You are on page 1of 3

TRAINING ASSESSMENT DAY 3

1. What would be used to determine viscosity? Rotational viscometers Dynamic viscosity ,Krebstormer viscometer kinematics viscosity Flow viscometer Free flow paints ford flow cup no -4

2. What is the name of the vessel used when we determine Flash Point? Closed able cup

3. In a Ball mill, which type of abrasive balls could not be used for the production of white paints? Steel balls

4. By which standard must we determine tests on the properties and qualities of paints? BS 3900

5. At which temperature would you associate Stove Drying? Above 65 deg

6. Name four extenders? Slate floor, clay , tak ,chalk , kaosin

7. What are the two principles of the theory of Adhesion? Molecular interference physical Velcro Molecular Attraction chemical magnet

8. Name three rust inhibitive pigments, and their colour? Calcium plumbate white Red lead red (toxic ) Zinc Phosphate white

9. What are the basic properties of a binder? Binds the particles and holds them in suspension Improves adhesion Gives resistance to passage of water Acts as a film former (change liquid to solid) Impermeability

10. Which pigments would commonly be used for hot surface duty? Carbon Aluminium Silicone

Inorganic zinc silicate

11. Where power brushes are authorized for use on BGAS /TRANSCO sites, the wire is made from which material? Phosphor bronze Beryllium bronze

You might also like