You are on page 1of 3

STEPPER MOTOR SPEED CONTROLLING USING

CELL PHONE (DTMF)

INTRODUCTION
The Embedded Technology is now in its prime and the wealth
of knowledge available is mind-blowing. Embedded technology plays a major
role in integrating the various functions associated with it. This needs to tie up
the various sources of the Department in a closed loop system. This proposal
greatly reduces the manpower, saves time and operates efficiently without
human interference. This project puts forth the first step in achieving the desired
target. With the advent in technology, the existing systems are developed to have
in built intelligence.

Project description:
The aim of this project “stepper motor speed controlling using
cell phone (DTMF)” is used to control the stepper motor by using the cell phone.
Here we are using the DTMF (Dual tone multi frequency) to transmit the data
from cell phone to Microcontroller. The scan codes are scanned
U by the
microcontroller from mobile which gives audio frequency L from key pad of
N
mobile. For each key it will produces different audio frequency. This project
2
consists of Power supply, Microcontroller, PWM, and motor0 driving units. The
input will be givenDTMF
to the controller through set switches.
0 The controllerStepper
receives
Mobile
the data according to the value set by the cell phone switches.
3 motor
This can be done
driver
by manual. Then the controller gives digital input to the PWM, which converts
the digital data in to analog and drives the motor unit.
U
L
N
BLOCK DIAGRAM: Micro 2 Stepper
controller 0 motor
0
3
driver

You might also like