You are on page 1of 7

1.

Introduction
This pamphlet explains in brief the basic steps for
testing of selection table of PI&RRI (Metal to
Metal) installation, which is useful during
commissioning as well as periodic testing of such
installation.
2. Main Signal
2.1 Back Locking
• Clear the concerned signal. Drop & Pick up each TR/TPR
in the route of the signal, its overlap and isolation.
• The signal should go to danger when TR/TPR is dropped
and should be off when track circuit is picked up.
• It ensures that the concerned track circuits have been
taken in GR2 circuit.
• Fail the TR/TPR permanently and after a few seconds
pick it up.
• The signal should not re-clear. It indicates that GR1 has
dropped.
• Fail the TPR during testing and do three button
cancellation with TPR failed. No such sub route should
get released.
• Again do three button cancellation and keep GN and UN
buttons pressed and pick up the TPR being tested.
• All sub route and Ovs should get released as soon as the
TPR is picked up. In case the track circuit is berthing
track, Overlap track or isolation track, the routes will get
released even with TPR dropped.
• In case of dead approach signal, the above testing must be
done after the final timer relay AJTR3 has picked up.
Repeat the above testing till the last OV track.
2.2 Red lamp protection
• Take off the concerned signal and remove the RG fuse of
the signal ahead.
• The indication of the ahead signal should be flashing red.
• The rear signal should go to danger
• Re-insert the fuse
• The rear signal should not re-clear
2.3 Route indicator testing
• For all signal movements with diversion remove the route
indicator lamps supply fuse.
• The indication for route indicator on panel should start
flashing. The signal should go to danger.
• Ensure that route lamp checking relay (UECR) does not
pick up with three or more lamps fused in the junction
type route indicator
• Re-insert the fuse
• The signal should re-clear.
2.4 Proving of points in the route
• Take off the concerned signal. Flash (fail) each point in
the run(route) of the signal, its overlap and isolation as
per selection table.
• The signal should go to danger, when point is failed and
should re-clear when point indication is steady.
• This ensures that the concerned points have been taken in
GR2 circuit.
• Fail point permanently and after few seconds pick it up.
• The signal should not clear. This indicates that GR1 has
dropped.
2.5 Crank handle interlocking
• Clear the signal and try to give slot (control) for
concerned crank handle key lock relay (KLR).
• The slot should not go and signal should not go to danger.
• Fail the crank handle key lock-checking relay (KLCR)
coming from site.
• The crank handle indication becomes flashing red on the
panel.
• Give the slot for concerned KLR and try to clear the
signal. Signal should not clear.
• For PIs the route will initiate and for RRIs the route will
set but the point will not get locked and the point will not
operate in chain group operation. Indication on the panel
flashing white.
• In both cases the point must be free for individual
operation after slot for concerned KLR is given.
• Extract the KLR key
• Indication in the panel flashing red.
2.6 Sub routes and overlaps
• Clear the signal and normalize each sub route one at a
time manually or by (EUYN) emergency route
cancellation button.
• The signal should go to danger and indication of that
particular sub route should extinguish on the panel.
• Normalize the (OV) overlap relay.
• The signal should go to danger.
• Alternatively remove the overlap common fuse and then
try to clear the signal.
• The overlap will not set and signal will not clear.
2.7 Approach locking
• Clear the signal. Fail the approach track. Do three-button
cancellation.
• The approach lock timer will start.
• Fail each track, which is part of approach track.
• Try to do three button cancellation with the timer
flashing.
• It must not be possible to release the route
• After the timer becomes steady try to release the route by
three buttons.
• The route should get released.
3. Points
3.1 Track locking
• Fail the track circuit with the other track circuit of point/
crossover as pick up
• It must not be possible to individually operate the points
through WWN common points button
• It must be possible to operate the point through EWN and
EWN counter must increment.
• Fail the other track circuit with first track circuit of a
point /cross over as pick up and repeat testing as above.
Point operation through WWN should not be possible as
above.
• When the both track circuits of a point/crossover are
picked up it must not be possible to operate the point by
EWN.
4. Subsidiary Signal
4.1 Calling on Signal
• For testing of calling on signal after clearing calling on
signal testing of points proving, KLRs testing, sub route
testing, station masters slide testing must be carried out.
With calling on given all conflicting signal must be
locked.
• Drop the calling on /approach track of the concerned
signal. Press buttons on panel to clear calling on signal.
The calling on signal should be clear only after two
minutes after calling on /approach track being occupied
and should go to danger when this track circuit is picked
up.
• At many places a signal and calling on are conflicting i.e.
“A” sign clears only for straight route and calling on only
for diversion. The same must be tested.
4.2 Shunt Signal
• For testing of shunt signals, track circuits testing (Back
locking) except berthing, OV track and isolation track
must be done. Testing of points proving, KLRs testing,
sub route testing, approach locking must be done similar
to testing of main signal.
• Fail points and KLRs and again pick them up, the shunt
signal will re-clear, there is no cascading in shunt signal.
5. Station master’s slide testing
• Pull each slide of slide frame, the concerned YR only will
pick up and YNCR must drop and YNCPR must remain
up as route is not set. The panel indication must be
checked accordingly.
• Fail the first track before the berthing track, the concerned
YR must drop and if sub route is set, YR must not pick up
even if track is picked up.
• Set the sub route and pull the station master’s slide, the
concerned YR must not pick up as YNCPR has dropped.
Thus YR will pick up only when sub route is not set.
6. Testing of Gates
• The concerned signals, gate signals, “A” sign, calling on,
shunts signals must go to danger when the XCKR of gate
is failed.
• It must not be possible to open the gate with sub route or
overlap leading over it is set for any line or when only
“A” sign is given with route released, the slot for gate
opening must not go and the signal should not go to
danger.
• When gate is open, it must be possible to initiate the route
and operation should take place up to GLSR.
7. Testing using simulation panel
The following testing shall be done using simulation
panel as per control table.
7.1 Random check
• Check up that indirectly conflicting signals cannot be
taken off simultaneously.
• Keep one or more points in the route in unfavorable
position and try to take off signal, which should not be
possible.
• For taking off calling on signal, keep all the track circuits
in dropped condition including the approach track and
check whether it could be taken off. For automatic
signaling territory the calling on should clear only when
the first track ahead of the signal is picked up. For other
than automatic territory, the calling on signal should clear.
• Special attention may be given for overlap point detection
whether required or not as per circuit.

 It is clarified that information given in this pamphlet does


not supersede any existing provision laid down in “Signal
Engineering Manual”, Railway Board publications and
RDSO publications. This document is not statutory and
instructions given in it are for the purpose of guidance
only. If at any point contradiction is observed, then SEM,
Railway Board and RDSO guidelines or Zonal Rly.
instructions may be followed.

You might also like