Professional Documents
Culture Documents
2. Determine the force in each member of the loaded truss. All triangles are isosceles.
4.A small bolt cutter operated by hand for cutting small bolts and rods is shown in the sketch.For a hand grip P=150N,Detemine the force Q developed by each jaw on the rod to be cut.
5.The unstretched length of spring EF is 300mm.Determine the magnitude of the pin reaction at O.
8.Find the distance Z from the vertex of the rigth-circular cone to the centriod of its volume.
10.Calculate the X-,Y-,and Z-coordinates of the mass center of the bracket formed from the steel plate of uniform thickness.
11.Detemine the distance H from the bottom of the base to the mass center of the bracket casting.
12.Detemine the volume V generted by revolving the quarter-circular area about the Z-axis through an angle of 90.
13.The two circular arcs AB and BC are revolved about the vertical axis to obtain the surface of revolution shown.Compute the area A of the outside of this surface.
14.Detemine the volumeV and total surface area A of the solid generated by revolving the area shown through 180 about the Z-axis.
15.Determine the polar moments of inertia of the semi-circular area about points A and B.
16.Calctulate the moments of inertia of the shaded area about the X-axis.
17.Detemine the moment of inertia of the shaded area about the X-axis in two ways.The wall thickness is 20mm on all four sides of the rectangle.
18.Determine the moments of inertia of the Z-section about its centriodal Xo- and Yo-axes.
19.Determine the product of inertia of the shaded area about the X-Y axes.
20.Calculate the maximum and minimum moments of inertia of the structure angle about axes through its corner A and find the angle measured counterclockwise from the axis of maximium moment of inertia.Neglect small radii and fillet.