<u _ , ( -
::::::::::::::!]: §
o :::::::::::::::;: g
• e - - - ---;- L. m
:::::::::::::::!: §
_:•:::*:•:::•:::•:•:"":""::::::::::: : i : \ \ -
::::::::::::::::
. ..
: ^
-i-
i
:::::::::::::::i!: §
— - ! -
JU. J_ _. — 1 1 - ,L. O
-- -- • | -::::::::::::::: : S
<D ^« N O 00 W ^ 0 g
TH ,-f
DATE 23 March 1963 PAGE .5.82
MODEL 1:3 REPORT 930^
ejed '
DAi-E 25 March 1963 PAGE 5.83
MODEL 133 REPORT
6 'g
6 P
sI
fI
11
s s
a a
DATE 25 March 1963 PAGE 5.84
MODEL 133 REPORT 930**
0 ... go
1
u
«:::•£
'gij.ge
- rt 5
e
II
9.
o g
§ § § S 1 1 § S
i. 'anquadmo) jno Ma« t"!"! i, 'uttpuadma) jna ^^ (apri pioaaios \)«H S3H
J I I
§ s
1, '•nquadaot inn ,&, ^pq pioaapB VH BOH »nn l^u
1
8
is No. 8
>
j
•
•
Plot number U
§
9 ..-.
Jal 1 1 1
._..
_ . .—
_ .-_-_—
::::::::!:
_ .
. .
§
"
mtffttmi
- - - - (K
0)
'mtfflffl'-s
:::::::::: "3w
i, :::::::::: o
_ _
t>
- <* r -••- - - - - - - - - - - -
i :::::::::::::
§ """"" .£
it temperature, low - \
1 1 1| 1 1 1 i 1 1 1 aT
.
•-
...i.
J_.
I..
1--
- - . , _P
_-..,
§
:::::::::::::i!;:[!!::j!::;;:;;;;;is:L!2:::
E...!
..»
• T "j "" ' <
1__ .3T
p. _-f
I _ . _3
-- f
.-L
1-- '-•;
...;... 3
.-5
t —i
9 1 ; 1 1 1 1 ; i 1 1 1 1 1 j: : - . - M \ : \ \ :
. . -B ~
_ ». . . - k -
j[!^.,.Hj-^.r|,^,|(-.->i:t:-.5
.J___
"-'::['-':\\'il\
-
»
[ . . . ] [ _ . oT
---j 6 RCS H2O2 solenoid inlet "B" m
._.
g
/\
- •-1 yaw left (automatic) (segment 14)
So
--- g --
_
_
_
_
_
-
• i E i l i i ^ E f i "i
i
\ \ l l \ \ ] : " K r-
~
.:
-.-
_1
---t imiHiiiMiiiiiiimmiiim
..-
_. .._
\\\i\\'-\'-'-\ i -:-
\'.. :::::::: a RCS K2o2 solenoid inlet "B" m t temperature, low ' " " : -::•
°
" 0
-
----1
>!-»<-. , < - . : i - > i ' - [ E ! - [ i l . [ i i . [ i i . L E J . [ E J . ! T""rj''i''ij]"i'''ijM'ij]riij[:j-i5;";
S
s
><> < > i k 5 - [r S J L : : : . r[ ? : . _9:
- . . - . , . - ... > i :.*! . • . * : . . * J, . L a i . L ?.!.
..
- ^>-5rs«r;i3-E«<-"'-E5i-;si-[» - ' -
/sj— / < - - - -
::::^§2, /£:::;!::::
::::..:..:...:.., ::..:.
::::::::::::::::! ::::::
mi
--
150
---1 + RCS H2O2 solenoid inlet "B" nut temperature, low —
- - - ! - - roll ccw (automatic) (segment 27)
i"f
- --1-- I | | | i : 1 i 1 1 1 1 1 | | 1 1 1 1 1 | | | i in | ' [ i f
! ! i , , ! H l ! ! i j « B ! : 8 ^ > 6 » J > ( ^ . "[ • * j i, <j ^' | '>i i' ;» « ' ' E^ Ti*- '' i IS " 1
5 £ ? 5 £ ! f ! : < ' m ' ' ! I'm!!!!!! j ^ , ; ; H j
«-'Mj»;--j;-:rl'j5(?|l'
I
100 1'- '- .j __ :(!»»!.!.- ._
- f - - - 5 :--":
ffl g frffii
REPORT
:!!;;!;j;li;!3=;!!!!!;l
1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 If 1 II 1 1 j [ 1 1| 1 1 1 1 1 jf 1 1| | ' ' 'fHlffl
«
1s ?iftffP
{•
s
§ •g 8 S °S
l
piouaioa o*H SOH Jim ,.H., l<>m Ptonaios 'Q'H SOH
I
0
8 tn
Jo '
— Ma,, lam ppuaps ^'H SDH
DATE 25 March 1963 PAGE 5.93
MODEL REPORT 93QU
8 1 §
i, 'MitpuodBiai jnu Ma.. J8TO piouaibs •Q'H SOH ., jajpn ppusfos ^"H S3H
o
B
JOT ,,a,
PATE 2$ Marr.b 1963 PAGE
MODEL 133 REPORT 930^
§ §
'ajniuadmo* inn ugu )apn ppnaioa V/H EOH 'ampuadma) jnn ,,g,, )ajui piocajoa •Q'H SOH
I I I I
DATE 25 March 1963 PAGE
REPORT
MODEL .133
DATE 25 March 1963 PAGE_ j>.?6
MODEL 133 REPORT 9301*'
MODEL
MODEL
s
«o
s»
npqs jajno pire piap)B JESH
DATE 23 March PAGE 5.103.
MODEL 133 REPORT 930V
?.
?.
I.
S
5
8
s
S
1
e
S
Vrapuadma} ;ec|3(u-oJM|
l l
4, J«)HD poe piarqg ?*3H
DATE :
25 March 1963 PAGE s 5.105
••••••••••*•••••••••••••••••••••••••••••••••••••••••••ri
•••••••••••••••••••••••••••••••••••••••••••••••a ••••••r •«••••••••••
••••••••••••••••••••••••••••••••••••••••••••••••••••••r
••••••••••*•••••••••••••••••••••••••••••••••••••••••••r....
•••*••••••*••••••••••••*••••••••••••••••••••••••••••••*••• ••••••
•••••••••••••••••••••••••••••••••••••••••••••••IB
••••••••••••••••••••••••••••••••••••••••••••••••a
•••••••••«•••••••••••••••••••••••••••••••••••••!•
3 8
i
'ainjBjwJtaa) on* jajno poe piapjB ^SH
SATE 25 March 1963 PAGE
§ *
8.2
9.
8 8 8
25 March 1963 PAGE 5.107
MODEL 133 REPORT 930**
s
s
8
o
S
I
8
§
S
I
s
I
m
5
si
1
OS o
I
f.
8
S
S
S 8
TE 25 March PAGE $.108
MODEL 133 REPORT 930**
§o
5
§
§
I. I
+ .8.
§
6°
§
o
25 March 1963 PAGE 5.109
1
t
&.
DATE 25 March 1963 PAGE 5.110
I§
ss.
I
8 §
—+ B
S
s
3
?
I
8
s.
DATE £[• March 1963 PAGE 5.111
1
•aB £
8 s
8
DATE 25 March 1963 PAGE
8 5 8 8 *
\
TATE PAGE
March 1903
a s
1*
-© JB
« 2 oo
jjji
BoQO
:::
DATE 25 March 1^6.3 PAGE 5-116
- r
§
- 4- - - _ . . . _ I - _ B- _ . - _ ..
: E : ^ : :::::::::::::::::::::::::::::::::::::::: <=>
0 — '-•;
::[;:::::::::::::-;;:::::[:::::::::::::::::: 8
: : : : : : r : : : : : : : : : ^ ::::::: S. ::::::::
'- - f - -
:i;!:::::5p:::!:»:::::":::::::::::::: |
-*• S" • • *-t - - > 2 :-!::::::= 1 ;-::::;!!:::::::::::: * ':: ~'*M
;:;!;::;:;g, S : : : : : E E i : ! " " E : : : : : E ' S b ::
ifit
- -:• • < ? s ------- -
« s 1 1 1 fji m 1 1 1 1 1 11 1 ~n
s. - - 8 '
S"'-^,'
1
ill III- I
•P^M• 1
\\\\im* Nl
:::::::::::|:::::::::::::::!:{::::::S ^ § g
EEEEEEEE::l!EEEE-EEE!jEEE!EEEiEEEEEiJ|E? S
8
;EEEE;EEEEE:iE::EEEE:?EEEEEEEEEEEEiES*E!
:::::::::::!;:::::::::::::::::j;::::sS; ^
ill
E . ! E E E E E E E E E E i E E E E E E E E E E E ! E E E E E E ! E E - filf
§
( ! i
§
:si::::::::::!!::::::::::::::::::s::::::::::: 8
o in o O o o o o o
; - * oo e* to in O
• uopisod IO.TJUOO ^jojtaoo
Jo *3<nqcJadtQa) i^nn )fns
^^^•^^^i^
S
1
o *
o *
o ^^H^
o s
S S 8 a §
Jo
'ajmsjadma)
DATE
PAGE 5.117
REPORT 930^
MODEL
E; o 1
:: S S
MODEL
DATE 25
^
/
13fr
o
B
Mercury-Atlas No. 8
S
o.
CO
L
o
March 1963
- T -
::::
=j==!jEj;ii;;=»;:-;E-;|E»»™»;»™;:;;
t (tlfttrn
•
C4
o
- Suit comfort control position
•
' :::::::::±:
..
OH ::::: :::::::::;ci
:::::"" = :--•
O
2
*-*
'+•'• •- ::.::::
- -e -1 :-.
J
-
O
O
In n rH iWlfWW 11• • 1j jIDlI
' ! < u i i Bi i ; > "m
"m r 5IE
(•
2
S
"'-.rS|:r-
g----
ll 1 1 1 1 : 1 1 1 : . : i i : : : : i : u.i i : : ; , i
j Q Cabin temperature (high comm )(segi
OS
g
O -
_
'
\--- A Suit inlet temperature (low comm)(se
||||||||iiiiiiiiiii i
S
x - i T i 1 1 1 i i i i i i i 1 1 1 M M ! - -:TT: : :-:•: ; ;T
+ Suit inlet temperature (high comm)(s
„_
r
.!
i •-- j .
\
g
-- C - - • !
;:;EEEEIEEE;EEEE3EEEEE;EEEEEEEEE;EE-8:E;S;;EEEE
r +
III II^JB
_
_
.
.
.
.
.
1 1 i H 1 1 nffirnrnril H'ffll H HI n
:
_->
........... 1 1 1 1 1 j 1 1 1 1 1 1 1 • Power do
IIIIIIPsHi fiBBIsf
. .—
_-_-.
.«P
-.._.
m»THS
_.__..
P/XG15
_
REPORT
::.:.::.:.
::::::::::::::::
- : . : : - ±o± ibody j|flllllllllllHirrrmTff
l | | | temperature
(1Jgh comm)(scgnl
§
in
;
. . -i
. •- i J
..,,1.
L
;;ii<r»i<HiHriB^;n:m:m:iu;;r:mi;;i;;5i3;
- - _ J -.
. . _ .. -
_ — - " ~7 ^
..,L
..^l
. _ , I 4-
. ._. fi-
J_, L_U
Jo
|._j
ipoa
::::::::::::::::::: ::::::::!::::::::::::::::::::::
.
.
_-,
,
::::::::::::::::: ::::::::::±:: ::::::::::::::::::::
-::-::-:-::::::::E:-::::
::::::::::::::::;::::::EJ
.. - - L - - - - -.
::::::::::::::::;t::::::
*
-J~-
in
01
l i l l l i l l l l l l III
°
Q
O
o
^
eg
g
O
... &
§
o
§£
~* s "i ' ' i i ' i:::-:::::::::: ::^:::::- S
:::: :::::::::: ::: !:::::: §
„_. ^
40:00 02:45:00 02:50:00 02:55:00 03:00:00 03:0£
§
:-:::::::::::::::: S
-<>J
Elapsed time -- hours :mlnuteB:aeconds
•
930^
5.118
IlllllllllilllllllllllHtttHiiiniiiiiiiitmiiiiim s
;;:;;;;;;;S;;;H;;;;;;;~;;;;;;;EyL;;!::;;;; = = ; E
DATE PAGE >H9
MODEL 133 REPORT 930**_
DATE March PAGE 5°120
MODEL - • ^133 REPORT 9304
B::
ttniQ -»
04:4
s
uo^isod XOJ;UOQ
fl
ara|oaci2oiG| uiqiQ
L j ,
DATE 25 March 1963 PAGE 5.121
M03F.L
4°
iwa
ipog
j
DATE 2$ March 1963 PAGE 5.122
MODEL 133, REPORT 9304
13
,o
do '
DATE 25 March PAGE 3.123
MODEL REPORT 930^
g 8
4. 'ajiquadma) jam we
DATh' 2.5 March 1963 PAGE
MODEL •. 133 REPORT
4o 'anquadma) irtq»o
DATE 25 March 1963 .:- PAGE 5.126
uopisod iOJ)iroo iJ
DATE 25 March 1963 /A3E
ol
l
mm
+ Suit Inlet
g *
ipoa
DATE 25 March 19&3 PAGE
MODEL
DATE 2r> . 5.3PQ
MODEL
DATE 2? March^963 PAGE 5.130
MODEL. 133 REPORT 9304
IfUnnuUi
i.
§ i
1
;s
g
f
5,3
s,3
DATE 25 March 1^63 PAGE
MODEL 133 REPORT
0:07:40
00:
:mlmiteB:
:40
Hme
6:20
8,3
DATE 25 March 1963 PAGE
s
s
g§
§
§
§
I
8,3
8,8
?E 25 March 1?63 PAGE 5.133
<D | | | | | | | 1 | | | 1 | 1 1 1 1 1 1 1 1 1 1 1 1 1 1 I 1 pf| 1 1 | 1 | 1 | 1 1 1 1 1 1 1
i ::::i:± :::::::::::::::::::::;:::::::::::::::
c _ X_ j-p _ ^— r — --
::::•::--:- :::::::.:..::-.:.::::::: g
•-:•'; - ; »
-;;;;:; - - - f ± 'S
.-..E — .|:::::::::::::j|:::::|::::::::::: g
I •-- : ' g
— i '. — y
.f- -_ , X 4- -t 3 l -p, --
-j-p-
Li -J
h
-. j 1 .
1. _ _ _ . . O
"
::E;;EEEEEEEEE;E;EEEEE;;|EEEEEEEEE;EEE;EEE:; §
CO -l-i--i
H^JD 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 E| 1 1 1 1 1 1 1 1 1 1 1 j 1 1 ^±fl s s
:E::!E:EEEEEEEEE:EEEEEE:!EEEE:EE:EEE:E::E::: §|
^||||||||||||||||||||||||lll|lllllllllllffP
a :::::::::::::::::::::::
,3 .._
:::! E:::::::::
_ . _ ^H» _ _ 1 s .
:::: Mpi: g:ip::::: :::: >.:E: :::::::::::::::::::: a "\
__....,, C
L,-!. » , \f\ I -i-U- -i-,-. J «
3 :::::::::::::::::::: :::!^ ::;sr[~^j~::::r;:iT"
lUij p
S g. 5
S :::!:::::::::::: 3 ::::>::::::::::::::::::: S S
- -E-
--- B - r
u: -Q
.5 oa _
-!
i
3
EEE;IEEEEEEEEE;E:EEEEEE;JEEEEEEEEE;E;EE;;EE;
::::j:::::::::::::::::::[::::::::::::::::::: S
?.
--- g - >. :: :°3 - f i _ °
s
:::|:|:::::::::::::::::::|EEEEEEEEEEEEEEE
IlllliIllll III 1 III II II lid 1 llnTfm llm i
i .. .i _ . - t _ - - - - - - ra
i I
1 ._. £ £ ., ._..__.. JL. ...._.__
:::5;::::::::::::::::::-*::::::::::::::::::: 8
i
EEEEiEEEEEEEEiEEEEEEEEEifEEEEEEEEilEEiEiEE:: s
-—!--- ±--Z- -- §
— 3 —i _ 1. — -. ^
5,3
25 March 1963 PAG E 5.13^
MODEL
L 133 REPOR3? 9304
§
£ IE ITT. - -4..1-I U--T- -*% -U-
\ 1 ._ _ ,. „— ' _| j_l_
» :::::::::::::::::::: ::::::::: 3 1:: !i!=:!|I. ,
U1
I
* --
-
[
5
-£-
in • »• m
-x :• 8 m
i :::±::::::::::±::: >;-:: - t s Sj
0. 5 5---
7 1 ' > +
- - *
8 '
44 — — it---*— *, _._ -.-ijJ u i r _ T __ i_ :::::::::: 8
X_ L
i" °
"t~1 <*
--- - --
j
i»- - -
—
i
[
::::::::::::::::J:::::::::::::::::::l::::::::
j
••
::::::::;: S
^ IHIIIIHH ° -• CO
o
1 1 I I 1 1 I 1 I 1 |] 1 1 | | 1 [ 1 | | 1 1 1 1 1 1 1 | |j[ | |'['
s
1 if H
:::::::::: S
f IIHIIHIH §
08:50:00
:.. ) _ i .
; h
cc ------- - ? fi. --
i ;;:;;;E;::;;;:;E:;;:;;^::E#»E J
j
J
[
*
08:58:40
a $ t- - - ! - - - - <
K
-. <
> [
g
1 ::::::::::::::::::::::*
;;;;-;;;;;-;;;;;;;| j::::;::::
;;;!;;:;y4l||J4J4. _ CJ , V [
08:58:20
s t mi s E
IIIIIIIIH x 1 1 1 fr[ [ [ | [ 1 1 [ [ 1 1 a||[[{]|[||[[||
JO |— + y o i
08:58:00
,__. _, . !__.__._.
08:57:40
- i
1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 IT 1 1 1 1 O
M
--- - } . .. . t-
!—
j •f O
h [
| • ^
I I 8
gj
— o
^ 1 — o
------- •j--- \
• [ CD
j i- -
III [jjll IH s
::: :
;;;;;;;;;;;;;;;;{;;: ; ;;;;i;;;;;;[;;;;;;;; ::::::::: g
' 1, «
•£>.
s.3 <Z
V s,S
5,3
DATE 25 March 1963 PAGE 5.135
9
ss
s
n, A
9.
3,3
s,S
DATE
MODEL
II!I|!!I!IMIIIIIIIIIIIIIIIMI| • • • •
- -»•— .Antenna fairing release and • • - •
AO[ddp «*jnqj dnSoJtj — *-• - main chute deploy ....
S: :::••::••••:::::::•::::::::::::::::: : :•::••: - TtTtT \( '• '• Ml! •-!-! H-! 1 > 1 H ! 1 1 i i t- • • • •
f —— Impact bag deploy
: : : : : : : •«:::::•:::••::::::::::::::::::::::::::
: ::::: :l: : : : : : : : : : : : : : : : : : : : : : : : : : : : ::::: : : : :
: : : : : : • • : ; \: : : : : • : : • - • : : : : :i ::::::::::::::::::::
: :::::::::::t:::::::::::::::::::::::::::::::::!=j;
i .. i , i . . . . . 1 0 Acceleration, Az ~ ' . ' . ' . ' ' ' . ' . ' " " ". I . I ". . . 1 1 1 . I . . ' . ' . . . ' . '. I . . I . . . . .
f -fr £ ; • - ;
! ::!:!:::!:i!!::i:::::!:i!!:!i::!!!!i;::;::::::::i
133
25 March 1963
.Ml.ifd,,!...]*]]!,:,].^),...*.....
5 ; i . . ! u, I E . ! : . | . . j [ ^ e E i n ! . ! . c J ( C . . i e ^ r . . H ^ v ^ H ^ i r l , ! r . ( ! e , k ^ - ^
[
J '
:
•
1 |
• : : : : : :::::::::::::,::::;[i:::::iiiii::::::::::::i:...
j
[j -f Acceleration, Ax _ j ,
Illlitllllllllllimf ' -::::::--::::::::::::::::::
..i
--.!
- - - 4
• •; !
- -- »
<
rrrtlltl'tttttttt"5
i
>
1- - - • -
PAGE
::::::::::::::::^:::::!:::::::::::::::::::
:::!:::::::::::: g :::: :::::::::::::::::::
tillfllltttillmrrtittti
:i:3i 1:1 : i : : : : : : : • • : •;: ; : i : : - - : i : ::::::::::
REPORT
1
8
8
.
5.136
930^
i
i' !'• \
t
i'
/' '
!
MODEL 133 REPORT 9301*
g
"**
m
II 1 1 1 1 1 1 1 1 1 i 1 1 1 1 1 1 1 1 1 1 1 i 1 1 la ffi-L:::::::::: §
•H-p—
^ ... .. . — .. _j_ . s
11 '
1 -! - E
'-I rl 1 1 1 1 1 1 1 1 1 1 1 1 W 1 1 1 1 1 1 E 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 LrJ 1 1
* 0 It-.-JL.
::::::::::::::: 3
::::::::::::::: 8
(--;-: >---::::::-::::: : •£. -+E----S:::
-3 i! - ~ j^ __ ». -
— ^
g
j• - •h ' .5 • g - • • " • • ; ! :
_(. "* _ « 1 1 ' i ) I
'! ' Ji
* ' ' ' !1 1 '_!_' ' [
'r*
t""I" I r.
^±i::i:i:±i: S
luMQUtlKltlllTITtm ^ TOu^i it '
g g
,_ — j.i _ ? — ::::;!::::::::: S S
05
III 1 1 1 1 III —- — i— ^ — ;|;;|;:;;:;;; » s
Mercury-Atlas No
r Ll
- O Acceleration, Az - -
1m
.... .... x ... H
< h
H
- •
_ _ _ . j >, .„
<-
' IT.
1 ----
--•-:::-:
— - a*• E"
:::::::::::::::§ ^:i: ;::::::::: :: §-:::!E::: ::::::::::::::: 8 *
1
;E|:;::|;;;;; § §
- + S .- D £ - - - J
£3
::::::::::::::: 8
::::::::::::::: 8
— ~ •"• o
..... .. ....... E! a
». 1— E — ::::::::::::::: S
i ........... — .- < ). - ; 1
— ....__- — . o
::::::::::::::: 9.
::::::::::::::: 8
1 i;;-;!;:;!;;;;;;;;:;;;;;;!j- - j- - r —
;;-;;;;;;::;: I
•a 1 1 1 [ i ! ! 1 1 ! 1 1 1 1 1 1 1 1 i 1 1 1 1 1 1 1 1 1'] j-U-j-jj-i-j-i [ [ [ [ [ [ [ §
E 1;
O
a s ::::::::::::::: 3,
m o m o m i-i o
T °
Body tempe
defective
gB-8
25 March 1963 1 PAGE 5.139
MODEL
V " ' 133 •"•; REPORT 930^
' f
^^^^^^^^^^^^^^P^H ••••••••••••»••••••••••••••••»••••••••••••••••••••••»."•••••••••••••••••••••••••••••••»•••• •w.^^l' '^m^m^m^m^m^mm
m m m m m m m m m m m m m m m m m m m p j ^ m - a m m m m m m m m m m ^ m m m m m m m f m m m m m m m m f m m m m m m m m - a m m m m m m m m m m m m m L •*••••* -'!•••••••* ••••pB«*B| • ?•••••••• ••^•V' '^BBBBBBBBBBBBBI
•* " " '•• ' ' • f fy f ' T • • •
£ ":"::: ::•:•:::•'•:
S i ' •: ; ' ;; :
Ii
:::::::::::::::::::: 8
:::::::::::::::::::: 8
:::::::::::::::::::: 8
• • • 4 - • • - - 1;
::::::* ::::::::::§
:;;;:EI
^|j:i I; ; ;I ; : ; ; 8; ; ; i
;;;;;;* !;;:;;;:;; s i
0
Body temperature (high ca
EUpMdttme— hoonnnlnutei:
is defective until 01:52:0
00:4240
I ! ! ! i ! ! i i i i i i i i E f! i ! !
A. !!;!!!!!!;!!!!!!Eg Ilil
OO^OM
00:S8.-00
00:3B.-00
•
:::::::::::::::::::: §
i!!!!!!!!!!!!!!!!!!! I
;;;;;;:;;::;;;:;;;;: 1
::;;;;;;;;;;;;;:;;;; s
•• tf i l !
EEE!E;;:;;;;;;;;;;i: s
™ o
o 2
•*
0
M
0 4
£
hiijijiiiiijiiiiiiil § 88
I»»J nonu(dn« t
1 I I I
o o o s
DATE 25 March 1963 PAGE
j£poa
1
uim/£)iaq '»
25 March 1963 PAGE
MODEL REPORT
X •••••••••••••••••••••••••••••••£•••••••••••••••••••••••••••••
m m m m m m m m m m m m m m m m m m m m ' » m m m m m m m m m ' m m m m m m m m m m m m m m m m m m m m m m m m m m m m m m•
mm••££.•••••
m r . f m m m m m m•••••••••••••!!••••••
mmmmmmmmmmmm?tmmmmmm
c
o
o.
•8
s 1 I
DATE 25 March 1965 PAGE
S i §
DATE_25 Marcb 1963 PAGE
•• • •• > ' ,• :
ipog
DATE March 1961 PAGE 5.1U6
MODEL 133 REPORT 930U
s
*3JTq«J3dai3) ipoe
DATE March 1963 PAGE
••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••I•••••
•••••••••••••••••••••••••••• ••»]••••••••••••••••••••••• ••••••••••••••••••••••••••••••••••
•••••••••••••••••••••••••••••• ••••••••••••••••••••••••••••••••••^•••••i
i i
DATE 25 farch 1963 PAGE
o
• 0.
04:68:00
04:56:00
04:64:00
pe
8
opn/sqTE3Jq
DATE PAGE 5.11*9
MODEL 133 REPORT 930*1
«
Sg
HB9H
A
:00 06:04:00
jnni-HTiii
:::: 3 f
mri s i
g
ipog
§
trpn/spsaq 'a
i «
1
DATE 25 March 1963 PAGE ^gl1}!
MODEL 1'3 f> '. = .' ' ' .' | ' ' ' . REPORT ' . . 9304
• • • • - • • 1 • • i
Bjllm ImllllllllllllHtttiffl 8
I::::::::::::::::::::::::::::::::::::: :::::: S
:..\.,,^...{
06:24:00
:
-;. .
06:22:00
*
,'
1 HB£rt rate, ECG (chest) - - qr - - -
------
! |. . ! - - , ] ' • S 1 J - I
S !:::EEEEEEEEEEEEP;EiEEEEEE:;EEEiEEEE;;EEE]
06:18:80
|i ; ; ; ; •<E : E E:E;EEEE:EI;:
_
L
j Body temperature ~
&;;;;;;:;=:;;:=;i=|;;ii:::i=;ii=»:::;;;;::=
_
2 W . W Uti- ' 1 4 - S I M
g :::::::::::::-:: £ ::::ii:i::::::n:::::::i:
Wtttit
06:16:00
j ' i i ' 1 ' " ' I ; "'
-
06:14:00
1 -- s !>r - - < t - •-
IE
08:12:00
-j-S' ;
:::::::::::::::::::(:::::::::::::::::: :::::: g
::::::::::::::::::!-:::::::::::::::::: ::::::
g
H til
I::::::::::::::::...:.;:::::::::::::::IlFfflffl
:::::: g
H :::::::::::::::::::: i'.: ::::±:::: :::: :::::: S
j ^
M '
tJ :::::::::::::;: -iiii:
1
i >
.
S 1
0
C9
nopuidsaa ^pofl
DAG
\TE_ PAGE 5.133
MODEL 133 REPORT ,,'
1.2
ss
Xpog
I
DATE__ ^5 frarcb 19oj PAGE
MODEL 13.3 REPORT 9304
8
§2
S
§
3
S
I.
to
I
£
§
ti
§
S
S
8
S
I
S
S
?.
5
|
«
.S
S
ipog
§
DATE 25 Marehl963_ PAGE
j
I
fff>S
<nm/s)eaq 'a
;DATE ' 25 March 196 PAGE
j.056.
.
MODEL 133 REPORT
EEEEiEEEEEEEEEEE^illiEEEEEEEEiEEElEEEEEEEEi
.
Illll 1 1 II Illllllll III II 1 II II 1 1 Illllllllllllillllllll
08:44:00
i. .
,t
...'... . 1 . . . .
; — ] . _ ! ] _ . u ..; — , — :. . ' i
08:42:00
*
i
l - J - T j - - * , - - - - * ; ' -
-
08:40:00
•~-
-
Mercury-Atlas No. 8
...]»..]
08:38:00
+ Respiration rate
Body teirperature
08:36:00
........ 3 b ;. . !
4-
08:34:00
08:32:00
-—
i -}
,._
,
rpr;:^;,!*.^:^:: ::::::::::::::::::::::: g
EEE;;;EEEEEEEE;E^|EEEEEEE|E|EEEgrE|EE 1
o o o o m 0 a S
CD -* 0) 0 S 01 g
^ 'ajn)«jadma>) ipoe
DATE 25 March 1963 _ PAGE
MODEL_ 133 REPORT
ipog
DATE 25 March 1^63 PAGE 5.158
g!iii!iii!;!iiiiiiii;iiii!ii!iiii:;;iii:;ii=!!
£ :::::::::::::::::::::::::::::::::::::::::::::
| ::::::::::;::::::::::::::::::::::::::::::::::
S :::::::::::::::::: ::::::••
E:::::::::::::::::::::::::::::::::::::::::::: g
:::::::::: :::::!:::::::::::::::::::::::::!::
::-8 : : : : : : : : : : : : : : : : : : : : : : s : : : : : : : : : : : : : : : :
::||:::: :::::::::::::::::::!:::::::;::::::
ipiiiiiijiijiiiijiiiijliiiiiJiiijij! ::::::::::::::::::::;:::::::
iJilllilillllBili
;;ij=;;: »* ;;^:::!;';;;:;;;;;;;;;;;;;;;
ill
rttTTTTnTTrrHrmTTTTTTr^ ^ - § rrfri
:::: I
=ii;!»ii=i;=iii;;E;iiiii!i:;i | f { ;;:; |
::|§;;;; {:^-:::\\\\\\\\\\\\-::\':\
1 |• i j > H"
::::::::::::::::::;::::::::: i 0 i :::: | ]
i!=::::iii!::: : :iiii!i!iiiiii:ii!iiii;:i!ii;:]
|ii!:=:!iii;;!!i;;!!!;;i!ii;!ii!;;;;;Jii!;;;;!!i;E!ii!;!;;E!!!;iJi!iiiiiiiiiJii!iiiiiii;ii! 1 1
lillllllillliilllil
1 III II ||; i
S
aDiraiJBA pire iream BJBJ )-re3H
nun/
DATE 25 March 1963 PAGE
MODEL REPORT
131
01 ui 'ajnstaid poo|g
DATE 25 March 1963 PAGE 5.1M
CO
a^- u
oE
ao
CO
1
«1
«
•- c
O
0.2
CN
CO
8. -^
CN
81
uiui 'ajnitaad
DATE 25 March 1963
MODEL 133
•o
MODEL
£ 133 REPORT 930^
i
Si
O
c»
^ O4
CO
-^ .
r?
1 CO
.D
C CN °
O ^
'
O
«o 2e 1
Ml *-
Ov
-f o ^ tf*
0 0
O Q.
}
o
CO
oa
M
.2
N
0
|
0 °
8 €)"e
E
•o
CO
|c
*• o -f
0.2
ol E
s 0.2
c~ £
CO
1 CN
L
CO CO
•
—FT
"7f " " 3 •
CO
JL_
CO M
— - "=.
X. --
_: r.
CN-0
r --.
CO O - -_-
f O
Z
O —
—• "
— - -^
c^ *» — _ _ -- cs *
1
1 :
_-J ^_ o
TJ 0
• - -
..I - ^J- - . CM E
i CM
o
- - - - - O
•t - - - :"i - M '
t. n
o - n
1"
•;. - UJ - :
f-. . . . - UJ
•—•
/L _
**
CO
-- •- -
CO
.
r .'
•o .
•i
^"
/
I
C<4 • CM
/
/ 0 I o
r
>1
j
z
/ // CO
•o
/
_l
V -
a / /
3
3 i
o " o o o o o
/-\
o~ o
/o o o o o
/^
o~ :
o • -o <N «o CM
O
CN
O
—
CN
—
00
<N ^- —
uiui 'aanjsojd poojcj
DATE 23 March 1963 FAGS
REPORT 9304
MODEL 133
1 •0
•«
V) •*
o
CO
V
0>
0 f CN
J> O •<»
£
3
C
IO
CN°
oE
1
u *- •<?
J>
Q.
0^
j CO
O o
4
V- M CO
C Q.
N_o
o o •o o o
CO E
EC
*• o
^ «t
0.*
51 E
T CO
cZ E
O 2
r
.
CN
--
CO
-
^p
JL_ . CO
-
1- '• ~-
CO •> £ CO ••
CNTJ CN-0
* C
CO —- - — •- O O
O
0 g 'I O o
CN « CN «•
z -: - - — - - - 1
«• •V 0 o
• - - ..i
_0 CN £ E
'
< "JL ~"n
CN
•jT.r
—.JL, CN -0
X
D - - ::JL •" O
M
u
w ""? Si O 0
s
O
J_ UJ ^
<N —
J_ CD
f
- - - '
0
-y1 ^
cx
I o
1
/
]
CO
,• \
^ \
/
/ CN
)
)
O O O O O 0 O~ O O O
•«• O O CN CO •<» •* o -o o
' 04 CN — — CN CN —
poo|g
-DATE 25 March 1963 PAGE 5-165
MODEL 133 REPORT 950**
O& Q O
•^ o .• « CN
01 fM ^ P-
ujui 'ajn$tajd
DATE - 25 March 1963 PAGE 3.167
MODEL 133 REPORT 930**
o o o o o
•* O «O Ot oo
C* CN •- t-
uiui poo|g
DATE 25 March PAGE- 3.168
§
8
g
g
8
8
o
I
§
CO
:
8
"f
1*1 ™V - .
3
8
O a
3;;;;; i
8
II o
i
- ;O 2
8
o
8
8
8
DATE 25 March 1963 PAGE 5*171
MODEL 133 REPORT 930**
aa
25 Marcb PAGE___ 5-1T2
DATE__
MODEL 133 REPORT
g
8
DATE 23 March 1963 PAGE 5.173
MODEL 133 REPORT 9304
S s
£ §
m
eo
S
-•g-
©2 -Q>
o
MODEL
\ DATE 23 March 1963 PAGE •-5.176
MODEL 133 REPORT 930^
£
DATE 23 March 1963 PAGE | 5.177
MODEL 133 REPORT
DATE 25 March 1963, PAGE 5.178
I.
f.
«
O
I
8
I.
11
E 6
1
bo M
a v
£ S.
O O
t
k h
as D>
§
1
O
§
S
§
1 I I
J0 'ajiquadma) ORB irjqso
DATE 23 March 1963 PAGE S.17Q
8
•*
-S
8
8
§
be be
I »
u y
•• i;
SS
g § S
j, 'ojnjEjadmaj up(s ojq^o
25 March PAGE 5.180
133 REPORT 930*
DATE 23 March 1963 PAGE 5.181
MODEL 133 REPORT 930k
i
a 1
§
DATE 25 March 1963 PAGE 3.182
MODEL 133 REPORT 9,30V
mill
a :
CO
o' f« : <:?"
e-g •s :*
lii
§
DATE, PAGE
?.
8
8
8
8
8
8 1
as 1I
fr
u !
i 8 1
8 8
•»
8
«
4. *uniuadai9| flfterqs
•" DATE 25 -March 0,96^ - •''"i ^ :- * . . --•--.,,^ j^,^ ., -.- PAGE ' .' ,. lfl(.
se L lU-ULL
0,
g ::::::::::
o
±^
1 11
"^i(x - ::::::::::;:£:::::::::::::::::
:+ ^
ill m HI lilllllllilllll
••
Illllls5
^^^^^^^^^^^^V^^^LwLjw A_J«4 JBt Bt J— J— J_JaJni J_ JBJ(.J =K:?=3=ac3=ac.>c3=aciir^BDcac..f..;..rc;..?fl^^^^^^^^^^^^^H
^^^^^^^^•^^HliBtl •••••••!"••••••••••• ••••••••
^^^^^^•[^^•••••••••••"••••••••••••••••••1
uM^^^^^^^^^^IEaii •••••••><•• •••••••••••••••••
••••••••••••••••••••^^•••••••••••^^^^^^^^^^^^^H
••••••••••••••••••••»- ••••••••••••••^^•^•^.•^•^•^•H
••••••••••••••••••••••••••><• •••••••••••••••••• •••••••••••• •••••••!» 4 ••••••••••• K,j,V^B^B^B^B^B^BflBH
••••••••••••••••••••••••••Ml ••••••••••••••••• !•••••••••••••••••••*- 4MB*.IBBBB«B.llP^I^I^I^I^I^I^I|
• •••••••••••••••••• •••••••>•<• ••••••••••••••••• •••••••••••• IBBBBBBlr- 4B ••«•••••• Bk^^^^^^^^^^^H
^ 1 1 II 1 1 1 1 1 1 1 1 1 1 1 1 1
06:35:00
5
lilw !!
::::::::::::::::::: £::::£:: ::::§>:::::::::::
'"MB "
i:;;;;;;;;;EiE:;;;;:E;;j;;;i;
06:25:00
im44M444m
-..: :
1 §
-. 5 — 5
is ffifffffffl
---.:
::::::-::::::::::
W - . . J J f/j
-- o j-- o
06:20:00
:::.
U Er U
-- -- + fr- >
06:15:00
::::..::::
-
•-::
10:00
:::::::::::::::::::: :::::::::::: S
.... ..... , . . , . _ | • -_.
i 8
E;;;EEEEEEEEEEEEEEE; ;:;EEEEEEE:: ?.
::::::::::::::::::: :::::::::::: 8
| 8
z\]\\\-\\\\\\\\:]\\\ j;;;;:;;;;;; §
ftfflfjltjjf
i i ::::::::::
rt
D.
rt '
- - - - - -ft' -
-I,
t1
-
:::::::::::::::::::: |::::::::::: 8
::::::::::::::::::::
::::::::::::::::::::
!::::::::::: 8
j::::::::::: g
ji illlilllllllllllllllllllilllllllllll Illlll ::::::::::::::::::::
::::::::::::::::::::
5;:::::::::: g
:::::::::::
TnnniT :: ffl : lTlllaT :::::: fffl s
0
8 5
DATE PAGE 5.186
MODEL 133 REPORT
a||
<3
©±°
|,
DATE 25 March 1963 ':' PAGE 5.18?
MODEL 133 REPORT 9304
DATE 25 March PAGE 5.188
MODEL 133 REPORT
•£• I
o-
j. 'ajiq«jadma| af^VRS
DATE 25 March 1965 PAGE 5.189
E E
8 ?.
4 CO «
3 •5 «
h »-
3c -S
c
So
-I- »
8
i
DATE March 1963- ''•• ' PAGE/ ' 5.190
MODEL, 133 REPORT 9304
'' '
£? March 1963 PAGE 5.191
MODEL REPORT
:
AvY>.V, ; : nl:
DATE_ .March '19p3 •• \' ••• '• /'-i'''. 5.192
MODEL 133 KEPORT 9304
E
•a
y t • ' , i1; ;:; 4 i • ;. ; •' .'•'"/^- \3' ' '
W ' ""''<• -''I*-. :/f"SV •• ;![ 1 Vj'•,'':,'
DATE 2p.March 1963 ' ' ' PAGE 5.193
MODEL 133 REPORT
E
DATE , 23 March 1963 . PAGE ' ' 5.195
.MODEL X"'? REPORT 930k
•'': : - ' ' / ' ",' ' '-'i '' • _ - . ;!" •'.V:-;'; 1 .*,,' ' -3 . ' > . • ' . '• .
v-Wi'E March ,t< • • >: l..;i'.\' >'-^; K:Y .FAffE ''_'.'>' - '• j ' ' . . . =
MODEL
REPORT 93Q4
8
rititlllii m^ B l^^ I
sS 1*
8
f
8
n
8
'»jrejrjadma»
DATE 25 March 1963 PAGE 5.197
So
DATE 25 March PAGE 5.JQ8
I
8
I
1
a•= s -'.'.
• • s «•» a .
M£j .. gs
§ § § §
4.
1
.,--.•: ;....•' ' ,;'.•:,-• • s .-..I ;'' •>, >,...' . , ' ' • . .?,':'•(.'; ^,"-i;'
'• ' .', ' ' ' •', ' • > ^ ...•? / '•• ,',.', ' i ,' '•' ' < . . , .
1
o
I
DATE 25 March 1963 PAGE 5.201
3 :: | cO) .::. f :! £
to - - w> ' - & :i E
0-" 4- .
|8
cn ^ "' w ^ i 1
8
s
DATE 25 March 1963 'PAGE 5.209
I —
MODEL 133 REPORT 930U
1
DATE £-3 March 1963 FAGE 5.210
MODH, 1-'; 930*
CQ
^^
•35
o X!
a*
bE •"
" "
o
OS •s
!
8
so
rt 33
u +->
<n 0)
I
8
IO
o
8
8
DATE •25 March PAGE 3.211
j, 'wrgwadnia* *naa
j
8 o
s
DATE 25 Marc.h_ 1961 PAGE 5.212
• MODEL 133 REPORT
EiATE. PAGE 5-213
i
MODEL 133 REPORT 93PA
Oi --.
U
oH
lo
8 § §
5.214
9304
s
PAGE 5.215
REPORT
EfATE 25 March PAGE 5.216
§.
^CQ
** -i
eo K
o> X
"wi0-
2«" 9
©s oS
§
8 8
8
s
DATE 25 March PAGE__ 5.217
fiODEL 133 REPORT 930^
DATE 25 March lQ6l PAGE : 5.218
MODEL 13':- REPORT 930^
|S
a -H
hi m
u i-<
as
:•* s«
•* o
"S-
D H
!
2s" *•
co2
t
io
•i-'S *£
§
§
S
5-219
DATE 25 March 1963
•3N
I'
V i-(
i- tft
U rt
3S
-t-E s
§ §
ss
March-12& PAGE 5.220
MODEL
IfflPORT 9304
___.2.5 March 1063. PAGE 5.221
MODEL 133 REPORT 9304
«R
?.
s
DATE 25 March 1963 PAGE 5.222
§
o
3
- 33
^
s m
§
8
8
8
e
1st
El!
-O r S{:
;>• t s §
6
I'ATE 25 March' 196^
InGDEL 133 REPORT 9304
8
O ,
7.
s,
§;
«/•>
« '
s
I
o
•>•
s
§
t£>
C4
*i
= |
J
s
DATE 25 March 1963 PAGE___ 5.224
1 i • l ••«•••• T» • mmmm mim r V
8
S
8
S-.. o
g
51
1? •Sg
C
«Sf
CJ in
U 2
S
8
\f>
S
^
8
DATE 25Marchl963 PAGE 5.225
MODEL 133 REPORT 930**
I
s
.
8
8 I
8
88
Is CM
1
^iilt
f S - E»
8
§
S
IB I .
OJ -
I
Ss'E O ir-
U 3 '
n NC OS:
&
4 8
DATE 25 March 1963 PAGE 5.226
1
1
S.
8
in
»
s
I.7.
s
8
?.
S
w -
8
%
2pC If S
Jsf
CJ irT
o3
8
8
S
8
S
DATE March 196.3 PAGE 3.227
MODEL 133 REPORT
DTE March 1963 PAGE 5*228
t
DATE 25 March' 1963 PAGE 5.230
MODEL 133 REPORT 930u
DATE 25 March 1963 PAGE 5.231
REPORT
MODEL 133
__<
8 t-f»
-S
H: F=F
|f -£
~?r s
in?
ttffiIT«i SI«i
tS-
. Sap *i«Jjno oi£8 m*A SOSV "3ap 'jndino cu£3 DUB jauueas uoiid SDSV 3ap *)nzino ojXa pire jamreas no^ SDSV
Sap l ^>IOD9IOB
ass/Sap 'aisj n<>H
DATE 25 March 1963 5.232
:1
o •!
o 5* ll
| X
o * A
^
*J K
0 •* 1
&
«• 1 n
" e * II 8
f e * -H
>•
I V)
^
01
« •*
i
«
o
< *
* ^
g 8
O '<
% .
0 1 «1
o « ** | 8
s e + 1
s Q 4- 1
'n
id
F
f «>
* I 8
•§o i*
1
o «• 1
o „ 1
c n fr • * 1 VI
£ "o a i3 \ 1 -8
o
j> (. 1- l- ^ n'
o
1 to
£ " "i . C p n *
1 £ —
t,; 8 I -\
-I ?rt
§
SiJ y c f V
S
s
•5 f
• 'o c 1 *, 8
- 8
D
^ n c u e 1
JE O
??q B 1 j£ U
a *
" 0
f — fi c/- i
1
j
1 J-
e
1 £
nX (>
j+1 1 X
B
)c C
0 * -fl _ •
? •°
o 1 +
o «. et
o o» H S
j( *o
yi
0
0
1 4
ii t.
X
8 > •
e eq
8
o 0
i
» s
o
*
o e •*• —
o >*• s
«
£ •
Jl
*•
x
8 *
o < 4 §
. o ra
0 i
s
0 e »
£ *
c
C)
p•a
cD
e ^ c9
^' §
••p *indp«> oail ami fiDSV
i 0e a o 0 o c a. •* «
° "^ 7 Eg
q3pl
oppaaioa top 'Domaod J3UUG35 3gp 'uoptSOd UOpI&Od ^^1 *PPU3IOB
•xiSDH Mi/Sap 'ajw
DATE 25 March 1963 PAGE £,233
MODEL 133 REPORT
-h-
1=3
•i
8ap
S ° 2 E • 8
000081
pjoaaios »»£ S3B P"» J3UUE38 Sap *UOp]50d jaronsDS gap "nonisod "ppnatos jiw SDH P"
ipud SOU noi soa n«H 338/Sap 'o^j nou
PAGE
DATE 2$ March 1963
. • f REPORT 930U-
MODEL 133 .
3JO031
«oi 'ppusios qoijd soa P10O3IOB mo, "pionaios noJ soa P"
33S/3ap '3|CJ n<" soa noa oaa/Sap '
DATE 2g March 1963 PAGE 1.235
i I
'ysuss
" s SiS
flap *)n£)no <w£8 ptre jaoneas n1" SOSV
PPU3IOB J3UUE38
qoild S3H
' '' #
DATE 25 March 1963 PAGE
M3m 9JOU3I
piouaios jauircas Sap *uopisod Plouajos jamreos gap "uonjBod
qoild SDH <PHd 3 3
t ns qD}|d n<" SDH
DATE 25 March 1963 PAGE S.2UU
0
<
12 >
to o
ft
6 o
3 o
l
•R
o ,
o
'
o <
o (
0
o
0
0
o <
o
o
o \
o (
e
0 .
0 j
g J
a
•JFI
r
£ 8
cifi
9
<
ta.
BJ
1 V £ - 1.1
0
& J!fe
T > i
1
?
'\
n
liti:
l«|-s-
:mi
:18:
( ss . tL. s -
(-, o
o
«
VP
c
B
s
°-.|.L
ft ° •* c
<y 0 -* f
£ L Z3 J b «
c
r i ri n O
«--- r
3 «
O I
o
0 <
0
<
o <
&
8
o
o
^
0
<
o t
0
o ^(
0 \
o.
o
o
-"
b t
• o !
5 o <
» o
0
<
i
o , f
1 o 1
e> c>
oi 8
Sap ^nrtjn
*3 put
ppueioe Sap aoj 'pioaafos na£ sou puv i 'piouajos qa^id SDH
oas/3ap *ajBJ qaiw
DATE 25 March 1963 PAGE
i*~-n
!~~.&~J
• i-t-- a
a
1
i
a «
o
I
tf
i i
Dap •jndjnD oust «£ SDSV 'Sap ^nd)no OJXS puc jamreas Sap *)nd}no ooiS pro jaotraDS noJ SOSV
1
8 o o ^
H8jll
qjp,
Sap "ppuetoB A«^ soy ptn pjoua^os jamreDS 3ap *uonisod uopisod »DI *pjou31os qojid gOH ptre PfOU3|O8 J roue os 3ap , "piouatos noJ SOU P=»
IP" SDH TIOH V 33S/33P 'ajBJ n°H
M3«d SDH »PJid 1Dne qaiid qan^s
»
pjonaios
MiiSOH
DATE March 1963 PAGE
MODEL 133 REPORT 930ii
PAGE 5.250
DATE 2^ March 1963
REPORT 930k
MODEL 133
-^-!—
o.
OJOU3,
piouaios jamrejs Sap 'uoijisod uotitsod »oi 'ptouaps ipjid gou pire jsmreas 3ap 'uomsod s n°J soa pro
qoitd SOH IP)M 13ns qDJM qo)i«s OSS/Sap '3)BJ n°a
PAGE 5.252
DATE 25 March 1963
REPORT 930U
MODEL 133
g
t^
-8- S
g|TT S
s
-i- --1s
-Ui-
4
..«!
±d
H-
i IT
l i i -s—
TIT
E:a
&. £
-i
•s i
g a
II
'1 1"~: r
—13 :B si;:
s| 't-\£
o i° I
o *^ oL .0 + _J
s1
'3gp *ind)no oJ£8 put tpild SDSV oita pro
l__i
E o o o
-*-•£•
-g
6--
2
I!
o
11
•; 2 S g
Sap &B£ SDH pm oi 'Piousios qajid SDH pu* ptoaatos jsmreas 3ap 'nonisod «ioj "ppnaios nw SOU pn«
at* SDH nojsoa ROH oas/Bap ' O
PAGE
DATE 2$ March 1?63
MODEL 133 •
REPORT 930U
= o I
8 o . o
fcp 'I'ndiDo oiAS ui gosv
s
*>P •Sap *}nd}no ojX3 pus jawreas M3)Td gosv
2 ° 2 £ -
Sap *ppn7[os ae^ sou pm i jauireas Sap *uoiiisod uotiisod 'piouaios tiDjid soa
oas/Sap 'a^j MA MDlid SOU
DATE 2$ March 1963 PAGE 5. 260
HM SOH n«H
DATE 2$ March 1963 PAGE 5.261
top 'indjio <VUQ Mil SOSV •Sap ^nd)no ojA3 pus jaureas qo?pl SDSV
o g a, •» «
M^W ajou3i
Sap 'ooRigod ttoj "pionaios xxA soa I piouaios jainreos Sap uopisod AOJ 'piouaios pfongjos
,3BB MX ^lld 13R aas/3ap ' TPU SOH noH
DATE _25 March 1963, PAGE 5.263
' § 3 2 o
H9p| ajou3i
PJOU3JOS J9UUE3B Sap *UOT)ISOd
ipltd SDH M^M ^I^ns q^lW
PAGE 5.261*
DATE 2$ March 1963
REPORT
MODEL 133
TT
-!-„-
I !
t
e *
£ 0 0) 'g
•g
--
-I
O ~ ».
.1 ll^s
Kfhs " •*
:| °
-I *-
-8 •SI
-K •s| 3 !-
!o o
•a I o 0 o 01
S ~ 7 T1
•3ap 'jndjno oxiS puE jauireos uo^fd SOSV
+ ' g ? 2 2 E °
^W aaouSi- '
PIOU3IOS-J3UUEDS Sap "lionised »oi 'piouaios
MiSOH M«I<1 SOH M«M 1PB» 1=l!d
PAGE 5.266
DATE 2$ March 1963
MODEL 133
REPORT ^3014
ffiGE 5,267
DATE 2$ March 1963
REPORT
MODEL 133
B S
8JOU3]
ppaatos jamigas Sap *aonTSod tl<" SOH pm
n<" SDH n«H ^SBB n»H 'OJBJ n°H
PAGE $.268
DATE_ 2g March 1963
REPORT 930h
MODEL 133
• § °
lap ^Klpo oiO auC EOSV Sap *)nd)no oj£3 pus jauneoa iplld SDSV
§ S 2 o 2 8g
pjonaioa
piooeios Jannvaa IP" SOa pn»
aas/Sap *a n»j soa oas/Sap 'a
DATE 25 March 1963 PAGE 5.269
RCS HO SUPPLY
JO La REFERENCE LINE
PITCH RATE
f*mmmvi*t'f*~»f«t*-fT^^
J5a 10
'!«'.
I
0*3&30
i i I
0*37:00
i i 0*3900
i i 01:39:30
i i i 142:30
MA -4 MISSION ELAPSED TIME - HR.MIN.SEC
Ml
h
^^^
«)i e s>
Si"" DYNAMIC PRESSURE
WE CHUTE DEPLOY J
RCS HjOj SUPPLY
• I
30 La REFEBENCE LINE
£«
wv&i&JSWwwv*^^
1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 i i I i i I
03>ll<00 030h30 0312^00 OilZ'30 OilJJO 03:|4'00
MA- 5 MISSION ELAPSED TIME~HRMN<SEC
DYNAMIC PRESSURE
I > I i i I i i I i i I i i I
04.4400 04.4SOT 04-45^30 04:46«0 04:4030 04:47:00
M A - 6 MISSION ELAPSED TIME~HR.MI»SEC
•r .05 0 RELAY
DYNAMIC PRESSURE
I I • I I I I I I I I I I I I
04:47OO 04^7-JO 0-*:46OO 04^4fi:30 0449:00 04:50^3
7 .. _
|
'
' •J t
^WA^VV^V^
53°
I I w:%3:oo i
094>3:30
i I 09:04:00
\: