You are on page 1of 195

ORDER NO.

CRT4519
AVH-P3200BT/XNUC

DVD AV RECEIVER

AVH-P3200BT /XNUC

AVH-P3250BT/XNRD
AVH-P3200DVD/XNUC
AVH-P3250DVD/XNRC
AVH-P3250DVD/XNRD
AVH-P3250DVD/XNRI
This service manual should be used together with the following manual(s):
Model No. Order No. Mech.Module Remarks

CX-3250 CRT4300 LS1 DVD Mech. Module : Circuit Descriptions, Mech. Descriptions, Disassembly

For details, refer to "Important Check Points for Good Servicing".

PIONEER CORPORATION 1-1, Shin-ogura, Saiwai-ku, Kawasaki-shi, Kanagawa 212-0031, Japan


PIONEER ELECTRONICS (USA) INC. P.O. Box 1760, Long Beach, CA 90801-1760, U.S.A.
PIONEER EUROPE NV Haven 1087, Keetberglaan 1, 9120 Melsele, Belgium
PIONEER ELECTRONICS ASIACENTRE PTE. LTD. 253 Alexandra Road, #04-01, Singapore 159936
PIONEER CORPORATION 2010
K-ZZZ. JAN. 2010 Printed in Japan
1 2 3 4

SAFETY INFORMATION
CAUTION
A
This service manual is intended for qualified service technicians; it is not meant for the casual do-it-yourselfer.
Qualified technicians have the necessary test equipment and tools, and have been trained to properly and safely repair
complex products such as those covered by this manual.
Improperly performed repairs can adversely affect the safety and reliability of the product and may void the warranty.
If you are not qualified to perform the repair of this product properly and safely, you should not risk trying to do so
and refer the repair to a qualified service technician.

WARNING
This product may contain a chemical known to the State of California to cause cancer, or birth defects or
other reproductive harm.
Health & Safety Code Section 25249.6 - Proposition 65
B
Where in a manufacturer’s service documentation, for example in circuit diagrams or lists
of components, a symbol is used to indicate that a specific component shall be replaced only
by the component specified in that documentation for safety reasons, the following symbol shall
be used:

- Safety Precautions for those who Service this Unit.


When checking or adjusting the emitting power of the laser diode exercise caution in order to get safe, reliable
results.

C Caution:
1. During repair or tests, minimum distance of 13 cm from the focus lens must be kept.
2. During repair or tests, do not view laser beam for 10 seconds or longer.

CAUTION:
USE OF CONTROLS OR ADJUSTMENTS OR PERFORMANCE OF PROCEDURES OTHER THAN THOSE
SPECIFIED HEREIN MAY RESULT IN HAZARDOUS RADIATION EXPOSURE.

CAUTION
CLASS 1M INVISIBLE LASER RADIATION WHEN OPEN. DO NOT VIEW DIRECTLY WITH OPTICAL INSTRUMENTS

WARNING!
The AEL (accessible emission level )of the laser power output is less than CLASS 1
but the laser component is capable of emitting radiation exceeding the limit for
CLASS 1.
A specially instructed person should do servicing operation of the apparatus.

E
Laser diode characteristics
Wave length:
DVD:660 nm to 670 nm
CD:780 nm to 800 nm
Focus lens on Maximum output:
CD:6.26 mW(Emitting period :9 sec.)
DVD:1.27 mW (Emitting period : unlimited)

Additional Laser Caution

Transistors Q1103 and Q1104 in PCB drive the laser diodes for DVD and CD
F
respectively. When Q1103 or Q1104 is shorted between their terminals,
the laser diodes for DVD or CD will radiate beam. If the top cover is removed
with no disc loaded while such short-circuit is continued, the naked eyes may
be exposed to the laser beam.

AVH-P3200BT/XNUC
2
1 2 3 4
5 6 7 8

[Important Check Points for Good Servicing]


In this manual, procedures that must be performed during repairs are marked with the below symbol.
Please be sure to confirm and follow these procedures.
A
1. Product safety
Please conform to product regulations (such as safety and radiation regulations), and maintain a safe servicing environment by
following the safety instructions described in this manual.

1 Use specified parts for repair.

Use genuine parts. Be sure to use important parts for safety.

2 Do not perform modifications without proper instructions.

Please follow the specified safety methods when modification(addition/change of parts) is required due to interferences such as
radio/TV interference and foreign noise.

3 Make sure the soldering of repaired locations is properly performed. B

When you solder while repairing, please be sure that there are no cold solder and other debris.
Soldering should be finished with the proper quantity. (Refer to the example)

4 Make sure the screws are tightly fastened.

Please be sure that all screws are fastened, and that there are no loose screws.

5 Make sure each connectors are correctly inserted.

Please be sure that all connectors are inserted, and that there are no imperfect insertion.

6 Make sure the wiring cables are set to their original state.

Please replace the wiring and cables to the original state after repairs.
In addition, be sure that there are no pinched wires, etc. C

7 Make sure screws and soldering scraps do not remain inside the product.

Please check that neither solder debris nor screws remain inside the product.

8 There should be no semi-broken wires, scratches, melting, etc. on the coating of the power cord.

Damaged power cords may lead to fire accidents, so please be sure that there are no damages.
If you find a damaged power cord, please exchange it with a suitable one.

9 There should be no spark traces or similar marks on the power plug.

When spark traces or similar marks are found on the power supply plug, please check the connection and advise on secure
connections and suitable usage. Please exchange the power cord if necessary.

a Safe environment should be secured during servicing. D

When you perform repairs, please pay attention to static electricity, furniture, household articles, etc. in order to prevent injuries.
Please pay attention to your surroundings and repair safely.

2. Adjustments
To keep the original performance of the products, optimum adjustments and confirmation of characteristics within specification.
Adjustments should be performed in accordance with the procedures/instructions described in this manual.

3. Lubricants, Glues, and Replacement parts


Use grease and adhesives that are equal to the specified substance.
Make sure the proper amount is applied.
E

4. Cleaning
For parts that require cleaning, such as optical pickups, tape deck heads, lenses and mirrors used in projection monitors, proper
cleaning should be performed to restore their performances.

5. Shipping mode and Shipping screws


To protect products from damages or failures during transit, the shipping mode should be set or the shipping screws should be
installed before shipment. Please be sure to follow this method especially if it is specified in this manual.

AVH-P3200BT/XNUC
5 6 7 8
3
1 2 3 4

CONTENTS
SAFETY INFORMATION..................................................................................................................................... 2
1. SERVICE PRECAUTIONS ............................................................................................................................... 5
A
1.1 SERVICE PRECAUTIONS ........................................................................................................................ 5
1.2 NOTES ON SOLDERING .......................................................................................................................... 6
2. SPECIFICATIONS ............................................................................................................................................ 7
2.1 SPECIFICATIONS ..................................................................................................................................... 7
2.2 DISC/CONTENT FORMAT .......................................................................................................................11
2.3 PANEL FACILITIES.................................................................................................................................. 12
2.4 CONNECTION DIAGRAM ....................................................................................................................... 14
3. BASIC ITEMS FOR SERVICE........................................................................................................................ 21
3.1 CHECK POINTS AFTER SERVICING..................................................................................................... 21
3.2 PCB LOCATIONS .................................................................................................................................... 22
3.3 JIGS LIST ................................................................................................................................................ 23
3.4 CLEANING............................................................................................................................................... 23
B 4. BLOCK DIAGRAM.......................................................................................................................................... 24
5. DIAGNOSIS.................................................................................................................................................... 34
5.1 OPERATIONAL FLOWCHART ................................................................................................................ 34
5.2 INSPECTION METHOD OF PICKUP UNIT............................................................................................. 35
5.3 DIAGNOSIS FLOWCHART ..................................................................................................................... 38
5.4 ERROR CODE LIST ................................................................................................................................ 65
5.5 CONNECTOR FUNCTION DESCRIPTION ............................................................................................. 69
6. SERVICE MODE ............................................................................................................................................ 70
6.1 MONITOR TEST MODE .......................................................................................................................... 70
6.2 DVD TEST MODE ................................................................................................................................... 80
7. DISASSEMBLY .............................................................................................................................................. 84
8. EACH SETTING AND ADJUSTMENT ........................................................................................................... 92
C
8.1 DVD ADJUSTMENT ................................................................................................................................ 92
8.2 MOTHER UNIT ADJUSTMENT ............................................................................................................. 100
8.3 MONITOR PCB ADJUSTMENT............................................................................................................. 102
9. EXPLODED VIEWS AND PARTS LIST........................................................................................................ 104
9.1 PACKING ............................................................................................................................................... 104
9.2 EXTERIOR(1) ........................................................................................................................................ 108
9.3 EXTERIOR(2) .........................................................................................................................................110
9.4 DVD MECHANISM MODULE .................................................................................................................112
10. SCHEMATIC DIAGRAM..............................................................................................................................116
10.1 MOTHER UNIT(AUDIO) .......................................................................................................................116
10.2 MOTHER UNIT(SYSTEM)(GUIDE PAGE) ...........................................................................................118
D 10.3 MOTHER UNIT(POWER SUPPLY) ..................................................................................................... 124
10.4 MOTHER UNIT(DV5U)(GUIDE PAGE)................................................................................................ 126
10.5 MOTHER UNIT(IN/OUT PUT)(GUIDE PAGE)..................................................................................... 132
10.6 MOTHER UNIT(TUNER) ..................................................................................................................... 138
10.7 INTERFACE PCB ................................................................................................................................ 140
10.8 DVD CORE UNIT(GUIDE PAGE) ........................................................................................................ 142
10.9 CONNECT PCB ................................................................................................................................... 148
10.10 KEYBOARD PCB............................................................................................................................... 150
10.11 MONITOR PCB(GERDA)(GUIDE PAGE) .......................................................................................... 152
10.12 MONITOR PCB(BACKLIGHT) ........................................................................................................... 158
10.13 SD PCB AND BT ANT PCB ............................................................................................................... 160
10.14 WAVEFORMS .................................................................................................................................... 162
E 11. PCB CONNECTION DIAGRAM.................................................................................................................. 164
11.1 MOTHER UNIT .................................................................................................................................... 164
11.2 INTERFACE PCB................................................................................................................................. 168
11.3 DVD CORE UNIT ................................................................................................................................. 170
11.4 CONNECT PCB ................................................................................................................................... 172
11.5 KEYBOARD PCB ................................................................................................................................. 174
11.6 MONITOR PCB .................................................................................................................................... 176
11.7 SD PCB ................................................................................................................................................ 180
11.8 BT ANT PCB ........................................................................................................................................ 181
12. ELECTRICAL PARTS LIST ........................................................................................................................ 182

AVH-P3200BT/XNUC
4
1 2 3 4
5 6 7 8

1. SERVICE PRECAUTIONS
1.1 SERVICE PRECAUTIONS
A

1. You should conform to the regulations governing the product (safety, radio and noise, and other regulations),
and should keep the safety during servicing by following the safety instructions described in this manual.
2. Be careful in handling ICs. Some ICs such as MOS type are so fragile that they can be damaged by electrostatic
induction.
3. Before disassembling the unit, be sure to turn off the power. Unplugging and plugging the connectors during
power-on mode may damage the ICs inside the unit.
4. To protect the pickup unit from electrostatic discharge during servicing, take an appropriate treatment
(shorting-solder) by referring to "the DISASSEMBLY" .
5. After replacing the pickup unit, be sure to skew adjustment. B
6. During disassembly, be sure to turn the power off since an internal IC might be destroyed when a connector
is plugged or unplugged.
7. Countermeasures to user complaints on iPhone/iPod touch lip synchronization
When a video is replayed, the video and audio may be out of synchronization depending on the connected
iPod or iPhone.
If it is annoying, perform the following operation.
However, this operation will slightly deteriorate the sound quality of the iPod source.
Also, it will disable the ASR function when the iPod source is used.

[Default]
Audio digital mode
C
[Switching procedure]
Press MODE and EJECT and turn on Accessory simultaneously

The above switches the “Audio digital mode” to the “Audio analog mode”.
When the mode is switching, the BEEP1 sound will be heard.

[Supplement]
• The mode switching operation can only switch the “Audio digital mode” to the “Audio analog mode”.
(The BEEP1 sound will be heard every time.)
• No indication of the mode is provided.

[Resetting the mode] D

Reset or BackUP OFF

The above resets the mode to the “Audio digital mode”.

8. recautions for AEQ measurement


If the microphone is not connected securely, the microphone input signals may become inaccurate and an
error message “Plug the supplied microphone securely into the jack” may appear due to the measurement failure.
9. EJECT LOCK MODE for DVD mechanism
How to enter : Press RESET while pressing [FORWARD] and [EJECT] keys together.
How to exit : Same procedure to enter this mode.
10. When EEPROM is initialized, eject lock may be enabled. Please cancel eject lock in this case. E

AVH-P3200BT/XNUC
5 6 7 8
5
1 2 3 4

1.2 NOTES ON SOLDERING

A For environmental protection, lead-free solder is used on the printed circuit boards mounted in this unit.
Be sure to use lead-free solder and a soldering iron that can meet specifications for use with lead-free solders for repairs
accompanied by reworking of soldering.

Compared with conventional eutectic solders, lead-free solders have higher melting points, by approximately 40 C.
Therefore, for lead-free soldering, the tip temperature of a soldering iron must be set to around 373 C in general, although
the temperature depends on the heat capacity of the PC board on which reworking is required and the weight of the tip of
the soldering iron.

Compared with eutectic solders, lead-free solders have higher bond strengths but slower wetting times and higher melting
temperatures (hard to melt/easy to harden).

B The following lead-free solders are available as service parts:


Parts numbers of lead-free solder:
GYP1006 1.0 in dia.
GYP1007 0.6 in dia.
GYP1008 0.3 in dia.

AVH-P3200BT/XNUC
6
1 2 3 4
5 6 7 8

2. SPECIFICATIONS
2.1 SPECIFICATIONS
A

AVH-P3200BT/XNUC, AVH-P3200DVD/XNUC
General Equalizer (8-Band Graphic Equalizer):
Power source............................14.4 V DC (10.8 V to 15.1 V Frequency......................... 40/80/200/400/1k/2.5k/8k/
allowable) 10k Hz
Grounding system.................. Negative type Gain .................................... ±12 dB
Maximum current consumption HPF:
....................................................10.0 A Frequency......................... 50/63/80/100/125 Hz
Slope...................................–12 dB/oct
Backup current.........................5.0 mA or less
Subwoofer (mono):
Dimensions (W × H × D): Frequency......................... 50/63/80/100/125 Hz B
D Slope...................................–18 dB/oct
Chassis .....................178 mm × 100 mm × 165 Gain .....................................+6 dB to –24 dB
mm Phase .................................Normal/Reverse
(7 in. × 3-7/8 in. × 6-1/2 in.) Bass boost:
Nose ...........................171 mm × 97 mm × 7 mm Gain .....................................+12 dB to 0 dB
(6-3/4 in. × 3-7/8 in. × 1/4
in.) DVD Player
Weight .........................................1.8 kg (4.0 lbs) System ........................................ DVD video, Video CD, CD,
Display WMA, MP3, AAC, DivX,
Screen size/aspect ratio.......5.8 inch wide/16:9 JPEG system
(effective display area: 128.4 Usable discs .............................DVD video, Video CD, CD, C
× 70.9 mm) CD-R/RW, DVD-R/RW/RDL
Pixels ........................................... 345 600 (1 440 × 240) Region number ....................... 1
Display method ....................... TFT active matrix, driving Frequency response.............. 5 Hz to 44 000 Hz (with DVD,
type at sampling frequency 96
Color system.............................NTSC kHz)
Durable temperature range (power off) Signal-to-noise ratio.............. 96 dB (1 kHz) (IEC-A net-
...................................................-20 °C to +80 °C work) (RCA level)
Audio Output level:
Maximum power output .......50 W × 4 Video...................................1.0 Vp-p/75 ohm (±0.2 V)
70 W × 1/2 ohm Number of channels ............. 2 (stereo)
(for subwoofer) MP3 decoding format .......... MPEG-1 & 2 Audio Layer 3 D
Continuous power output ... 22 W × 4 (50 Hz to 15 000 WMA decoding format ........ Ver. 7, 7.1, 8, 9, 10, 11 (2ch
Hz, 5 % THD, 4 ohm load, audio)
both channels driven) (Windows Media Player)
Load impedance ..................... 4 ohm (4 ohm to 8 ohm AAC decoding format........... MPEG-4 AAC (iTunes en-
(2 ohm for 1 ch) allowable) coded only) (.m4a)
Preout maximum output level (Ver. 8.2 and earlier)
...................................................4.0 V DivX decoding format........... Home Theater Ver. 3, 4, 5.2,
6 (.avi, .divx)

USB
USB standard specification E
...................................................USB 1.1, USB 2.0 full speed
Maximum current supply .... 500 mA
USB Class..................................MSC (Mass Storage Class)
File system.................................FAT16, FAT32
MP3 decoding format .......... MPEG-1 & 2 Audio Layer 3
WMA decoding format ........ Ver. 7, 7.1, 8, 9, 10, 11 (2ch
audio)
(Windows Media Player)
AAC decoding format........... MPEG-4 AAC (iTunes en-
coded only)
(Ver. 8.2 and earlier) F

AVH-P3200BT/XNUC
5 6 7 8
7
1 2 3 4

A DivX decoding format............Home Theater Ver. 3, 4, 5.2,


6 (.avi, .divx)

SD
Compatible physical format
....................................................Version 1.10
Maximum memory capacity
...................................................2 GB
File system.................................FAT12, FAT16, FAT32
MP3 decoding format ...........MPEG-1 & 2 Audio Layer 3
WMA decoding format .........Ver. 7, 7.1, 8, 9, 10, 11 (2ch
B audio)
(Windows Media Player)
AAC decoding format............MPEG-4 AAC (iTunes en-
coded only)
(Ver. 8.2 and earlier)
DivX decoding format............Home Theater Ver. 3, 4, 5.2,
6 (.avi, .divx)

FM tuner
Frequency range..................... 87.9 MHz to 107.9 MHz
Usable sensitivity.................... 9 dBf (0.8 μV/75 ohm,
C mono, S/N: 30 dB)
Signal-to-noise ratio...............72 dB (IEC-A network)

AM tuner
Frequency range..................... 530 kHz to 1 710 kHz (10
kHz)
Usable sensitivity.................... 25 μV (S/N: 20 dB)
Signal-to-noise ratio...............62 dB (IEC-A network)

Bluetooth
(AVH-P3200BT)
D Version ........................................ Bluetooth 2.0 certified
Output power .......................... +4 dBm Max.
(Power class 2)

CEA2006 Specifications

E Power output ............................14 W RMS × 4 Channels (4


ohm and 1 % THD+N)
S/N ratio ..................................... 91 dBA (reference: 1 W into
4 ohm)

Note
Specifications and the design are subject to mod-
ifications without notice.

AVH-P3200BT/XNUC
8
1 2 3 4
5 6 7 8

AVH-P3250BT/XNRD,
AVH-P3250DVD/XNRC, AVH-P3250DVD/XNRD, AVH-P3250DVD/XNRI A

General DVD Player


Rated power source...............14.4 V DC System .........................................DVD video, Video CD, CD,
(allowable voltage range: WMA, MP3, AAC, DivX,
12.0 V to 14.4 V DC) JPEG system
Grounding system.................. Negative type Usable discs .............................DVD video, Video CD, CD,
Maximum current consumption CD-R/RW, DVD-R/RW/RDL
....................................................10.0 A Region number :
Backup current.........................5.0 mA or less for Middle East Asian and South African models
Dimensions (W × H × D): ...................................... 2
D for Southeast Asian models B
Chassis .....................178 mm × 100 mm × 165 ...................................... 3
mm for South American and Oceanian models
...................................... 4
Nose ...........................171 mm × 97 mm × 7 mm
Weight .........................................1.8 kg Frequency response...............5 Hz to 44 000 Hz (with DVD,
at sampling frequency 96
Display kHz)
Screen size/aspect ratio.......5.8 inch wide/16:9 Signal-to-noise ratio...............96 dB (1 kHz) (IEC-A net-
(effective display area: 128.4 work) (RCA level)
× 70.9 mm) Output level:
Pixels ........................................... 345 600 (1 440 × 240) Video....................................1.0 Vp-p/75 ohm (±0.2 V)
Display method ........................TFT active matrix, driving Number of channels ..............2 (stereo) C
type MP3 decoding format ...........MPEG-1 & 2 Audio Layer 3
Color system.............................NTSC/PAL/PAL-M/SECAM WMA decoding format .........Ver. 7, 7.1, 8, 9, 10, 11 (2ch
compatible audio)
Durable temperature range (power off) (Windows Media Player)
...................................................-20 °C to +80 °C AAC decoding format............MPEG-4 AAC (iTunes en-
coded only) (.m4a)
Audio
(Ver. 8.2 and earlier)
Maximum power output .......50 W × 4
DivX decoding format............Home Theater Ver. 3, 4, 5.2,
70 W × 1/2 ohm
6 (.avi, .divx)
(for subwoofer)
Continuous power output ... 22 W × 4 (50 Hz to 15 000
USB
Hz, 5 % THD, 4 ohm load, D
USB standard specification
both channels driven)
...................................................USB 1.1, USB 2.0 full speed
Load impedance ..................... 4 ohm (4 ohm to 8 ohm
Maximum current supply .... 500 mA
(2 ohm for 1 ch) allowable)
USB Class..................................MSC (Mass Storage Class)
Preout maximum output level
File system.................................FAT16, FAT32
...................................................4.0 V
MP3 decoding format ...........MPEG-1 & 2 Audio Layer 3
Equalizer (8-Band Graphic Equalizer):
WMA decoding format .........Ver. 7, 7.1, 8, 9, 10, 11 (2ch
Frequency......................... 40/80/200/400/1k/2.5k/8k/
audio)
10k Hz
(Windows Media Player)
Gain .................................... ±12 dB
AAC decoding format............MPEG-4 AAC (iTunes en-
HPF: coded only) E
Frequency......................... 50/63/80/100/125 Hz (Ver. 8.2 and earlier)
Slope...................................–12 dB/oct DivX decoding format............Home Theater Ver. 3, 4, 5.2,
Subwoofer (mono): 6 (.avi, .divx)
Frequency......................... 50/63/80/100/125 Hz
Slope...................................–18 dB/oct
Gain .....................................+6 dB to – 24 dB
Phase .................................Normal/Reverse
Bass boost:
Gain .....................................+12 dB to 0 dB

AVH-P3200BT/XNUC
5 6 7 8
9
1 2 3 4

A
Compatible physical format
....................................................Version 1.10
Maximum memory capacity
...................................................2 GB
File system.................................FAT12, FAT16, FAT32
MP3 decoding format ...........MPEG-1 & 2 Audio Layer 3
WMA decoding format .........Ver. 7, 7.1, 8, 9, 10, 11 (2ch
audio)
(Windows Media Player)
AAC decoding format............MPEG-4 AAC (iTunes en-
B coded only)
(Ver. 8.2 and earlier)
DivX decoding format............Home Theater Ver. 3, 4, 5.2,
6 (.avi, .divx)

FM tuner
Frequency range..................... 87.5 MHz to 108.0 MHz
Usable sensitivity.................... 9 dBf (0.8 μV/75 ohm,
mono, S/N: 30 dB)
Signal-to-noise ratio...............72 dB (IEC-A network)

C AM tuner
Frequency range..................... 531 kHz to 1 602 kHz (9 kHz)
530 kHz to 1 640 kHz (10
kHz)
Usable sensitivity.................... 25 μV (S/N: 20 dB)
Signal-to-noise ratio.............. 62 dB (IEC-A network)

Bluetooth
(AVH-P3250BT)
Version ........................................ Bluetooth 2.0 certified
Output power ........................... +4 dBm Max.
D (Power class 2)

Infrared remote control


Wavelength............................... 945 nm
Output ......................................... typ; 10 mw/sr per Infrared
LED

Note
Specifications and the design are subject to mod-
ifications without notice.
E

AVH-P3200BT/XNUC
10
1 2 3 4
5 6 7 8

2.2 DISC/CONTENT FORMAT

is a trademark of DVD Format/Logo Licensing Corporation.


B

(RC, RD, RI models) (UC model only)

(BT model only)

The Bluetooth word mark and logos are owned by the Bluetooth SIG, Inc.
and any use of such marks by Pioneer Corporation is under license. D
Other trademarks and trade names are those of their respective owners.

AVH-P3200BT/XNUC
5 6 7 8
11
1 2 3 4

2.3 PANEL FACILITIES

Head unit
CAUTION
• Use an optional Pioneer USB cable (CD-U50E)
2 to connect the USB audio player/USB mem-
1 3 ory as any device connected directly to the
unit will protrude out from the unit and may
4 be dangerous.
B 5 • Do not use unauthorized products.
76 • When inserting an SD card into the card slot,
8
9 make sure that the label is facing the left.
a (UC model only)
b
cd • For details on how to operate a navigation unit
from this unit, refer to its operation manual.

Note
When the navigation unit is connected, press
C P art P art MODE to switch to the navigation display. Press
MODE MODE and hold to turn the display off.
1 RESET 8 Turning the infor- PressMODE again to turn the display on.
mation display off.

MENU
Displaying the
2 (eject) 9 menu. Optional remote control
Returning to the The remote control CD-R55 is sold separately.
normal display.
For details concerning operations, see the re-
D 3 Disc loading slot a
SD memory card mote control manual.
slot

USB port
+ /– (VOLUME/ When connecting,
4 b
VOL) open the USB con-
nector lid.

AUX input jack (3.5


mm stereo/video
/ (TRACK/
5 c jack)
SEEK )
Use to connect an
auxiliary device.
E
Auto EQ micro-
phone input jack
6 SRC/OFF d Use to connect an
auto EQ micro-
phone.

7 MUTE

AVH-P3200BT/XNUC
12
1 2 3 4
5 6 7 8

AVH-P3250BT/XNRD,
AVH-P3250DVD/XNRC, AVH-P3250DVD/XNRD, AVH-P3250DVD/XNRI
A

Remote control Part Operation


Press to select the
tuner band when
tuner is selected as a
source. Also used to
cancel the control
mode of functions.
Press to switch be-
i BAND/ESC
tween modes when
playing discs with B
compressed audio
and audio data (CD-
DA) such as CD-
EXTRA and MIXED-
MODE CDs.
Press to display the
MENU DVD menu during
DVD playback.
j
Press to return to the
Part Operation
TOP MENU top menu during DVD C
Click to recall Menu. playback.
e Thumb pad Use to select a menu
Press to change the
on the DVD menu.
audio language during
Press to display the DVD playback.
AUDIO
PBC (playback con- Press to switch audio
f RETURN output for Video CD/
trol) menu during PBC
playback. DivX.
k
Press to pause or re- Press to change the
sume playback. SUBTITLE subtitle language dur-
ing DVD playback.
Press to return to the D

previous track (chap- Press to change the


ter). ANGLE viewing angle during
g
DVD playback.
Press to go to the next
track (chapter). Press to cycle through
all the available rear
Press to stop play- l REAR SRC sources.
back. Press and hold to turn
the rear source off.
Press to select the
next/previous disc/
folder.
E
h / (FOLDER/P.CH) Press to recall radio
station frequencies as-
signed to preset tun-
ing keys.

AVH-P3200BT/XNUC
5 6 7 8
13
F
E
B
A

D
C

14
Connecting the power cord
26 pin cable (Supplied with Navigation unit)

1
1

This product
Insert the 26 pin cable in the direction 4 m (13 ft. 1 in.)
Microphone (AVH-P3200BT only)
indicated in the figure.
Wired remote input
Navigation unit can Hard-wired remote control adaptor can be connected
RGB input (sold separately).
be connected
(AVIC-U220(sold Fuse resistor
separately)). Antenna input
Violet/white
Please contact your Of the two lead wires connected to the back lamp, connect the one
dealer to inquire about Fuse (10 A) in which the voltage changes when the gear shift is in the
Microphone input (AVH-P3200BT only)
the connectable REVERSE (R) position. This connection enables the unit to
navigation unit. sense whether the car is moving forwards or backwards.

Yellow Yellow/black
Connect to the constant 12 V supply terminal. If you use an equipment with Mute function, wire this lead to
the Audio Mute lead on that equipment. If not, keep the Audio
Mute lead free of any connections.

2
2

2.4 CONNECTION DIAGRAM

Orange/white Fuse resistor


Connect to lighting switch terminal. Connection method

Red Fuse resistor 1. Clamp the lead. 2. Clamp firmly with


Connect to terminal controlled by ignition switch (12 V DC). needle-nosed pliers.

Black (chassis ground) Note:


Connect to a clean, paint-free metal location. · The position of the parking brake switch depends on the vehicle model. For details,
consult the vehicle Owner’s Manual or dealer.
AVH-P3200BT/XNUC, AVH-P3200DVD/XNUC

White Gray

AVH-P3200BT/XNUC
Front speaker Front speaker Light green
Used to detect the ON/OFF status of the parking Parking brake
Left White/black Gray/black Right brake. This lead must be connected to the power Power supply side switch
supply side of the parking brake switch.

3
3

Green Violet
Rear speaker or Rear speaker or Ground side
Subwoofer (4 ) Subwoofer (4 )
Green/black Violet/black Blue/white
Connect to system control terminal of the power amp or
auto-antenna relay control terminal (max. 300 mA 12 V DC).

When using a subwoofer of 70 W (2 ), be sure to connect with Violet and Violet/black leads of this unit. Do not
With a 2 speaker system, do not connect anything to the speaker leads
connect anything to Green and Green/black leads.
that are not connected to speakers.

Note:
Green Violet
· Change the initial setting of this unit (refer
Subwoofer (4 ) to the Operation Manual). The subwoofer
Not used.
×2 output of this unit is monaural.
Green/black Violet/black

4
4
Connecting the system (AVH-P3200DVD) When connecting to separately sold power amp

Microphone Rear output (AVH-P3200BT only)


5

5
for hands-free phoning Front output
(supplied with Bluetooth adapter)
Bluetooth adapter Power amp
IP-BUS input (e.g. CD-BTB200) (sold separately)
To rear output
(sold separately)
Power amp
(sold separately)
Wired remote input To front output
Hard-wired remote control Power amp
Subwoofer output
adaptor can be connected (sold separately)
(sold separately). This product
Black To subwoofer
output
This product 1.5 m (4 ft. 11 in.) Connect with RCA cables
(sold separately)

IP-BUS cable
(Supplied with Bluetooth adapter)

6
6

Connecting the system (AVH-P3200BT)


System remote control
IP-BUS input

Blue/white
Connect to system control terminal of the
Wired remote input
power amp or auto-antenna relay control
Hard-wired remote control HD radio tuner
terminal. (max. 300 mA 12 V DC).
adaptor can be connected (sold separately)
(sold separately).

AVH-P3200BT/XNUC
L ef t R i ght

This product 3 m (9 ft. 10 in.)

7
7

IP-BUS cable
(Supplied with HD radio tuner)
Subwoofer Subwoofer

Front speaker Front speaker

Rear speaker Rear speaker


Perform these connections when
using the optional amplifier.
8

8
15
E
A

D
C

F
B
F
E
B
A

D
C

16
When connecting with a rear view camera When connecting the external video component and the
When this product is used with a rear view camera, it is possible to automatically switch display

1
1

from the video to rear view image when the gear shift is moved to REVERSE (R).
Display with RCA
WARNING input jacks (sold
separately)
USE INPUT ONLY FOR REVERSE OR MIRROR IMAGE REAR VIEW CAMERA. OTHER USE MAY
RESULT IN INJURY OR DAMAGE.

CAUTION
• The screen image may appear reversed.
• The rear view camera function is to be used as an aid for backing into a tight parking spot. To video input
Do not use this function for entertainment purposes.
• Objects in the rear view may appear closer or more distant than they actually are.
To audio input

CAUTION

2
2

Rear monitor output ( V OUT )


Rear view camera input (R.C IN ) You must use a camera (AVH-P3200BT only) RCA cables
which outputs mirror Video input (V IN) (sold separately)
(AVH-P3200BT only)
reversed images.
Rear audio output Mini pin plug cable
(REAR AUDIO OUT ) (sold separately)
To video output
Rear view camera To video output
(sold separately)

RCA cable (sold separately)


To audio outputs
This product This product Audio input
(L IN , R IN )

AVH-P3200BT/XNUC
Fuse resistor

Violet/white
Of the two lead wires connected to the back lamp, connect the one

3
3

in which the voltage changes when the gear shift is in the


REVERSE (R) position. This connection enables the unit to
sense whether the car is moving forwards or backwards. External video
component (sold
separately)

• It is necessary to set Camera Polarity properly in System when connecting the rear view
• It is necessary to change AV Input in System when connecting the external video component.
camera.
When using a display connected to rear video output
This product’s rear video output and rear audio output are for connection of a display to
enable passengers in the rear seats to watch the DVD, etc.

WARNING
Never install the display in a location where it is visible to the driver while driving.

4
4
Connecting the power cord
Microphone
(AVH-P3250BT only)
5

5
4m Microphone input (AVH-P3250BT only)

RGB input Wired remote input


Hard-wired remote control adaptor can be connected (sold separately).

Fuse resistor

Violet/white
Of the two lead wires connected to the back lamp, connect the one
This product Fuse (10 A) in which the voltage changes when the gear shift is in the
Antenna input
REVERSE (R) position. This connection enables the unit to
sense whether the car is moving forwards or backwards.

Yellow Yellow/black
Connect to the constant 12 V supply terminal. If you use an equipment with Mute function, wire this lead to
the Audio Mute lead on that equipment. If not, keep the Audio

6
6

Mute lead free of any connections.


Orange/white Fuse resistor
Connect to lighting switch terminal. Connection method

Red Fuse resistor 1. Clamp the lead. 2. Clamp firmly with


Connect to terminal controlled by ignition switch (12 V DC). needle-nosed pliers.

Black (chassis ground) Note:


Connect to a clean, paint-free metal location. · The position of the parking brake switch depends on the vehicle model. For details,
consult the vehicle Owner’s Manual or dealer.
AVH-P3250BT/XNRD, AVH-P3250DVD/XNRC,
AVH-P3250DVD/XNRD, AVH-P3250DVD/XNRI

White Gray

AVH-P3200BT/XNUC
Front speaker Front speaker Light green
Used to detect the ON/OFF status of the parking Parking brake
Left White/black Gray/black Right brake. This lead must be connected to the power

7
7

Power supply side switch


Green Violet supply side of the parking brake switch.
Rear speaker or Rear speaker or Ground side
Subwoofer (4 ) Subwoofer (4 )
Green/black Violet/black Blue/white
Connect to system control terminal of the power amp or
auto-antenna relay control terminal (max. 300 mA 12 V DC).

When using a subwoofer of 70 W (2 ), be sure to connect with Violet and Violet/black leads of this unit. Do not
With a 2 speaker system, do not connect anything to the speaker leads
connect anything to Green and Green/black leads.
that are not connected to speakers.

When you connect the separately sold Note:


Green Violet
multi-channel processor (DEQ-P7650) to this · Change the initial setting of this unit (refer
Subwoofer (4 ) unit, do not connect anything to the speaker to the Operation Manual). The subwoofer
Not used.
×2 leads and systemremote control (blue/white). output of this unit is monaural.
Green/black Violet/black
8

8
17
E
A

D
C

F
B
F
E
B
A

D
C

18
Connecting the system (AVH-P3250DVD) When connecting to separately sold power amp

1
1

Microphone Rear output (AVH-P3250BT only)


for hands-free phoning Front output
(supplied with Bluetooth adapter)
Bluetooth adapter Power amp
IP-BUS input (e.g. CD-BTB100) (sold separately)
(sold separately) To rear output
Power amp
Wired remote input (sold separately)
Hard-wired remote control To front output
adaptor can be connected Power amp
Subwoofer output
(sold separately). (sold separately)
This product
Black To subwoofer
output
This product 1.5 m Connect with RCA cables
(sold separately)

IP-BUS cable
(Supplied with Bluetooth adapter)

2
2

Connecting the system (AVH-P3250BT)


IP-BUS input
System remote control

Blue/white
Wired remote input
Connect to system control terminal of the
Hard-wired remote control DVD changer
power amp or auto-antenna relay control
adaptor can be connected (sold separately)
terminal (max. 300 mA 12 V DC).
(sold separately).

AVH-P3200BT/XNUC
L ef t R i ght

This product

3
3

IP-BUS cable
•When you connect the separately sold
Subwoofer Subwoofer
multi-channel processor (DEQ-P7650) to this
unit, do not connect anything to the speaker
leads and system remote control (blue/white).
•When you connect the multi-channel
processor to this unit, refer to multi-channel
processor’s installation manual for the
Front speaker Front speaker
connection method.

Rear speaker Rear speaker


Perform these connections when
using the optional amplifier.

4
4
When connecting with a rear view camera When connecting with a multi-channel processor
When this product is used with a rear view camera, it is possible to automatically switch
from the video to rear view image when the gear shift is moved to REVERSE (R). Microphone
5

5
for hands-free phoning
(supplied with Bluetooth adapter)
WARNING
USE INPUT ONLY FOR REVERSE OR MIRROR IMAGE REAR VIEW CAMERA. OTHER USE MAY
RESULT IN INJURY OR DAMAGE. Bluetooth adapter
(AVH-P3250BT only) (e.g. CD-BTB100)
This product (sold separately)
CAUTION (AVH-P3250DVD only)
IP-BUS input
• The screen image may appear reversed. Wired remote input
• The rear view camera function is to be used as an aid for backing into a tight parking spot. Hard-wired remote
Do not use this function for entertainment purposes. control adaptor
• Objects in the rear view may appear closer or more distant than they actually are. can be connected
(sold separately).
Blue Black
CAUTION ToSWL
Optical

6
6

You must use a camera ToSWR output


Rear view camera input ( R.C IN )
which outputs mirror IP-BUS cable
(AVH-P3250BT only) reversed images. (Supplied with Bluetooth adapter)

Black
To video output Optical cable connection box
Rear view camera (CD-DD25)
(sold separately) (sold separately)

RCA cable (sold separately) Optical cable


(supplied with
RCA cable (supplied with multi-channel processor)
This product
multi-channel processor)
Fuse resistor Blue

AVH-P3200BT/XNUC
Violet/white
Of the two lead wires connected to the back lamp, connect the one Multi-channel processor
in which the voltage changes when the gear shift is in the (DEQ-P7650)

7
7

REVERSE (R) position. This connection enables the unit to (sold separately)
sense whether the car is moving forwards or backwards.

IP-BUS cable (supplied with


multi-channel processor) Black Blue
• It is necessary to set Camera Polarity properly in System when connecting the rear view
camera.
DVD changer
IP-BUS cable (sold separately)
8

8
19
E
A

D
C

F
B
F
E
B
A

D
C

20
Connecting and installing the optical cable connection box When connecting the external video component and the display
WARNING Installing the optical cable

1
1

• Avoid installing the optical cable connection


connection box
Display with RCA
box in locations where the operation of safety • When installing the optical cable input jacks (sold
devices such as airbags is prevented by this connection box with the hook and separately)
unit. Otherwise, there is a danger of a fatal loop fastener.
accident. Install the optical cable connection box
• Avoid installing the optical cable connection using the hook and loop fastener in the
box in locations where the operation of the ample space of the console box.
brake may be prevented. Otherwise, it may
result in a traffic accident.
• Fix the optical cable connection box securely
with the hook and loop fastener or lock tie. If To video input
the unit is loose, it disturbs driving stability, Hook fastener
which may result in a traffic accident.
Loop fastener To audio input

CAUTION

2
2

• Install this unit using only the parts supplied with


Rear monitor output ( V OUT )
this unit. If other parts are used, this unit may be
damaged or could dismount itself, which leads to (AVH-P3250BT only) RCA cables
• When installing the optical cable Video input (V IN) (sold separately)
an accident or other problems.
• Do not install this unit near the doors where connection box with the lock tie.
rainwater is likely to be spilled on the unit. Wrap the optical cable and connection box Rear audio output Mini pin plug cable
Incursion of water into the unit may cause smoke with the protection tape and fasten with the ( REAR AUDIO OUT ) (sold separately)
or fire. power code using the lock tie.
To video output
Connecting the optical cable Wrap with the protection tape
1. Connect the optical cable and ground
lead to the main unit. To audio outputs
Connect the optical cable so that it does not This product Audio input

AVH-P3200BT/XNUC
(L IN , R IN )
protrude from the main unit, as shown in the
illustration. Fasten the ground lead to the
protrusion on the back of the main unit.
Screw

3
3

Fasten with the lock tie

External video
component (sold
separately)

2. Connect the optical cable to the • It is necessary to change AV Input in System when connecting the external video component.
optical cable connection box.
When using a display connected to rear video output
This product’s rear video output and rear audio output are for connection of a display to
enable passengers in the rear seats to watch the DVD, etc.

WARNING
Never install the display in a location where it is visible to the driver while driving.

4
4

optical cable
5 6 7 8

3. BASIC ITEMS FOR SERVICE


3.1 CHECK POINTS AFTER SERVICING
A
To keep the product quality after servicing, please confirm following check points.

No. Procedures Item to be confirmed


1 Confirm whether the customer complain has The customer complain must not be
been solved. reappeared.
If the customer complain occurs with the Display, video, audio and operations must be
specific media, use it for the operation check. normal.
2 DVD Measure playback error rates at the Deterioration of mecha-drive can be
innermost and outermost tracks by using the checked.
test mode with the following disc. The error rate must be less than the
DVD test disc (TDV-582) threshold value. B
(Refer to the chapter of DIAGNOSIS for the
threshold value.)
3 DVD Play back a DVD. Display, video, audio and operations must be
(Menu operation; Title/chapter search) normal.
4 CD Play back a CD. Display, audio and operations must be
(Track search) normal.
5 FM/AM tuner Check FM/AM tuner action. Display, audio and operations must be
(Seek, Preset) normal. * If the reception sensitivity is poorer
Switch band to check both FM and AM. than normal, the gasket on the FM/AM tuner
unit may be damaged or lost.
C
6 Check whether no disc is inside the product. The media used for the operating check must
be ejected.
7 Appearance check No scratches or dirt on its appearance after
receiving it for service.

For check items concerning image and voice, please refer to the followings:

Check items concerning image Check items concerning voice


Block-noise Distortion
Crosscut noise Noise
Dot noise Low volume D
Distorted image (Image skip) High volume
Low brightness Changes in level
Too bright Pause of sound
Color fading
Partial discoloration

AVH-P3200BT/XNUC
5 6 7 8
21
1 2 3 4

3.2 PCB LOCATIONS

C DVD Core Unit


D Connect PCB
G SD PCB
B B Interface PCB
H BT ANT PCB

E Keyboard PCB

C
A Mother Unit
F Monitor PCB

P:AVH-P3200BT/XNUC
Q:AVH-P3250BT/XNRD
J:AVH-P3200DVD/XNUC
K:AVH-P3250DVD/XNRC
L:AVH-P3250DVD/XNRD
M:AVH-P3250DVD/XNRI
D
Unit Number : (P)
Unit Number : (Q)
Unit Number : (J)
Unit Number : (K)
Unit Number : (L)
Unit Number : (M)
Unit Name : Mother Unit
Monitor I/F Unit
Consists of
Interface PCB
Keyboard PCB
Monitor PCB
E SD PCB
BT ANT PCB
Unit Number : (P,Q)
Unit Number : (J,K,L,M)
Unit Name : Monitor I/F Unit
Unit Number : YWX5013
Unit Name : DVD Core Unit
Unit Number :
Unit Name : Connect PCB

AVH-P3200BT/XNUC
22
1 2 3 4
5 6 7 8

3.3 JIGS LIST

A
Disc TDV-582 Skew adjustment, Check points after servicing,
Inspection method of Pickup Unit
Disc TCD-782 Inspection method of Pickup Unit
GGF1539 Disconnect the Cord Assy of the BT ANT PCB

- Grease List
Name Jig No. Remarks
Grease GEM1024 DVD Mechanism Module
Grease GEM1038 DVD Mechanism Module
Grease GEM1045 DVD Mechanism Module
Locking agents 1401M Skew adjustment (1401M:produced by THREE BOND) B
Bond GEM1033 Skew adjustment
Bond 1530 Skew adjustment (1530:produced by THREE BOND)

3.4 CLEANING

Before shipping out the product, be sure to clean the following portions by using the prescribed cleaning tools: D
Portions to be cleaned Cleaning tools
DVD pickup lenses Cleaning liquid : GEM1004
Cleaning paper : GED-008

AVH-P3200BT/XNUC
5 6 7 8
23
1 2 3 4

4. BLOCK DIAGRAM

A Note: When ordering service parts, be sure to refer to " EXPLODED VIEWS AND PARTS LIST" or
"ELECTRICAL PARTS LIST".

REAR AUDIO OUT


WIRED REMOTE
IP BUS

model

BUSL- 11
BUSR- 10

ASENBO 8
BUSL+ 7
BUSRG 6
BUS- 5
MAINTEST 4
BUSLG 3
2
BUSR+ 9
RCAVR 6
RCAVL 5
RCAGND 4
WIRED 3
WIREDAD 2
GNDD 1
P : AVH-P3200BT/XNUC
Q : AVH-P3250BT/XNRD JA2503
YKS5001-E
JA2504
CKS3414-A

J : AVH-P3200DVD/XNUC
K : AVH-P3250DVD/XNRC
B
L : AVH-P3250DVD/XNRD
M : AVH-P3250DVD/XNRI

40
39
38
37
36
REARMUTE

WIREDAD
RCAVR
WIRED
RCAVL
S/PDIF
POWER SUPPLY
OUT

16
15
14
13
12
11
10
9

1
2
3
4
5
8
7
6
5
4
3
2
1
1
2
3

BGSENS

BREM
GND
ACC

MUTE
BUP

RR+
FR+
PB
RL+
1

RR-
FL+
CPRDY

ILM

FR-
JA581

RL-
FL-
2 CPRST CKN1042-A
3 SDA
4 For Q,K,L,M, JA101
SCL CKM1376-A
5 GNDD
6 IECOUT

C D 7
8
9
10
GNDD
D+
D-
WAKEUP
C 11 VIDEO_GND
CN1901

12 COMPOSIT
DVD 13 AGND
CKS3871-A
CN751
MECHANISM 14
15
ANALOG_LOUT
AGND
MODULE
A 1/6
16 ANALOG_ROUT
17 AGND
18 STANBY
19 SLVSTS

A 2/6
20 HSTCMD
21 IRQPWR
22 XRESET
23 AMUTE
24
25
26
27
VD5
PGND
PGND
PGND
A 3/6
28
29
30
VD8
VD8
VD8
A 4/6
G SD PCB
A 5/6
GND4 18
NC1 15
WP 14

13

17
12

1 1 BT_MIC1P
11 2 2 SYS+B
D
A 6/6
GND3
CD/WP

CD

GND2
8 3 3 BT_MIC1N
DAT1
7 4 4 BT_RST
DAT0
5 5 BT_SPK1P
CN7501

6
CKS6180-A

VSS2
5 6 6 BT33
CLK
7 7 BT_SPK1N
SD CARD VDD
4
3 8 8 S_BTTX
9850S-22C-TR

VSS1
9 9 GNDBT
CN795

2
CMD
1 10 10 BT_SRX
CN7502

CD/DAT3
CKS4670-A

9 11 11 SDDAT0
20 GND6

19 GND5

DAT2
NC2

10 12 12 SDDAT1
GND1
13 13 VCC33
CN541
16

14 14 SDCMD
NRST_CPU

CKS3861-A
VCC_MIC

15 15 SDW
U3OUT

U1OUT
MIC1N

USB-+ 10
MIC1P

16 16 SDDAT3
LEDB1 1
19 VCC33LEDG1 2
LEDR1 3
HDRESET 4
16 GNDKEYKDT1 5
KDT0 6
7
USBGND 8
USB- 9
VSS

AUXL USB5V

17 17 SDDET
AUXAGND

12 AUXVGND

18 18 SDDAT2
5 10
4 11
3 12
2 13
1 14

CN7503
ILMGND
7 8
6 9

BT MODULE 19 19 GND
AUXV
AUXR
REM
ILMB

CKS6192-A
20 20 DGND
NBOOTS

SPK1N
SPK1P
VSS

BT33
U3IN

U1IN

SDCLK
20

18
17

15
14
13

11

21 21
22 22 DGND
1
2
3
4
5
6
7

CKS3861-A
CN3501
20
19
18
17
16
6 AUXAGND 15
7 AUXL KDT0 14
13
12
11

PWRVI
PWRVI
PWRVI

E
GNDD
GNDD
GNDD

2 1 CN3811
USBGND
HARDRST

USB+
LEDG1

USB5V
LEDR1

USB-
LEDB1

KDT1

NC

CKS5749-A

E
8 AUXVGND

3
4 GNDKEY

10 ILMGND
1 VCC33

5 AUXR

9 AUXV
3 ILMB

50
49
48
47
46
45
44
2 REM

H KEYBOARD CN3502 JA3501


BT ANT PCB PCB YKS5032-A CKN1078-A
AUXR
1 S AUXV
AUXL
USBGND
USBGND

R2 GND
USB5V
USDM
USDP

4 R1
3T
2
1
2
3
4
5

AUX INPUT

USB
CN5101
CKS5561-A
PLYV
PLYV
PLXV
PLXV
ADVX
ADVX
ADVY
ADVY

40 GND
NC

10 NC

F
1
2
3
4
5
6
7
8
9

TOUCH PANEL

AVH-P3200BT/XNUC
24
1 2 3 4
5 PLXV 2
FR-
6 ADVX 1
7 ADVX BUSL- 11

S5561-A
N5101
8 ADVY BUSR- 10
9 ADVY BUSR+ 9
PWRVI

H PANEL
10 NC 50 1 ASENBO 8
PWRVI
49 2 BUSL+ 7
PWRVI RCAVL
48 3 1 40 BUSRG 6
NC REARMUTE

IP BUS
47 4 2 39 BUS- 5
GNDD RCAVR
46 5 3 38 MAINTEST 4

CKS3414-A
JA2504
GNDD WIRED
45 6 4 37 BUSLG 3
GNDD WIREDAD
40 GND 44 7 5 36 BUSG 2
PWGR BUZZ
39 DCLK 43 8 6 35 BUS+ 1
ADVY GNDD
38 GND 42 9 7 34
ADVX BUS-
37 B0 41 10 8 33
PLXV BUS+
36 B1 40 11 9 32
PLYV ASENBO
35 B2 39 12 10 31
371_ILMR BUSR+
34 B3 38 13 11 30
371_ILMG BUSR-

B
33 B4 37 14 12 29
5

BTMICIN

5
371_ILMB GND
32 B5 36 15 13 28 NC 2
GNDD BUSL+ 3 BT MIC
GND BTMICG 1
31 35 16 14 27
BUSL-

JA2502
GNDD

CKN1018-A
30 G0 34 17 15 26
VCC33 NC
29 G1 33 18 16 25
371_REM BTMICIN
28 G2 32 19 17 24
371_KEY1 BTMICGND
27 G3 31 20 18 23
371_KEY0 NC
26 G4 30 21 19 22
GNDILM NC
25 G5 29 22 20 21 GNDD 26
NC NC
24 GND 28 23 21 20 NAVI_TO_SYS 25
ILM+B NC
23 R0 27 24 22 19 SYS_TO_NAVI 24

CKS6062-A

CKS6051-A
CN521
CN2501
371_RESET GNDA
22 R1 26 25 23 18 VSW5 23
D_to_G NAVITOSYS
21 R2 25 26 24 17 MONON 22

A 4/6 MOTHER UNIT(DV5U)


G_to_D SYSTONAVI
20 24 27 25 16 GION 21

CN511
R3

DKN1385-A
A 1/6 MOTHER UNIT(AUDIO)

CN5002
DKN1385-A
DGCLK GUIDEON

LCD MODULE
19 R4 23 28 26 15 TVON 20

A 6/6 MOTHER UNIT(TUNER)

CKS6062-A
CN5601
S_to_G TVON
18 R5 22 29 27 14 DSEN 19

A 2/6 MOTHER UNIT(SYSTEM)


G_to_S ONSEI-
INTERFACE PCB
17 GND 21 30 28 13 CCREM 18
GRST ONSEI+
16 SHUT 20 31 29 12 GNDRAU 17
GNDV GNDSIG
15 GND 19 32 30 11 REAUL 16

A 5/6 MOTHER UNIT(IN/OUT PUT)


N_G CSYNC
14 HSYNC 18 33 31 10 REAUR 15
N_R GNDSIG
13 VSYNC 17 34 32 9 ONSEI- 14
N_CSYNC ANB
12 TEST 16 35 33 8 ONSEI+ 13
N_B GNDSIG
11 TEST 15 36 34 7 GNDAU 12

A 3/6 MOTHER UNIT(POWER SUPPLY)


GNDV ANG
CKS4497-A

10 TEST 14 37 35 6

F 1/2 MONITOR PCB(GERDA)


CN2502

GNDSIG CCAUR 11
9 13 MONVBS 38 5
NC 36
NAVI INTERFACE

GNDBL ANR CCAUL 10


8 VCC 12 39 37 4 NC
9
GNDD

6
6

7 VCC 11 GNDBL 40 3 8
38 YS
GNDBL BCAMIN
6 VCC 10 41 39 2 7

F 2/2 MONITOR PCB(BACKLIGHT)


NC BCAMGND GNDDVD
5 VCC 9 42 40 1 6
PWRBL DVDVBS
4 NC 8 43 5
PWRBL GNDSIG
3 GND 7 44 4
PWRBL CCSYNC
2 GND 6 45 3
BLERR1 CCB
1 GND 5 46 2
BLSYNC CCG
4 47 VCR_RG 1 1
MBLPW CCR
3 48 VCR_RIN 2
2 DIMMER 49 VOUT_G 3
1 TEMPSEN1 50 VOUT 4
VCR_LG 5
JA561

1 LED4 VCR_LIN 6
CKB1085-A
RCA V IN OUT

2 LED3 VCR_VG 7 B.CAM_IN 2


3 LED2 VCR_VIN 8 BCAM INPUT
BCV_GND
4 LED1 1
NC
CKB1065-A

5
JA2501

6 BLP
7 BLP

CKS5561-A
CN5701
8 NC GND 10

BACK LIGHT
9 TEMP1 GND 9
10 GNDD GND 8

AVH-P3200BT/XNUC
GND 7
FRONT_L 6
FRONT_R 5
JA562

7
7

XKB7001-B

SW_L 4
REAR OUT
FRONT OUT

SW_R 3
REAR_L 2
REAR_R 1

3
1 2
ANT

JA402
CKX1070-A
FM/AM
8

8
25
E
A

D
C

F
B
1 2 3 4

A
A MOTHER UNIT (1/2)
CN751
VD5 SPDIFSENS
24 VD5
28
I
VD8
VD8 1
5 K L M Q ONLY
30 4 Q581 SPDIFOUT
IECOUT SPDIF 2
6
IC581 TC7SET08FUS1
ANALOG_LOUT LS_L
14

BUSL+ 11
Q751 Q752 IN4L+
SYS+B BUSL- 12
IN4L-
AV_LOUT 8
IN2L
BT_TEL 9
IN3L
ONSEI+ 14
C CN1901
STANBY STNBY ONSEI- 15
IN5L
18 IN5G
B 19
LS1−>SRX MS_SRX
18
S−>LS1TX S_MSTX MICIN
20
IRQPWR IRQPW
21
XRESET XRST
22
AMUTE AMUTE
23
STNBY 90

COMPOSIT MS-SRX 44
12 AV SELECTOR S-MSTX 43
IC251
IRQPW 111
BH7649KS2
XRST 110
LS-L 2
LIN1 AMUTE 112
LS-V 39
JA561 VIN1
14 Q361 Q363
VCR_LIN VCR_L 162
6 LIN4
RCA VCR_VIN VCR_V 45
8 VIN4
V IN/OUT VOUT RCA_V 28
4 VOUT2 105

C TO 2/2
IC7551 NJM4558V CN795(1/2) P Q ONLY 2
SOC_L 6
LIN2 22
Q362 Q364
163
2 1 BT_SPKIP LOUT1
5 5
TUN_L 18
BT BT_MICIP 1EQ_2BT
1 1 1 LIN5
MODULE BT_MICIN BTGND
CN7503 CN7502(1/2)
3 3 TO 2/2
Q365
G SD PCB (1/2) AUX_AGND 11
ARET3

B INTERFACE PCB CN2501


RCAVL
CN521 AUX_L

RCA_VL
10

24
LIN3
Q366
40 1 LOUT2 37 AVSCL 68
AUX_V 43 SCL
JA2501 VIN3 36 AVSDA 67
2 B.CAMIN BCAMIN BCAMIN 49 SDA
2 39 VIN6 MONVBS
35
B.CAMERA VOUT1
INPUT 1 BCV_GND VDIN1
34

D AUX_V
CN2502
ONSEI+ ONSEI+ ONSEI+
13 12 29 AUX_L 3 TO 2/2
ONSEI- ONSEI- ONSEI- AUX_R
14 13 28
NC Q601
9 29
TVON TVON TVON
20 14 27
NAVI I/F CCSYNC CSYNC CSYNC
4
CCR ANR
10 31
ANR
P Q ONLY
1 4 37
CCG ANG ANG
2 6 35
CCB ANB ANB
3 8 33

2 BTMICIN BTMICIN
24 17
BT 3
MIC 1
P Q ONLY
BTMICGND AUX_AGND
23 18
JA2502

BZ2501 BZ BZ 34
35 6
E JA2504 BUZZER
Q331
ASENBO ASENBO ASENBO ASENBO 35
8 31 10 BUP_1

BUSL+ BUSL+ BUSL+


7 27 14 ASENBO S_to_IP 36

BUSL- IP_to_S 37
BUSL- BUSL-
11 26 15
IP BUS WIREDAD 161
BUS+ 1 S_to_IP
BUS+ BUS+ 6 WIRED 160
1 32 9 BUS+ DIN1
IC331
BUS- BUS- BUS- 5 HA12241FP 2 IP_to_S
5 33 8 BUS- ROUT 128
IP-BUS DRIVER
6 Q2501(1/2) Q164 REAR
REAR 5 REARMUTE REARMUTE REARMUTE2 MUTE1
AUDIO 39 2
3
OUT 4 2
JA2503
3 WIRED WIRED WIRED
37 4
WIRED 2 WIREDAD WIREDAD WIREDAD
36 5
REMOTE 1 GNDD
F

AVH-P3200BT/XNUC
26
1 2 3 4
5 6 7 8

JA581
SPDIFSENS 3
SPDIFOUT 2
S/PDIF OUT
GND 1

61 RCA_FL RCA MUTE FRONT_L


Front_L 6

USL+ 11
IN4L+
E.VOL CAMELEON 60 RCA_RL Q561
USL- 12 IC201 Rear_L (1/2) FRONT OUT
IN4L-
PML020A Q562 REAR OUT
AV_LOUT 8 REAR_L
IN2L (1/2) 2
BT_TEL 9 59 RCA_SWL SW_L
IN3L Pre/SW_L 4
ONSEI+ 14
IN5L JA562
ONSEI- 15 31 EVDATA Q561
IN5G DATA
(2/2)
18 30 EVCLK Q162 Q161
B
CLK
MICIN
32 EVSTB BUP_1
STB

Q163
AMP
IC151
TNBY 90 101 EVDATA PA2030A
STB EVSDA
MS-SRX 44 PA_FL 11 JA101
RXLS1 102 EVCLK FLIN
EVSCK 9 FL+
-MSTX 43 PA_RL 15 FL+ 7
TXLS1 103 EVSTB RLIN
RQPW 111 EVSEL Q155 7 FL-
IRQPW 4 FL- 5
RST 110 SYS+B STBY
XRST 17 RL+
RL+ 8
MUTE 112
AMUTE 19 RL-
131 RL- 6
AMPPW
61 Q363 Q153
162
MICSENL
(1/2) AMPMUTE 25 B.REM 11
B.REMOTE
129 22
AMPMUTE MUTE
105 D153
AEQAUXSW
OFFMUTE B.UP
Q154 BUP_1 16
Q153
(2/2) C
62 Q364 BUP_1
163
MICSENR

21 Q122(1/2) ASENS ACC 14


ASENS
SYSTEM UCOM POWER
Q122(2/2)
Q365 IC602(1/2) BSENS CONNECTOR
20
BSENS BUP_1
P J Q125
PE5725A8

Q366
K L M Q Q123(1/2)
PBSENS
PE5727A8 PBSENS
146 P.B. 9
68
AVSCK
67 Q123(2/2)
AVSDATA TELMUTE
145 MUTE
TELMUTE 10

Q121
ISENS
148 ILM
ISENS 12
D
Q124
BGSENS
147 BGSENS
BGSENS 13

Q601 29
RGBRI CN511
Q982 (1/2)
150 PNLXV PLXV
PNLXV 11

Q983
151 PNLYV PLYV
PNLYV 12

Q981
ADVX
10

152 PNLVD
PNLVD ADVY
9
172
PNLADX
171
PNLADY
34
BEEP
TXMON
98 S_to_G S_to_G
29 E
ASENBO 35 97 G_to_S G_to_S
ASENBO RXMON 30

MONIRST
99 GRST GRST
31
F CN5002
S_to_IP 36
TXIE PWRVI 1
IP_to_S PWRVI I
37 3
RXIE
WIREDAD 161
WIREDAD
J : AVH-P3200DVD/XNUC RGB VIDEO ISOLATOR
VCC33
VCC33
18

WIRED 160
WIRED K : AVH-P3250DVD/XNRC IC301 ILMB
ILM+B
24
NJM2138V PWRBL 43
L : AVH-P3250DVD/XNRD PWRBL I
45
128
REARMUTE M : AVH-P3250DVD/XNRI CSYNC 10 8 N_CSYNC
35
REAR
MUTE1
P : AVH-P3200BT/XNUC ANR 5 7 N_R
34

2 Q : AVH-P3250BT/XNRD ANG 3 1 N_G


33
ANB 12 14 N_B
36

MONVBS
38 1 F
2 TO 2/2
3

AVH-P3200BT/XNUC
5 6 7 8
27
1 2 3 4

A
A MOTHER UNIT (2/2)

7 REMIN
REMIN Q1002 Q1001
16 RESET VDD33V
RESET VDD33
174 KDT1 IC1001
KDT1
175 KDT0 S-812C33AUA-C2N
KDT0
53 ILMLD 2 3
ILMLD VIN VOUT
55 ILMCK
ILMCK SYS+B
ILMDT
54 ILMDT IC1201
NJM2388F84
VDCNT5
1 2
BUP_1 VIN VOUT SYS+B
JA402 CONTROL
1 ADAC
ANTENNA 4
IC941
130 SYSPW
2,3 SYSPW PCM1753DBQ
TUN3.3V
IC1741
B S-1132B33-U5
1 1
AM_ANT 5 BCK
1 VCC5 VIN VOUT TUN33V 2
FM_ANT SW DATA
3 3
4 LRCK
Lch TUN_L SYSPW
23 1 TO 1/2 SOC_L 7
SL 168 TO 1/2 2 VOUTL
MD
13
5 TUNSL 14
CE2 86 MC
6 TUNPCE2 Q942 15
CE1 85 HIOUT12V Q1621 ML
8 TUNPCE (1/2)
CK 89 DD8 EV12
FM/AM TUNER UNIT

9 TUNPCK Q1622
DI 88 Q1623 3
10 TUNPDO Vcc IC1621 5
DO 87 66 7 Out SYS+B
14 TUNPDI HIOUTCLK OSC TK11840L Q941
(1/2)
U402

IC1771 SOAMU
Q941
NJM2855DL1-33
VCC (2/2)
4 SYS+B 1 3
VIN VOUT VCC33
ROM_VDD
13 VDD33
VDD_3.3
IC1791
C 17 TUN33V PQ012GN01Z
1 3
Q403 (1/2) VIN VOUT VCC12
RDS_HSLK HSLK 126 X
21 RDS57K
25
Q403 (2/2)
IC1781 P Q ONLY
S-1132B33-U5
RDS_LOCK RDSLK 127
20 RDSLK 5 1
VIN VOUT BT33
Q404 (1/2)
RDS_DATA RDT 125 P1721
19 RDT

Q404 (2/2) D/D CONVERTER SDRAM (64M)


RDS_CK RCK 96 IC1501 IC901
18 RCK BD9017KV K4S641632N-LC75
13 P1711
SW1 VD5
P ONLY Q1501 DD5
P1731
113 VDCNT5 26 12 PWRVI FLASH (16M)
VD5 EN1 OUTH1 IC921 A[0-9]
D 114 VDCNT8 27 D[0-15]
VD6 EN2 CWW2021
92 34
DDCCLK SYNC
15
OUTL1
21
FLASH (16M)
FB1 IC922 A[0-9]
22 D[0-15]
COMP1 CWW2020
SYSTEM UCOM P1501 7
IC602 (2/2) BUP_1 VCC P1611
48
8 SW2 VD8
P J 5
VCCCL1
VCCCL2 Q1502 DD8
PE5725A8 10
CL1
K L M Q 3
CL2 OUTH2
1 P1651 LATCH
A[0-9]
IC923
PE5727A8 41 D[0-15]
EXTVCC ILMB TC74LCX16373FT
PWRBL 1LE 2LE
46
OUTL2 4 25

FB2
39 IC1221 IC924
38 S-1200B50-M5 TC7SZ08FU
COMP2
1 5 4 2
INA
E VIN VOUT AVCC5 OUTY
1
INB
14
X1
X601
15 3.93216 MHz
X2

CN511
(2/2)
G_to_D
27
F 26
D_to_G
CN5002 DGCLK
28

F 1
2 TO 1/2
3

AVH-P3200BT/XNUC
28
1 2 3 4
5 6 7 8

E KEYBOARD PCB
A

VDCNT5
IC3501
RESET CN541 CN3501 GP1UXC14RK
IC601 REMIN REM REM 1
S-80827CNNB-B8M 19 2 REMOTE
VCC33 VCC33 3 SENSOR
2 1 VCC33 20 1
VDD33 VDD OUT S3501 RESET
RESET HDRESET RST
4 17

KDT1 KDT1 KDT1 S3506


5 16
SOC KDT0 KDT0 S3502 SOURCE
KDT0
IC801 Q951 6 15
EJECT S3507
ADAC MN2DS0018MAUB (1/2) FORWARD
IC941 S3503
61
P14 VCC33 DISP. OFF S3508
PCM1753DBQ
S3504 REVERSE
VOL+ S3509
Q951 S3505 MODE B
1 149 (2/2) VOL- S3510
BCK SRCK
2 151 MENU
DATA ADOUT
3 150 5
LRCK LRCK
4 VCC IC341 D3508
7 CPRST
VOUTL 13 SDODAC 63 nRESET BH2227AFV
MD SDODAC Q3501 (1/2)
14 SCKDAC 64
MC SCKDAC 46 CPDT 13 ILMLD 10 1 LEDR1 LEDR1
15 LTDAC 62 USBPN I2C_SDA CSB AO1 3 18 ILMB
ML LTDAC

47 CPCK 12 Q3501 (2/2)


CPRST I2C_SCL
ILMCK 11 2 LEDG1 19 LEDG1
CLK AO2 2
IC951
341S2162 Q3502
SOAMUTE 71 iPod CP ILMDT 12 5 LEDB1 LEDB1
FG DI AO3 1 20
IC802
TC7SZU04FU
50 4 2
USB_CLOCK OUT_Y IN_A
3 C
155
OSCI X802
X801
1
25 MHz
OSCO
156
IC542 CN3502
TC7MBL6126SFK USB5V
1
144 USB_D- 2 12 L541 USDM
USB-
LOUT A1 B1 9 12 2 USB
146 USB_D+ 3 11 USB+ USDP
SDRAM (64M) MDQ[0-15]
ROUT A2 B2 10 11 3
IC901 MA[0-11]
K4S641632N-LC75
IC541
R5523N001B
60 USBCNT 1
P13 EN 5 USB5V
16M) VOUT 7 14
A[0-9] A[0-9] 65 USBFLG 3
1 USBLMIT FLG
D[0-15] D[0-15] D
021

16M) P Q ONLY JA3501


2 A[0-9]
D[0-15] AUXL
020 AUXL 14 7
TO 1/2 AUXR AUX
AUXR 16 5
3
AUXV
AUXV 12 9

A[0-9]
D[0-15]
373FT
J : AVH-P3200DVD/XNUC
IC924
K : AVH-P3250DVD/XNRC
TC7SZ08FU L : AVH-P3250DVD/XNRD
4
OUTY
INA
2 XCSF1 59
XCSSR M : AVH-P3250DVD/XNRI E
INB
1 XCSF2 213
NEXCE P : AVH-P3200BT/XNUC
Q : AVH-P3250BT/XNRD G SD PCB (2/2)
CN795 CN7502
(2/2) (2/2) CN7501
2 SDDT0
EXDT9 11 11
1 SDDT1
EXDT1 12 12
8 SDDT2 SD
EXDT11 18 18
7 SDDT3 CARD
EXDT3 16 16
G_to_D 53
CMDCOMN
D_to_G 54
STSCOMN
DGCLK 55 12EJ

AVH-P3200BT/XNUC
5 6 7 8
29
1 2 3 4

A
C DVD CORE UNIT

NRES

VIDEO+
IC1
MN2DS0
70
NRES

B
FLASH 16M

D0-15
IC1401
CWW2267 A0-19
26 XCFS1 59
CE XCSSR

IC1402
CWW2268
26 XCFS2 213
CE NEXCE

11 XWR1 31
WE NEXWE

NRES 12 28 XRD 214


RESET OE NEXOE
C

SDRAM
IC1480
K4S641632N-LC75
MA0-11

MDQ0-15

15 DQM0 179
LDQM DQM0
39 DQM1 180
UDQM DQM1
20 193
BA0 BA0
21 197
BA1 BA1
16 XWE 181
WE NWE
17 XCAS 188
CAS NCAS
18 XRAS 189
RAS NRAS
19 XCSM 190
CS NCSM
D CLK
38 MCK 183
MCK
185
MCKI

D CONNECT PCB MOTOR DRIVER


IC1201
LS1 MECHA UNIT CN701 CN1201 BD8231EFV
BR CRG- CRG/LE- 32 1 VHALF 110
LOADING/CARRIAGE 1 18 SL/LDO- VC VHALF
M GY CRG+ CRG/LE+ 31 2 TD 126
MOTOR 2 17 SL/LDO+ TKIN TD
3 FD 127
FCIN FD
SPINDLE MOTOR SLIN
4 CRGDRV 67
CRGDRV
CN101 5
SLOPOUT
V V COIL V 10 COIL_V 27 6 62
1 1 9 V LDIN LDIN
U U COIL U 11 COIL_U 26 7 MD 66
2 2 8 U SPIN MD
W W COIL W 12 COIL_W 28 8 CONT1 63
3 3 7 W CTL1 CONT1
9 CONT2 64
CTL2 CONT2
HUP(HU+),HUM(HU-) HUP(HU+),HUM(HU-) 12 71
H1 FG FG

E FCO+ 33 FOP

H2 HVP(HV+),HVM(HV-) HVP(HV+),HVM(HV-) FCO-


34 FOM
36 TOP
TKO-
35 TOM
TKO+
HWP(HW+),HWM(HW-) HWP(HW+),HWM(HW-)
H3 HALL_BIAS-
H- 4 4 H- HALL BIAS- 3 14
16 HB
H+ H+ HALL BIAS+ HALL_BIAS+
10 10 13 6 VCC5
HOME
S101
HOME HOME 65
16 3 HOME
8cm
S102
8SNS 8cm 49
15 4 08EJ
12cm
S103
DSCSNS 12cm(DSCSNS) 55
14 5 12EJ

AVH-P3200BT/XNUC
30
1 2 3 4
5 6 7 8

CN1901
NRES XRESET
9

VIDEO+AUDIO
IC1501 AUDIO 2CH ANALOG OUT
MN2DS0018MAUB IC1801
PCM1753DBQ
70 LOUT
NRES 149 SRCK 1 7 ANALOG LOUT
SRCK BCK VOUTL 17
151 ADOUT 2
ADOUT DATA
150 LRCK 3
LRCK LRCK
57 SDODAC 13 ISC_SCL SCL
SDODAC
58 SCKDAC 14
MD 27 B
SCKDAC MC I2C_SDA SDA
28
56 LTDAC 15 CP_Reset RESET
LTDAC ML 29
148 DACCK 16 IFCOUT
DACCK SCK 25
D+
D-
23 A CN751
22
COMPOSITE COMPOSIT
19
STANDBY STANBY 13
59
XCSSR STSCOMN SLVSTS 12
CMDCOMN HSTCMD
11
IRQPWR
10
AMUTE
8
VD5
VCC5 REG. VDD5 7
213
NEXCE 47
IC1002 1
VD8
I2C_SCL
46
S-1133850-U5 2
31 I2C_SDA 4 VD8
NEXWE 61 5 VIN 3
CP_Reset VCC5 VOUT 3
152 ON/OFF
214 IECOUT
NEXOE 146 D+
ROUT
LOUT
144 D-
AVCC5 REG. C
138 IC1003
COMPOSITE
STANDBY
191 S-1200B50-M5
54 1
STSCOMN 5 VIN
53 AVCC5 VOUT 3
CMDCOMN ON/OFF
48
IRQPWR
75 AMUTE
EXTRG1

81
TRCST
80
TRCDATA3
79
TRCDATA2
179 78
DQM0 TRCDATA1
180 77
DQM1 TRCDATA0
193 76
BA0 TRCCLK
197 74
BA1 EXTRG0 CN1951
181 73
NWE SDATA
188 72 TRCST
NCAS SCLOCK 1
189 TRCDATA3
NRAS 2
190 TRCDATA2
NCSM 3
TRCDATA1
183
MCK 3.3V REG. 4 D
185 TRCDATA0
MCKI IC1004 5
112 TRCCLK
F+H_G+H NJM2885DL1-33 6
111 EXTRG0 DEBUG
E+G_E+F 7
106 3 1 SDATA
LPCO2 VCC33 OUT IN VDD5 8
104 SCLOCK
LPCO1 9
100 B
VIN3RF
99 A 1.2V REG. VCC33 12
VIN4RF
98 C IC1005 13
110 VIN2RF
VHALF 97 D R1232D121B
126 VIN1RF
TD 115 FE1 2
127 VIN7 8 VDD5
FD 116 FE2 VCC12 LX VIN
3 CN1101
67 VIN8 VDD
CRGDRV 105 5 4 Vref
CDMPD VOUT CE VREF 2
103 VCC
62 DVDMPD VCC5 3
LDIN 122
66 TEMP
MD 96 RF F+H_G+H F+H/G+H
63 RFINP 4
CONT1 E+G_E+F E+G/E+F
64 5
CONT2 Q1102 Q1104
71 109
FG VREFH VREF LPCO2 78LD
120 7
VIN1
VIN2
119
Q1101 Q1103
E
118
VIN4 LPCO1 65LD
117 8
VIN3
114
VIN6 B
113 10
VIN5 A
11
C 12
156 D
PU (DP10)
OSCO 13
FE1
X1501 14
65 FE2
HOME 27 MHz 15
155 CDMPD 78MD
OSCI 17
49 DVDMPD 65MD 18
08EJ
121 TEMP 20
VDSENS RF
55 22
12EJ

FOP F+
25
FOM F- 24
TOP T+ 23
TOM T-
26
F

AVH-P3200BT/XNUC
5 6 7 8
31
1 2 3 4

A
F MONITOR PCB
3.4V to 1.2V
IC5201
CN5101 PQ1LA125MSPQ
5V to 3.4V
5 4
ADVY GD12V VOUT VIN GD33V IC5202
9
ADVY
S-1172B34-E6
8
ADVX 1 6
7 V33A VOUT VIN PWRVI 41
DV0R5
ADVX
38
TOUCH 6
PLXV
GERDA-L DV0R4
PANEL 5
IC5502 142
PLXV SDATA
4 145
PLYV MN103SH13UB SCLOCK
3
PLYV
2 34 - 37 TRC
DV0R0-3

CN5002 EEPROM
PLYV IC5501
39 S-93C66BD0I-I8
B 40
PLXV
4 67 114 - 119
ADVX DO GPI015 LCD0R0-5 LR[0
41 3 68
DI GPI014
ADVY 2 69
42 SK GPI013
IC5311 IC5312 1 70 108 - 113
CS GPI012 LG[0
LCD0G0-5
TC75S57FU TC7SET08FUS1
3 4 2 4 43
16 CSYNC IN+ OUT INA OUTY DV0VSY
99,100,102 - 105
LCD0B0-5
LB[0
Q5806
ANA_R 63 88
17 AV2IN LCD0CLK
87
GPIO9
Q5807 92
LCD0C1
ANA_G 50 93
18 AV0INA LCD0C0

Q5805
ANA_B 57 64M F
15 AV1IN I
IC5301 CW
C NJM2505AF Q5808
MONVBS 4 1 52 FDA[0-21]
13 VIN VOUT AV0INB

133
FDATA[0-15]
GRST GRST
20 NRST
G_to_S
A 21
S_to_G
G_to_S 72
GPIO11 NPRWE
122 11
WE
CN511 22 73 125 26
S_to_G NPRCS0 CE
DGCLK GPIO10
23 123 28
DGCLK 77 NPROE OE
G_to_D GPIO2
24
G_to_D 75
D_to_G GPIO1
25
D_to_G 74
GPIO0
RGBVI IC5503
48 PWRVI TC7SHU04FUS1
PWRVI
135 4 2
50
LCDICLK OUTY INA
VCC33
33 VCC33
ILMB
27 ILMB
D
6 3 1
PWRBL
PWRBL
8 89
OSCXO
X5502
1
MBLPW
9.597 MHz
3 X5501
BLERR1 33 MHz
5 90
3 OSCXI
BLCLK
4
DIMPLS
2
TEMP1
1

MBLPW

E BLERR1

IC5702
TC7SET08FUS1
BLCLK 2 4 8
INA OUTY

Q5705 10
DIMPLS

TEMP1

AVH-P3200BT/XNUC
32
1 2 3 4
5 6 7 8

CN5501
GD33V
GD33V 1

2
GRST1
4
TRCST
5 GERDA
TRCCLK
6
REWRITE
SDATA
8
SCLOCK
9

11
TRCD[0-3]
14
LCD PANEL
CN5601
B
18
LR[0-5]
23

25
LG[0-5]
30

32
LB[0-5]
37
LCD
DCLK
39
SHUT
16
HSYNC
14
VSYNC
13
VCC 5
GD33V
8
64M FLASH ROM
IC5703
CWW2019 C
DA[0-21]
37
VCC GD33V

DATA[0-15]

11
WE
26
CE
28
OE

IC5503
TC7SHU04FUS1
4 2
OUTY INA

D
3 1
X5502
9.597 MHz

CN5701
Q5703
Q5701 6

7 E
Q5702

IC5702 3 1
C7SET08FUS1 FAULT SW
15 LED4
LCD BACKLIGHT
2 4 8 LED4 1
INA OUTY CLKI
17 LED3
LED3 2
18 LED2
LED2 3
Q5705 10 19 LED1
DIM LED1 4

IC5701
TK61222CQ6
TEMP1
9

AVH-P3200BT/XNUC
5 6 7 8
33
1 2 3 4

5. DIAGNOSIS
5.1 OPERATIONAL FLOWCHART
A

RESET

VDD : Pin11
VDD = 3.3 V?

/BSENS : Pin20
/BSENS = L?
B Y
/ASENS : Pin21
/ASENS = L?

/STB : Pin90
/STB = H?

/SOCSTB : Pin91 /SOCSTB = H?


C
Y
Standby

ASENBO : Pin35 ASENBO <- H

DDCCLK : Pin92 DDCCLK <- Clock Out


(Frequency of 370 kHz)

D VD5 <- H
VD5, 8 : Pin113, 114
VD8 <- H

Starts
Communication
with Display microcomputor

Source Keys operartive


E
Source ON

SYSPW : Pin130 SYSPW <- H

AVH-P3200BT/XNUC
34
1 2 3 4
5 6 7 8

5.2 INSPECTION METHOD OF PICKUP UNIT

Disc to be used
A
CD-DA: TCD-782
DVD-Video: TDV-582

Execution method
START Replace the PICK UP

LD turned on? Check parts SKEW ADJ.


B
No
Yes
Check point:
Check point: RF level check
LD current check AS MAX check
LD current check

Is it OK? Replace the PICK UP Is it OK?


No No
Yes Check point: Yes
Error rate check
Error rate check

Is it OK?
No
Check point:
RF level check Yes
AS MAX check

PICK UP Perform lens


Is it OK?
cleaned? cleaning
No No
Yes Yes

Replace the PICK UP D


Check point:
Error rate check
Error rate check

PICK UP Perform lens


Is it OK?
cleaned? cleaning
No No
Yes Yes

Replace the PICK UP

E
Ckeck parts
Finished
other than PICK UP

AVH-P3200BT/XNUC
5 6 7 8
35
1 2 3 4

LD current check

A Check
Status: [Foucs closed] of TEST MODE

NO. Disc Check Point Threshold Remarks: LD current


1 GGV1025 DVDLD1-VCC5_3 60 - 390 (mV) 10 - 65 (mA)

Expansion
B

C
NO. Disc Check Point Threshold Remarks: LD current
2 TCD-782 CDLD1-VCC5_3 60 - 360 (mV) 10 - 60 (mA)

Expansion
D

Notes: Please pay attention to the laser diode damage by static electricity.

AVH-P3200BT/XNUC
36
1 2 3 4
5 6 7 8

ASMAX check
A
ASMAX value shows the value of RF level.
Status: [Foucs closed] of TEST MODE

No. Disc Check Point Threshold Remarks:


8 digits value of Only four last digits are
more than
1 GGV1025 ASMAX displayed according to
on display 0000 0B00 the product.
8 digits value of Only four last digits is
more than
2 TCD-782 ASMAX displayed according to
on display 0000 0C00 the product.

Test mode display will not appear on the display of this product. Connect the rear monitor output to a monitor. B

In this case, the value is displayed for a split second.


When you tried to perform [FOCS CLOSE],
the display will charge automatically in the following order.
[1FFF0000]->[FEMAX]->[FE MIN]->[AS MAX]->
[ENV MAX]->[FE normal]->[Spindle gain]->
[TEMAX]->[TEMIN] ->[20000000]
Watch carefully the value of ASMAX.

Error rate check


Status: [Tracking Closed] of TEST MODE

No. Disc Check Point Threshold Remarks:


less than
1 GGV1025 ID: 40000
1.000E-03 D
less than
2 GGV1025 ID: 200000
1.000E-03
less than
3 TCD-782 ID: HOME Position
2.500E-03

Test mode display will not appear on the display of this product. Connect the rear monitor output to a monitor.

AVH-P3200BT/XNUC
5 6 7 8
37
F
E
B
A

D
C

38
BACK END section flow Is VDD5(VCC33, VCC12)
START power supply voltage OK?
Execute check 2.

Can the NO Standby NO

1
1

playback OK?
start? Execute
check 1.
YES
YES YES

Does the NO NO NO NO
NO Is the image Is the sound Reset OK?
operation Is the iPod play Is the USB play
in error? in error? Execute check 3.
take time? in error? in error?

YES YES YES YES YES YES

Is AVCC5 NO Is the iPod Is AVCC5 Is SDRAM Is VSENS


NO NO NO NO NO NO
Is the life of flash voltage OK? circuit OK? Is 48 MHz OK? voltage OK? IF OK? OK?
memory OK? Execute check 8. Execute check 14. Execute check 13. Execute check 8. Execute check 6. Execute check 4.
Conduct check item 12.

YES YES YES YES YES YES


YES

2
2

NO Is the video Go to the Is DACCLK Is VD8, VCC5 Is 27 MHz


product check. NO NO NO
Go to FE circuit OK? power supply OK?
5.3 DIAGNOSIS FLOWCHART

NO Is the USB normal?


section check. Execute check 11. circuit OK? Execute check 9. voltage OK? Execute check 5.
Execute check 14. Execute check 7.

YES NO The product YES YES YES


is normal?(iPod YES
attestation IC) Is the audio Go to FE
NO section check. Replace the unit.
Replace the unit. circuit OK?
Execute check 10.
YES

Replace the unit. YES

AVH-P3200BT/XNUC
Product repair
Go to FE
section check.

3
3

Repair the
defective part.

Go to FE
section check.
NO Normal?

Is FE section NO Go to FE related
YES
normal? repair process.
END
YES

Replace the unit.

YES

4
4

Normal?

YES

END
5 6 7 8

Check 1: Standby OK?

<Check> Check the voltage at the “STANBY” test point while the power is on. A

Use the “DGND1” test point at the reference.

NO. Check point Module No. Specification value Unit


1 STANBY-DGND1 ALL VCC33 V- V
0.6 V or more

Side A

DGND1

STANBY
Fig 1.1: STANBY check point

AVH-P3200BT/XNUC
5 6 7 8
39
1 2 3 4

Check 2: Is VDD5 (VCC33, VCC12) power supply voltage OK?


IC1401 FLASH power supply (Data)
A
VDD5 VCC33 (= 3.3 V) IC1402 FLASH power supply (Program)
IC1004
IC1481 SDRAM power supply
3.3 V output regulator
IC1501 DV5U power supply

IC1005 VCC12 (= 1.2 V)


DC/DC converter IC1501 DV5U power supply
1.2 V output
Fig 2.1: Power supply configuration
<Check> Check the voltage at the “VDD5_1, VCC33_1 and VCC12_1” test point while the power is on.
Use the “DGND1” test point at the reference.
B

NO. Check point Module No. Specification value Unit


1 VDD5_1 - DGND1 ALL 5.0 ± 0.4 V
2 VCC33_1 - DGND1 ALL 3.3 ± 0.15 V
3 VCC12_1 - DGND1 ALL 1.2 ± 0.12 V

Side A

VCC33_1
VCC12_1

DGND1

VDD5_1

Fig 2.2: VDD5, VCC33, VCC12 voltage check points

AVH-P3200BT/XNUC
40
1 2 3 4
5 6 7 8

Check 3: Reset OK?


A

<Check> Check the voltage at the “XRES” test point while the power is on.
Use the “DGND1” test point at the reference.

NO. Check point Module No. Specification value Unit


1 XRES-DGND1 ALL VCC33 × V
0.7 or more

Side A

DGND1

NRES

Fig 3.1: RESET check point

AVH-P3200BT/XNUC
5 6 7 8
41
1 2 3 4

Check 4: Is VSENS OK?


CN1901
A HOST I/F
IC1501
VD8 R1004, VSENS DV5U
R1007

VDD5 IC1004 VCC33


Regulator

IC1005 VCC12
DC/DC
STANBY converter

B
XRES

Fig 4.1: Power supply configuration and VSENS

<Check> Check the voltage at the “VSENS” test point while the power is on.
Use the “DGND1” test point at the reference.

NO. Check point Module No. Specification value Unit


1 VSENS - DGND1 ALL 0.95 - 1.07 V
C
VD8 = 8.0 ± 0.4 V

Side A

D VSENS

DGND1

E
Fig 4.2: VSENS check point

AVH-P3200BT/XNUC
42
1 2 3 4
5 6 7 8

Check 5: 27 MHz Normal?


<Outline> Each clock is created inside the IC1501 using the 27 MHz master crystal oscillator (X1501).
A

IC1501

DVD-LSI
X1501 OSCO
27 MHz
crystal OSCI

B
VCC33 VCC12
Fig 5.1: Clock configuration

<Check method> Turn the power on, and check with DGND being the reference.
In case of NG, check the applicable line, periphery of IC1501,
soldering of the peripheral components and defective components.

NO. Check point Module No. Specification value Unit


27 MHz
2 IC1501 169pin ALL
± 50 ppm ppm
C

Specification
value

GND
Fig 5.2: Clock specification value

Side A D

IC1501 158pin

DGND1

Fig 5.3: 27 MHz check point

AVH-P3200BT/XNUC
5 6 7 8
43
1 2 3 4

Check 6: Is SDRAM I/F OK?

A <Outline> In order to secure the MPEG stream data as the buffer,


the capacity of communication I/F SDRAM between the LSI and the memory is 64Mbit.
Be careful as XCSM, XWE, XCAS and XRAS of IC1480 are called differently in IC1501,
namely NCSM, NWE, NCAS, NRAS.
IC MA0 - 11 IC1501
1480 MDQ0 - 15 DV5U
SDRAM MCK
XWE(NWE)
XCAS(NCAS)
XRAS(NRAS)
XCSM(NCSM)
DQM0
B
DQM1
BA0
BA1

Fig 6.1: SDRAM I/F

AVH-P3200BT/XNUC
44
1 2 3 4
5 6 7 8

<Check> Check the conductivity at “check point 1” and “check point 2” without power.
In case of NG, check the soldering and defective components throughout the
“output t input” of the applicable section.
A

NO. Signal name Check point 1 Check point 2 Specification value


1 MA0 IC1480 23pin IC1501 201pin 56 ohm ± 5 %
2 MA1 IC1480 24pin IC1501 203pin 56 ohm ± 5 %
3 MA2 IC1480 25pin IC1501 207pin 56 ohm ± 5 %
4 MA3 IC1480 29pin IC1501 209pin 56 ohm ± 5 %
5 MA4 IC1480 30pin IC1501 208pin 56 ohm ± 5 %
6 MA5 IC1480 31pin IC1501 206pin 56 ohm ± 5 %
7 MA6 IC1480 32pin IC1501 202pin 56 ohm ± 5 %
8 MA7 IC1480 33pin IC1501 200pin 56 ohm ± 5 %
9 MA8 IC1480 34pin IC1501 198pin 56 ohm ± 5 %
10 MA9 IC1480 33pin IC1501 194pin 56 ohm ± 5 % B
11 MA10 IC1480 22pin IC1501 199pin 56 ohm ± 5 %
12 MA11 IC1480 35pin IC1501 192pin 56 ohm ± 5 %
13 MDQ0 IC1480 2pin IC1501 160pin 56 ohm ± 5 %
14 MDQ1 IC1480 4pin IC1501 162pin 56 ohm ± 5 %
15 MDQ2 IC1480 5pin IC1501 164pin 56 ohm ± 5 %
16 MDQ3 IC1480 7pin IC1501 168pin 56 ohm ± 5 %
17 MDQ4 IC1480 8pin IC1501 170pin 56 ohm ± 5 %
18 MDQ5 IC1480 10pin IC1501 172pin 56 ohm ± 5 %
19 MDQ6 IC1480 11pin IC1501 176pin 56 ohm ± 5 %
20 MDQ7 IC1480 13pin IC1501 178pin 56 ohm ± 5 %
21 MDQ8 IC1480 42pin IC1501 177pin 56 ohm ± 5 %
C
22 MDQ9 IC1480 44pin IC1501 175pin 56 ohm ± 5 %
23 MDQ10 IC1480 45pin IC1501 171pin 56 ohm ± 5 %
24 MDQ11 IC1480 47pin IC1501 169pin 56 ohm ± 5 %
25 MDQ12 IC1480 48pin IC1501 167pin 56 ohm ± 5 %
26 MDQ13 IC1480 50pin IC1501 163pin 56 ohm ± 5 %
27 MDQ14 IC1480 51pin IC1501 161pin 56 ohm ± 5 %
28 MDQ15 IC1480 53pin IC1501 159pin 56 ohm ± 5 %
29 MCK IC1480 38pin IC1501 183pin 0.17 ohm or lower
30 XWE IC1480 16pin IC1501 181pin 56 ohm ± 5 %
31 XCAS IC1480 17pin IC1501 188pin 56 ohm ± 5 %
32 XRAS IC1480 18pin IC1501 189pin 56 ohm ± 5 %
33 XCSM IC1480 19pin IC1501 190pin 56 ohm ± 5 % D
34 DQM0 IC1480 15pin IC1501 179pin 56 ohm ± 5 %
35 DQM1 IC1480 39pin IC1501 180pin 56 ohm ± 5 %
36 BA0 IC1480 20pin IC1501 193pin 56 ohm ± 5 %
37 BA1 IC1480 21pin IC1501 197pin 56 ohm ± 5 %

AVH-P3200BT/XNUC
5 6 7 8
45
1 2 3 4

Side B

Check point 1 (IC1480)

Side A
C

Check point 2 (IC1501)


Fig 6.2: SDRAM I/F check point
E

AVH-P3200BT/XNUC
46
1 2 3 4
5 6 7 8

Check 7: Is VD8, VCC5 power supply voltage OK?

A
VD8_1 F.E. driver system

VD8_2 IC1002 VCC5 (= 5.0 V) Power supply


REG IC for PU
for VCC 5 V.

Fig 7.1: Power supply configuration

<Check> Check the voltage at the “VD8_1, VD and VCC5_1” test point while the power is on.
Use the “PGND3 and AGND1” test point at the reference. B

NO. Check point Module No. Specification value Unit


1 VD8_1 - PGND3 ALL 8.0 ± 0.4 V
2 VD - PGND3 ALL 8.0 ± 0.4 V
3 VCC5_1- AGND1 ALL 5.0 ± 0.1 V

Side A

AGND3
C

VCC5_1

PGND1

VD8_1 PGND3
VD

Fig 7.2: VD8, VCC5 voltage check points


E

AVH-P3200BT/XNUC
5 6 7 8
47
1 2 3 4

Check 8: Is AVCC5 voltage OK?

A IC1003
VD AVCC5 (= 5.0 V) IC1801
REG IC Audio-DAC
for AVCC 5 V.

Fig 8.1: Power supply configuration

<Check> Playback DVD-REF-A1 TITLE 1 and check the voltage at the stylus.
Check with PGND and GNDAU being the reference.

NO. Check point Module No. Specification value Unit


B 1 VD - PGND_3 ALL 8.0 ± 0.4 V
2 AVCC5 - GNDAU1 ALL 5.0 ± 0.1 V

Side A

AVCC5

VD PGND3 GNDAU1

Fig 8.2: VD8, AVCC5 voltage check points

AVH-P3200BT/XNUC
48
1 2 3 4
5 6 7 8

Check 9: Is DACCLK normal?


<Outline> DACCLK for Audio-DAC is created by IC1501 using the 27 MHz master crystal oscillator (X1501).
A
IC1501

X1501 DVD-LSI IC1801


27 MHz DACCLK Audio-DAC
crystal

VCC33 VCC12
Fig 9.1: Clock configuration
B
<Check method>
DVD: DVD-REF-A1 TITLE 1
CD: Playback a normal CDDA.
Common to all DVD-V compatible modules.
Check with DGND being the reference.
In case of NG, check the applicable line, the periphery of IC1501, soldering of the peripheral components and
defective components.
NO. Check point 1 (stylus) Media Specification value 1 Specification value 2 Specification value 3
1 DACCK DVD 2.0 V~VCC33 V DGND~0.8 V 36.864 0 MHz ± 300 ppm
2 DACCK CD 2.0 V~VCC33 V DGND~0.8 V 33.868 8 MHz ± 300 ppm
Specification C
value 1

Specification
value 2 Specification
value 3

GND

Fig 9.2: Clock specification value

AVH-P3200BT/XNUC
5 6 7 8
49
1 2 3 4

Side B

Check point 1 (DACCK stylus)

Side A
C

Check point 2 (IC1501 148 pin)


DGND2
E

Fig 9.3: 27 MHz, DACCLK check point

AVH-P3200BT/XNUC
50
1 2 3 4
5 6 7 8

Check 10: Is the audio circuit OK?


<Outline> The serial 3 lines digital output + DACCLK, output from DVD-LSI (IC1501), are converted to analog audio
signal at Audio-DAC (IC1801) and are output from the HOST I/F (CN1901). A
Simultaneously, the analog MUTE signal is also output from DVD-LSI (IC1501) via the HOST I/F.
The digital audio signal (IECOUT), output from DVD-LSI (IC1501).
CN1901
HOST I/F
IC1501
IECOUT
DVD-LSI
LRCK IC1801 LO
ADOUT Audio-DAC
SRCK RO

GNDAU B

Fig 10.1: Audio circuit

<Check method> Playback DVD-REF-A1 TITLE 2 CHAPTER 1 (48 k/16 bit 1 kHz 0 dB),
and check with DGND being the reference.
In case of NG, check the applicable line, periphery of major components as described in the above drawing,
soldering of the peripheral components and defective components.
NO. Check point 1 (stylus) Specification value 1 Specification value 2 Reference waveform
1 ADOUT3 VCC33 V-0.6 V or higher 0.4 V or lower Waveform 1
2 SRCK VCC33 V-0.6 V or higher 0.4 V or lower Waveform 2 C
3 LRCK VCC33 V-0.6 V or higher 0.4 V or lower Waveform 3

Specification
Specification value 2
value 1
GND

Fig 10.2: Serial 3 lines specification value

AVH-P3200BT/XNUC
5 6 7 8
51
1 2 3 4

Side A

DGND2
ADOUT
LRCK
Side B
C

SRCK

E
Fig 10.3: Serial 3 lines check points

AVH-P3200BT/XNUC
52
1 2 3 4
5 6 7 8

The following checks shall be conducted using the following measurement circuits with GNDAU1 being the reference.
47 kohm 47 kohm
A

LO GNDAU1 RO
NO. Check point 1 (stylus) Specification value (rms) Reference waveform
4 LO 1 400 ± 150 mV Waveform 4
5 RO 1 400 ± 150 mV Waveform 4

B
Specification value is the root-mean-square value (rms).

Fig 10.4: Analog audio out (LO, RO) specification value.

Side A

RO LO GNDAU1

Fig 10.5: Analog audio out check point

Check with DGND being the reference. E

NO. Check point 1 (stylus) Specification value 1 Specification value 2 Reference waveform
6 IEC VCC33 V-0.6 V or higher 0.4 V or lower Waveform 5

AVH-P3200BT/XNUC
5 6 7 8
53
1 2 3 4

Side A

IEC DGND2

Fig 10.6: Digital audio signal (IECOUT) check point


C

AVH-P3200BT/XNUC
54
1 2 3 4
5 6 7 8

Check 11: Is the video circuit OK?


<Outline> Composite signal and component signal are output from DVD-LSI (IC1501), and are output from the
HOST I/F (CN1901) via a buffer circuit. A

CN1901
HOST I/F
IC1501
DVD_LSI

Video Composite COMPOSITE


DAC
section

B
Fig 11.1: Video circuit

<Checking method> Playback DVD-REF-A1 TITLE2 CHAPTER5 (WHITE 100%), and monitor COMPOSITE signal with
an oscilloscope with GNDV1 (stylus) being the reference. Set the trigger mode to “TV trigger” and
the trigger line to “150 line”.
Check point 1 (stylus)
NO. Specification value Reference waveform
1 COMPOSITE 1 000 mVpp ± 5 % Waveform 6
In case of NG, check the applicable line, the periphery of the major components in the drawing above, soldering of the C

peripheral components and defective components.


PEAK

COMPOSITE signal Reference


value
Color burst
Pedestal level
BOTTOM
Horizontal sync signal

Fig 11.2: Waveform for the case of composite white 100% output
D

AVH-P3200BT/XNUC
5 6 7 8
55
1 2 3 4

Side A

COMPOSITE GNDV

C Fig 11.3: VIDEO signal check point

AVH-P3200BT/XNUC
56
1 2 3 4
5 6 7 8

Check 12:How to judge whether the flash memory has reached its life or not.
If the reaction to user operation is slow or operation is slow in general, there is a possibility that the flash memory A
has reached its life.
Make judgment regarding the flash memory life by looking at the display of the LD energizing time.

1.Let the LD energizing time displayed.


(Refer to the FE test mode for the method of displaying the LD energizing time.)
2.If the second digit from the left of the energizing time display is showing E,
such as “ E ”, it means that the flash memory has reached its life.

Example:

0E000BB8

AVH-P3200BT/XNUC
5 6 7 8
57
1 2 3 4

Check 13: 48 MHz Normal?


<Outline> Each clock is created inside the IC1501 using the 48 MHz master crystal oscillator (X1501).
A

IC1501

DVD-LSI
X1950
48 MHz
crystal USB_CLOCK

VCC33 VCC12
Fig 13.1: Clock configuration

<Check method> Turn the power on, and check with DGND1 being the reference.
In case of NG, check the applicable line, periphery of IC1501,
soldering of the peripheral components and defective components.

NO. Check point Module No. Specification value Unit


48 MHz
2 IC1501 50pin-DGND1 ALL
± 50 ppm ppm
C

Specification
value

GND
Fig 13.2: Clock specification value

AVH-P3200BT/XNUC
58
1 2 3 4
5 6 7 8

Side A

IC1501 50pin

DGND1

Fig 13.3: 48 MHz check point

AVH-P3200BT/XNUC
5 6 7 8
59
1 2 3 4

Check 14: Is USB Circuit OK?


<Outline>
The data is transmitted through D+, D- and SDA of HOST I/F while playing USB/IPOD.
A
USB memory uses only D+ and D-, but IPOD uses SDA (DATA) and SCL (CLOCK)
in addition to D+ and D-. CN1901
IC1501 HOST I/F
CP_RESE
DVD-LSI
I2C_SDA

I2C_SCL

D+

D-
B
DGND

Fig. 14-1: USB Circuit

<Check Method>
1.USB Memory: Play a song from USB memory and check D+ and D- with the DGND standards.
2.iPod: Connect iPod and check CP_RESET, SDA and SCL with the DGND standards until the pioneer log appears.
C Play a song from iPod and check D+/D- with the DGND standards.
When it does not conform to the standards, check appropriate line, main parts shown in the above figure,
soldering of peripheral parts and malfunctions in parts.

No. Checking spot (stylus) Standard value 1 Standard value 2


1 CP_RESET VCC33*0.7or more
2 SDATA VCC33*0.7or more VCC33*0.2 or less *Until the pioneer log appears after connecting the iPod
3 SCLOCK VCC33*0.7or more VCC33*0.2 or less *Until the pioneer log appears after connecting the iPod
4 D+ VCC33*0.7or more VCC33*0.3 or less
5 D- VCC33*0.7or more VCC33*0.3 or less

Standard value 2
Standard value 1

Fig. 14.2: USB Circuit Communication Wave

AVH-P3200BT/XNUC
60
1 2 3 4
5 6 7 8

Side A

SDATA

CP_RESET

SCLOCK

D- D+ DGND2

AVH-P3200BT/XNUC
5 6 7 8
61
1 2 3 4

AUDIO

A CH1:LO
CH1:ADOUT3 CH2:RO
Reference voltage: DGND2 1 V/div. 5 usec/div Reference voltage: GNDAU2 1 V/div. 500 usec/div

G->

B G-> G->

Waveform 1 Waveform 4

CH1:SRCK CH1:IECOUT
Reference voltage: DGND2 1 V/div. 5 usec/div Reference voltage: DGND2 1 V/div. 500 nsec/div

G->
G->

Waveform 2 Waveform 5

D
CH1:LRCK
Reference voltage: DGND2 1 V/div. 5 usec/div

G->
E

Waveform 3

AVH-P3200BT/XNUC
62
1 2 3 4
5 6 7 8

VIDEO

A
[WHITE 100IRE]

CH1:COMPO

Reference voltage: GNDV1 200 mV/div. 10 usec/div

Waveform 6

USB memory
USB memory USB memory

C
Reference voltage:DGND 1 ms/div 2 V/div Reference voltage:DGND 200 ns/div 2 V/div

D- D-

DGND DGND
D+ D+

Waveform 7 Waveform 8

AVH-P3200BT/XNUC
5 6 7 8
63
1 2 3 4

iPod
iPod iPod
A

Reference voltage:DGND 1 ms/div 2 V/div Reference voltage:DGND 200 ns/div 2 V/div

D- D-

DGND DGND
D+ D+

Waveform 9 Waveform 10

iPod iPod

Reference voltage:DGND 20 ms/div 1 V/div Reference voltage:DGND 2 ms/div 1 V/div

CP_RESET

DGND

SDA

NRES

Waveform 11 Waveform 12
D

iPod

Reference voltage:DGND 500 us/div 1 V/div

SCL

Waveform 13

AVH-P3200BT/XNUC
64
1 2 3 4
5 6 7 8

5.4 ERROR CODE LIST


Generation source Method of reset
UART USB USB ACC Source Eject Play Key
Error status OSD *1 *2 Meaning Disc (MSC) (iPod) Off/On Off/On
A disc containing the unplayable A
M e d ia E r r o r NON-PLAYABLE DISC 00h X - - X X X -
Format only

INCOMPATIBLE DEVICE 00h USB device that doesn't correspond - X X X X - -

USB device of format alone that


UNPLAYABLE FILE 00h - X - X X - -
cannot be reproduced
Open (No display) 10h Door open error X - - * * * *
Read Error E R R O R -0 2 -9 9 20h Transfer start error X - - X X X X
Focus Error(Focus Error
in mechanism set u p) E R R O R -0 2 -9 0 21h Focus error X - - X X X X
Focus error during set up
Surface Error E R R O R -0 2 -9 E 22h (A focus has never been achieved X - - X X X X
with that disc.)
Address no t
found(Invalid Track) ERROR-02-80 23h Address not found. X - - X X X X

Spindle lock NG
Spindle Lock ERROR-02-91 24h (the disc cannot rotate) X - - X X X X
Carriage home NG
Carriage HOME ERROR-02-92 25h (The pick up tries to return to carriage X - - X X X X
home, but it cannot go back and stopped.) B
ID/SUBCODE Read Error (ID/SUBCODE
ID/SUBCODE Read Error ERROR-02-94 26h cannot be read due to scratch or stain.) X - - X X X X
AV CHIP decode NG
AV CHIP decode Error ERROR-02-9A 2Ah (AV chip cannot be decoded.) X X - X X X X

AV CHIP Recovery NG ERROR-02-9B 2Bh AV CHIP recovery NG X X X X X X X


Error of PLAY BAC K Playback state error
ERROR-02-9C 2Ch (An error due to software bug.) X X - X X X X
Mode Status
Disc Data Error ERROR-02-9D 2Dh Disc Data NG X - - X X X X
Temp Error High temperature
(In Case of High THERMAL 30h (Playback is stopped because the pick up X - - X - - -
Tem perature ) PROTECTION IN MOTION temperature is 89 C or higher.)
No Disc Disc has not been inserted.
( including Disc loading (No display) 40h (Including Load in process or X - - * * * *
and e jectin g) Eject in process.)
Loading_Mecha Error Loading mechanism error
(No display) 50h (The disc cannot be clamped.) X X X X - X -
Communication fault attesting iPod E R R O R -02-60 60h Communication fault attesting iPod X - X - - X - C
iPod authentication data is abnormal E R R O R -02-61 61h iPod authentication data is abnormal X - X - - X -
iPod attestation retrying failure E R R O R -02-62 62h iPod attestation retrying failure X - X - - X -
iPod attestation time out E R R O R -0 2 -6 3 63h iPod attestation time out X - X - - X -
Error when iPod is connected/ Error when iPod is connected/
It is generated STALL by the USB E R R O R -0 2 -6 4 64h It is generated STALL by the USB - - X - - X -
communication communication
Error setting iPod E R R O R -0 2 -6 5 65h Error setting iPod - - X - - X -
Demand timeout when Demand timeout when
initial is communicated E R R O R -0 2 -6 6 66h initial is communicated - - X - - X -
Protocol version Protocol version
non-correspondence E R R O R -0 2 -6 7 67h non-correspondence - - X - - X -
Timeout when protocol Timeout when protocol
version is judged E R R O R -0 2 -6 8 68h version is judged - - X - - X -

No songs error (No display) 69h No songs error - - X - - X -


iPod control forwarding/ iPod control forwarding/
Intarapta forwarding error E R R O R -0 2 -6 A 6Ah Intarapta forwarding error - - X - - X -
Demand timeout Demand timeout
iPod's reproducing E R R O R -0 2 -6 B 6Bh iPod's reproducing - - X - - X - D
Remote switch error ERROR-02-6C 6Ch Remote switch error - - X - - X -
Remote switch demand Remote switch demand
timeout ERROR-02-6D 6Dh timeout - - X - - X -

D R M E rro r PROTECTED DISC 70h DRM error (All music cannot be played X - - - - X -
back due to DRM.)
NO ACCESSIBLE DRM error (All music cannot be played
DATA AVAILABL 70h - X - - - - -
back due to DRM.)
Region code NG (Unable to be played back
Region code Error NG DIFFERENT REGION DISC 90h due to incorrect mechanism region.) X - - - - X -

C P R M *7 K e y E rro r *8 NON-PLAYABLE DISC 93h Key Error for playback X - - - - X -


REQUEST error ERROR-02-A0 A0h REQUEST error X - - X X X X
Failure in issuing read Failure in issuing the read command
E R R O R -0 2 -A 1 A1h X - - X X X X
command (chip dependent)
Adjustment of L0 is NG. ERROR-02-A2 A2h L0 adjustment is NG. X - - X X X X
Adjustment of L1 is NG. ERROR-02-A3 A3h L1 adjustment is NG X - - X X X X
LD system NG ERROR-02-A4 A4h LD system NG X - - X X X X
Gain adjustment system NG. ERROR-02-A5 A5h Gain adjustment system NG. X - - X X X X
Gain determining system NG. ERROR-02-A6 A6h Gain determining system NG. X - - X X X X E
Servo initial setting related items NG. ERROR-02-A7 A7h Servo initial setting related items NG. X - - X X X X
Disc is not clamped yet. ERROR-02-A8 A8h Disc is not clamped yet. X - - X X X X
Tracking system NG. ERROR-02-A9 A9h Tracking system NG X - - X X X X
Media setting system NG. ERROR-02-AA AAh Media setting system NG X - - X X X X
Focus Error ERROR-02-AB ABh JUMP over layers NG X - - X X X X
Error of PLAY BACK
E R R O R -0 2 -B 0 B0h Navigation command error X - - X X X X
Mode Status
Error of PLAY BACK
Mode Status E R R O R -0 2 -B 1 B1h Retry over X - - X X X X
Audio Property Timeou t
ERROR-02-C0 C0h Audio property timeout error X - - X X X -
Error *9
Error when MCS is connected/ Error when MCS is connected/
It is generated STALL by the USB ERROR-02-D0 D0h It is generated STALL by the USB - X - - - X -
communication communication
CBW and CSW forwarding error ERROR-02-D1 D1h CBW and CSW forwarding error - X - - - X -
Audio class band securing failure ERROR-02-D8 D8h Audio class band securing failure - - X - - X -
Audio class FS setting failure ERROR-02-D9 D9h Audio class FS setting failure - - X - - X -
Undefined Error ERROR-FF-FF FFh Undefined error X - - X X X X

AVH-P3200BT/XNUC
5 6 7 8
65
1 2 3 4

X: Cancel the error by operation. -: Error is not cancelled by operation. *: No setting


*1 A content displayed on OSD. As for the items having multiple display patterns, the upper row is for the Japanese version Full GUI, and the lower row is for
the Touch Panel model and Full GUI (English version).
*2 A parameter of UART command, such as “receipt error notice”, that the DVD mechanism transmits.
A *3 CPPM(Content Protection for Prerecorded Media) : A copyright protection technique used in DVD-A. The protection is realized by using the keys recorded
on the media and the device key held by the player.
*4 DVD-A compatible model only.
When an error has occurred, only the audio output will be muted but playback operation will continue. Furthermore, acceptance of the user operation will be
the same as usual.
*5 AWM (Audio WaterMark): Electronic watermark. Information on the copyright owner or CCI (copy control information) are recorded so that illegally copied
discs can be identified.
*6 Notice as an error status will not be given
*7 CPRM(Content Protection for Recordable Media) : A copyright protection technique for digital contents used for re-writable DVD or memory card.
(DVD-VR model only)

AVH-P3200BT/XNUC
66
1 2 3 4
5 6 7 8

AVH-P3200BT/XNUC
5 6 7 8
67
1 2 3 4

AVH-P3200BT/XNUC
68
1 2 3 4
5 6 7 8

5.5 CONNECTOR FUNCTION DESCRIPTION

RGB IN IP-BUS INPUT POWER SUPPLY


A
25 1 5
1 8
6
2 9
10
1 3 5 7 9 11 13 15
3
26 2 7
4 11 2 4 6 8 10 12 14 16

1 : CCR 10 : CCAUL 19 : DSEN


11 : CCAUR 20 : TVON 1. BUS+
2 : CCG 1. FR- 9. P. BRAKE
12 : GNDAU 21 : GION 2. BUSG
3 : CCB 2. RR- 10. MUTE
13 : ONSEI+ 22 : MONON 3. BUSLG
4 : CCSYNC 3. FR+ 11. B.REM
14 : ONSEI- 23 : VSW5 4. MAINTEST
5 : GNDSIG 4. RR+ 12. ILM
15 : REAUR 24 : SYS_TO_NAVI 5. BUS-
6 : DVDVBS 5. FL- 13. BGSENS
16 : REAUL 25 : NAVI_TO SYS 6. BUSRG
7 : GNDDVD 6. RL- 14. ACC
17 : GNDRAU 26 : GNDD 7. BUSL+ B
8 : YS 7. FL+ 15. GND
18 : CCREM 8. ASENBO
9 : NC 8. RL+ 16. B.UP
9. BUSR+
10. BUSR- REAR AUDIO
REAR CAMERA IN
11. BUSL- OUTPUT
FRONT OUTPUT
VIDEO
REAR OUTPUT INPUT/OUTPUT AUX IN(*) WIRED REMOTE
CONTROL

ANTENNA IN OPTICAL OUTPUT(*)


AUDIO INPUT E

SUBWOOFER OUTPUT

AUX IN OPTICAL OUTPUT


AVH-P3200BT/XNUC
AVH-P3250BT/XNRD
AVH-P3200DVD/XNUC
AVH-P3250DVD/XNRC
AVH-P3250DVD/XNRD
AVH-P3250DVD/XNRI
F

AVH-P3200BT/XNUC
5 6 7 8
69
1 2 3 4

6. SERVICE MODE
6.1 MONITOR TEST MODE
A
[Method for Mode IN]

When the reset start is done while pushing REVERSE and EJECT, it shifts to the monitor test mode.

[Display specifications]

[Operation specification]
Operational description Remote controller key
Selection cursor up movement 2
Selection cursor down movement 8
Menu enter 5
C

1. Version Check
[Method for Mode IN]

Choose "Version Check" among the monitor test mode menu screen.

[Display specifications]

When 8 digits of read number is strange,


displayed with red.

[Operation specification]
E
Operational description Remote controller key
Return to test mode mene 1
Page up 9
Page down 7

AVH-P3200BT/XNUC
70
1 2 3 4
5 6 7 8

2. Touch Panel Test


[How to activate the touch panel test mode]
A
Choose "Touch Panel Test" among the monitor test mode menu screen.

[Menu types in the mode]


The calibration test mode consists of the following menus.

Top menu
Outermost circumference inspection
Calibration inspection
Coordinate inspection
Calibration verification
B
Data initialization

[Operation specification]
Operational description Remote controller key
Selection cursor up movement 2
Selection cursor down movement 8
Return to test mode mene 1
Menu enter 5

[Description of the top menu]


[Display specification]

Conditions for lighting of the adjustment complete mark “ * ”. D

Outermost circumference inspection :


In case the outermost circumference inspection has been completed normally.

Calibration inspection :
In case the calibration has been completed normally.

Conditions for the adjustment complete mark “ * ” to go out.

Outermost circumference inspection :


In case the outermost circumference inspection has never been performed. E
In case the EEPROM initialization has been performed.
In case the adjustment value has been initialized.

Calibration inspection :
In case the calibration inspection has never been performed.
In case the EEPROM initialization has been performed.
In case the adjustment value has been initialized.

AVH-P3200BT/XNUC
5 6 7 8
71
1 2 3 4

[Outermost circumference inspection]

[Outline]
A
Outermost circumference value of X and Y is obtained by tracing the outermost circumference of
the touch panel screen.
When exiting the menu screen by pressing 5 key, the captured value is stored in the EEPROM.
Furthermore, when storing the value, checking is made as to whether the value is within the range or not.

When the value is within the range.


Write the following value and adjustment information to the EEPROM, then “OK” is displayed.
1. The outermost value of X and Y(min/max) : 4 byte
2. The reference value for A/D correction of X,Y : 2 byte
3. Adjustment information(Adjustment OK) : 1 byte

B When the value is within the range.


Write the following adjustment information to the EEPROM, then “NG” is displayed.
1. Adjustment information(Adjustment NG) : 1 byte

The initial value and the setting value allowable range are as follows.

<Before initial value> <After initial value>


Outermost value Outermost value
Xmin : 39h Xmin : 78h
Ymin : 3Eh Ymin : 78h
Xmax : F7h Xmax : B4h
Ymax : EFh Ymax : B4h
C A/D correction value A/D correction value
X : 33h X : 00h
Y : 38h Y : 00h
Setting value allowable range
X direction Minimum value : 00h to 80h
Maximum value : 9Eh to FFh
Maximum value - Minimum value : more then 73h
Y direction Minimum value : 00h to 83h
Maximum value : 9Ah to FFh
Maximum value - Minimum value : more then 6Bh

[Display specifications]
D
Outermost circumference inspection in process

X/Y information of [MIN] and [MAX] of the outermost circumference are displayed.
[BEFOR] indicates the value stored in the EEPROM.
[AFTER] indicates MIN/MAX of the A/D value currently captured.

[Operation specification]
Operational description Remote controller key
Return to top mene 5

AVH-P3200BT/XNUC
72
1 2 3 4
5 6 7 8

[16 points adjustment]

[Outline] A
When correctly touched, the cursor will disappear, and the next cursor will appear. Calibration is conducted
by repeating this process 16 times.
When the 17th point has been finally touched, setting information for the 16 points and the normal ending
information, total of 17 byte data, are written into the EEPROM, and the screen returns to the TOP menu.

[Display specifications]
16 points adjustment in process

Order of display of the locations to be pressed.

This point is intended to end the D


calibration inspection, and therefore, the
corrected value of this point is not obtained.

[Operation specification]
Operational description Remote controller key
Return to top mene 5

AVH-P3200BT/XNUC
5 6 7 8
73
1 2 3 4

[Coordinate inspection]

A [Outline]
The coordinate before correction and after correction at the time of pressing the touch panel are displayed for
coordinate verification.
Furthermore, the red "+" cursor can be moved by the key operaiont mentioned bellow, and the coordinate of
the cursor center is displayed.

Fixed display
[Display specifications]

Each displayed coordinate is as follows.


The values under [Factory] are the corrected values in the Factory region and the values under [User] are
C the corrected values in the User region.
• Sampling : A/D value (X direction, Y direction) of the pressed point is displayed.
• AD Value : The coordinate (X direction, Y direction) of the A/D value of the pressed point corrected by
the reference value for A/D correction is displayed.
• Normalization : The coordinate (X direction, Y direction) after normalizing the A/D corrected coordinate
within the effective range is displayed. (0~255)
• Calibration : The coordinate (X direction, Y direction) which is the result of adding the correction
by calibration to the normalized coordinate is displayed.
Movable "+" cursor is displayed in red.
16 calibration points are displayed in white.

[Operation specification]
D
Operational description Remote controller key
Return to top mene 1

AVH-P3200BT/XNUC
74
1 2 3 4
5 6 7 8

[Calibration verification]

[Outline] A
Touch the cursor “+” displayed on the screen. The correct touch will delete the cursor and another cursor
will be displayed. The incorrect touch will make the characters of cursor turn red.
Repeat this for 4 points, and “OK” is displayed upon the last press of 4th point.

[Display specifications]

confirming

The pushing order

[Operation specification]
Operational description Remote controller key
Return to top mene 1 D

AVH-P3200BT/XNUC
5 6 7 8
75
1 2 3 4

[Data initialization]
[Outline]
A Result of outermost circumference inspection and of calibration inspection (corrected value) are returned to
their initial values.
As for the initialized items, the initial values are written into the EEPROM and the adjustment information
is cleared.
[Display specifications]

Conditions for the adjustment completion mark (*) to be lighted up.


(The mark will be lighted up if one of the multiple conditions is met.)
Outermost circumference inspection
When the outermost circumference inspection of the calibration for line has been completed normally.
Calibration inspection
C
When the calibration inspection of the calibration for line has been completed normally.
User outermost circumference inspection
When the user outermost circumference inspection of the calibration for line has been completed normally.
User calibration inspection
When the user calibration inspection of the calibration for line has been completed normally.

Conditions for the adjustment completion mark (*) to go out.


Outermost circumference inspection
When the above mentioned lighting conditions are not applicable.
When the adjusted value has been initialized (Data initialize).
D When the EEPROM has been initialized.
Calibration inspection
When the above mentioned lighting conditions are not applicable.
When the adjusted value has been initialized (Data initialize).
When the EEPROM has been initialized.
User outermost circumference inspection
When the above mentioned lighting conditions are not applicable.
In case the outermost circumference inspection of the calibration for line or the 16-point adjustment is normally
terminated after normal termination of the outermost circumference inspection for user calibration.
When the adjusted value has been initialized (Data initialize).
When the EEPROM has been initialized.
E
User calibration inspection
When the above mentioned lighting conditions are not applicable.
In case the outermost circumference inspection of the calibration for line or the 16-point adjustment is normally
terminated after normal termination of the outermost circumference inspection for user calibration.
When the adjusted value has been initialized (Data initialize).
When the EEPROM has been initialized.

[Operation specification]
Operational description Remote controller key
Selection cursor up movement 2
Selection cursor down movement 8
F Return to test mode mene 1
Menu enter 5

AVH-P3200BT/XNUC
76
1 2 3 4
5 6 7 8

3. EEPROM Adjust
[Method for Mode IN]
A
Choose "EEPROM Adjust" among the monitor test mode menu screen.

[Display specifications]
The setting items and the adjusted values are displayed on each page.
*The adjusted value section indicates initial values stored in EEPROM.
*If writing a value fails, the indication will not change.
Setting item Adjustment value
example)

[Operation specification]
Operational description Remote controller key
Selection cursor up movement 2
Selection cursor down movement 8 C
Item content value up 6
Item content value down 4
Next menu page 9
Former menu page 7
Return to test mode mene 1

4. EEPROM Initialize
[Method for Mode IN]
Choose "EEPROM Initialize" among the monitor test mode menu screen.

D
[Display specifications]
When EEPROM is initialized, eject lock may be enabled. Please cancel eject lock in this case.

Default of a cursor is the location of "No".


Choose "YES" and decide, initialize a setting value.
*) Don't turn off power while initializing.

When normally ends, "success" is displayed.


When will not end in four seconds, judged to be abnormal, "failure" is displayed.
[Operation specification]
Operational description Remote controller key
Selection cursor left movement 4 F
Selection cursor right movement 6
Return to test mode mene 1
Menu enter 5

AVH-P3200BT/XNUC
5 6 7 8
77
1 2 3 4

5. Display Test
[Method for Mode IN]
A
Choose "Display Test (Test Pattern)" among the monitor test mode menu screen.

[Display specifications]

[Operation specification]
Operational description Remote controller key
Selection cursor up movement 2
Selection cursor down movement 8
Page up 9
Page down 7
Return to test mode mene 1
C Menu enter 5

[RGB]

RGB is plotted in the following pattern:


R100% -> R50% -> G100% -> G50% -> B100% -> B50% -> BLACK -> GRAY -> WHITE -> GREEN and MAGENTA
dot signal
(The display of the screen will be changed in 1 second.)

[Operation specification]
Operational description Remote controller key
Return to test mode mene 1
D Stop/Restart 5

[MONOCHROME STRIPE]

Display of monochrome stripe signal (1dot Width)

[Operation specification]
Operational description Remote controller key
Return to test mode mene 1

E
[COLOR BAR]

Display of color bar signal

[Operation specification]
Operational description Remote controller key
Return to test mode mene 1

AVH-P3200BT/XNUC
78
1 2 3 4
5 6 7 8

[RAMP & 10STEP]

Display of step signal and signal for alpha blend check A

[Operation specification]
Operational description Remote controller key
alpha blend rate up 2
alpha blend rate down 8
Return to test mode mene 1
Next signal 5

[RASTER SIGNAL]

Display of signal for step confirmation


B

[Operation specification]
Operational description Remote controller key
Return to test mode mene 1
Next signal 5

[CONTRAST]

Display of Black/White signal

[Operation specification] C
Operational description Remote controller key
Return to test mode mene 1
Next signal 5

[CENTER MARKER]

Display of signal for screen central location setting.

[Operation specification]
Operational description Remote controller key
Return to test mode mene 1

AVH-P3200BT/XNUC
5 6 7 8
79
1 2 3 4

6.2 DVD TEST MODE

Test mode display will not appear on the display of this product. Connect the rear monitor output to a monitor.
A
Image of the test mode.
[MUTE] + [FORWARD] + Reset start
Switch position of the remote control unit.
[AVH mode]
(1)-(8) and EJECT is the key of remote control unit.
Legend: … Key operation
… Operation state

Start of the test mode. … The content displayed on the DVD mechanism (video only)
8 characters data is sent to the product side (HOST) by UART communication.

B TEST [Note] Higher level 4 characters only. Lower level 4 characters are spaces.

(1) (2) (3) (4) (5)

FE test selection EDC1 test selection EDC2 test selection LD power on time Simple FE test mode
mode selection

Hereafter, to FE test Hereafter, to EDC1 Hereafter, to EDC2 Hereafter, to LD power on Hereafter, to simple
mode image. test mode image. test mode image. time mode image. FE test mode.

[Note] In order to move on to another test after selecting a test (FE/EDC1/EDC2), it is necessary to restart the DVD mechanism in the test mode.

C
Image of the front end test mode.
Legend: … Key operation
… Operation state
… The content displayed on the DVD mechanism (video only)
8 characters data is sent to the product side (HOST) by UART communication.

FE test mode

0 x 00 0000

(1) (2) (3) (4) (5) EJECT


D Power on FE offset coefficient Disc type DVD1 Disc type DVD2 EJECT
TE offset coefficient Disc type CD Disc type CD-RW
layer layer
AS offset coefficient
0FFF 0000 ENV offset coefficient
TG offset coefficient 0000 0000 0100 0000 0200 0000 0300 0000
DBAL coefficient
VIN1 offset cancel value
VIN2 offset cancel value
VIN3 offset cancel value
VIN4 offset cancel value
VIN5 offset cancel value

1 x 00 0000

(1) (2) (3),(4) (5) (6) (7) (8)


E F close F search CRG+/- LD-ON/OFF CRG_HOME CRG_OUTSIDER Power_OFF

S curve
measurement
1FFF 0000 Activates while the key When LO-ON: 1100 0000 1D00 0000 1E00 0000
1A00 0000 is being pressed. When LD-OFF: 1000 000
(2) 1B00 0000 : CRG+
1C00 0000 : CRG-
F search

1100 0000
[Note] If no action is taken for approximately 10 seconds after LD-ON, it will become LO-OFF automatically.
If F close is selected during LD-OFF, it will become an error.
During focus search (S character measurement mode), too, safety regulation applies if LD_OFF is not selected
Focus close state within 10 seconds. Therefore, even if focus search is selected after LD-ON, it will become LD-OFF after 9 seconds.
FEMAX level In order to F close after focus search (S character measurement mode), set to Power_OFF first then power on again
FEMIN level before F close.
ASMAX level
ENVMAX level
FE normalization coefficient
Spindle gain coefficient
TEMAX level indication
TEMIN level indication
F (2)

a b

AVH-P3200BT/XNUC
80
1 2 3 4
5 6 7 8

a b
(2)

2 x 00 0000
A
(1) (2) (3),(4) (8)
Tracking balance Focus Jump CRG +/- Power_OFF

When L0 layer: 2000 0000 It operates while the key


2FFF 0000 When L1 layer: 2100 0000 is being pressed.
2B00 0000 : CRG+
TBAL coefficient (layer 0) 2C00 0000 : CRG-
TBAL coefficient (layer 1)
TE normalization coefficient (layer 0)
TE normalization coefficient (layer 1)
Off track adjustment result

3000 0000

(1) (3),(4) (5) (8)


Tracking close CRG +/- RF level value Performed including the tracking close processing. Power_OFF

3FFF 0000 It operates while the key 3FFF 0000


is being pressed. B
3B00 0000 : CRG+
3C00 0000 : CRG- Tracking close state FBAL coefficient (layer 0)
FBAL coefficient (layer 1)
Focus gain coefficient (layer 0)
Focus gain coefficient (layer 1)
Tracking gain coefficient (layer 0)
Tracking gain coefficient (layer 1)
AS normalization adjustment value (layer 0)

5000 0000

(1) (2) (7) (8)


RF level value Error rate
indication start measurement T.OPEN Power_OFF

Error rate
RF level is informed Focus gain coefficient (layer 0) To (2)
every 500msec. Focus gain coefficient (layer 1)
Tracking gain coefficient (layer 0) C
Tracking gain coefficient (layer 1)
(1)
AS normalization adjustment value (layer 0)
RF level value
indication end

FBAL coefficient (layer 0)


Tracking close state
FBAL coefficient (layer 1)
Focus gain coefficient (layer 0)
Focus gain coefficient (layer 1)
Tracking gain coefficient (layer 0)
Tracking gain coefficient (layer 1)

4000 0000

4 x 00 0000 D

(1) (2) (5) (6) (3),(4) (7) (8)


Error rate Playback speed T.Jump+/- Power_OFF
measurement switching Focus Jump ID Search T.OPEN

Error rate Jump+ : 4B00 0000


Focus gain coefficient (layer 0) When L0 layer: 4x00 0000 4A00 0000 Jump- : 4C00 0000 To (2)
Focus gain coefficient (layer 1) DVDX1.3~ When L1 layer: 4x00 0000
Tracking gain coefficient (layer 0) 1.6CAV (1)-(4) (3)
Tracking gain coefficient (layer 1) CDX4CLV: Track number
4x00 0000 ID designation designation
AS normalization adjustment value (layer 0)

ID display Track number


indication The higher 2 digits of the designated ID are the value showing the test state.
(5) (5) The lower 6 digits show the ID.
Example) If 300000 is desired to be designated as the ID, designated ID: 4A03 0000.
Search start Jump start

Error occurrence

The number for designation of the track number shall be selected from the track numbers previously prepared. E
Switch to cyclic by (3). Fix by (4).
Error display For CD: Tracks 1, 4, 10, 11 and 32
L0 layer DVD X 1.3~1.6CAV, CD X 4CLV :4000 0000
For DVD: Tracks 1, 4, 10, 11, 32, 64 and 100
L1 layer DVD X 1.3~1.6CAV :4100 0000
(8)
Change the method for ID address designation.
Power_OFF Designation of digit by command (1) and (2). UP/DOWN of numbers by command (3) and (4). Fix by command (5).

Error occurrence at Power_OFF

[Note] If an error occurs at Power_OFF, reset cannot be made. In such a case, it is necessary to turn the power off and start the test mode once again.
Error display

AVH-P3200BT/XNUC
5 6 7 8
81
1 2 3 4

Legend:
… Key operation
EDC. Image of the test mode
A … Operational state
… The content displayed on the DVD mechanism (video only)
8 characters data is sent to the product side (HOST) by UART communication.

EDC1/2 test mode [Note] Image is the same for both EDC1 and EDC2.

0000 0000
EJECT operation
[Note] Eject can be effected any time during the EDC test mode.
(1) (2)

Layer 0 selection Layer 1 selection

Eject
B
0000 0000 0100 0000 Test mode Eject

1003 0000 1103 0000


After completion of EJECT operation

(1)-(4)
ID designation

Layer 0: 10** ****


Layer 1: 11** ****
[Note] ** **** is the ID designation value

(5)
C
EDC1/2 start

Layer 0: 20** ****


Layer 1: 21** ****
[Note] ** **** is the present ID designation value

**** **** [Note] The display is updated at 0.5 seconds interval until 0/1 layer is selected or Eject is effected.
[Note] **** **** is the present ID designation value

Image of the LD power on time mode.


Legend: … Key operation
… Operational state
… The content displayed on the DVD mechanism (video only)
D LD power on time mode 8 characters data is sent to the product side (HOST) by UART communication.

0000 0000
Not for service use
(1) (2) (5) (6)
CD LD power on DVD LD power on CD LD power on DVD LD power on
time indication time indication time setting time setting

10** **** 20** ****


[Note] ** **** is the CD LD [Note] ** **** is the DVD LD 30** **** 40** ****
power on time. power on time. [Note] ** **** is the setting time. [Note] ** **** is the setting time.

(1)-(4) (1)-(4)
Setting time (8) Setting time (8)
E designation designation
(5) (5)

Setting time Setting time


registration registration

10** **** 20** ****


[Note] ** **** is the CD LD [Note] ** **** is the DVD LD
power on time. power on time.

[Method of setting time designation]


Designate the digit by command (1) and (2). UP/DOWN of numbers by command (3) and (4).
Fix by command (5). Cancel by command (8).
F

[Note] If the power on time is 999999 hours or more, it is always reported as 999999 hours.
[Note] If the power on time is “*E** ****”, the value may not be correct due to the life of the flash memory.

AVH-P3200BT/XNUC
82
1 2 3 4
5 6 7 8

Simple test mode


The selection of the figure of each screen can be selected by "Key command for the test".
A

<Flow chart>
TEST MODE

1: LD ON
2: ASMAX
3: Skew Adjustment
4: Error Rate
5: CRG Move Outer
6: Eject

Please Input Number

LD ON LD ON LD ON
1 select
1: DVD Single Layer LD ON 1: Power OFF select
select
2: DVD Dual Layer Completion
3: CD B
5 Return select 4: CD-RW
5: Return

Please Input Number Now Running Please Input Number

2 select ASMAX ASMAX ASMAX


ASMAX
1: DVD Single Layer 1: Power OFF select
select value set
2: DVD Dual Layer
3: CD
5 Return select 4: CD-RW
5: Return ASMAX Level : 000000 ASMAX
Level display

Please Input Number Now Running Please Input Number

Skew Adjust ment Skew Adjust ment Skew Adjust ment


3 select
RF Level
1: DVD Single Layer value set 1: Power OFF
select select C
5 Return select RF Level
5: Return RF Level : 000000 display
Update 500 msec.
Search ID
Please Input Number Now Running 0x00100000 Please Input Number

*1 *1
4 select Error Rat e Error Rat e Error Rat e - Inner Error Rat e - Inner
Error Rate
1: DVD Single Layer 1: Inner Measurement 1: Power OFF select
DVD select select set
2: Outer Measurement
3: CD 3: Middle Measurement
5 Return select
5: Ret urn 5: Ret urn Error Rate : 000000
5 Return
select
Please Input Number Please Input Number Search ID Now Running Please Input Number
inner :
0x00040000 Error Rate
outer : display
0 00200000 *1 *1 : The position in which
Error Rate -CD select was done is
displayed.
D
DVD Inner
CD select DVD Outer
DVD Middle
CD CD

Now Running Search CRG


home position

5 select CRG Move Out er CRG Move Out er CRG Move Out er

1: DVD Single Layer CRG Move 1: Power OFF select


2: DVD Dual Layer select Completion
3: CD
5 Return select 4: CD-RW
5: Return CRG moves
to the most
outer
Please Input Number Now Running Please Input Number

<Error> E
ERROR

1: Power OFF select

Code : 00000000

Please Input Number

<Error : Power OFF>

ERROR

Code : 00000000

Please Reset F

AVH-P3200BT/XNUC
5 6 7 8
83
1 2 3 4

7. DISASSEMBLY
- Removing the Monitor Assy (Fig.1) Case
A

Remove the Case.(Fig.1)


1 1
1 Remove the four screws.(Fig.1) Monitor Assy
2 2

1 1
2 Remove the two hooks.(Fig.1)
Fig.1
B

Disconnect the two FFC


3
and then remove the Monitor Assy.(Fig.2)

Fig.2
C

- Removing the LCD Assy (Fig.3)


Holder LCD Assy
3
1 Disconnect the FFC.
2 2
3
2 Remove the four screws.

Remove the two screws


D 3 1
and then remove the Holder.
2 2
Remove the three hooks
4 Fig.3
and then remove the LCD Assy.

- Removing the Monitor PCB (Fig.4)


2 2

1 Disconnect the two FFC.


E

1 2
2 Remove the five screws
and then remove the Monitor. 2 1 2 Fig.4
Monitor PCB

- Removing the Keyboard PCB (Fig.5)

1 Keyboard PCB
Remove the screw
F 1
and then remove the Keyboard PCB.
Fig.5

AVH-P3200BT/XNUC
84
1 2 3 4
5 6 7 8

- Removing the DVD Mechanism Module (Fig.6)

1 Remove the four screws. 1

2
Disconnect the FFC
2 and then remove the DVD Mechanism Module.
1 1

Fig.6

DVD Mechanism Module

- Removing the Heat Sink and Holder (Fig.7)


Heat Sink Holder

1 Remove the two screws.


2 2
C
2
Remove the three screws
2 and then remove the Heat Sink
and Holder.
1 1
Fig.7

- Removing the the Upper Chassis (Fig.8, 9, 10)


D

1 Fig.8

1 Remove the screw.(Fig.8)

Upper Chassis E

Fig.9
2 2

Remove the four screws


2
and then remove the Upper Chassis.(Fig.9, 10)

2 2
Fig.10 F

AVH-P3200BT/XNUC
5 6 7 8
85
1 2 3 4

- Removing the Service Unit (Mother Assy) (Fig.11)


Service Unit (Mother Assy)
A

2
1 Remove the two screws. 2

Straighten the tabs


2
at two locations indicated.
3
3
Remove the two screws
3
and then remove the Service Unit 1
B (Mother Assy). 1
Fig.11

When unplugging the Coaxial Jumper, make sure to use jig GGF1539.
If the antenna cable is directly unplugged without using jig GGF1539, you might damage your fingertip or fingernail.

- How to Remove the Coaxial Jumper


When unplugging Coaxial Jumper, hook the point of jig GGF1539 on the lid of Coaxial Jumper
and vertically draw out along with the engagement axis of connector.
C

GGF1539

Coaxial Jumper

D
Connector

- How to Attach the Coaxial Jumper


For inserting Coaxial Jumper, adjust cord assy with the engagement axis of connector and insert it as vertically
as possible.
Do not insert the Coaxial Jumper in extreme slant, as the connector might suffer damage.

- Removing the the BT ANT PCB (Fig.12)

Disconnect the Cord Assy 1


1
using GGF1539. 2

Remove the screw Fig.12


2
and then remove the BT ANT PCB.

BT ANT PCB
F

AVH-P3200BT/XNUC
86
1 2 3 4
5 6 7 8

How to have it
1.Have a specified part.
A

Handling OK

Handling NG

AVH-P3200BT/XNUC
5 6 7 8
87
1 2 3 4

Mecha Module_Bringing into the Clamp State with No Disc Loaded


1. Remove the relay FFC from the connector on the module PCB side (Fig. 1).
(Precaution) When it is difficult to apply 4V to the motor in procedure 2 below, remove the connector on the relay
A
PCB side, then remove the FFC, and remove the solder of the CRG motor lead and apply voltage to the lead.
2. Push the Disc detection arm while applying 4V to the CRG motor (Fig. 2)
By this action, the mecha moves to the clamp state and the PU moves to the outer periphery.
3. Stop the motor when the PU comes to the vicinity of the intermediate periphery.
(Precaution) If the PU goes to the outer most periphery, it idles.
It is not a problem, but please try not to let it idle as much as possible.

GND the brown line


4V to the gray line
B Fig. 1 Fig. 2

Relay FFC Connector (relay FFC)

AVH-P3200BT/XNUC
88
1 2 3 4
5 6 7 8

CRG Mecha_Bringing into the Clamp State with No Disc Loaded


1.Remove the T-case washer and then remove the drive gear. (Fig. 1)
2.Lift the clamp arm assy until it is in the state shown in Fig. 2_b (open-lock state).
A
3.Put your finger on the area A of Fig. 2_c and then slide it to the direction of the arrow (the direction of the playing state).
4.Push down the clamp arm.
(Precaution) When bringing the CRG mecha into the ejecting state again, install the drive gear after sliding the drive
lever and bringing it to the ejecting state, in order to prevent the cog of the pinion in the drive gear from chipping at the
time of its installation.

Fig. 1

T-case washer
Drive gear

Fig. 2

a.Ejecting state b.Open-lock state c.Clamp state with no disc loaded

D
A

There is a There is
space no space

AVH-P3200BT/XNUC
5 6 7 8
89
1 2 3 4

Removing the Module PCB


1.Short-circuit two spots on the land of the pick up FPC. (Fig. 1)
2.Remove the pick up FPC and the relay FFC from the connector. (Fig. 2)
A 3.Temporarily attach the pick up FPC to the pick up rack. (Fig. 3)
(in order to prevent the damage to the pick up FPC)
4.Remove the two PCB clinch screws and then remove the module PCB. (Fig. 2)
Connector (pick up FPC) Short-circuit
Fig. 2
Pick up FPC
Fig.1

Fig.3
B

Connector PCB clinch screw


Relay FFC
(Relay FFC)
Removing/Installing the Relay PCB
C Removing) Hook A Solder on the lead
1.Remove the relay FFC from the connector Fig. 4
(remove both sides so that the entire FFC will be removed). (Fig. 2)
2.Remove the solder on the lead for the CRG motor. (Fig. 4)
3.Remove the one relay PCB clinch screw. (Fig. 4)
4.Slide the relay PCB to the direction of the arrow and then remove
the relay PCB from the hook A and the hook B. (Fig. 4)
5.Turn the relay PCB over and then remove the SPDL motor FFC
from the connector.

Installing) Hook B
1.Check the mecha is in the ejecting state (disc-load suspended state). Relay PCB clinch screw
When it is not in the ejecting state, apply 4V to the lead (motor) and then
D bring it to the ejecting state (4V to the brown line and GND the gray line). Fig. 5
2.Fit the SPDL motor FFC to the connector (back of the relay PCB).
3.Hold the relay PCB so that it does not touch the SW knob as in Fig. 5.
4.Insert it into the hook B as it is a little off to the clockwise direction.
(Precaution) This is to prevent the SW knob from getting into the NG
position as in Fig. 6.
5.Push down the relay PCB lightly and then rotate it to the
counterclockwise direction.
It sets the relay PCB in the hook A and the positioning dowel.
(Precaution) Pay attention so the SW knob will not get onto the PU rack.
(Fig. 6) Hook B
6.As in the Figures, while supporting the location A with your fingers, Fig. 6
screw the relay PCB. (Fig. 7 / Fig. 8)
E
7.Solder the lead for the CRG motor. OK NG
8.Fit the relay FFC to the connector.

Fig. 7 Fig. 8
A

AVH-P3200BT/XNUC
90
1 2 3 4
5 6 7 8

Removing the PU Unit


1.Hook the feed screw biasing spring on the temporary hook (Fig. 2b). Be careful not to get injured by the tip of the spring.
2.Hold the PU at the location A in Fig. 1 and slide and scoot it to the direction of the inner periphery.
3.As in Fig. 3, shift the back end of the feed screw to the side and then to above and remove it from the outside holder. A
4.Remove the tucking joint for the chassis at the location B and the PU unit by lifting them up without changing their
position and then remove the PU unit.
(Precaution) When installing the PU again, make sure to tuck the chassis in B and the PU unit (Fig. 4) first.
Moreover, do not forget to permanently hook the feed screw biasing spring (Fig. 2a).
Adjustments to the PU after its installation should be made according to the service manual.

Slide to the direction of inner periphery Permanently hooked position Temporary hooked position
Fig. 1
Fig. 2a Fig. 2b

B The spring is installed under the resin flange and inside


the bended metal plate.
A
C

Fig. 3 Fig.4

D
[Installation NG]
Back end of Outside holder Regularly installed position Install avoiding the
The chassis is not tucked
the feed screw area with blue broken
between the PU case and the
line (the connected
PU rack.
metal plate part)

Sending the PU to the outer periphery


1.Bring to the clamp state with no disc loaded according to the “Mecha Module_Bringing into the Clamp State with
No Disc Loaded” manual.
(Precaution) The relay FFC must be removed for certainty in order to prevent the IC damage.
2.Apply 1.5V to the CRG motor and then transfer the PU to the outer periphery.
(Precaution) Do not forget to reinstall the relay FFC after sending the PU to the outer periphery and take the E

necessary measures.

AVH-P3200BT/XNUC
5 6 7 8
91
1 2 3 4

8. EACH SETTING AND ADJUSTMENT


8.1 DVD ADJUSTMENT
A

1) Precautions
This product uses 5 V and 3.3 V as standard voltages. If the reference voltage is connected to GND by
The electrical potential that is the reference for signals, mistake, turn the regulator OFF immediately, or
is not GND, but VREF (approximately 2.2 V) and VHALF turn the power OFF.
(approximately 1.65 V) . Remove the filters and wires used for measurements
During product adjustments, if the reference voltage is only after the regulator has been turned OFF.
mistakenly taken as GND, and a grounding contact is After the power supply is turned on, regulator ON the
made, not only would it be impossible to measure the following adjustment and measurement are promptly
B accurate electrical potential, but also the servo motor done.
would malfunction, resulting in the application of a Whenever the product is in the test mode, the software
strong impact on the pick up. The following precautionary will not take any protective action. For this reason,
measures should be strictly adhered to, in order to special care should be taken to make sure that no
avoid such problems. mechanical or electrical shock could be applied to the
The reference voltage and GND should not be confused product when taking measurements in the test mode.
when using the minus probe of a measurement device. Whenever the EJECT key is pressed to eject the disk,
When an oscilloscope is being used special care should no other keys, other than the EJECT key, should be
be taken to make sure that the reference voltage is not pressed until the disk eject action has been completed.
connected to the probe of ch1 (on the minus side), Press the EJECT key only after the disk has stopped
while the probe of ch2 (on the minus side), is connected completely.
to GND. Further, since the body frame of most measurement If the product hangs up turn the power OFF immediately.
C devices have the same electrical potential as Laser didoes may be damaged, if the volume switch for
the minus side of the probe, the body frame of the the laser power adjustment of the pick up unit, is turned.
measurement device should be set to floating ground.

AVH-P3200BT/XNUC
92
1 2 3 4
5 6 7 8

- SKEW adjustment
When one of the following replacements has taken place, SKEW adjustment for the pick up will be required.
(1) Replacement of the pick up unit A
(2) Replacement of the spindle motor
(3) Replacement of the carriage chassis
(4) Replacement of the main shaft of the pick up unit
Measurement equipment and tools/jigs: Oscilloscope
Driver for SKEW adjustment -> Driver
Bond for fixing the SKEW -> GEM1033
Bond for resonance -> 1530 (1530 : produced by THREE BOND)
Bond for locking the screw -> 1401M (1401M : produced by THREE BOND)

Disc used:GGV1025
B
Measurement reference: AGND3
Measurement point: RF
Connection drawing
DVD core unit

AGND3
AGND3
C

RF
RF

Expansion

Oscilloscope

-3
Symptom in case the adjustment is not adequate: Worsening of the error rate 10
-4
(Normally 10 or less.)
Large RF jitter
RF waveform distortion
Tracking drawing/Unstable servo
* Caution: Do not look into the laser light during adjustment.

AVH-P3200BT/XNUC
5 6 7 8
93
1 2 3 4

There are two methods of making adjustment: a method of making adjustment through monitoring RF waves by the
oscilloscope (method 1) and a method of making adjustment through checking the numerical value of the RF level by
OSD (method 2).
A Adjusting procedure is shown below, but regarding how to start the test mode and the operating procedure, please refer
to the clause on the service test mode.

Adjusting Procedure:
1. Install the pickup
(Refer to the removal of the pickup from the mecha unit.)
When handling the pickup, refer to the precautions on how to handle the PU listed below.
2. Method 1:
Connect the oscilloscope according to the AGND3 standards with reference to the connection diagram so that the RF
signals can be monitored.
Method 2:
B The device does not need to be set. Proceed to the procedure 3.
3. Turn ON the power of the product.
4. Start the simplified FE test mode.
(Regarding how to start the test mode and the operating procedure, refer to the clause on the service test mode.)
5. Load the disc for adjustment (GGV1025).
6. TEST MODE
Select “3: Skew Adjustment.”
TEST MODE

1: LD ON
2: ASMAX
3: Skew Adjustment
C 4: Error Rate
5: CRG Move Outer
6: Eject

Please Input Number


7. Skew Adjustment
Select “1: DVD Single Layer.”
Skew Adjustment

1: DVD Single Layer

D
5: Return

Please Input Number


8. Adjust the Skew using a driver while checking the RF value.
Refer to the following pages concerning the locations to make SKEW adjustment.
Method 1:
Slightly turn the skew adjusting screw A while checking the RF wave level by the oscilloscope and make
adjustment so the wave level would reach its maximum.
Next, slightly turn the skew adjusting screw B so the wave level would reach its maximum.
Slightly turn the skew adjusting screw A again so the wave level would reach its maximum.
E
(Make adjustment in the order of A->B->A and in the end complete adjustment by turning each screw
in the clockwise direction.)

Method 2:
Slightly turn the skew adjusting screw A while checking the value of the RF level through the OSD display so the wave
level would reach its maximum.
Next, slightly turn the skew adjusting screw B so the level would reach its maximum.
Slightly turn the skew adjusting screw A again so the level would reach its maximum.
(Make adjustment in the order of A->B->A and in the end complete adjustment by turning each screw in the
clockwise direction.)

AVH-P3200BT/XNUC
94
1 2 3 4
5 6 7 8

Skew Adjustment

1: Power OFF
A

RF Level : 000000

Please Input Number


9. Skew Adjustment
Select “1: Power OFF.”
Skew Adjustment

1: Power OFF
B

RF Level : 000000

Please Input Number

10. TEST MODE


Select “6: Eject.”
TEST MODE

1: LD ON
C
2: ASMAX
3: Skew Adjustment
4: Error Rate
5: CRG Move Outer
6: Eject

Please Input Number


11. TEST MODE
Select “5: CRG Move Outer.”
TEST MODE

1: LD ON
2: ASMAX D
3: Skew Adjustment
4: Error Rate
5: CRG Move Outer
6: Eject

Please Input Number


12. In order to produce the clamping state with no disc loaded, slightly move the disc detection arm in the
counterclockwise direction while moving the switch arms outward.

Switch arms

AVH-P3200BT/XNUC
5 6 7 8
95
1 2 3 4

Disc Detection Arm


13. CRG Move Outer
Select “1: DVD Single Layer.”
CRG Move Outer

1: DVD Single Layer


C 2: DVD Dual Layer
3: CD
4: CD-RW
5: Return

Please Input Number


The pickup moves to the outer periphery.
Apply the adhesive to fix the skew, the resonance adhesive and the screw lock.
Refer to the next page regarding the locations of adhesive joining.

14. CRG Move Outer


1: Power OFF
D
CRG Move Outer

1: Power OFF

Please Input Number

15. TEST MODE


E Select “6: Eject.”
TEST MODE

1: LD ON
2: ASMAX
3: Skew Adjustment
4: Error Rate
5: CRG Move Outer
6: Eject

Please Input Number

AVH-P3200BT/XNUC
96
1 2 3 4
5 6 7 8

Locations to make SKEW adjustment

B
B

Locations to adhere the SKEW 1,2,3: GEM1033


C

2
3

1
D

1 2 3

AVH-P3200BT/XNUC
5 6 7 8
97
1 2 3 4

Bond for resonance 4:Three Bond 1530

B 6

adhesive

Bond for locking the screw 5,6 : Three Bond 1401M


D

5 6

Bond for locking the screw

AVH-P3200BT/XNUC
98
1 2 3 4
5 6 7 8

Precautions on handling the PU


*Precaution: Do not touch those shaded areas in the following figures.
Hologram (Beware of the static) A
.
Do not touch the optical part

RF level adjusting part


Do not touch the spring

AVH-P3200BT/XNUC
5 6 7 8
99
1 2 3 4

8.2 MOTHER UNIT ADJUSTMENT

MOTHER UNIT(SIDE B)
A
- Adjustment Point

BUP3
BUP2
BUP1

B SYS+B
EV12 DD5

VDD2

CLKOUT AVCC5
TUN33
DD8

BT33
VCC12
C
VCC33

ILMB

PWBL
PWVI
MOTV

AVH-P3200BT/XNUC
100
1 2 3 4
DC/DC CONVERTER
No Adustment/Check Item Input Point Input signal Measurement point Check/Adjustment Trigger Control/Frequency Note

Internal oscillatory frequency : 300 kHz Internal oscillatory /External frequency can't be
changed, when it is operating.
External oscillatory frequency
5

DDCCLK : 365.8 kHz/413.9 kHz

5
VDCONT5 and VDCONT8 conforms to the
1 DD5 TP : BUP1,2,3 DC14.4 V ± 0.3 V TP : DD5 5.0 V ± 0.4 V VDCONT5 hardware specifications.
Operational frequency range : 346.5 kHz to 450
kHz Please give to me as a setting that flows as a load
SYNC INPUT DUTY 50% by 50 mA or more.

2 DD8 TP : BUP1,2,3 DC14.4 V ± 0.3 V TP : DD8 8.0 V ± 0.4 V VDCONT8


Internal oscillatory frequency : 365.1 kHz Internal oscillatory /External frequency can be
changed, when it is operating.
External oscillatory frequency
HIOUTCLK : 476.6 kHz/515.7 kHz
3 EV12V TP : BUP1,2,3 DC14.4 V ± 0.3 V TP : EV12 12.1 V ± 0.4 V DD8
Operational frequency range : 467.5 kHz to 530.0
kHz
SYNC INPUT DUTY 10%

6
6

REGULATOR
No Adustment/Check Item Input Point Input signal Measurement point Check/Adjustment Trigger Note
1 VDD3.3V TP : BUP1,2,3 DC14.4 V ± 0.3 V TP : VDD2 3.3 V ± 0.2 V BUP
2 SYS+B TP : BUP1,2,3 DC14.4 V ± 0.3 V TP : SYS+B 8.4 V ± 0.3 V SYSPW
SYSPW
3 TUN3.3V TP : BUP1,2,3 DC14.4 V ± 0.3 V TP : TUN33 3.3 V ± 0.2 V
(DD5 supply)
4 PWRVI TP : BUP1,2,3 DC14.4 V ± 0.3 V TP : PWVI 5.2 V ± 0.3 V DD5
5 VCC3.3V TP : BUP1,2,3 DC14.4 V ± 0.3 V TP : VCC33 3.3 V +0.15/-0.3 V DD5
6 VCC1.2V TP : BUP1,2,3 DC14.4 V ± 0.3 V TP : VCC12 1.2 V ± 0.12 V DD5
7 BT3.3V TP : BUP1,2,3 DC14.4 V ± 0.3 V TP : BT33 3.3 V ± 0.1 V DD5 BT model ONLY
8 ILMB TP : BUP1,2,3 DC14.4 V ± 0.3 V TP : ILMB 8.1 V ± 0.3 V DD8

AVH-P3200BT/XNUC
9 PWRBL TP : BUP1,2,3 DC14.4 V ± 0.3 V TP : PWBL 8.1 V ± 0.3 V DD8
10 AVCC5V TP : BUP1,2,3 DC14.4 V ± 0.3 V TP : AVCC5 5.0 V ± 0.3 V DD8

7
7

Please supply power to each power source basically from BU.


When checking the Multi Media Decoder (SoC) unit using the UART etc., conform to the product movement for the time from the power on to
the reset cancellation/communication start, etc.

SYSTEM u-COM
No Adustment Item Input Point Input signal Measurement point Check/Adjustment Trigger Note
47.185 92 MHz ±
PCL After ACC, B.UP ON, Supply 3.3 V with
1 TP : BUP1,2,3 DC14.4 V ± 0.3 V TP : CLKOUT 188 Hz -
FREQUENCY IC602 : 149pin(TESTIN) and release reset.
(± 40 ppm less than)
8

8
101
E
A

D
C

F
B
1 2 3 4

8.3 MONITOR PCB ADJUSTMENT

MONITOR PCB(SIDE B)
A
- Adjustment Point

GD33
PNLVI

GD12V

PWRBL
B MONPW

PWRVI

CSYNC BLERR1
ANAB
ANAR
ANAG
MOVBS
BLP
C

AVH-P3200BT/XNUC
102
1 2 3 4
BACKLIGHT DRIVER
No Adustment/Check Item Input Point Input signal Measurement point Check/Adjustment Trigger Control/Frequency Note
DIMPLS Internal oscillatory frequency Internal oscillatory /External
Operational frequency : 381.67 kHz frequency can be changed, when it
: 200 Hz
5

is operating.

5
External oscillatory frequency
DIMMER is adjusted by : 476.6 kHz/515.7 kHz
1 BACKLIGHT TP : PWRBL DC 8.0 V ± 0.2 V TP : BLP 16.3 V ± 3 V the Duty. PWRBL, MBLPW, BLCLK, DIMPLS
(Operational frequency range : conforms to the hardware
430 kHz to 530 kHz) specifications.
SYNC INPUT DUTY 90%

DIMPLS An output voltage range in product


2 BLERR - - TP : BLERR1 0.981 V to 2.742 V -
(Duty 100%) normal operation

REGULATOR
No Adustment/Check Item Input Point Input signal Measurement point Check/Adjustment Trigger Note
1 GD33V TP : PWRVI DC8.1 V ± 0.2 V TP : GD33V 3.4 V ± 0.2 V MONPW TP : MONPW +3.0 V to +3.3 V

6
6

MONPW
2 GD12V TP : PWRVI DC8.1 V ± 0.2 V TP : GD12V 1.2 V ± 0.1 V TP : MONPW +3.0 V to +3.3 V
(GD33V)

A timing signal from the GERDA to the LCD module may destroy the built-in driver IC of the LCD module depending on its timing.
Please pay attention if you are going to control the GERDA directly with jigs.

When executing the display test mode with the UART etc., conform to the product movement for the time from the power on to
the reset cancellation/communication start, etc.

COMPOSITE SIGNAL

AVH-P3200BT/XNUC
No Adustment/Check Item Input Point Input signal Measurement point Check/Adjustment Trigger Note
Please do not input the signal when

7
7

composite signal you don't turn on the power supply.


1 composite TP : MOVBS - Display confirmation -
1.0 Vp-p ± 1%(at white 100%)
Check signal : Color bar, 10step

ANALOG-RGB SIGNAL
No Adustment/Check Item Input Point Input signal Measurement point Check/Adjustment Trigger Note
csync signal
HI Level 2.5 V more than 3.3 V
TP : CSYNC
less than Please do not input the signal when
1 analog-RGB LOW Level 1.5 V less than - Display confirmation - you don't turn on the power supply.
TP : ANAG 1.1 Vp-p at +2.4 V offset signal
TP : ANAB
TP : ANAR
8

8
103
E
A

D
C

F
B
1 2 3 4

9. EXPLODED VIEWS AND PARTS LIST


NOTES : Parts marked by " * " are generally unavailable because they are not in our Master Spare Parts List.
The > mark found on some component parts indicates the importance of the safety factor of the part.
A
Therefore, when replacing, be sure to use parts of identical designation.
"
Screw adjacent to mark on the product are used for disassembly.
For the applying amount of lubricants or glue, follow the instructions in this manual.
(In the case of no amount instructions,apply as you think it appropriate.)
9.1 PACKING

BT/RD
D DVD/RC
DVD/RD
DVD/RI

BT/UC
DVD/UC

BT/UC
BT/RD

AVH-P3200BT/XNUC
104
1 2 3 4
5 6 7 8

(1) PACKING SECTION PARTS LIST


Mark No. Description Part No. Mark No. Description Part No.

1 Cord Assy CDP1301


2 Screw Assy See Contrast table (2) 11 Clip Holder See Contrast table (2)
A
* 3 Polyethylene Bag CEG-127 12 Cushion See Contrast table (2)
4 Screw See Contrast table (2) 13 Remote Control Unit See Contrast table (2)
5 Screw TRZ50P080FTC 14-1 Owner's Manual See Contrast table (2)
14-2 Owner's Manual See Contrast table (2)
6 Cover See Contrast table (2)
7 Unit Box See Contrast table (2) 14-3 Owner's Manual See Contrast table (2)
8 Contain Box See Contrast table (2) 14-4 Installation Manual See Contrast table (2)
9 Protector CHP3952 * 14-5 Warranty Card See Contrast table (2)
10 Microphone Assy See Contrast table (2)

(2) CONTRAST TABLE B


AVH-P3200BT/XNUC, AVH-P3250BT/XNRD, AVH-P3200DVD/XNUC, AVH-P3250DVD/XNRC, AVH-P3250DVD/
XNRD and AVH-P3250DVD/XNRI are constructed the same except for the following:
Mark No. Description AVH-P3200BT/XNUC AVH-P3250BT/XNRD AVH-P3200DVD/XNUC
2 Screw Assy CEA3559 CEC3542 CEA3559
4 Screw CRZ50P090FTC Not used CRZ50P090FTC
6 Cover CEG1359 CEG1356 CEG1359
7 Unit Box CHG7171 CHG7172 CHG7167
8 Contain Box CHL7171 CHL7172 CHL7167

10 Microphone Assy CPM1083 CPM1083 Not used


11 Clip Holder CZN7912 CZN7912 Not used C
12 Cushion CZN7913 CZN7913 Not used
13 Remote Control Unit Not used CXE2833 Not used
14-1 Owner's Manual CRB3174 CRB3180 CRB3174

14-2 Owner's Manual CRB3175 CRB3181 CRB3175


14-3 Owner's Manual CRB3176 CRB3276 CRB3176
14-4 Installation Manual CRD4452 CRD4454 CRD4452
* 14-5 Warranty Card CRY1276 Not used CRY1276

Mark No. Description AVH-P3250DVD/XNRC AVH-P3250DVD/XNRD AVH-P3250DVD/XNRI


2 Screw Assy CEC3542 CEC3542 CEC3542
4 Screw Not used Not used Not used
D
6 Cover CEG1356 CEG1356 CEG1356
7 Unit Box CHG7168 CHG7169 CHG7170
8 Contain Box CHL7168 CHL7169 CHL7170

10 Microphone Assy Not used Not used Not used


11 Clip Holder Not used Not used Not used
12 Cushion Not used Not used Not used
13 Remote Control Unit CXE2833 CXE2833 CXE2833
14-1 Owner's Manual CRB3177 CRB3180 CRB3177

14-2 Owner's Manual CRB3178 CRB3181 CRB3182


14-3 Owner's Manual CRB3179 CRB3276 Not used
E
14-4 Installation Manual CRD4453 CRD4454 CRD4455
* 14-5 Warranty Card Not used Not used Not used

AVH-P3200BT/XNUC
5 6 7 8
105
1 2 3 4

Owner's Manual,Installation Manual


Part No. Language

CRB3174 English
A
CRB3175 French

CRB3176 Spanish(Espanol)

CRD4452 English, French, Spanish(Espanol)

CRB3177 English

CRB3178 Traditional Chinese

CRB3179 Korean

CRD4453 English, Traditional Chinese, Korean

CRB3276 English
B
CRB3180 Spanish(Espanol)

CRB3181 Portuguese(B)

CRD4454 English, Spanish(Espanol), Portuguese(B)

CRB3182 Arabic

CRD4455 English, Arabic

AVH-P3200BT/XNUC
106
1 2 3 4
5 6 7 8

AVH-P3200BT/XNUC
5 6 7 8
107
1 2 3 4

9.2 EXTERIOR(1)

BT/RD
A
DVD/RC
DVD/RD
DVD/RI

B F

C D

B
A

D A

F D
B

AVH-P3200BT/XNUC
108
1 2 3 4
5 6 7 8

(1) EXTERIOR(1) SECTION PARTS LIST


Mark No. Description Part No. Mark No. Description Part No.

1 Screw BMZ26P040FTC 20 Cushion CNN3208


2 Screw BSZ26P100FTC A
3 Screw BSZ26P160FTC 21 Lighting Conductor CNW1773
4 FFC CDE9118 22 Holder CNW1775
5 FFC CDE9119 23 Touch Panel CSX1153
24 Grille Unit See Contrast table (2)
6 Cord Assy CDP1301 25 Door(USB) CAT2914
7 Cap CNS1472
8 Resistor RS1/2PMF102J 26 Screw AMZ20P030FTC
9 Case CNB3544 27 Screw(M2 x 2) CBA1771
10 Holder CND4809 28 FFC CDE9139
29 Holder CND5462
11 Heat Sink CNR2052 30 Holder CND5463 B
12 Screw BPZ20P080FTC
13 Button( - + ) CAI2717 31 Insulator CNN3205
14 Button( < > ) CAI2718 32 Service Unit(Monitor PCB) CXX2763
15 Button(SRC, MUTE) CAI2719 33 Cushion CNN3049
34 LCD CWX3868
16 Button(MENU, MODE) CAI2720 35 Remote Control Unit See Contrast table (2)
17 Button(RESET, EJECT) CAI2721
18 Screw(M2 x 3) CBA1877 36 Cover See Contrast table (2)
19 Cover CNN2628 37 Service Unit(Keyboard PCB) CXX2764

C
(2) CONTRAST TABLE
AVH-P3200BT/XNUC, AVH-P3250BT/XNRD, AVH-P3200DVD/XNUC, AVH-P3250DVD/XNRC, AVH-P3250DVD/
XNRD and AVH-P3250DVD/XNRI are constructed the same except for the following:
Mark No. Description AVH-P3200BT/XNUC AVH-P3250BT/XNRD AVH-P3200DVD/XNUC
24 Grille Unit CXE2609 CXE2612 CXE2614
35 Remote Control Unit Not used CXE2833 Not used
36 Cover Not used CZN5357 Not used

Mark No. Description AVH-P3250DVD/XNRC AVH-P3250DVD/XNRD AVH-P3250DVD/XNRI


24 Grille Unit CXE2616 CXE2616 CXE2616
35 Remote Control Unit CXE2833 CXE2833 CXE2833
36 Cover CZN5357 CZN5357 CZN5357 D

AVH-P3200BT/XNUC
5 6 7 8
109
1 2 3 4

9.3 EXTERIOR(2)

BT/UC A
BT/RD B
E

C H

C
A

B
D

D
C B
E

AVH-P3200BT/XNUC
110
1 2 3 4
5 6 7 8

(1) EXTERIOR(2) SECTION PARTS LIST


Mark No. Description Part No. Mark No. Description Part No.

1 Screw ASZ26P050FTC 15 Cord Assy See Contrast table (2)


2 Screw BMZ25P040FTB A
3 Screw BMZ26P040FTC 16 Holder CND4811
4 Screw BSZ26P060FTC 17 Holder CND4814
5 FFC CDE9121 18 Holder CND5475
19 Holder See Contrast table (2)
6 Chassis CNA3156 20 FM/AM Tuner Unit See Contrast table (2)
7 Chassis CNA3157
8 Bracket CND5470 21 Holder CND4324
9 Insulator CNN2764 22 Bluetooth Module See Contrast table (2)
10 Service Unit(Mother Assy) See Contrast table (2) > 23 Fuse(10 A) YEK5001
24 DVD Mechanism Module(LS1) CXK6811
11 Screw See Contrast table (2) 25 Gasket CNN3364 B
12 Screw BPZ26P080FTC
13 Screw BSZ26P060FTC 26 Holder CND5502
14 FFC CDE8747

(2) CONTRAST TABLE


AVH-P3200BT/XNUC, AVH-P3250BT/XNRD, AVH-P3200DVD/XNUC, AVH-P3250DVD/XNRC, AVH-P3250DVD/
XNRD and AVH-P3250DVD/XNRI are constructed the same except for the following:
Mark No. Description AVH-P3200BT/XNUC AVH-P3250BT/XNRD AVH-P3200DVD/XNUC
10 Service Unit(Mother Assy) CXX2760 CXX2759 CXX2757
11 Screw ASZ26P050FTC ASZ26P050FTC Not used
C
15 Cord Assy CDE9124 CDE9124 Not used
19 Holder CND5572 CND5473 CND5574
20 FM/AM Tuner Unit CWE2097 CWE2098 CWE2097

22 Bluetooth Module CWX3865 CWX3865 Not used

Mark No. Description AVH-P3250DVD/XNRC AVH-P3250DVD/XNRD AVH-P3250DVD/XNRI


10 Service Unit(Mother Assy) CXX2754 CXX2755 CXX2756
11 Screw Not used Not used Not used
15 Cord Assy Not used Not used Not used
19 Holder CND5517 CND5517 CND5517
20 FM/AM Tuner Unit CWE2098 CWE2098 CWE2098
D
22 Bluetooth Module Not used Not used Not used

AVH-P3200BT/XNUC
5 6 7 8
111
1 2 3 4

9.4 DVD MECHANISM MODULE

A
(C)
(C)

B
B

(A)

(C)

(B)
G
D B C
C
(A)
D
C
(A)

(C)

(A)
(A)

(C)
D F

(A) (C)

(C)

A
G (C)
E

D (C)

E F
(A) : GEM1045
F
(B) : GEM1038
(C) : GEM1024

AVH-P3200BT/XNUC
112
1 2 3 4
5 6 7 8

DVD MECHANISM MODULE SECTION PARTS LIST


Mark No. Description Part No. Mark No. Description Part No.

1 Screw BMZ20P020FTC 50 Holder CNW1195


2 Screw BSZ20P040FTC A
3 Screw(M2 x 4) CBA1835 51 Damper CNW1197
4 Washer CBF1038 52 Damper CNW1198
5 Spring CBH2860 * 53 Connect PCB Unit CWX3618
54 •••••
6 Spring CBH3010 55 •••••
7 Spring CBH3011
8 Spring CBH3012 56 Motor(M2)(SPINDLE) EXM1050
9 Spring CBH3013 57 Screw Unit CXC8894
10 Spring CBH3014 58 Chassis Unit CXC8895
59 Arm Assy CXC8896
11 Spring CBH3015 60 Washer CBF1037 B
12 Spring CBH3016
13 Spring CBH3017 61 Washer CBF1038
14 Spring CBH3018 62 Arm CND4554
15 Spring CBH3019 63 Collar CNV6906
64 Roller CNW1196
16 Spring CBH3020 65 Gear Unit CXC8893
17 Spring CBH3030
18 Plate Spring CBL1797 66 Screw IMS20P030FTC
19 Cable CDE8631 67 Motor Unit(M1)(LOAD/CRG) CXC4026
20 Pickup Unit(Service) CXX2398 68 Screw JFZ20P025FTC
69 Screw JGZ17P022FTC C

21 Bracket CND4553 70 Washer YE15FTC


22 Arm CND4555
23 Lever CND5398 71 Screw IMS20P030FTC
24 Frame CND4557 72 DVD Core Unit YWX5013
25 Frame CND4558

26 Sheet CNN2280
27 Rack CNW1170
28 Guide CNW1171
29 Roller CNW1172 D
30 Arm CNW1173

31 Arm CNW1174
32 Roller CNW1175
33 Lever CNW1176
34 Arm CNW1177
35 Arm CNW1178

36 Gear CNW1180
37 Gear CNW1181
38 Gear CNW1182 E
39 Gear CNW1183
40 Rack CNW1184

41 Gear CNW1185
42 Gear CNW1186
43 Gear CNW1187
44 Gear CNW1188
45 Clamper CNW1190

46 Arm CNW1191
F
47 Arm CNW1192
48 Holder CNW1193
49 Holder CNW1194

AVH-P3200BT/XNUC
5 6 7 8
113
1 2 3 4

(A)
(A)

(C)
B
(C)

(C) (C)
(C) (C)

(C)
(A)

(A)

(A)

(A) : GEM1045
F (B) : GEM1038
(C) : GEM1024

AVH-P3200BT/XNUC
114
1 2 3 4
5 6 7 8

AVH-P3200BT/XNUC
5 6 7 8
115
1 2 3 4

10. SCHEMATIC DIAGRAM


10.1 MOTHER UNIT(AUDIO)
A Note: When ordering service parts, be sure to refer to " EXPLODED VIEWS AND PARTS LIST" or
"ELECTRICAL PARTS LIST".

AV_LOUT1

PA_RR
PA_FR
PA_RL
PA_FL
A 2/6

3.7V
3.7V
3.7V
3.7V
ANA-SYS BUS

DAN202U
BT_TEL

D161
A 5/6 ANA-I/F BUS
REARMUTE2

RCA_SWR
RCA_SWL

RCA_RR
AUX_AGND

RCA_FR
RCA_RL
BUSL+

AUX_L

RCA_FL
ONSEI+
1EQ_2BT

BUSL-
ONSEI-
MIC_BIAS

REARMUTE1

R202 R204 R203 R205 RCAMUTE


P,Q 12.3V EV12
0V

0V
0V
0V

0V
0V

0V
0V

1.8k 2.7k 1.8k 2.7k


B
A 4/6 NM

R224
R206 R208 R207 R209

R222

NM
1.8k 2.7k 1.8k 2.7k
C236
NM GNDA
AMPPW
MIC GND

SYSMUTE

1u/10

C232

C231
MICin

47u/16
GNDA

0.1u/16
C233

C238
10u/16

10p/50
E-VOL OU
C218

C239
GNDA FM(100%)UC: +9
1u/10 FM(100%)ES: +9
E-VOL INPUT AM(30%)UC: -0
64
63
Svin_FL 62
61
60
59
58
57
56
55
54
53
52
51
Front_R 50
49
FM(100%)UC:-14.0 dBs AM(30%)ES: -0
Rear_L

N.C.11
Tout_FL

Pre_SWL
N.C.13

N.C.12
Front_L

PGND
N.C.14

Pre_SWR
Rear_R
N.C.10
VP
Pref
C217 1u/10 1 48 FM(100%)ES:-14.0 dBs IP-BUS:+14
2 47 C219 AM(30%)UC:-24.0 dBs AUX:+14
R225
NM

3
Svin_RL Svin_FR
Tout_FR 46 1u/10
AM(30%)ES:-24.0 dBs VCR:+14
C234 Tout_RL IP-BUS: +2.2 dBs
ANA-SOC BUS

4 N.C.1
Svin_RR iPod(AUX):+13
NM 0.22u/50
APF_2 IC201 Tout_RR
45 C220 AUX: +2.2 dBs USB/SD:+14
C201 5 PML020A 44 1u/10 VCR: +2.2 dBs DVD/CD:+14
GNDA C235
APF_1 Svin_Pre iPod(AUX): +1.3 dBs NAVI GUIDE:+14
6 E. VOL IC INPUT 43 C221
0.22u/50 N.C.2 Tout_pre USB/SD: +5.2 dBs BT:+14
7 1 - 42 1u/10 DVD/CD: +5.2 dBs
IN1L N.C.9 NAVI GUIDE: +2.2 dBs
C207 1u/10 8 2 AV SEL. 41
IN2L IN1R
R226
BT: -1.8 dBs
9 3 B.T. TEL. 40 C208 1u/10 AV_ROUT1 PA_FL
IN3L IN2R
10 4 IP BUS 39

C202
NM PA_FR

NM
C C211 1u/10 11
N.C.3
5 NAVI GUIDE
IN3R
38
IN4L+ N.C.8
C213 1u/10 12 MIC for AEQ 37 C212 1u/10 BUSR+ PA_RR
IN4L- IN4R+
13 36 C214 1u/10 GNDA
BUSR- PA_RL
NM

SA_TEST_OUT

N.C.4 IN4R-
R377

MIC_AMP_Out

R227 R229 C215 1u/10 14 35


2.7k
IN5L N.C.7
TEST_OUT

R228 2.7k
SA_TEST

C216 1u/10 15 IN5G DVCC 34


DC_filter

IN5R MUTE
SACLK
MIC_in

DGND

5.6k
DATA
N.C.5
N.C.6

16 33 SYS+B
GND
VCC

CLK
STB
Cref

R376 8.4V

0 EVSTB
17
18
19
AEQT 20

21
22
23
24
25
26
27
28
29
30
31
32

R220
R223

R221
NM

NM
47k

C237 EVDATA
EVCLK
NM

NM

NM
NM

NM

10p/50
EVSACLK
R211

NM R210

C226
NM

NM

C225

0.47u/10

10u/16

EVSAOUT
C228

C227

C230

C229
NM

NM
0.1u/10

0.1u/10
AEQ
Q201

R219
R218

R217

R216
R215

C222
C223
2.2u/10
NM
NM
R214

R212

R213
NM

NM

NM
C224

TELMUTE

D
GNDA GNDA

0V VCR_VGND
0V VCR_V
SOC_V PBSENS
0V BC_VGND
AV SELECTOR INPUT 0V BCAM_IN
FM(100%)UC:-10.0 dBs 0V AUX_VGND
FM(100%)ES:-14.0 dBs 0V AUX_V
AM(30%)UC:-20.0 dBs
LS_V
AM(30%)ES:-24.0 dBs
NM
NM
R252

R260

R261

R266
R265

1u/10 R256
R257
NM

470

1u/10

AUX: +2.2 dBs


1u/10

VCR: +8.2 dBs AV SELECTOR


1u/10

iPod(AUX): +1.3 dBs


C279
NM

1u/10

BSENS
VIN7 50 C284
49 C283
1u/10

48 C268
47 C269
46 C271
45 C272
44 C273
43 C274
42 C276

C277
C278

USB/SD: +5.2 dBs GNDD ASENS


DVD/CD: +5.2 dBs
C291

C290
22u/16
0.1u/10

BGSENS
51
52

41
VRET1 40

ISENS
VRET3

VRET2
VRET4
VRET6

VRET5
VRET7

VIN2
VIN3
VIN4
VIN6

VIN5

1 39
VGND2 VIN1
0V GNDV 1u/10 2 38
LS_L LIN1 VREG GNDV
C251 3 VIDEO AUDIO 37
ARET1 AVSCL
SCL
LS_R 0V C285 1u/10 4 1 LS1 LS1 36 AVSDA
RIN1 SDA NM R269 NM
C252 5 2 SOC SOC 35 R268
E ABIAS
VOUT1 34 C293
SOC_L 0V 6 3 mini mini 0.1u/16 MONVBS
LIN2 VDIN1
C253 7 4 VCR VCR 33 R270 NM R271 NM
GNDD ARET2 VOUT2
SOC_R 0V C267 1u/10 8 5 - TUNER 32 R272
RIN2 VDIN2 C292 NM
C254 9 6 B.Cam x 31 C294 0.1u/16 NM
AGND VGND1 R258
SYS+B 10 7 - x 30
LIN3 VDSAG2 GNDV
8.3V C281 NM NM
11 IC251 29
ARET3 VDOUT2
R251

NM

NM
12 BH7649KS2 28 C282
RIN3 VDSAG1 75 R259
ARET4

RCA_V
ROUT2
ROUT1
ARET5

24 LOUT2

VDOUT1 27 R273
LOUT1

13
25 VVCC
VBIAS
RIN4

RIN5
ADR

NM
LIN4

LIN5

AVCC
MONITO
SYS+B
NM

NM

C264 0.1u/10

C265 0.1u/10

17
NM

15

19

21
14

16

18

20

22
23

26
C266 22u/16

470 8.3V
R267
NM
R253
R254
R255

R262
R263
R264

C260
C259
C280
470
D252

C263
D251

3.8V
3.8V

3.8V
3.8V

R274 NM R276 NM
NM :
C255

AUX_AGND C270
C256

C257
C275
C258
1u/10

NM
1u/10
1u/10
1u/10

R275
C286
NM

R277
C289

C288

C287
22u/16

0.1u/10

GNDA
0.1u/10

NM
VCR_GND

RCA_VR
RCA_VL
VCR_R
AUX_R

VCR_L
AUX_L

GNDA CHIP SIZE LEG


F
GNDBE2

GNDV

A 6/6
1608
TUN_R
TUN_L

2125
0V

0V
0V

0V
0V

0V

AV_ROUT1
AV_LOUT1

ANA-TUN BUS 3216


0V
0V
0V

ANALOG BUS

A 1/6
AVH-P3200BT/XNUC
116
1 2 3 4
5 6 7 8

UMD2N

3 1C
2 2B
1E
1B
2C
4
5
A 1/6 MOTHER UNIT (AUDIO)
1 2E 6 model
P : AVH-P3200BT/XNUC

Q161

Q162
Q164

LTA124EUB

LTA124EUB
BUP_1 SYS+B Q : AVH-P3250BT/XNRD
DAN202U

14.4V 8.3V
J : AVH-P3200DVD/XNUC
D161

Q163
2SC4116(GRBL)

R160
K : AVH-P3250DVD/XNRC

10k
R152
UMD3N

1k

R161

47k
R163

R162
E2 4 3 C2 L : AVH-P3250DVD/XNRD

47k

4.7k

1SS352
D154
B2 5 2 B1
C1 6
M : AVH-P3250DVD/XNRI
1 E1
MUTE1 Q155
GNDA GNDA

100u/16
C160
AMPMUTE SYS+B
IC151 AMP

DAN202U
PA2030A
B

D153
R153 R155 8.3V
GNDA
68k 68k 0V 1
TAB 1.TAB
Q153 R154 R156 0V 2
W E1 1 6 C1
6.4V PW-GND2 2.PW.GND2
UTE 1.5k 100 FR- 3
B1 2 5 B2

4.7u/6.3
OUT2(-) 3.RR-

C161
C2 3 4 E2 4V 4
6.4V STBY 4.STBY
UMH1N FR+ 5
SYS+B OUT2(+) 5.RR+
E-VOL OUTPUT 8.3V 14V 6
FM(100%)UC: +9.1 dBs OFFMUTE VCC2 6.VCC1/2
D155 R157 7
FM(100%)ES: +9.1 dBs OFMUTE2 OFMUTE1 GNDA
FL- 6.4V
OUT1(-) 7.RL-
AM(30%)UC: -0.9 dBs 1SS352 10k 0V 8
6.4V PW-GND1 8.PW.GND1
AM(30%)ES: -0.9 dBs
2SC4081(QRS)

R158 D156 9
FL+
IP-BUS:+14.3 dBs
10u
DCH1201-A

OUT1(+) 9.RL+
Q154
C166

C164 10u/35 10
AUX:+14.3 dBs 100k RKZ8.2KG(B2) 7.7V
RIPPLE 10.SVR
R159

VCR:+14.3 dBs
47k

(CCG1236-A) 6V 11
iPod(AUX):+13.4 dBs 12
IN1 11.FLIN
6.4V
USB/SD:+14.3 dBs IN2 12.FRIN
DVD/CD:+14.3 dBs 0V 13
PRE-GND 13.S-GND
NAVI GUIDE:+14.3 dBs GNDA 6.4V 14
BT:+14.3 dBs IN4 14.RRIN
6.4V 15
C162 C165 IN3 15.RLIN
6.3V 16
C151 C155 AC-GND 16.ACGND
0.47u/16 0.47u/16 2.2u/10 2.2u/10 17
UT1 PA_FL RL+ 6.4V
OUT3(+) 17.FL+
PA_FR C152 C156 GNDA 0V 18
0.47u/16 0.47u/16
6.4V
19
PW-GND3 18.PW.GND3 C
RL-
OUT3(-) 19.FL-
PA_RR C154 C158 14.1V 20
VCC1 20.VCC3/4
0.47u/16 0.47u/16
PA_RL RR+ 6.4V 21
C153 C157 OUT4(+) 21.FR+
0.47u/16 4.2V 22
0.47u/16 MUTE 22.MUTE
RR- 6.4V 23
OUT4(-) 23.FR-
0V 24
PW-GND4 24.PW.GND4
25
14V H-SW/VOS-DET 25.B.REMOTE

1SR154-400
D151
D152

C163
0.1u/50
1SR154-400

C159

0.1u/50
VCC33 GND GND
3.3V
PBSENS
R128

47k

D124 L122
TE R134 BTH1101-A
D
C1
B2
E2

10k
6
5
4
R122

UMT1N
47k

DAN202U
0.01u/50
Q123

C126

C129

C121
0.1u/50
NM
C2
1
2
3
E1
B1

S GNDD R130
47k
GNDD GND
TELMUTE JA101
CKM1376-A
R125 R131 D125 FR-
L121 R136 FR-
RR- 1 FR- 6.4V
47k 4.7k RR-
BTH1101-A 15k FR+ 2 RR- 6.4V
FR+
C127

DAN202U 3 FR+ 6.4V


ASENS RR+
0.1u/50

ASEN2 ASEN1
RR+

POWER SUPPLY
D122 4 RR+ 6.4V
R123 HZU7L(A1) GNDD FL-
FL-
RL- 5 FL- 6.4V
R137 10k RL-
BSEN2 FL+ 6 RL- 6.4V
NM
BSENS BSEN1
FL+
C1
B2
E2

7 FL+ 6.4V
6
5
4

D123 RL+
UMX 1 N

R124
R126

R133

C124

NS RL+
0.1u/50
Q1 2 2

47k

4.7k

PB 8 RL+ 6.4V
BSEN3 100k HZU7L(C3) 0V
2SC4081(QRS)

D127 MUTE 9 P.B.


R127
47k

R139 RKZ20KG(B2)
C2
1
2
3
E1
B1

6.4V
BREM 10 MUTE
Q125

10k 13.8V
ILM 11 B.REM
R140

R138
10k

GNDD 0V ILM
BGSEN 12
NM GNDD 0V
ACC1 13 BGSENS
GNDD GND2 11.2V E
14 ACC
GND3 GND1 0V
15 GND
VCC33
3.3V 14.1V 16
BUP_1 B.UP
BUP1
BUP2
BUP3
R132

BGSENS
100k

ISEN GND
ISENS R121 D121 14.4V
CEAT332M16-P35

1SR154-400
1SR154-400

D126
CTH1221-A

10k 1SS352 RKZ5.6KG(B2)


3300u/16

Q121
LTC114EUB

LTC114EUB BGSEN2 R135 L123


C123

R129

NM

C101

D101
D102

FM(100%)UC:+30.7 dBs
L101
0.1u/50
C122

CTF1295-A
MONITOR VBS ADJUST
1u/10

10k
FM(100%)ES:+30.7 dBs
C125
Q124

0.1u/50

C128
0.1u/50

AM(30%)UC:+20.7 dBs
AM(30%)ES:+20.7 dBs
IP-BUS:+35.9 dBs
GNDD GNDD AUX:+35.9 dBs
VCR:+35.9 dBs
iPod(AUX):+35.0 dBs
NM : No Mount USB/SD:+35.9 dBs
NOTE : DVD/CD:+35.9 dBs
Symbol indicates a resistor. NAVI GUIDE:+35.9 dBs
BT:+35.9 dBs
CHIP SIZE LEGEND No differentiation is made between chip resistors and
101 KEY & REM F
1608 discrete resistors.
2125 131 SENS
3216 181 IF CONNECTOR Symbol indicates a capacitor.
301 AV SELECTER No differentiation is made between chip capacitors and
371 MONITOR VBS ADJUST
discrete capacitors.
A 1/6
AVH-P3200BT/XNUC
5 6 7 8
117
F
E
B
A

D
C

118
A-a
A-a

A-a

A 2/6
A-b
A-b

A-b

1
1

Guide page
Large size

Detailed page
SCH diagram

SYS-DRV BUS

SYS-IF_1 BUS

INNER BUS

DRST
FLMD0

S_MSTX
MS_SRX
SYS-PWR BUS

SYS-IF_2 BUS

2
2

BZ
REMIN

N_to_S
S_to_N
RESET

IP_to_S
S_to_IP
RGBARI

ASENBO
GUIDEON
ANA-SYS BUS

ASENS
BSENS
R642

GNDD
CKS5757-A
47k

VCC33

CN601
47k
R644
R640
1 GNDD

RST
R603 NM
2 DCK
3 GNDD

47k
R641
R604 NM
4 RESET

NM
A-a 2/6

FLMD0 R605 NM
5 FLMD0
R606 NM
6 DMS
INNER BUS

GNDD
R607 NM
SYS-IF_2 BUS
SYS-IF_1 BUS

7 DRST
SYS-DRV BUS

SYS-PWR BUS

100k

2
ANA-SYS BUS

GNDD
1

Q601
R609

VDD
R608

OUT
NM DDI
8
R610 NM

1k
15p/50
C610
9 DDO

AVH-P3200BT/XNUC
15p/50
1SS352

R611
C609

2SC4081(QRS)
D601

IC601
10 VDD33
10.2 MOTHER UNIT(SYSTEM)(GUIDE PAGE)

3
4
11 VDD33

R612
R614
NC
1u/10

S-80827CNNB-B8M
VSS
1 2
C601

12 GNDD

X601
SYSTEM MICOM

13 NC

100k
100k

NM
R613
CSS1790-A
GNDD

3.93216MHz

3.3V
10
R643

3
3

VDD33
R655
VDD33

NM
3.3V

R647
R646
R639

4.7k

L602
NM

R622
R617
R645
R616
R615

R621
NM
NM

C613
C614

CTF1346-A
100

CTF1346-A
100k
L601

1k
R635
R681

47k
C602

4.7k
4.7k
R620
R619

NM
NM
0.1u/10

0.1u/10

NM
NM

C604
C605

100k

0.1u/10

GNDD
TSI
W2
W1

TCK

47k
47k

TSO
R731
W3
FLMD0

R618
RESET
4.7u/6.3

GON
C603

44
43
42
41
40
39
38
37
36
35
34
33
32
31
30
29
28
27
26
25
24
23
22
21
20
19
18
17
16
15
14
13
12
11
10
5

9
8
7
6
4
3
2
1

NC

X2
X1
0.1u/10

4.7k
4.7k

NC
NC
NC

TSI
NC

NC
NC
NC
NC
C611

NM

XT2
XT1
KDT01
R624
R623
R670

TCK
NC4
VSS
NC3
NC2
NC1

TSO
VDD

TXIE
RXIE
BEEP
AVSS

45

DRST
R625

REGC
NC2 176

TXLS1
RXLS1
EVSS1
FLMD0

EVDD1
RESET
REMIN

TXNAVI
/ASENS
/BSENS

RXNAVI
AVREF1
AVREF0

NC

/RGBARI

ASENBO
/H&OSW
46

GUIDEON
NC30 175 470 R626 KDT0

MOTPWR2
KDT0
R627 47k 47 DDI KDT1 174 KDT11 470 R634 NM KDT1
DDO TEMPSEN
48 173 NM PNLADX TEMPSEN1
R656
DCK PNLADX NM
R628 47k 49 PNLADY
172 R652 R657 NM
DMS PNLADY NM
R629 47k 50 PNLADCRT
SOtoS 171 R653 R658 NM
RXSOC PNLADCRT NM
3216
2125
1608

R630 47k 51
StoSO POS
170 R654 POS
TXSOC
R694 NM 52 169
ILMLD
*1

ILMLD TUNSL
R695 NM 53 168 C612 R675 100
ILMDT
CHIP SIZE LEGEND

ILMDT BLERR1
NM 54 167 BLERR1
ILMCK R696 NC R601 NM EVSAOUT
ILMCK 0.01u/16
J

P
K

TP609 55
Q
M

166 R714 NM MICSENSR


NC NC
TP610 56 165 R715 NM MICSENSL
NC SAIN RB751V-40
TP611 57 164 SAIN
D602 R712 WIREDAD
NC MICSENR
MODEL Number

RI

10k
BR
RD
UC
RD
RC
UC

TP636 58 163 WIRED


NC MICSENL D603 R713
TP637 59 162
NC WIREDAD RB501V-40
TP638 60 161 100k

4
IC602
Sys-uP
4

NC WIRED
61 160
PE5727A8
PE5726A8
PE5725A8
PE5727A8
PE5727A8
PE5727A8
PE5725A8

NC MODEL3
62
*1

159 R648
NC MODEL2 R734
63
R737

MODEL1 158 R649 R735


NC
64 157
MODEL0 R650 R736
NC
MODEL SEL

65
R651

HIOUTCLK R724 470 156 R651


HIOUTCLK MVIPW R737
66 MVIPW C606 PWGR
IC602

AVSDA R680 220 R632 1.8k 155


AVSDATA BVSS2
UPD70F3480

67
R736

AVSCL R679 R633 1.8k 154 0.1u/10 L605


220
AVSCK BVDD2
L603 CTF1346-A 68 153 CTF1346-A PNLVD
EVDD2 PNLVD
69
R650

C607 152 PNLYV


EVSS2 PNLYV
DESTINATION

0.1u/10 70 151 TESTIN2 PNLXV


NC9 PNLXV
71
R735

R716 150
NC TESTIN R660 47k
72 149 47k R711 ISENS

BTESTIN
47k BTTESTIN /ISENS
R649

R665 73 148 BGSENS


BTTESTMD /BGSENS
BT_SRX R663 NM 74 147 PBSENS
47k BTRX PBSENS
R734

S_BTTX R664 NM 75 146 TELMUTE

TESTMD
BTTX TELMUTEIN
76 145
BT H/F

BTRST
/BTRST NC
R648

BTMICMUTE TP644 R702 47k 77 144


BTMICMUTE NC
78 143
NC NC
5 6 7 8

A-b 2/6 model


P : AVH-P3200BT/XNUC
Q : AVH-P3250BT/XNRD
A
BT + SD G CN7502
J : AVH-P3200DVD/XNUC
K : AVH-P3250DVD/XNRC

SDW

GND
DGND

DGND
SDCMD
GNDBT

SDDET

SDCLK
SYS+B

VCC33
SDDAT0
SDDAT1

SDDAT3

SDDAT2
BT33

BT_SRX
BT_RST

S_BTTX
BT_SPK1N
L : AVH-P3250DVD/XNRD

BT_SPK1P
BT_MIC1N
BT_MIC1P
SDCD>SDDET
SDWP>SDW
M : AVH-P3250DVD/XNRI

10
11
12
13
14
15
16
17
18
19
20
21
22
1
2
3
4
5
6
7
8
9

3.3V
CN795

3.3V

3.3V

3.3V

0V
0V

3.3V
3.3V

0V

0V
3.3V

3.3V
0V

0V
0V

3.3V
0V
0V
CKS6184-A-T
A 2/6 MOTHER UNIT (SYSTEM)

470u/10

SDCMD
BTMIC1P

S_BTTX

SDDET
BTSRX
BTRST
BTSPK
GNDD

SDDAT0
SDDAT1

SDW
SDDAT3
GND
P,Q

C795

VCC33
BT33

3.3V
401 TUNER
GNDBT 451 LS1
501 BT
601 SYSTEM MICOM

SYS-DRV BUS
A 5/6
SYS-I/F_1 BUS

A 5/6

REARMUTE1

BT_SRX
BT33

S_BTTX
C797

BTRST
NM
B
PNLVD
PNLYV
PNLXV

BTMICMUTE

R797

NM

SYS-PWR BUS
R798 A 3/6

VDCNT8
VDCNT5
1EQ_2BT

NM
BTGND

SYS-I/F_2 BUS
A 5/6

VDCNT5

SYSPW
BT_TEL

SPDIF
ANA-SYS BUS
A 1/6
AMPPW

Q795
BGSENS

SYSMUTE
PBSENS

LS_R
LS_V
TELMUTE

LS_L
ISENS

SDCMD
NM

SDDET

SDCLK
SDDT0

SDDT1

SDDT3

SDDT2
EVSACLK
NM
R795

C798
NM

SDW
NM
R729 SYS-SOC BUS

GNDBT GNDBT A 4/6


VDCNT5
47k

NM
CTF1346-A

R730
L605

SYS-TUN BUS
R660

A 6/6
FLPLES

NC26
R711
TESTIN2
0.1u/10

R710

R636
100k

100k

C
47k
154
153
152
151
150
149
148
147
146
145
144
143
142
141
140
139
138
137
136
135
134
133
NC
NC
NC
NC
NC
NC

NC

132
NC
NC

NC26
FLMD1
BVDD2
PNLVD

PBSENS
PNLYV
PNLXV

/BGSENS

NC
TESTIN

TELMUTEIN
/ISENS

/FLAPLESS

131 AMPPW
AMPPW
130 SYSPW
SYSPW
129 R709
22k
AMPMUTE
128 R631
22k
REARMUTE
127 R706 22k
/RDSLK
/RDS57K
126 R705
22k P,J
125 R707 22k
RDT
124 L604 CTF1346-A
BVDD1
123 C608
0.1u/10
BVSS1
122
NC
121 FLPILM
FLAPILM
120 SOCTEST
NC
ESTINATION BT H/F 119 R671
NC
6 R650 R735 R649 R734 R648 118 100k
NC
117 SOAMUTE
SOCAMUTE
116 SOCIRQ
SOCIRQPW
115 SOCRES
/SOCXRST
LS1
RDSLK

TUNSL
HSLK

114
RDT

VD8
113
VD8
CN751
VD5 CKS3871-A
112 AMUTE 8.0V VD8
AMUTE 8.0V
111 SYS+B 30 VD8
IRQPW IRQPW 8.3V VD5 8.0V
29 VD8
/XRST
110 /XRST R751 0.1u/10 8.0V
28 VD8
D
6 C1
5 B2
4 E2

109 GNDDDC 0V PGND


NC14 1k
27 PGND
108
C751
UMD3N

NC13 0V PGND
Q751

26 PGND
107 GNDDDC 0V
NC12 DGND
25 PGND
106 CLKOUT 5.1V 5.1V
E1 1
B1 2
C2 3

CLKOUT 24 VD5
105 AEQAUXSW R752 AMUTE
AEQAUXSW AMUTE 470 3.3V
R602 23 AMUTE
104 SACLK R753 XRST
SACLK /XRST 1k 3.3V
22 XRESET
103 0 EVSTB IRQPW 0V
EVSEL IRQPW 220 R754
21 IRQPWR
102 EVCLK
EVSCK S_MSTX 220 R755 HSTCMD 3.3V S LS1TX

EVSDA
NC10
101
100 R637
EVDATA MS_SRX
STNBY
220
220
R756 SLVSTS
R757 STANBY
3.3V
3.3V
LS1 SRX
20
19
HSTCMD
SLVSTS C
18
/MONIRST
99 47k GNDA
STANBY
AGND
CN1901
TXMON
98 R638 P,J R758 LSR 0V LS_ROUT
17
16 ANAROG_ROUT
97
RXMON NM
47k 15 AGND
96 22k R667 RCK R759
/RCK LSL 0V LS_LOUT
14 ANALOG_LOUT
95 LDET
/LDET NM
13 AGND
94 R760 LSV GNDA
NC 0V
12 COMPOSIT
93 GNDV
NC R708 0 0V
92 470 DDCCLK
DVD/CD: +5.2 dBs GNDV
11 VIDEO_GND
DDCCLK 0V
R763

WAKEUP
C2

10
B1
E1

4.7k

/SOCSTB 91
3
2
1

SOCSTBY
RT3C99M
BTMICMUTE

/STB
BTTESTMD

0V 9 D-
/TUNPCE2
BTTESTIN

Q752
TELBEEP

90
DIMMER

TUNPDO

STNBY
TUNPCE
BLSYNC
MFLPW

TUNPDI
AVSCK

/BTRST
EVDD2

0V D+
EVSS2

470 8
BTRX

89
BTTX

TUNCK S_PDIF
NC9

TUNPCK 0V
4
5
C1
6
E2
B2
NC
NC

NC

7 DGND
R762

Q,K,L,M
4.7k

R704 R761
SYS-TUN BUS

1.6V
6 IECOUT
67
68
69
70
71
72

73
74
75
76
77
78
79
80
81
82
83
84
85
86
87
88

100 0V
5 DGND
TP645
TP646

GNDA
BTESTIN 0V 4 SCL
TESTMD GNDD
0V 3 SDA
E
R703

470

0V 2 CPRST
750
R633 1.8k

R665

NM
NM
47k

47k
C607

R716

VCC33
0.1u/10
CTF1346-A

S_TTUN 0V
3.3V GNDD 1 CPRDY
T_STUN DGND
L981
47k

TUNCE2 CTF1473-A
TUNCE PNLVD
R699
R700
R701
R702
L603

PNLADCRT
SYS-SOC BUS

ANA-SYS BUS

PNLXV
SYS-PWR BUS

3
4
5
NM

NM
220

PNLYV
3
4
5

PNLADY R982 NM PLXV


6 Q982 1
FMG12
R990
10k

Q981
TP644

PNLADX C1 E1
5 2
R679

R983 NM PLYV
R663
R664

B2 B1
3 R992
1SS352

4
D981

1
R989
NM

E2 C2
2

UMF5N 10k
R985 NM ADVX
R984 NM ADVY
AVSCL

PLYV
INNER BUS

1000p/50

6 Q983 1
R991

C983

R986

R981
10k

R987

ANA-SYS BUS
1k

1k
1M

C1 E1
AEQAUXSW

5 2
B2 B1 C982
4 3 R993 0.047u/10
C985
0.1u/10

E2 C2
10k C981
SYS-IF_2 BUS UMF5N
GNDD 0.047u/10
1000p/50
R988

C984
1M

SYS-PWR BUS GNDD


BTMICMUTE
BT_SRX
S_BTTX
BTRST

INNER BUS

F
DIMMER

BLSYNC
MBLPW

G_to_S
S_to_G
GRST

SYS-IF_1 BUS

A 2/6
AVH-P3200BT/XNUC
5 6 7 8
119
F
E
B
A

D
C

120
A-a A-b
A-b 2/6 model
P : AVH-P3200BT/XNUC
CN7502 Q : AVH-P3250BT/XNRD
BT + SD G J : AVH-P3200DVD/XNUC

1
1

K : AVH-P3250DVD/XNRC

SDW
GND
L : AVH-P3250DVD/XNRD

BT33
DGND
DGND

SYS+B
GNDBT
VCC33
SDCMD
SDDET
SDCLK
SDCD>SDDET

BT_RST
S_BTTX
BT_SRX
SDDAT0
SDDAT1
SDDAT3
SDDAT2
SDWP>SDW
M : AVH-P3250DVD/XNRI

BT_MIC1P
BT_MIC1N
BT_SPK1P
BT_SPK1N

1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22

0V

0V
0V
0V

0V
0V

0V
0V

0V
CN795

3.3V

3.3V
3.3V
3.3V
3.3V

3.3V
3.3V
3.3V

3.3V
CKS6184-A-T

GNDD
A 2/6 MOTHER UNIT (SYSTEM)

470u/10
GND

SDW

BTRST
BTSPK
BTSRX
SDCMD
SDDET
P,Q

S_BTTX

BTMIC1P
SDDAT0
SDDAT1
SDDAT3

C795
3.3V
401 TUNER

BT33
VCC33
GNDBT 451 LS1
501 BT
601 SYSTEM MICOM

SYS-DRV BUS

2
2

A 5/6
SYS-I/F_1 BUS

BT33 A 5/6

NM

C797
BTRST
S_BTTX
BT_SRX

REARMUTE1

NM

R797
SYS-PWR BUS
R798

BTMICMUTE
A 3/6
NM

VDCNT8
VDCNT5

BTGND

1EQ_2BT
SYS-I/F_2 BUS
A 5/6

AVH-P3200BT/XNUC
SYSPW
SPDIF

BT_TEL
ANA-SYS BUS

VDCNT5
Q795 A 1/6
NM

LS_V
LS_L
LS_R

AMPPW

NM

NM
NM

R795
C798
SYS-SOC BUS

SYSMUTE
SDDT0
SDDT1
SDCMD
SDW
SDDT3
SDDET
SDDT2
SDCLK

3
3

R729

EVSACLK
GNDBT GNDBT A 4/6
VDCNT5

NM
R730

SYS-TUN BUS

NC26
A 6/6

FLPLES
R710
100k
R636
100k

145
144
143
142
141
140
139
138
137
136
135
134
133
132

NC
NC

NC
NC
NC
NC
NC

NC
NC
NC

NC26
131 AMPPW

FLMD1
AMPPW
130 SYSPW
SYSPW

4
4

129 R709

/FLAPLESS
22k
AMPMUTE
128 R631
22k
REARMUTE
127 R706 22k
/RDSLK
126 R705
22k P,J
/RDS57K
125 R707 22k
RDT
124 L604 CTF1346-A
BVDD1
123 C608
0.1u/10
BVSS1
122
NC
121 FLPILM
FLAPILM
120 SOCTEST
NC
F 119 R671
NC
R648 118 100k
NC
117 SOAMUTE
126 R705
22k P,J
/RDS57K
125 R707 22k
RDT
124 L604 CTF1346-A
BVDD1
123 C608
0.1u/10
BVSS1
122
NC
121 FLPILM
FLAPILM
120 SOCTEST
NC
F 119 R671
NC
R648 118 100k
NC
117 SOAMUTE
SOCAMUTE
116 SOCIRQ
SOCIRQPW
115 SOCRES
/SOCXRST
114 LS1
VD8
5

RDT
HSLK
RDSLK
TUNSL
113 CN751

5
VD5 VD8 CKS3871-A
112 AMUTE 8.0V VD8
AMUTE 8.0V
SYS+B 30 VD8
111 IRQPW 8.3V
IRQPW VD5 8.0V
29 VD8
110 /XRST R751
/XRST 8.0V
28 VD8
109 GNDDDC 0V PGND
NC14 1k

6 C1
5 B2
4 E2
27 PGND

0.1u/10
108 0V PGND
NC13 26 PGND

C751
107 GNDDDC 0V DGND

Q751
NC12

UMD3N
25 PGND
106 CLKOUT 5.1V
CLKOUT 5.1V
24 VD5

E1 1
B1 2
C2 3
105 AEQAUXSW R752 AMUTE
AEQAUXSW AMUTE 470 3.3V
R602 23 AMUTE
104 SACLK R753 XRST
SACLK /XRST 1k 3.3V
22 XRESET
103 0 EVSTB IRQPW 0V
EVSEL IRQPW 220 R754
21 IRQPWR
102 EVCLK 3.3V S LS1TX
EVSCK S_MSTX 220 R755 HSTCMD
20 HSTCMD
101 EVDATA
EVSDA MS_SRX 220 R756 SLVSTS 3.3V LS1 SRX
19 SLVSTS C
100 R637
NC10 STNBY 220 R757 STANBY 3.3V
18 STANBY
99 47k GNDA
/MONIRST CN1901
17 AGND
98 R638 P,J R758 LSR
TXMON 0V LS_ROUT
16 ANAROG_ROUT
97
RXMON NM
47k 15 AGND
96 22k R667 RCK R759
/RCK LSL 0V LS_LOUT
14 ANALOG_LOUT
95 LDET
/LDET NM

6
6

13 AGND
94 R760 LSV GNDA
NC 0V
12 COMPOSIT
93 GNDV
NC R708 0 0V
470 DVD/CD: +5.2 dBs 11 VIDEO_GND
92 DDCCLK GNDV
DDCCLK 0V
10 WAKEUP

C2
3
B1
2
E1
1
/SOCSTB 91 SOCSTBY
R763
4.7k
/STB 0V 9 D-
90 STNBY
0V D+

Q752
470 8
89 TUNCK S_PDIF

RT3C99M
4
5
6
TUNPCK 0V

E2
B2
C1 7 DGND

MFLPW

NC
DIMMER
NC

TELBEEP
/TUNPCE2

BTMICMUTE
TUNPDO

BLSYNC
TUNPCE
TUNPDI

/BTRST
R704 Q,K,L,M R761 1.6V
R762
4.7k

6 IECOUT

76
77
78
79
80
81
82
83
84
85
86
87
88
100 0V
5 DGND
GNDA
0V 4 SCL

TP645
TP646
GNDD
0V 3 SDA

SYS-TUN BUS
0V 2 CPRST

470

R703

750
S_TTUN VCC33 0V

NM
NM
3.3V GNDD 1 CPRDY
T_STUN DGND
L981
TUNCE2 CTF1473-A

47k
TUNCE PNLVD

AVH-P3200BT/XNUC
PNLADCRT

R699
R700
R701

R702
PNLXV
3
4
5

PNLYV
3
4
5

7
7

PNLADY R982 NM PLXV


6 Q982 1
10k

PNLADX C1 E1
R990
Q981

5 2
FMG12

TP644
R983 NM PLYV

SYS-SOC BUS
B2 B1

ANA-SYS BUS
SYS-PWR BUS 4 3 R992
2
1

E2 C2
2
1

NM

D981

10k
R989

UMF5N
1SS352

R985 NM ADVX
R984 NM ADVY
PLYV

6 Q983 1
1k
1k

ANA-SYS BUS
10k
1M

C1 E1
R991
C983
R986
R981

R987

5 2
C982
1000p/50

B2 B1
4 3 R993 0.047u/10
E2 C2
INNER BUS

10k C981
C985

SYS-IF_2 BUS UMF5N

AEQAUXSW
0.1u/10

GNDD 0.047u/10
1M
R988
C984

GNDD
1000p/50

SYS-PWR BUS

BTRST
BTMICMUTE
INNER BUS
8

8
DIMMER
MBLPW
BLSYNC
G_to_S
S_to_G
GRST
SYS-IF_1 BUS

A-a A-b
A-b 2/6

121
E
A

D
C

F
B
4 3 2 1
122
AVH-P3200BT/XNUC
A-a 2/6
F
FLMD0

E
REMIN

RESET
RST
INNER BUS

GNDD
SYS-IF_2 BUS
SYS-IF_1 BUS
SYS-DRV BUS

SYS-PWR BUS

100k
2
ANA-SYS BUS

R609
VDD
OUT

15p/50
C610
15p/50
1SS352

C609
D601

IC601
3
4

NC
1u/10

S-80827CNNB-B8M
VSS
1 2
C601

X601
SYSTEM MICOM
A-a A-b

CSS1790-A
GNDD

3.93216MHz

10
R643
R655
VDD33

NM
3.3V

NM
R615
NM
NM

C613
C614

100

CTF1346-A
100k
L601
R635
R681
C602

R619
0.1u/10
0.1u/10

C605

FLMD0

RESET
4.7u/6.3
C603
C

16
15
14
13
12
11
10
5

9
8
7
6
4
3
2
1

X2
X1
0.1u/10

4.7k
4.7k

NC
NC
C611

NM
KDT01

R624
R623
R670

VSS
NC3
NC2
NC1

VDD
AVSS
R625

REGC
176

FLMD0
REMIN
AVREF1
AVREF0
NC30 175 470 R626 KDT0
KDT0
KDT1 174 KDT11 470 R634 NM KDT1
TEMPSEN
173 R656 NM PNLADX TEMPSEN1
PNLADX NM
172 R652 R657 NM PNLADY
PNLADY NM
171 R653 R658 NM PNLADCRT
PNLADCRT NM
3216
2125
1608

POS
170 R654 POS
169

*1
TUNSL
168 C612 R675 100
CHIP SIZE LEGEND

BLERR1
167 BLERR1
NC 0.01u/16 R601 NM EVSAOUT

J
166 R714 NM MICSENSR
NC
165 R715 NM MICSENSL
SAIN RB751V-40
164 SAIN
D602 R712 WIREDAD
MICSENR

MODEL Number
10k

UC
163 WIRED
MICSENL D603 R713
162
WIREDAD RB501V-40
161 100k

IC602
Sys-uP
WIRED B
160

PE5725A8
MODEL3

*1
159 R648
MODEL2 R734

R737
MODEL1 158 R649 R735
157 R650
MODEL0 R736

MODEL SEL
R651
156 R651
MVIPW MVIPW R737 PWGR
C606

IC602
155
BVSS2

UPD70F3480

R736
154 0.1u/10 L605
BVDD2
153 CTF1346-A PNLVD
PNLVD

R650
152 PNLYV
PNLYV

DESTINATION
151 TESTIN2 PNLXV
PNLXV

R735
150
TESTIN R660 47k
149 47k R711 ISENS
/ISENS

R649
148 BGSENS
/BGSENS
147 PBSENS
PBSENS

R734
146 TELMUTE
TELMUTEIN
145

BT H/F
NC

R648
144
NC
143
NC
142
A
NC
141
NC
140
NC
139
NC
138
NC
R710
137 FLPLES
A-b 2/6
4 3 2 1
REMIN 100 7
REMIN IC602
R681 8
NC UPD70F3480
R635 FLMD0 9
X601 NC3
FLMD0 CSS1790-A 100k 10
FLMD0
C609 3.93216MHz L601 11
VDD
15p/50 CTF1346-A C603 12
REGC

2
4.7u/6.3 13
VSS

C602

1
14 *1 MODEL Number Sys-uP MODEL SEL DESTINATION BT H/F

0.1u/10
X1
GNDD C610 R643 15 IC602 R737 R651 R736 R650 R735 R649 R734 R648
RST RESET
X2
RESET 15p/50 10 R619 16 J UC PE5725A8
RESET
1k 17 K RC PE5727A8
XT1
18 L RD PE5727A8
XT2
19 M RI PE5727A8
NC
R614 100k
5

20

5
BSENS P UC PE5725A8
/BSENS
R612 100k 21 BR PE5726A8
ASENS R620
/ASENS
DRST 22 Q RD PE5727A8
47k DRST
VCC33 23
NC4
W1 24
NC
W2 25
/H&OSW
W3 26
NC

47k

R642
27
GON MOTPWR2
GUIDEON 28
NM R639 100k GUIDEON
R644 29
RGBARI R640 /RGBARI
Q601 R616 NM 30
47k 2SC4081(QRS) TXNAVI
R641 R621 31
NM
47k RXNAVI
GNDD 47k 32
S_to_N NC
N_to_S 33
R731 NC
BZ R611 34
BEEP
1k 35
R645 ASENBO
4.7k 36
TXIE
37
RXIE
C604 38
EVSS1

6
6

ASENBO L602 0.1u/10 39


EVDD1
CTF1346-A TSI 40
S_to_IP
TSI
R646 4.7k TCK
IP_to_S 41 TCK
R647 4.7k TSO TSO
42 TXLS1
R617 RXLS1
S_MSTX NM 43

MS_SRX NM 44
NC
NC
NC
NC

NC
NC
NC
NC
NC
NC
MFLPW

HIOUTCLK
NC
DIMMER

NC
NC

R622 R618
NC
DDI
DDO
DCK
DMS
RXSOC
TXSOC
AVSDATA
AVSCK
EVDD2
EVSS2
NC9
BTTESTIN
BTTESTMD
BTRX
BTTX
TELBEEP

BTMICMUTE

ILMLD
ILMDT
ILMCK
BLSYNC
TUNPCE

/BTRST

NC
45
46
47
48
49
50
51
52
53
54
55
56
57
58
59
60
61
62
63
64
65
66
67
68
69
70
71
72
73
74
75
76
77
78
79
80
81
82
83
84

47k

GNDD
DCK
GNDD
RESET
FLMD0
DMS
DRST
DDI
DDO
CN601
CKS5757-A

1
2
3
4
5
6
7
8
9
BTESTIN
NC

10 VDD33
11 VDD33
12 GNDD
13 NC
NC2
TP609
TP610
TP611
TP636
TP637
TP638
TP645
TP646

TESTMD
750

VDD33
NM
NM
NM
NM
NM

1.8k

47k
47k
47k
47k
47k
R665

C607
R716

3.3V GNDD

NM
NM
NM
NM
NM
NM
NM
0.1u/10

GNDD R613
R633 1.8k

R627
R628
R629
R632

47k
CTF1346-A
47k

NM
R630

AVH-P3200BT/XNUC
R699
R700
R701

R702

R694
R695
R696
L603

R603
R604
R605
R606
R607
R608
R610
NM
NM

470
220
220

7
7

TP644

R724
R680
R679
R663
R664

SOtoS
StoSO

SYS-DRV BUS
ANA-SYS BUS

INNER BUS

SYS-IF_1 BUS
SYS-IF_2 BUS

SYS-PWR BUS
AVSDA
AVSCL

AN
ILMLD
ILMDT
ILMCK

SY
HIOUTCLK

SY
FLMD0
BT_SRX
S_BTTX
BTRST
BTMICMUTE

IN
8

8
DIMMER
MBLPW
BLSYNC

A-a A-b

A-a 2/6
A-b 2/6

123
E
A

D
C

F
B
1 2 3 4

10.3 MOTHER UNIT(POWER SUPPLY)

LITTEL SERIES
CHIP SIZE LEGEND CEK1278 0.5A 1001 VDD33V
1608 CEK1279 0.75A
A CEK1280 1A
1021 PWBL,PWGR
2125 CEK1281 1.25A 1061 SYS+B,AVCC5
3216 CEK1282 1.5A 1101 SOCPW (VCC33,VC12)
CEK1283 1.75A BT33
CEK1284 2A 1151 TUN33
CEK1285 2.5A
CEK1286 3A 1201 DDC
CEK1287 3.5A 1301 SWBUP
CEK1288 4A 1401 EV12
CEK1289 5A 1501 MOTV
1601 DISP5,SD33

PWRVI TUN3.3V
VCC12 IC1791
PQ012GN01Z
IC1741 1 5
PWRVI S-1132B33-U5 VOUT VIN
2
>

VOUT
GND
VCC12 5.2V VSS

VIN
5.2V TUN33V

NC

VB
3 4

PWRVI
PWVI L1731 P1731
VCC12 NM R1731 NC SW
1.2V

5
4
3
2
1
1 2
CEK1283-A NM 3.3V
(1.75A)

NM
1u/10

C1731

C1733
100u/16
TUN33

C1732
0.1u/10

0.1u/10
C1791

B
10u/6.3
10u

C1747

0.1u/10
C1792
C1793

C1746
NM

0.1u/10
C1745
GNDD
GNDD

GNDD C1742 C1741

R1741
NM NM
IC1771 C1744
VCC33 NJM2855DL1-33
NM
2 GND

VCC33
3 Vout

GNDRF GNDBE GNDD


1 Vin

3.3V VCC33 4.4V D1771

1SR154-400
0.33u/10
2.2u/10
C1771

C1772

GNDD
AVCC5
IC1781
S-1132B33-U5
C BT33 NC SW AVCC5
3 4 IC1221
VSS 5.0V AVCC5
BT33 2
VOUT VIN 5 1
3.3V
BT33
1 5
VOUT VIN
VSS
2 SYS+
C1221
4.4V

1u/10
D1781 4 3
NC ON/OFF

C1222
SYS

1u/10
1SR154-400
SYS+B
S-1200B50-M5
C1781

C1782
0.1u/16

0.1u/16

VCC5

C1201
GNDD

GNDD P,Q VCC5 P1721


>
CEK1284-A
1 2
(2.0A)
EV12
12.2V
DD5
EV12 2SC4081(QRS) EVV 14.1V
EV12 Q1621 D1622 L1621 47uH NM
VD5
D RB551V-30 ATH7061-A R1631 5.2V
R1622

NM
R1621

SCR=OFF 365.1kHz
680

C1701

C1702
NM
NM
IC1621
CTF1629-A

Q1622
L1712
R1623

D C1626 8 1
C1624
0.01u/16

300k

RSF014N03 FB EaIn
C1621

C1623

(D)
NM

7 2
0.1u/16

0.1u/16
CCG1222-A

G GNDDD
>
OSC SCP
C1628

EV1 6 3
VD5
11k (D)

GND Vcc
4.7u
CCG1222-A

P1711
25V
D1621

C1622

R1624

C1625

S 5 4 CEK1281-A
NM
HZU13(B1)

Out BR/CTL
/

R1626 (1.25A)
1000p/50
C1531
R1625

C1627

NM 1 2
4.7u

R1627
5.1k

620

0.1u/16

TK11840L
C1712
0.1u/10
R1630

NM

GNDHI GNDD
R1628
NM

476.6kHz/524.3kHz Q1623
HIOUTCLK
C1629
270p/25
R1629
4.7k
(D)

LTC143EUB

MOTV
E
GNDHI
VDCNT5
VDCNT8

PWRBL ILMB VD8


PWRBL ILMB VD8
8.1V

PWBL
8.0V L1661
8.0V
ILMB
P1651 > DD8
>
CTH1262-A
1 2
100uH DD8
CEK1282-A P1611
(1.5A) 8.1V
1 2
C1661
C1662

470u/16

CEK1285-A
0.1u/16

(2.5A)

F GNDBL

: The pow

A 3/6
AVH-P3200BT/XNUC
124
1 2 3 4
5 6 7 8

model
D33V
WBL,PWGR
S+B,AVCC5
P : AVH-P3200BT/XNUC
Q : AVH-P3250BT/XNRD A 3/6 MOTHER UNIT (POWER SUPPLY) A
CPW (VCC33,VC12)
33
J : AVH-P3200DVD/XNUC
N33 K : AVH-P3250DVD/XNRC
C
WBUP L : AVH-P3250DVD/XNRD
12
OTV
M : AVH-P3250DVD/XNRI
SP5,SD33
SYS-PWR BUS
A 2/6

SYSPW

DDCCLK
BUP_1
TUN3.3V
741 1 5
3-U5 VOUT
2
VSS
VIN
VDD33 IC1001
S-812C33AUA-C2N
VDD33V
33V 3 4 R1743 3.3V
VDD2 Q1001 VDD1
D1001 Q1002
NC 2SB1184F5(QR) 1SR154-400 2SD1664(PQR)
SW
47k
R1742

68k

.3V

R1003 R1002

R1005 R1004
R1001

R1006
2.2

2.2
390

910
1 GND
C1001

3 Vout
47u/4
N33

2 Vin
B

2.2

2.2
C1747

1SR154-400
0.1u/10
C1746

D1741

RKZ18KG(B2)
0.1u/10

C1005
0.1u/50
D1002
C1002

C1003
0.01u/16

0.01u/50
C1004
C1742 C1741 1000u/16
CEAT102M16-P30
R1741

NM

NM NM
C1744
NM GNDD

RF GNDBE GNDD

C
R1203

1k

IC1201
NJM2388F84
CONTROL

SYS+B
VOUT
GND
VIN

SYS+B
1
2
3
4

SYS+B 8.3V
C1201

C1202
100u/16

1.0u/35

R1201

68k

P1501 > DDCV L1507


CEK1262-A CTH1446-A
13.8V
GNDA 1 2 D1503
(6.3A) 10u RB050LA-30

C1526

4700u/16
C1523

RB050LA-30
1.0u/35

DD5
DD5 L1501
DDC D1504

CTH1434-A L1503 L1506 L1502


5.2V CTF1661-A CTF1661-A CTH1253-A
6.8u 15u D
D2-2

D2-1

D1-2

D1-1
5

D1-1

D1-2

D2-1

D2-2
22u

22u

5
C1701

C1702

CCG1223-A

CCG1223-A

CCG1223-A
NM

HAT2210RJ-TBB

C1520
NM

CCG1223-A
C1510

C1515
C1503

10u/35
10u/35

10u/35

0.1u/16
HAT2210RJ-TBB
Q1501

CCG1236-A-T
CCG1236-A-T
1000p/50
C1502

C1504

C1528

C1529

C1530
10u/35
0.1u/16

Q1502

GNDDDC C1501
1.0u/35
G2

G1
4

1
S2

S1

1000p/50
C1506

C1525

C1527
C1505

C1514
C1513
G1

G2
1

4
CTF1661-A S1

S2
CTF1661-A

0.1u/25 C1516
CCG1274-A-T
1000p/50

CCG1274-A-T

L1504

0.1u/25
R1516

D1501 RB551V-30
L1505

6.8

RB551V-30
R1509 D1502
12
11
10

6.8
1
9
8
7
6
5
4
3
2
VCC

R1522 R1523
OUTH1
BOOT1

BOOT2
OUTH2

13 48
CL1

CL2
VCCCL1

VCCCL2
N.C.3

N.C.2

N.C.1

2.2 14 47 2.2
SW1 SW2
5.20V OUTL1 R1508 15 DGND1 DGND2 46 R1515
2.2 OUTL2
OUTL1 OUTL2 1.9V R1521
R1502 2.9V 2.2 16 45
N.C.4 N.C.19
NM C1511 17 44 C1521 NM 8.10V
VREG5A VREG5
C1507

R1505 R1504
560 560p/50

22k

R1517

C1524
470p/50
(D)

4.7u/10 18 43 4.7u/10
82k
(D)

N.C.5 BD9017KV N.C.18


19 42
N.C.6 IC1501 N.C.17
R1503

33k

C1522 E
(D)

R1518

20 41
1k

N.C.7 EXTVCC
R1519
(D)

330

21 40 0.33u/50
FB1 N.C.16
22 39 GNDDDC
R1507
KN1501

4.3k

COMP1 FB2
M2R6TP_GND

C1518 R1514

23 SS1 COMP2 38
10k

N.C.8 SS2
N.C.10
N.C.11

N.C.12
N.C.13

N.C.14
N.C.15
SYNC
C1508

24 37
C1519
N.C.9
120p/50

R1531 R1532
47p/50
GND
EN1
EN2

RT
R1506

2200p/50
0.022u/16

0.022u/16
3300p/50

R1520
10k
(D)

C1509

0 NM
9.1k
C1512

C1517

(D)
25
26
27
28
29
30
31
32
33
34
35
36
NM

NM

GNDDDC GNDD GNDD


R1512

R1513
100k

1k

GNDDDC
R1510

R1511

DD8 OSC=300kHz 365.80kHz/425.1kHz

DD8
8.1V

The > mark found on some component parts indicates F


: The power supply is shown with the marked box. the importance of the safety factor of the part.
Therefore, when replacing, be sure to use parts of
identical designation.
A 3/6
AVH-P3200BT/XNUC
5 6 7 8
125
1 2 3 4

10.4 MOTHER UNIT(DV5U)(GUIDE PAGE)

A A-a 4/6
ANALOB BUS

SOC_V
C944 R942
A 5/6 SOC-I/F BUS SOC BUS

SOC_R

SDODAC
SCKDAC
SOAMUTE

LTDAC

USB_D+

USB_D-
4.7u 820

200 (D)

200 (D)
C946

CTF1528-A

R860
R847

R821
L821
C942
DCH1201-A

NM
R944
100k

NM

0
ADAC
R948

4.7k
C2
B1
E1
3
2
1
RT3C99M

AVCC5
Q942

7 VOUTL VCOM 10
6 ZEROR/ZEROA 11

ZEROL/NA 12
13
14

ML 15
16
GNDD4 5.0V

AGND 9
C1
4
5
6
E2
B2

MD
MC

SCK
R947

C941

PCM1753DBQ
X801

NM
GNDD

R943
100k
4.7k

R945

NM
27MHz
4 33 C819

(IEC/IPFLG)
IC941
VOUTR
C945 4

4 DGND
R941 0.1u/10

3 LRCK
2 DATA
GNDD

VCC
GNDD

1 BCK
R820 R823

NC
SOC_L
4.7u 820 1 2
1 2 10k (D) 24k(D)

5
C818
CSS1791-A 15k
C808 C811 R815 0.1u/10
12p/50 10p/50

R821

200
(D)
R814

R805

1.2k
C943
0.1u/10

100
100
100
220
3 C2
1 E1
2 B1

C820
GNDD 15k

1u/10
0 ohm

30k (D)
R812

R813

R860
R806

(D) 24

(D) 24
UMD3N

GNDD

R822
Q941

SYS+B 1M GNDDGNDD

R808
R809
R810
R811
GNDD
C1 6
B2 5
E2 4

1k 8.3V

0.1u/10
C817
MDQ1

MDQ0
MDQ14

MDQ15
R946
VCC12 GNDD
B 1.2V

C822
0.1u/10
C813
C809

0.1u/10

0.1u/10
R802

C812

0.1u/10
0

TP803

TP802
GNDD
VCC33

DCH1201-A
C840
3.3V GNDD

R871

NM

162
161

MDQ14 160
MDQ0 159

158
157
156
155
154
153
152
151
150
149
148
147
146
145
144
143
142
141
140
139
138
137
136
135
134
133
132
131
130
129
128
127
126
125
124
123
122
121
120
OSCO

AVDDG

COMP2

COMP1
GNDD

MDQ1

AVDDH

TEMP
ROUT

AVSSG

AVDDE

FD
TD

VDSENS
ADOUT

SRCK
DACCK

AVDDF

AVSSH
DAC5OUT

DAC1OUT
DAC2OUT
DAC3OUT
LOUT

VREF

AD4
AD2
MDQ15

AVSSE
LRCK

AVSSF
163

COMPOSITE
OSCI
MDQ13

VSS_9
IECOUT

AVDDI

VIN1
VSS_10

AVSSI

IREF1
VDD12_4

VDD33_6
DCH1201-A
ANA-SOC BUS MDQ2 164

C841
165 MDQ13
MDQ2
C802 166 VSS_11

A 1/6 GNDD
MDQ12 0.1u/10
MDQ3
167
168
VDD33_7
MDQ12
VCC33 MDQ3
MDQ11 169
3.3V MDQ11
MDQ4 170
MDQ4
MDQ10 171
L901 MDQ10
MDQ5 172
NM MDQ5
DCH1201-A

173
1000p/50
C908

C909

VSS_12
C803 174
VDD33_8
MDQ9 0.1u/10 175
MDQ9
MDQ6 176
IC901 MDQ6
R906 MDQ8 177
C901 1 54 GNDD 56 MDQ8
MDQ7 178
R901 0.1u/10 2 VDD1 VSS3 53 MDQ7
56 DQ0 DQ15 5 4 179
C902 MDQ15 DQM0
MDQ0 3 52 DQM0
VDDQ1 VSSQ4 6 3 180
5 4 MDQ14 DQM1
MDQ1 0.1u/10 4 51 DQM1
DQ1 DQ14 7 2 181
6 3 MDQ13 XWE
MDQ2 5 50 NWE
DQ2 DQ13 8 1 182
7 2 6 49 C907 VSS_13
MDQ3 C842 R804 L801
VSSQ1 VDDQ4 R907 NM 183
C 8 1 7
DQ3 DQ12
48 0.1u/10 56
MDQ12 C804 100 CTF1743-A184
MCK
8 47 VDD33_9
DQ4 DQ11 5 4 0.1u/10 185
R902 56 C903 MDQ11 MCK
MDQ4 9 46 MCKI
VDDQ2 VSSQ3 6 3 186
R913 56 MDQ10
MDQ5 0.1u/10 10 45 VSS_14
DQ5 DQ10 7 2 C801 187
R914 56 MDQ9
MDQ6 11 44 VDD12_5
DQ6 DQ9 8 1 0.1u/10 188
56 XCAS
MDQ7
R915 12 43 C906 NCAS IC801
VSSQ2 VDDQ3 R912 56 XRAS 189
13 42 0.1u/10 MDQ8 NRAS MN2DS0018MAUB
R903 DQ7 DQ8 XCSM R803 190
56 C904 14 41 NCSM
DQM0 VDD2 VSS2 191
5 4 0.1u/10 15 40 100k STANDBY
XWE LDQM N.C/RFU MA11 192
R910 56
6 3 16 39 DQM1 DQM3
XCAS WE UDQM BA0 193
17 38 R911 0 BA0
7 2 MCK
XRAS CAS CLK MA9 194
8 1 18 37 R908 MA9
RAS CKE 56 195
R904 19 36 VSS_15
56 CS N.C C805
XCSM 196
20 35 5 4 VDD33_10
5 4 MA11
BA0 BA0 A11 BA1 0.1u/10 197
21 34 6 3 BA1
6 3 MA9
BA1 BA1 A9 MA8 198
22 33 7 2 MA8
7 2 MA8
MA10 A10/AP A8 MA10 199
23 32 8 1 MA10
8 1 A0 A7 R909 200
56 MA7
R905 24 31 MA7 MA7
56 A1 A6 MA0 201
MA0 25 30 5 4 MA0
MA6
5 4 A2 A5 MA6 202
MA1 26 29 6 3 MA6
MA5
6 3 A3 A4 MA1 203
MA2 C905 27 28 7 2 MA1
MA4
7 2 VDD3 VSS1 204
MA3 0.1u/10 8 1 VSS_16
8 1 C806 205
K4S641632N-LC75
VDD33_11
GNDD5 MA5 0.1u/10 206
SDRAM MA2 207
MA5
MA2
MA4 208
MA4
MA3 209
GNDD MA3
210
D C807 211
VSS_17
VDD12_6
0.1u/10 212
EXADT0
213
NEXCE
214 NEXOE
VCC33 EXDT0
EXADR16

EXADR19

EXADR18
EXADR17
CN801
EXADT15
EXADT14
EXADT13
EXADT12
EXADT11
EXADT10
VDD33_1

VDD33_2

VDD12_1

VDD33_3
215

EXADT9
EXADT8

EXADT7
EXADT6
EXADT5
EXADT4
EXADT3
EXADT2
EXADT1
EXDT8
EXDT10

EXDT11

EXDT12

EXDT13

EXDT14

EXDT15

NEXWE
3.3V
3 EXDT1
EXDT9
4 EXDT2

EXDT3

EXDT4

EXDT5

EXDT6

EXDT7
VSS_1

VSS_2

VSS_3

VSS_4

VSS 5
CKS4374-A 216
1 20
2 19
3 18
4 17
5 16
6 15
7 14
8 13
9 12
10 11

1
2

6
7
8
9
5

10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
41
42
43
GNDD

0.1u/10
C810

0.1u/10

C821
C816
NM 0.1u/10

0.1u/10
C814
TP816
TP817
TP818
TP819
TP820
TP821

GNDD3
NM
NM
NM

NM

NM
150

100
100

R816
10k

10k
R817
R818
R819

R824
R825
10k
10k

10k

10k
CTF1778-A
L802

8
7
6
5

8
7
6
5

8
7
6
5

8
7
6
5
R936

R935

R934
150

150

150
R872
R859
R858
R868
R852

R855
R851

R853
R849

GNDD
2
3
4

2
3
4

2
3
4

2
3
4
1

1
47
330
D_SCLOCK
D_EXTRG0

SOCRES1
D_TRCCLK
D_TRCST
D_TRCD3
D_TRCD2
D_TRCD1
D_TRCD0

D_SDATA

XCSF2

XWR1
R854
XRD

R850

D15
D14
D13
D12

D11
D10
A16

A19

A18
A17
D0

D9
D8

D7
D6
D5

D4
D3
D2
D1
SOCSTBY

SDCMD
SDDET

SDCLK
SDDT1
SDDT0

SDDT3
SDDT2
SDW

E A 2/6 SYS-SOC BUS SOC BUS

3.3V L923 VCC


3.3V
FLASH 16M L921
VCC33 FLASH 16M L922 VCC33
LATCH CTF1473-A
1u/6.3
C932

IC921 CTF1473-A IC922 CTF1473-A IC923

A15 1 48 A16 A15 1 48 A16 1 48


A15 A16 C923 A15 A16 X10E 1LE
A14 2 47 A14 2 47 C926 A0 R937 2 47 D
A14 /BYTE 4.7u/6.3 A14 /BYTE 4.7u/6.3 1Q1 1D1
A13 3 46 (2125) A13 3 46 A1 150 3 46 D
(2125)
A13 Vss2 A13 Vss2 1Q2 1D2
A12 4 A12 45 D1 A12 4 A12 45 D1 4 45
DQ15_A-1 DQ15_A-1 GND1 GND8
A11 5 44 D2 A11 5 44 D2 A2 5 44 D
A11 DQ7 A11 DQ7 1Q3 1D3
A10 6 43 D3 A10 6 43 D3 A3 6 43 D
A10 DQ14 A10 DQ14 1Q4 1D4
A9 7 42 D4 A9 7 42 D4 C930 7 42 C929
A9 DQ6 A9 DQ6 Vcc1 Vcc4
A8 8 41 D5 A8 8 41 D5 A4 0.1u/10 8 41 0.1u/10 D
A8 DQ13 A8 DQ13 1Q5 1D5
A19 9 40 D6 A19 9 40 D6 A5 9 40 D
A19 DQ5 A19 DQ5 1Q6 1D6
10 39 D7 10 39 D7 10 39
XWR1 NC1 DQ12 NC1 DQ12 GND2 GND7
XWR1 11 38 D8 XWR1 11 38 D8 A6 11 38 D
/WE DQ4 /WE DQ4 1Q7 1D7
SOCRES1 R924 12 /RESET 37 C922 SOCRES1 R926 12 /RESET 37 C925 A7 12 37 D
Vcc Vcc 1Q8 1D8
220 13 36 0.1u/10 220 13 36 0.1u/10 13 36
C921

D9 D9 A8 D
C924

NC2 DQ11 NC2 DQ11 2Q1 2D1


0.01u/16
0.01u/16

14 35 D10 14 35 D10 A9 14 35 D
NC3 DQ3 NC3 DQ3 2Q2 2D2
15 RY_/BY 34 D11 15 RY_/BY 34 D11 15 34
DQ10 DQ10 GND3 GND6
A18 GNDD 16 33 D12 A18 GNDD 16 33 D12 A10 16 33 D1
A18 DQ2 A18 DQ2 2Q3 2D3
A17 17 32 D13 A17 17 32 D13 A11 17 32 D1
A17 DQ9 A17 DQ9 2Q4 2D4
A7 18 31 D14 A7 18 31 D14 C928 18 31 C927
A7 DQ1 A7 DQ1 Vcc2 Vcc3
A6 19 30 D15 A6 19 30 D15 A12 0.1u/10 19 30 0.1u/10 D1
A6 DQ8 A6 DQ8 2Q5 2D5
A5 20 29 D0 A5 20 29 D0 A13 20 29 D1
A5 DQ0 A5 DQ0 2Q6 2D6
F A4 21
A4 /OE
28 XRD A4 21
A4 /OE
28 XRD 21
GND4 GND5
28 D1
A3 22 27 A3 22 27 A14 22 27
A3 Vss1 A3 Vss1 R929 2Q7 2D7
A2 23 26 A2 23 26 4.7k A15 23 26 D1
R925

R927

A2 /CE A2 /CE 2Q8 2D8


100k

100k

A1 24 25 A1 24 25 24 25
A1 A0 A1 A0 X20E 2LE
A0 GNDD XCSF1 A0 XCSF2
TC74LCX16373FT
CWW2021 CWW2020

A 4/6
R928
NM GNDD
GNDD

AVH-P3200BT/XNUC
126
1 2 3 4
5 6 7 8

A-b 4/6 A

A 4/6 MOTHER UNIT (DV5U)


SOC BUS

model
VCC33
P : AVH-P3200BT/XNUC
3.3V
Q : AVH-P3250BT/XNRD
J : AVH-P3200DVD/XNUC

R801

NM
K : AVH-P3250DVD/XNRC
L : AVH-P3250DVD/XNRD 2001-
2201-
:POWER
:USB

DCH1201-A
M : AVH-P3250DVD/XNRI

C836
2251- :iPod CP
2301- :SDCARD
2401- :SOC
2501- :SDRAM
2601- :FLASH
GNDD
2701- :AUDIO DAC

CHIP SIZE LEGEND


1608
2125
3216

B
C822
0.1u/10

TP803

TP802

GNDD
131
130
129
128
127
126
125
124
123
122
121
120
119
118
117
116
115
114
113
112

E+G_E+F 111
VREFH 110
109
AVDDH

TEMP
FD
TD

VDSENS
AVSSH
DAC1OUT
DAC2OUT
DAC3OUT

AD4
AD2

FE2
FE1

108
VHALF
F+H_G+H
VIN1
VIN2
VIN4
VIN3

VIN6
VIN5

107 C832
AVSSB 106
VIN8

VIN7

0.1u/10
AVDDB
LPCO2 105
CDMPD
104
LPCO1 GNDD
103
DVDMPD
102
VREFL5
101
VREFH5
100
VIN3RF
99
VIN4RF
98
VIN2RF
97
VIN1RF
96
RFINP
95
RFINN
94
ANAMONI2
93
ANAMONI1
92 GNDD
AVDDC
91 C827 NM
CDATA
90 C828 NM
CCAPA
89 C837
AVSSC
88 C829 0.1u/10
VREFL7
87 NM C835 0.1u/10 C
SOC BUS

AVSSD
86 C830 NM
VREFH7
85 C831
PLFIL1
84 NMGNDD GNDD
AVDDD
83 C833
VDD12_3
82 0.1u/10
VSS_8
MAUB 81 D_TRCST
TRCST
80
TRCDATA3
79 D_TRCD2
TRCDATA2
78 D_TRCD1
TRCDATA1
77 D_TRCD0
TRCDATA0
76 D_TRCCLK
TRCCLK
75
EXTRG1
74 D_EXTRG0
EXTRG0 R838 1k
73
SDATA R839 1k
72
SCLOCK R835 4.7k
71 SOAMUTE
FG
70 R844 220 R848 SOCRES
NRES C826 0.01u/16
69 4.7k SOCRES1
VDD33_5
68 R845 100k
VSS_7
67 C834 0.1u/10
NC
66 TP814 R869
FRAME
65 R836 100k NM USBFLG
USBLMIT
64 SCKDAC
SCKDAC
63 R846 1k SDODAC
SDODAC
62 LTDAC
LTDAC
61 R827 CPRST CPRST
P14
P13
60 100 R870 USBCNT
D
59 R857 XCSF1 NM
XCSSR R837
58 R843 100
100k SOCIRQ
IRQPWR
220
SDODAC 57
USB_CLOCK

CMDCOMN
CP_READY

STSCOMN

LTDAC 56
EXADR18
EXADR17
VDD33_3

VDD12_2

VDD33_4

12EJ R856
EXADT7
EXADT6
EXADT5
EXADT4
EXADT3
EXADT2
EXADT1

USBPW
CPRST

47k
VSS_4

VSS_5

VSS_6
StoSO
SOtoS

55 R831 DGCLK
0 R826

R840
32
33
34
35
36
37
38
39
40
41
42
43
44
45
46
47
48
49
50
51
52
53
54

D_to_G 100k
R832 NM
NM G_to_D
R833
100k
0.1u/10

0.1u/10

VCC33
C823
C821

R830

C824

ROM BUS
0.1u/10
R807
180

220

R957 CPV
3.3V
C825
180
R834
R867

NM
100k
10k
R824
R825
10k

0.1u/10 UMD22N
1M
R841

CX3225SB48000D0HPQZ1
R959

R951
10k

E2 4 3 C2
10k

5 1 X802
4 33
R829

VCC NC
100k
8
7
6
5

8
7
6
5

4 B2 5 2 B1
R842

2
470
R934

R933

IN_A
150

150

C839

C1 6 1 E1
10p/50

4 3 1 2 Q951
OUT_Y GND
DVXTL

10p/50

2
2
3
4

2
3
4
1

1
C838

VDCNT5
R828

IC802
220

TC7SZU04FU CPRST
XWR1

SOC BUS
A18
A17

D7
D6
D5

D4
D3
D2
D1

R952

R955

GNDD CPDT
100k

IPOD CP IC
1k
STOSO
SOTOS

CPCK
StoSO
SOtoS

IC951
2
5

1
4
3

341S2162
MODE1
VCC

NC1
NC2
nRESET

6 20 E
10k

NC3 NC13
CPCK
CPDT

SOC BUS
0.1u/10

NC4 NC12
7 19
NC5 NC11
R958
C951

8
0.1u/10

18
I2C_SDA
I2C_SCL

NC6 NC10
MODE0

9 NC7 NC9 17
C952

VCC33
VSS

NC8

L923
3.3V 10 16
CTF1473-A
1u/6.3
C932

11 12 13 14 15
R930
R953

R954
100

100

330 R932 IC924


R956

D0
100k

NM
D1 XCSF2 1 5
INB VCC
XCSF1 2
C931

0.1u/10

INA
D2 R931 3 4
NM GND OUTY
D3 GNDD
C929 TC7SZ08FU
0.1u/10 D4
D5 GNDD

D6
D7
D8
D9

D10
D11
C927

0.1u/10 D12
D13
D14 F
D15

A 4/6
AVH-P3200BT/XNUC
5 6 7 8
127
F
E
B
A

D
C

128
A-a A-b
A-b 4/6
A 4/6 MOTHER UNIT (DV5U)

1
1

SOC BUS

model
VCC33
P : AVH-P3200BT/XNUC
3.3V
Q : AVH-P3250BT/XNRD
J : AVH-P3200DVD/XNUC

NM

R801
K : AVH-P3250DVD/XNRC
L : AVH-P3250DVD/XNRD 2001- :POWER
2201- :USB
M : AVH-P3250DVD/XNRI 2251- :iPod CP

C836
2301- :SDCARD
2401- :SOC

DCH1201-A
2501- :SDRAM
2601- :FLASH
GNDD
2701- :AUDIO DAC

CHIP SIZE LEGEND


1608
2125
3216

2
2

C822
0.1u/10
TP803
TP802
GNDD

130
129
128
127
126
125
124
123
122
121
120
119
118
117
116
115
114
113
112
109
108

FD
TD
AD4
AD2
FE2
FE1
C832

TEMP
VIN1
VIN2
VIN4
VIN3
VIN6
VIN5
107

AVDDH
AVSSH
VHALF
VREFH 110

VDSENS
AVSSB 106 0.1u/10

DAC2OUT
DAC3OUT
F+H_G+H
E+G_E+F 111
AVDDB

VIN8
VIN7
LPCO2 105
CDMPD
104
LPCO1 GNDD
103
DVDMPD
102
VREFL5

AVH-P3200BT/XNUC
101
VREFH5
100
VIN3RF
99
VIN4RF
98
VIN2RF
97

3
3

VIN1RF
96
RFINP
95
RFINN
94
ANAMONI2
93
ANAMONI1
92 GNDD
AVDDC
91 C827 NM
CDATA
90 C828 NM
CCAPA
89 C837
AVSSC
88 C829 0.1u/10
VREFL7
87 NM C835 0.1u/10
AVSSD
86 C830 NM
VREFH7
85 C831
PLFIL1
GNDD
SOC BUS

84 NMGNDD
AVDDD
83 C833
VDD12_3
82 0.1u/10
VSS_8
UB 81 D_TRCST
TRCST
80
TRCDATA3
79 D_TRCD2
TRCDATA2
78 D_TRCD1
TRCDATA1

4
4

77 D_TRCD0
TRCDATA0
76 D_TRCCLK
TRCCLK
75
EXTRG1
74 D_EXTRG0
EXTRG0 R838 1k
73
SDATA R839 1k
72
SCLOCK R835 4.7k
71 SOAMUTE
FG
70 R844 220 R848 SOCRES
NRES C826 0.01u/16
69 4.7k SOCRES1
VDD33_5
68 R845 100k
VSS_7
67 C834 0.1u/10
NC
66 TP814 R869
FRAME
65 R836 100k NM USBFLG
USBLMIT
74 D_EXTRG0
EXTRG0 R838 1k
73
SDATA R839 1k
72
SCLOCK R835 4.7k
71 SOAMUTE
FG
70 R844 220 R848 SOCRES
NRES C826 0.01u/16
69 4.7k SOCRES1
VDD33_5
68 R845 100k
VSS_7
67 C834 0.1u/10
NC
66 TP814 R869
FRAME
65 R836 100k NM USBFLG
USBLMIT
64 SCKDAC
SCKDAC
63 R846 1k SDODAC
SDODAC
62 LTDAC
LTDAC
61 R827 CPRST CPRST
P14
5

5
60 100 R870 USBCNT
P13
59 R857 XCSF1 NM
XCSSR R837
58 R843 100
100k SOCIRQ
IRQPWR
220
SDODAC 57
LTDAC 56
12EJ R856
47k
55 R831 DGCLK
0 R826

StoSO
SOtoS

VDD33_3
EXADR18
EXADR17
EXADT7
EXADT6
EXADT5
EXADT4
EXADT3
EXADT2
EXADT1
VSS_5
VDD12_2
USB_CLOCK
VSS_6
VDD33_4
CMDCOMN
STSCOMN

CPRST

CP_READY
USBPW
R840 100k

33
34
35
36
37
38
39
40
41
42
43
44
45
46
47
48
49
50
51
52
53
54
D_to_G
R832 NM
NM G_to_D
R833
100k

VCC33

0.1u/10
C823
0.1u/10

C821
R830
C824

180
220
CPV

R807
R957

0.1u/10
3.3V
C825
NM

180
ROM BUS

10k
R834

R867
100k
UMD22N

10k
0.1u/10

R824
R825
CX3225SB48000D0HPQZ1

1M
X802 E2 4 3 C2
5 1

R841
10k
10k
4

8
7
6
5
8
7
6
5
R959
R951
VCC NC 4 33 B2 5
2 2 B1

R829
100k
IN_A

470

R842
C1 6 1 E1

150
150
4 3

R934
R933
1 2 Q951
OUT_Y GND

C839

2
3
4
2
3
4

1
1
2

10p/50
1 VDCNT5

6
6

IC802

DVXTL
C838
10p/50
TC7SZU04FU CPRST

220
R828

A18
A17
D7
D6
D5
D4
D3
D2
D1
GNDD CPDT
1k
R952
R955
100k

CPCK IPOD CP IC

SOC BUS

STOSO
SOTOS
2

5
1

IC951
4
3

341S2162

StoSO
SOtoS
NC1

VCC
NC2

6 NC3 NC13 20
MODE1

10k

SOC BUS NC4 NC12


nRESET

7 19

CPDT
CPCK
NC5 NC11
0.1u/10

8 18
NC6 NC10
R958
C951

9 NC7 NC9 17
0.1u/10

L923 VCC33
3.3V 10 16
VSS
MODE0
I2C_SDA
NC8

I2C_SCL

C952

CTF1473-A

11 12 13 14 15

C932
1u/6.3
R930

D0 330 R932 IC924


100
100

R953
R954

NM
R956
100k

AVH-P3200BT/XNUC
D1 XCSF2 1 5
INB VCC
XCSF1 2
INA
D2 R931 3 4

C931
NM GND OUTY

0.1u/10

7
7

D3 GNDD
C929 TC7SZ08FU
0.1u/10 D4
D5 GNDD

D6
D7
D8
D9

D10
D11
C927

0.1u/10 D12
D13
D14

D15
8

8
A-a A-b
A-b 4/6

129
E
A

D
C

F
B
F
E
B
A

D
C

130
A-a A-b
A-b 4/6
ANALOB BUS

SOC_V

A-a 4/6
SOC-I/F BUS SOC BUS
A 5/6

1
1

C944 R942
SOC_R
4.7u 820
C946

LTDAC

SDODAC
SCKDAC
DCH1201-A

USB_D+
USB_D-

NM
200 (D)
200 (D)

R860

R847
L821
R821

SOAMUTE

C942

100k
R944
ADAC

NM

C2
3
B1
2
E1
1
R948
4.7k
CTF1528-A
AVCC5

Q942
5.0V

12
13
14
16
GNDD4

RT3C99M
4
5
6

E2
B2
C1
X801 GNDD

MD
MC
ML 15

NM
SCK
27MHz

NM

R947
4.7k
C941

100k
R943
AGND 9
4 C819

R945
4 33
C945 R941 0.1u/10

IC941
GNDD GNDD R820 R823

ZEROL/NA
SOC_L

VOUTR
VCC
NC
4.7u 820 1 2

PCM1753DBQ
2 10k (D)

(IEC/IPFLG)
1

8
7 VOUTL VCOM 10
6 ZEROR/ZEROA 11
5
4 DGND
3 LRCK
2 DATA
1 BCK
24k(D)
C818
CSS1791-A 15k
C808 C811 R815 0.1u/10
12p/50 10p/50
200
(D)

R821

R814

R805
1.2k
100
100
100
220
GNDD 15k

C943

1 E1
2 B1
3 C2
C820

0.1u/10
R806 GNDD
1u/10

R812
R813
R860
0 ohm

SYS+B 1M
30k (D)

GNDDGNDD
(D) 24
(D) 24
R822

Q941
UMD3N
GNDD

R808
R809
R810
R811
1k 8.3V

C1 6
B2 5
E2 4

2
2

R946
C817

VCC12

MDQ1
MDQ0
0.1u/10

GNDD

MDQ14
MDQ15
1.2V
C822

0
C813

C809
0.1u/10

R802
C812
GNDD

0.1u/10
0.1u/10

0.1u/10
TP803

VCC33
3.3V GNDD

C840
NM
162
161
158
157
156
155
154
153
152
151
150
149
148
147
146
145
144
143
142
141
140
139
138
137
136
135
134
133
132
131
130
129
128
127
126
125
124
123
122

DCH1201-A
R871
GNDD 163
FD
TD

MDQ13
AD4
AD2

LOUT
VREF
TEMP

MDQ1
MDQ0 159
OSCO
OSCI
LRCK
SRCK
ROUT

ANA-SOC BUS MDQ2 164


AVSSG
AVDDG
AVDDE
AVSSE
AVSSF
COMP2
IREF1
COMP1
AVDDF
AVDDH
AVSSH

MDQ14 160
MDQ15
VSS_9
ADOUT
DACCK
AVDDI
AVSSI

VSS_10
IECOUT

165 MDQ13
DAC5OUT
DAC1OUT
DAC2OUT
DAC3OUT

C841
VDD12_4
VDD33_6

MDQ2
VSS_11
COMPOSITE

C802 166

DCH1201-A
VDD33_7
GNDD 167
MDQ12 0.1u/10
A 1/6 MDQ12
MDQ3 168
VCC33 MDQ3
MDQ11 169

AVH-P3200BT/XNUC
3.3V MDQ11
MDQ4 170
MDQ4
MDQ10 171
L901 MDQ10
MDQ5 172
NM MDQ5
173
VSS_12
C803 174

C908
C909

3
3

VDD33_8
175

1000p/50
MDQ9 0.1u/10

DCH1201-A
MDQ9
MDQ6 176
IC901 MDQ6
R906 MDQ8 177
C901 1 54 GNDD 56 MDQ8
VSS3 MDQ7 178
R901 0.1u/10 2 VDD1 53 MDQ7
56 DQ0 DQ15 5 4 179
C902 MDQ15 DQM0
MDQ0 3 52 DQM0
VDDQ1 VSSQ4 6 3 180
5 4 MDQ14 DQM1
MDQ1 0.1u/10 4 51 DQM1
DQ1 DQ14 7 2 181
6 3 MDQ13 XWE
MDQ2 5 50 NWE
DQ2 DQ13 8 1 182
7 2 6 49 C907 VSS_13
MDQ3 C842 R804 L801
VSSQ1 VDDQ4 R907 NM 183
8 1 7 48 0.1u/10 MCK
DQ12 56 C804
DQ3 MDQ12 100 CTF1743-A184
8 47 VDD33_9
DQ4 DQ11 5 4 0.1u/10 185
R902 56 C903 MDQ11 MCK
MDQ4 9 46 MCKI
VDDQ2 VSSQ3 6 3 186
R913 56 MDQ10
MDQ5 0.1u/10 10 45 VSS_14
DQ5 DQ10 7 2 C801 187
R914 56 MDQ9
MDQ6 11 44 VDD12_5
DQ6 DQ9 8 1 0.1u/10 188
R915 56 C906 XCAS
MDQ7 12 43 NCAS IC801
VSSQ2 VDDQ3 R912 56 XRAS 189
13 42 0.1u/10 MDQ8 NRAS MN2DS0018MAUB
R903 DQ7 DQ8 XCSM R803 190
56 C904 14 41 NCSM
DQM0 VDD2 VSS2 191
5 4 0.1u/10 15 40 100k STANDBY
XWE LDQM N.C/RFU MA11 192
R910 56
6 3 16 39 DQM1 DQM3
XCAS WE UDQM BA0 193
17 38 R911 0 BA0

4
7 2 MCK
4

XRAS CAS CLK MA9 194


8 1 18 37 R908 MA9
RAS CKE 56 195
R904 19 36 VSS_15
56 CS N.C C805
XCSM 196
20 35 5 4 VDD33_10
5 4 MA11
BA0 BA0 A11 BA1 0.1u/10 197
21 34 6 3 BA1
6 3 MA9
BA1 BA1 A9 MA8 198
22 33 7 2 MA8
7 2 MA8
MA10 A10/AP A8 MA10 199
23 32 8 1 MA10
8 1 A0 A7 R909 200
56 MA7
R905 24 31 MA7 MA7
56 A1 A6 MA0 201
MA0 25 30 5 4 MA0
MA6
5 4 A2 A5 MA6 202
MA1 26 29 6 3 MA6
MA5
6 3 A3 A4 MA1 203
MA2 C905 27 28 7 2 MA1
MA4
7 2 VDD3 VSS1 204
MA3 0.1u/10 8 1 VSS_16
8 1 C806 205
K4S641632N-LC75
VDD33_11
GNDD5 MA5 0.1u/10 206
MA5
SDRAM
5 4 BA0 A11 0.1u/10 197
BA0 6 3 BA1
21 34 MA9 BA1
6 3 BA1 A9 198
BA1 7 2 MA8
22 33 MA8 MA8
7 2 A10/AP A8 199
MA10 8 1 MA10
23 32 R909 MA10
8 1 A0 A7 200
56 MA7
R905 24 31 MA7 MA7
56 A1 A6 MA0 201
MA0 25 30 5 4 MA0
MA6
5 4 A2 A5 MA6 202
MA1 26 29 6 3 MA6
MA5
6 3 A3 A4 MA1 203
MA2 C905 27 28 7 2 MA1
MA4
7 2 VDD3 VSS1 204
MA3 0.1u/10 8 1 VSS_16
8 1 C806 205
K4S641632N-LC75
VDD33_11
GNDD5 MA5 0.1u/10 206
MA5
SDRAM MA2 207
MA2
MA4 208
MA4
MA3 209
GNDD MA3
210
VSS_17
5

5
C807 211
VDD12_6
0.1u/10 212
EXADT0
213
NEXCE
214 NEXOE
VCC33 215 EXDT0
CN801 EXDT8
3.3V
CKS4374-A 216

EXDT1
EXDT10
VSS_1
VDD33_1
EXDT3
EXDT11
EXDT4
EXDT12
EXDT5
EXDT13
EXDT6
EXDT14
VSS_2
VDD33_2
EXDT7
EXDT15
VSS_3
VDD12_1
EXADR16
EXADT15
EXADT14
EXADT13
EXADT12
EXADT11
EXADT10
EXADT9
EXADT8
EXADR19
NEXWE
VSS_4
VDD33_3
EXADR18
EXADR17
EXADT7
EXADT6
EXADT5
EXADT4
EXADT3
EXADT2

1
2
3 EXDT9
4 EXDT2
6
7
8
9

5
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
41

1 20
2 19
3 18
4 17
5 16
6 15
7 14
8 13
9 12
GNDD

10 11
0.1u/10

C810
C821

C816

C814

GNDD3
0.1u/10

0.1u/10

TP816
TP817
TP818
TP819
TP820
TP821

NM 0.1u/10
NM

NM
NM
NM
NM

150
100
100
10k
10k

10k
10k
10k
10k

R816
R817
R818
R819
R824
R825

L802
8
7
6
5
8
7
6
5
8
7
6
5
8
7

CTF1778-A
GNDD
150
150
150

R936
R935
R934

R872
R859
R858
R868
R852
R855
R851
R853
R849
2
3
4
2
3
4
2
3
4
2

1
1
1
1

47

330

6
6

D_TRCST
D_TRCD3
D_TRCD2
D_TRCD1
D_TRCD0
D_EXTRG0
D_SDATA
D_SCLOCK
SOCRES1
D0
XCSF2
XRD
A16
D15
D14
D13
D12
D11
D10
D9
D8
A19
XWR1
A18
A17
D7
D6
D5
D4
D3

R854
R850

D_TRCCLK
SOCSTBY
SDW
SDDET
SDDT1
SDDT0
SDCLK
SDCMD
SDDT3
SDDT2

SYS-SOC BUS SOC BUS


A 2/6
3.3V L923
3.3V
FLASH 16M L921 FLASH 16M L922 VCC33 CTF1473-A
VCC33 LATCH
IC921 CTF1473-A IC922 CTF1473-A IC923
C932
1u/6.3

A15 1 48 A16 A15 1 48 A16 1 48


A15 A16 C923 A15 A16 X10E 1LE
A14 2 47 A14 2 47 C926 A0 R937 2 47
A14 /BYTE 4.7u/6.3 A14 /BYTE 4.7u/6.3 1Q1 1D1
(2125) 150

AVH-P3200BT/XNUC
A13 3 46 A13 3 46 (2125) A1 3 46
A13 Vss2 A13 Vss2 1Q2 1D2
A12 4 A12 45 D1 A12 4 A12 45 D1 4 45
DQ15_A-1 DQ15_A-1 GND1 GND8
A11 5 44 D2 A11 5 44 D2 A2 5 44
A11 DQ7 A11 DQ7 1Q3 1D3

7
7

A10 6 43 D3 A10 6 43 D3 A3 6 43
A10 DQ14 A10 DQ14 1Q4 1D4
A9 7 42 D4 A9 7 42 D4 C930 7 42 C929
A9 DQ6 A9 DQ6 Vcc1 Vcc4
A8 8 41 D5 A8 8 41 D5 A4 0.1u/10 8 41 0.1u/10
A8 DQ13 A8 DQ13 1Q5 1D5
A19 9 40 D6 A19 9 40 D6 A5 9 40
A19 DQ5 A19 DQ5 1Q6 1D6
10 39 D7 10 39 D7 10 39
XWR1 NC1 DQ12 NC1 DQ12 GND2 GND7
XWR1 11 38 D8 XWR1 11 38 D8 A6 11 38
/WE DQ4 /WE DQ4 1Q7 1D7
SOCRES1 R924 12 /RESET 37 C922 SOCRES1 R926 12 /RESET 37 C925 A7 12 37
Vcc Vcc 1Q8 1D8
220 13 36 0.1u/10 220 13 36 0.1u/10 13 36
D9 D9 A8
NC2 DQ11 NC2 DQ11 2Q1 2D1

C921
14 35 D10 14 35 D10 A9 14 35
C924

NC3 DQ3 NC3 DQ3 2Q2 2D2


15 RY_/BY 34 D11 15 RY_/BY 34 D11 15 34
0.01u/16

0.01u/16
DQ10 DQ10 GND3 GND6
A18 GNDD 16 33 D12 A18 GNDD 16 33 D12 A10 16 33
A18 DQ2 A18 DQ2 2Q3 2D3
A17 17 32 D13 A17 17 32 D13 A11 17 32
A17 DQ9 A17 DQ9 2Q4 2D4
A7 18 31 D14 A7 18 31 D14 C928 18 31 C927
A7 DQ1 A7 DQ1 Vcc2 Vcc3
A6 19 30 D15 A6 19 30 D15 A12 0.1u/10 19 30 0.1u/10
A6 DQ8 A6 DQ8 2Q5 2D5
A5 20 29 D0 A5 20 29 D0 A13 20 29
A5 DQ0 A5 DQ0 2Q6 2D6
A4 21 28 XRD A4 21 28 XRD 21 28
A4 /OE A4 /OE GND4 GND5
A3 22 27 A3 22 27 A14 22 27
A3 Vss1 A3 Vss1 R929 2Q7 2D7
A2 23 26 A2 23 26 4.7k A15 23 26
A2 /CE A2 /CE 2Q8 2D8
A1 24 25 A1 24 25 24 25

R925
100k
R927
100k

A1 A0 A1 A0 X20E 2LE
A0 GNDD XCSF1 A0 XCSF2
8

8
TC74LCX16373FT
CWW2021 CWW2020
R928
NM GNDD
GNDD

A-a A-b

A-a 4/6
A-b 4/6

131
E
A

D
C

F
B
F
E
B
A

D
C

132
A 5/6
A 1/6

A 4/6
A 2/6

A 2/6

1
1

ANA-I/F BUS

SOC-I/F BUS
SYS-I/F BUS_1
SYS-I/F BUS_2
R325 100
R326 100
R327 100

100
R319
R309 4.7k
R306 4.7k R305 4.7k

KN301
R302 27k R301 4.7k

M2R6TP_GND
R310
TEMPSEN 2.2V TEMPSEN1
TEMPSEN1 50 4.7k
A 5/6 MOTHER UNIT (IN/OUT PUT)
DIMMER DIMMER 0V DIMMER
49 R308 4.7k R307

NM
R313
MBLPW 3.3V MBLPW 27k
MBLPW 48 C302
BLSYNC BLSYNC 0V BLSYNC R312 6p/50 C301
47
BLERR 1.3V BLERR1 6p/50

GND
BLERR1 46 0

C_-IN
PWRBL 45

D_OUT 14
D_-IN 13
D_+IN 12
V- 11
C_+IN 10
9
C_OUT 8
PWRBL 44

2
2

8V
PWRBL 43

PWRBL
NC 42 IC301

GNDBL 41

NJM2138V

GNDBL
GNDBL 40
R513
GNDBL 39
NM

4V+
2.1V MONVBS
MONVBS 38

2A_-IN
6B_-IN

3A_+IN
5B_+IN
MONVBS

1A_OUT
7B_OUT
model

GNDV 37 R304

MONITOR
N_B 2.4V N_B
N_B 36 4.7k C303 6p/50
NCSYNC 2.4V N_CSYNC
N_CSYNC 35 R303 4.7k
N_R 2.4V N_R
N_R 34 R314
N_G 2.4V N_G
N_G 33 6p/50 C304 4.7k
GNDV 32 R318 R315

GNDV
GRST 3.3V GRST
GRST 31 4.7k 4.7k
GTOS 3.4V G_to_S
4.7k
R328

G_to_S 30 R316
STOG 3.3V S_to_G R317 4.7k
S_to_G 29 4.7k
A-a 5/6

DGCLK 3.3V DGCLK


Q : AVH-P3250BT/XNRD
P : AVH-P3200BT/XNUC

DGCLK 28
M : AVH-P3250DVD/XNRI

GTOD 0V G_to_D
L : AVH-P3250DVD/XNRD
K : AVH-P3250DVD/XNRC
J : AVH-P3200DVD/XNUC

G_to_D 27
DTOG 3.3V D_to_G
C315
C314
C313
C312
C311
C310
C309
C308

D_to_G 26
1RST D301
371_RESET 25
8V RKZ2.4KG(B)

AVH-P3200BT/XNUC
ILM+B 24

ILMB
NC 23
DCH1256-A
DCH1201-A
DCH1201-A
DCH1201-A
DCH1256-A

C305
DCH1201-A
DCH1256-A
DCH1201-A

GNDILM 22 1u/10
RGB VIDEO ISOLATOR

R320

F 1/2 CN5002
371_KEY0 21
150
R311

GNDILM
371_KEY1 20 NM
371_REM 19 R321
10.5 MOTHER UNIT(IN/OUT PUT)(GUIDE PAGE)

3.3V

3
3

VCC33 18 220
GNDD 17 R322

VCC33
GNDD
GNDD 16 C306 220
371_ILMB 15 NM R323

371_ILMG 14 220
NM
R324

371_ILMR 13
PLYV 0V PLYV
AVCC5

PLYV 12
PLXV 3.3V PLXV
PLXV 11
ADVX 0V ADVX GNDSIG
ADVX 10
ADVY 3.3V ADVY ANB
ADVY 9
PWGR 3.3V PWGR ANG
PWGR 8
ANR
GNDD 7
CSYNC
GNDD 6

GNDD 5

GNDD
NC 4

PWRVI 3

PWRVI 2

PWRVI 1

PWRVI
5.1V

DKN1385-A
CN511
>

P521 GNDD2
1 2 0V
GNDD

USB buffer

4
miniSMDC075F/24
4

USBFLG BC_VGND 0V BCGND BCAMGND


40
USBCNT BCAM_IN 0V BCIN BCAMIN
39
USB_D+ GNDD
38
ANR

GNDD
USB_D- ANR 2.1V ANR
37
GNDSIG 0.2V GNDSIG GNDSIG

3
2
1
IF

36
ANG 2V ANG

EN
R558 4.7k 35 ANG

FLG
GND
34

IC541
GNDSIG

GNDD
R549 NM 2V ANB
ANB

R5523N001B
33 ANB
7
6
5
4
3
2
1

VIN

GNDD
VDCNT5

VOUT
R548 NM 32 GNDSIG
CSYNC

4
5
2V
A4
A3
A2
A1

CSYNC
4OE
1OE

31 CSYNC
GND

R554
C547 30
C541

GNDSIG
IC542

0 ONSEI+
0.1u/10

ONSEI+ 0V
R553

DD5
1u/10 29 ONSEI+
TC7MBL6126SFK
B4
B3
B2
B1

3OE
2OE

ONSEI-
VCC

ONSEI- 0V

5.2V
0 C542 28 ONSEI-
8
9

R555 TVON
10
11
12
13
14

RGBARI 0V
0.1u/10 27 TVON
0 C543 GUIDEON 3.3V GUIDEON
26 GUIDEON
1u/10 R521 470 3.3V STON
VCC33

S_to_N
25 SYSTONAVI
N_to_S R522 470 0V NTOS
24 NAVITOSYS
44 3 3
G
34

541
GNDSIG

NDD
R549 NM 2V ANB
ANB

N001B
33 ANB

7
6
5
4
3
2
1

VIN

GNDD
VDCNT5

VOUT
R548 NM 32 GNDSIG
CSYNC

4
5
2V

A4
A3
A2
A1
CSYNC

4OE
1OE
31 CSYNC

GND
R554
C547 30

C541
GNDSIG

IC542
0 ONSEI+

0.1u/10
ONSEI+ 0V
R553

DD5
1u/10 29 ONSEI+

TC7MBL6126SFK
B4
B3
B2
B1

3OE
2OE
VCC
ONSEI- 0V ONSEI-

5.2V
0 C542 28 ONSEI-

8
9
R555 TVON

10
11
12
13
14
RGBARI 0V
0.1u/10 27 TVON
0 C543 GUIDEON 3.3V GUIDEON
26 GUIDEON
1u/10 R521 470 3.3V STON

VCC33
S_to_N
25 SYSTONAVI
N_to_S R522 470 0V NTOS
24 NAVITOSYS
44 3 3
C544 23 GNDA
0.1u/50

GNDA
22 NC
D542 AUX_VGND

GNDMP
11 2 2

B
21 NC
CTF1713-A

P,Q
L541 BTGND R532 0
DZ2S068C 20 NC
19 NC
AUX_AGND 0V AUAGND
18 BTMICGND
AUX_L 0V AUXL
17 BTMICIN

P,Q
1EQ_2BT R531 0
16 NC
5

NM
R545

5
C344 BUSL- 2.5V
BUSL-
15 BUSL-
CN2501
2.2u/10 BUSL+ R528 R523 BUSL+
2.5V BUSL+
14

GND
1k R527 180

D-2
D+2
22k GND

USB5V2
IC341 J,K,L,M 13

USBGND2
GND
BUSR- R529 R526 0V BUSR-
C341 22k BUSR-
1 14 12

RGB DRIVER
AO1 1k R524 180 BUSR+
NM VSS BUSR+ 0V BUSR+
C342 2 13 11
AO2 ASENBO
NM VFS 5.1V 4.2V ASENBO
3 TESTMONI1 12 ILMDT R331 10
E2 C2 R525 2.2k 0V BUS+
DI BUS+

GNDD
4 TESTMONI2 11 ILMCK 4 3 5.6k 9
ASENBO B2 B1 0V BUS-
C343 CLK 8 BUS-
5 AO3 10 ILMLD 5 2

14.4V

3.3k
C1 E1

R332
CSB 7 GNDD
NM 6 AO4 9 6 1
Q331 BUZZ

BUP_1
VDD BZ 0V
7 8 6 BUZZ
NC1 WIREDAD
NC2 R341 WIREDAD UMF23N 3.3V WIREDAD
5

LEDB1
LEDR1
LEDG1
WIRED 3.3V WIRED
BH2227AFV 4 WIRED
NM RCAVR

VCC33
RCA_VR 0V RCAVR
3
3216
2125
1608

REARMUTE2 5.23V REARMUTE


REARMUTE
R345 0 2
RCA_VL RCAVL
0V RCAVL

VCC33
1
1 R333
CHIP SIZE LEGEND

20 LEDB1 LEDB1 R346 0


15
19 VCC33 LEDG1 C331
LEDG1 2 HA12241FP
REM R347 0 IC331 1000p/50

C333
C332

ILMB
C545 18 3 LEDR1

0.1u/10
LEDR1 R336

1000p/50
ILMB 100 R334 47
NM 17 4 HDRST GND BUS-
CKS6051-A

HDRESET 4 5 100

GNDD
CN521

GNDD
16 GNDKEY KDT1 5 KDT_1 R349 0 DIN2 BUS+
3 6 R335
AUXR IP_to_S
15 6 KDT_0 ROUT VCC
KDT0 R348 0 2 7 R337
S_to_IP
14 AUXAGND 7 DIN1 STBY

KDT0
USB5V 1 8 1k
AUXL
13 USBGND 8
NM
R338

KDT1
9
J,K,L,M

12 AUXVGNDUSB- KDT0

C546
AUXV
VCC5

NM
11 10

D544
USB-+ KDT1
ILMGND

GNDILM
NM
1
1

6
6

CKS3861-A
R547 0

NM
P563
NM
GN D I L M
P562

2
AUX_R
CN541 TP587 R546 0
2
FOR SERVICE

AUX_AGND
R573
AUX_L VCR_V 75 VCR_VI
8 VCR_VIN
AUX_VGND VCR_VGND VCR_VIG
7 VCR_VG
AUX_V VCR_L VCR_L
6 VCR_LIN
REMIN VCR_LG
VCR_LG
22k

5
R574

P561 VCR_VO

E
RCA_V
>

4 VOUT
A-b 5/6

RESET 1 2 VCR_VOG
3 VOUT_G
GNDV

VCR_R miniSMDC075F/24 VCR_R


2 VCR_RIN
VCR_GND VCR_RG
1 VCR_RG
RCA V IN OUT

SPDIF
22k
R586

CN3501
0.1u/50
D561
D563
D562
D564

C567
C569
C568
CKB1085-A
JA561

GND

MICSENSR

TO KEYBOARD
VCR: +8.2 dBs

AEQAUXSW
R374
DZ2S068C
DZ2S068C

DZ2S068C
DZ2S068C

MICSENSL

GNDD
100k

R373

33k
RCA_RR C564 R564
C361 R372

AVH-P3200BT/XNUC
4.7u/10 39
470p/16 1.5k
22k

4.7k
R570

(3.9V)
E1
B1
C2

1
2
3

R575

NM
R581
R368 R366 R370 R367 R365
Q562

RT3C99M

R582 47k 100k 4.7k 47k 100k

7
7

6
5
4
GNDA

4.7k
22k

VDD33
B2
E2

C1

R576
R569

47k C563 R563

MIC SENS
RCA_RL

B1
E1
B1
E1

C2
C2

3
2
3
2

3
2
1
4.7u/10 39

1k
R371

INA
INB
UMF23N
UMF23N
D361

GND
4
5
1 Q364 6
4
5
1 Q363 6
RCA_SWR C566 R566

E2
B2
E2
B2
GNDD

C1
C1
RCA_RR

IC581
0V

GNDD
RKZ3.9KG(B2) 4.7u/10 39 1 REAR_R

GNDD
RCA_RL

Vcc

TC7SET08FUS1
0V

OUTY
22k

2 REAR_L
4.7k
R572
REAROUT
BT:+14.3 dBs
NAVI GUIDE:+14.3 dBs
DVD/CD:+14.3 dBs
USB/SD:+14.3 dBs
iPod(AUX):+13.4 dBs
VCR:+14.3 dBs
AUX:+14.3 dBs
IP-BUS:+14.3 dBs
AM(30%): -0.9 dBs
AM(30%)UC: -0.9 dBs
AM(30%)EW: +3.1 dBs
FM(100%): +9.1 dBs
FM(100%)UC: +9.1 dBs
FM(100%)EW:+13.1 dBs

E1
B1
C2

1
2
3

1.2k
R577

RCA_SWR
R375

0V

4
5
RCAMUTE 3 SW_R

GNDD
R362 R361
RCA_SWL 0V
Q563

10k 4 SW_L
GNDA

RT3C99M

120
100k 100k RCA_FR
4.7k

R583
6
5
4

0V
SYS+B

R364 R363
R578
22k

5 FRONT_R
B2
E2

C1

R369
R571

5.2V
C565 R565 RCA_FL 0V
Q361
D581 FRONT_L

VCC5
47k 47k RCA_SWL 6

Q365
DZ2S068C 0V
C581

Q366
4.7u/10 39 7 GND

LTA114EUB

Q362
2SA1576A(QRS)

0V

2SA1576A(QRS)

OPTB

GNDD
Q581
L582
CCG1171-A 8 GND

CTF1379-A
10/6R3 0V
RCA_FR C562 R562 9 GND

C 2
E 1
0V

2SD2114K(UVW)

2SA1576A(QRS)
C582 4.7u/10 39 10 GND
0.1u/10

100k

B3
R584
22k

4.7k
R568

L581
FRONTOUT

E1
B1
C2

1
2
3

R579

CTF1389-A
MICin
Q561

10k

R585
RT3C99M

MIC GND
MIC GND
4.7k
6
5
4
XKB7001-B
JA562

R580
22k
GNDA

B2
E2

C1
R567

RCA_FL C561 R561


RCA_G

OPTSEN
OPT
4.7u/10 39

3
2
1
C571
GNDRF

1000p/50

Q,K,L,M
S/PDIF OUT

CKN1042-A
C570

JA581
8

MIC_BIAS

NM
GNDA

8
AUX_AGND

AUX_R
2
>

P564
1
miniSMDC075F/24

GNDA

A 5/6
133
E
A

D
C

F
B
4 3 2 1
134
AVH-P3200BT/XNUC
VDCNT5
32 GNDSIG
CSYNC 2V CSYNC
31 CSYNC
30 GNDSIG
ONSEI+ 0V ONSEI+

A-b 5/6
29 ONSEI+
ONSEI- 0V ONSEI-
28 ONSEI-
RGBARI 0V TVON
27 TVON
GUIDEON
F
GUIDEON 3.3V
26 GUIDEON
S_to_N R521 470 3.3V STON
25 SYSTONAVI
N_to_S R522 470 0V NTOS
24 NAVITOSYS
23 GNDA
GNDA

22 NC
AUX_VGND
B

21 NC
P,Q

BTGND R532 0
20 NC
19 NC
AUX_AGND 0V AUAGND
18 BTMICGND
AUX_L 0V AUXL
17 BTMICIN
P,Q

1EQ_2BT R531 0
16 NC
CN2501

BUSL- BUSL-
2.5V BUSL-
15
BUSL+ R528 R523 BUSL+
2.5V BUSL+
R527 14
1k 180
22k GND
J,K,L,M 13
GND

BUSR- R529 R526 0V BUSR-


22k 12 BUSR-
1k R524 180 0V BUSR+
BUSR+ BUSR+
11
ASENBO
5.1V 4.2V 10 ASENBO
ILMDT R331 BUS+
E2 C2 R525 2.2k 0V BUS+
GNDD

ILMCK 4 3 5.6k 9 E
ASENBO B2 B1 0V BUS-
8 BUS-
ILMLD 5 2
14.4V

3.3k

C1 E1
R332

7 GNDD
6 1 BUZZ
Q331
BUP_1

BZ 0V
6 BUZZ
WIREDAD UMF23N 3.3V WIREDAD
5 WIREDAD
WIRED 3.3V WIRED
4 WIRED
RCA_VR 0V RCAVR
3 RCAVR
3216
2125
1608

REARMUTE2 5.23V REARMUTE


REARMUTE
2
RCA_VL RCAVL
0V RCAVL
1
R333
CHIP SIZE LEGEND

15
C331

HA12241FP
1000p/50

IC331
C333
C332

0.1u/10

R336
1000p/50

100 R334 47
GND BUS-
CKS6051-A

4 5 100
GNDD
CN521

DIN2 BUS+
3 6 R335
IP_to_S
ROUT VCC
S_to_IP 2 7 R337
DIN1 STBY
1 8 1k
NM
R338
J,K,L,M

KDT0
VCC5

KDT1 D
1
1

NM
P563
NM
P562

2
2
FOR SERVICE

R573
VCR_V 75 VCR_VI
8 VCR_VIN
VCR_VGND VCR_VIG
7 VCR_VG
VCR_L VCR_L
6 VCR_LIN
REMIN VCR_LG
VCR_LG
22k

5
R574

RCA_V P561 VCR_VO


>

4 VOUT
RESET 1 2 VCR_VOG
3 VOUT_G
GNDV

VCR_R miniSMDC075F/24 VCR_R


2 VCR_RIN
A-a A-b

VCR_GND VCR_RG
1 VCR_RG
RCA V IN OUT

SPDIF

22k
R586
0.1u/50
D561
D563
D562
D564

C567
C569
C568
CKB1085-A
JA561

GND
MICSENSR C
VCR: +8.2 dBs

AEQAUXSW
DZ2S068C
DZ2S068C

DZ2S068C
DZ2S068C

MICSENSL
RCA_RR C564 R564
72
4.7u/10 39
k
22k

4.7k
R570

(3.9V)
E1
B1
C2

1
2
3

R575
Q562

RT3C99M
6
5
4
GNDA

4.7k
22k

B2
E2

C1

R576
R569
C563 R563

MIC SENS
RCA_RL
4.7u/10 39
D361
RCA_SWR C566 R566
RCA_RR 0V
B2) 4.7u/10 39 1 REAR_R
RCA_RL 0V

22k
2 REAR_L

4.7k
R572
REAROUT
BT:+14.3 dBs
NAVI GUIDE:+14.3 dBs
DVD/CD:+14.3 dBs
USB/SD:+14.3 dBs
VCR:+14.3 dBs
iPod(AUX):+13.4 dBs
AUX:+14.3 dBs
IP-BUS:+14.3 dBs
AM(30%): -0.9 dBs
AM(30%)UC: -0.9 dBs
AM(30%)EW: +3.1 dBs
FM(100%): +9.1 dBs
FM(100%)UC: +9.1 dBs
FM(100%)EW:+13.1 dBs

E1
B1
C2

2
3

1.2k
R577
RCA_SWR

R375
0V
RCAMUTE 3 SW_R
RCA_SWL 0V

Q563
4 SW_L

GNDA

RT3C99M
RCA_FR

4.7k
6
5
4
0V

SYS+B
R578
22k
5 FRONT_R

B2
E2

C1
R571
B
C565 R565 RCA_FL 0V
RCA_SWL 6 FRONT_L
0V
4.7u/10 39 7 GND
0V
8 GND
C562 R562 0V
RCA_FR 9 GND
0V
4.7u/10 39 10 GND

22k

4.7k
R568
FRONTOUT

E1
B1
C2

1
2
3

R579
Q561

RT3C99M

4.7k
6
5
4
XKB7001-B
JA562

R580
22k
GNDA

B2
E2

C1
R567
RCA_FL C561 R561

RCA_G
4.7u/10 39
C571

GNDRF
1000p/50
C570
NM

GNDA
2
>
A

P564
1
miniSMDC075F/24

GNDA
4 3 2 1
8 7 6 5
135
AVH-P3200BT/XNUC
7
6
5
4
3
2
1

DD
UT

R548 NM
4
5
A4
A3
A2
A1

4OE
1OE

GND

R554
C547
C541

IC542

0
0.1u/10

A-b 5/6
R553
DD5

1u/10
TC7MBL6126SFK
B4
B3
B2
B1

3OE
2OE
VCC

5.2V

0 C542
8
9

R555
10
11
12
13
14

0.1u/10
0 C543
F
1u/10
VCC33

44 3 3
C544
0.1u/50
D542
GNDMP

11 2 2
CTF1713-A
L541
DZ2S068C
NM
R545

C344
2.2u/10
GND

D-2
D+2

USB5V2

IC341
USBGND2

C341
1 14
RGB DRIVER

AO1
C342 NM VSS
2 AO2 13
NM VFS
3 TESTMONI1 12
DI
E 4 TESTMONI2 11
C343 CLK
5 AO3 10
CSB
NM 6 AO4 9
VDD
7 NC1 8
NC2 R341
LEDB1
LEDR1
LEDG1

BH2227AFV NM
VCC33

R345 0
VCC33

20 1 LEDB1 R346 0
LEDB1
19 VCC33 LEDG1 2 LEDG1
REM R347 0
ILMB

C545 18 LEDR1 3 LEDR1


ILMB
NM 17 4 HDRST
HDRESET
GNDD

16 GNDKEY KDT1 5 KDT_1 R349 0


AUXR
15 KDT0 6 KDT_0
R348 0
14 AUXAGND 7
KDT0

USB5V
AUXL
13 USBGND 8
KDT1

12 AUXVGNDUSB- 9
C546

AUXV
NM

11 10
D544

USB-+
ILMGND
D
GNDILM
NM

CKS3861-A
R547 0
GN D I L M
AUX_R
CN541 TP587 R546 0
AUX_AGND
AUX_L
AUX_VGND
AUX_V
E

A-a A-b
CN3501
TO KEYBOARD

C
R374
GNDD

100k
R373

33k

C361 R372
470p/16 1.5k
(3.9V)

NM
R581
R368 R366 R370 R367 R365
R582 47k 100k 4.7k 47k 100k
VDD33

47k
MIC SENS

B1
E1
B1
E1

C2
C2

2
3
3
2

3
2
1
1k
R371

INA
INB
UMF23N
UMF23N

D361

GND
4
5
1 Q364 6
4
5
1 Q363 6

E2
B2
E2
B2
GNDD

C1
C1

IC581
GNDD

RKZ3.9KG(B2)

GNDD

Vcc

TC7SET08FUS1
OUTY
1.2k
R375

4
5
GNDD
R362 R361
10k

120
100k 100k

R583
SYS+B

R364 R363
R369

5.2V
B
Q361

D581

VCC5
47k 47k
Q365

DZ2S068C
C581

Q366
LTA114EUB

Q362
2SA1576A(QRS)

2SA1576A(QRS)

OPTB

GNDD
Q581
L582
CCG1171-A

CTF1379-A
10/6R3

C 2
E 1
2SD2114K(UVW)

2SA1576A(QRS)
C582
0.1u/10

100k

B3
R584

L581
CTF1389-A
MICin

10k

R585
MIC GND
MIC GND

OPTSEN
OPT

3
2
1

Q,K,L,M
S/PDIF OUT

CKN1042-A
JA581
MIC_BIAS

AUX_AGND

AUX_R
A
8 7 6 5
4 3 2 1
136
AVH-P3200BT/XNUC
A-a 5/6
A 1/6

A 4/6
A 2/6

A 2/6

F
ANA-I/F BUS

SOC-I/F BUS
SYS-I/F BUS_1
SYS-I/F BUS_2

R325 100
R326 100
R327 100
100
R319

R309 4.7k
E
R306 4.7k R305 4.7k
KN301

R302 27k R301 4.7k


M2R6TP_GND

R310
TEMPSEN1
4.7k
A 5/6 MOTHER UNIT (IN/OUT PUT)

DIMMER
R308 4.7k R307
NM
R313

MBLPW 27k
C302
BLSYNC R312 6p/50 C301
BLERR1 6p/50
GND

0
C_-IN

D_OUT 14
D_-IN 13
D_+IN 12
V- 11
C_+IN 10
9
C_OUT 8
IC301

NJM2138V
4V+

MONVBS
2A_-IN
6B_-IN

3A_+IN
5B_+IN

1A_OUT
7B_OUT
model

R304
4.7k C303 6p/50
D
R303 4.7k
R314
6p/50 C304 4.7k
R318 R315
GRST
4.7k 4.7k
G_to_S
4.7k
R328

R316
S_to_G R317 4.7k 4.7k
A-a A-b

DGCLK
Q : AVH-P3250BT/XNRD
P : AVH-P3200BT/XNUC

M : AVH-P3250DVD/XNRI

G_to_D
L : AVH-P3250DVD/XNRD
K : AVH-P3250DVD/XNRC
J : AVH-P3200DVD/XNUC

D_to_G
C315
C314
C313
C312
C311
C310
C309
C308

D301
RKZ2.4KG(B)
DCH1256-A
DCH1201-A
DCH1201-A
DCH1201-A
DCH1256-A

C305
DCH1201-A
DCH1256-A
DCH1201-A

1u/10
RGB VIDEO ISOLATOR

R320
150
R311

NM
R321
220 C
R322
C306 220
NM R323
220

NM
R324
PLYV AVCC5
PLXV
ADVX GNDSIG
ADVY ANB
PWGR ANG
ANR
CSYNC
B

>
P521 GNDD2
1 2 0V

GNDD
miniSMDC075F/24
USBFLG BC_VGND 0V BCGND BCAMGND
40
USBCNT BCAM_IN 0V BCIN BCAMIN
39
USB_D+ GNDD
38
USB_D- ANR 2.1V ANR ANR
37
GNDSIG 0.2V GNDSIG GNDSIG
IF
36
ANG 2V ANG
35 ANG
34 GNDSIG
2V ANB
ANB
33 ANB
VDCNT5
32 GNDSIG
CSYNC 2V CSYNC
31 CSYNC
30 GNDSIG A
ONSEI+ 0V ONSEI+

A-b 5/6
29 ONSEI+
ONSEI- 0V ONSEI-
28 ONSEI-
RGBARI 0V TVON
27 TVON
GUIDEON 3.3V GUIDEON
26 GUIDEON
S_to_N R521 470 3.3V STON
25 SYSTONAVI
NTOS
4 3 2 1
8 7 6 5
137
AVH-P3200BT/XNUC
A-a 5/6
A 4/6

F
SOC-I/F BUS

E
TEMPSEN1 50 TEMPSEN 2.2V TE
DIMMER DIMMER 0V
49
MBLPW 48 MBLPW 3.3V
BLSYNC BLSYNC 0V
47
BLERR 1.3V
BLERR1 46
PWRBL 45
PWRBL 44
8V
PWRBL 43
PWRBL

NC 42
GNDBL 41
GNDBL

GNDBL 40
R513
GNDBL 39
NM 2.1V
MONVBS 38
MONVBS
GNDV 37
MONITOR

N_B 2.4V N_B


N_B 36
NCSYNC 2.4V N_CSYNC
D
N_CSYNC 35
N_R 2.4V N_R
N_R 34
N_G 2.4V N_G
N_G 33
GNDV 32
GNDV

GRST 3.3V
GRST 31
GTOS 3.4V
G_to_S 30
STOG 3.3V
S_to_G 29

A-a A-b
DGCLK 3.3V DGCLK
DGCLK 28
GTOD 0V G_to_D
G_to_D 27
DTOG 3.3V D_to_G
D_to_G 26
1RST
371_RESET 25
8V
ILM+B 24
ILMB

NC 23
GNDILM 22

F 1/2 CN5002
371_KEY0 21
GNDILM

371_KEY1 20
371_REM 19
3.3V
VCC33 18
C
GNDD 17
VCC33
GNDD

GNDD 16
371_ILMB 15
371_ILMG 14
371_ILMR 13
PLYV 0V
PLYV 12
PLXV 3.3V
PLXV 11
ADVX 0V
ADVX 10
ADVY 3.3V
ADVY 9
PWGR 3.3V
PWGR 8
GNDD 7
GNDD 6
GNDD 5

GNDD
NC 4
PWRVI 3
PWRVI 2
PWRVI 1

PWRVI
5.1V
B

DKN1385-A
CN511
USB buffer
USBFLG
USBCNT
USB_D+

GNDD
USB_D-

3
2
1
EN
R558 4.7k

FLG
GND
IC541
GNDD
R549 NM

R5523N001B
7
6
5
4
3
2
1

VIN

GNDD
VOUT
R548 NM

4
5
A4
A3
A2
A1

4OE
1OE

GND
R554
C547

C541

IC542
0
A

0.1u/10
A-b 5/6
R553

DD5
1u/10

TC7MBL6126SFK
B4
B3
B2
B1

3OE
2OE
VCC

5.2V
0 C542

8
9
R555

10
11
12
13
14
0.1u/10
0 C543
1u/10

VCC33
8 7 6 5
1 2 3 4

10.6 MOTHER UNIT(TUNER)

model
A P : AVH-P3200BT/XNUC
Q : AVH-P3250BT/XNRD
J : AVH-P3200DVD/XNUC
K : AVH-P3250DVD/XNRC
L : AVH-P3250DVD/XNRD
M : AVH-P3250DVD/XNRI A 6/6 MOTHER UNIT (TUNER)
CHIP SIZE LEGEND
1608
2125
3216

ANA-TUN BUS A 1/6


B
TUN_R
P,J P,J
TUN_L
100k
GNDBE2 SYS-TUN BUS
100k

1200p/50
1200p/50

P,J
A 2/6
C414
C413

R422

R421

Q403
E1 1 6 C1 HSLK

GNDBE B1 2 5 B2
GNDBE
C2 3 4 E2
FM(100%)UC:-10.0 dBs
TUN_R

UMH1N
TUN_L

FM(100%)ES:-14.0 dBs
AM(30%)UC:-20.0 dBs R409
AM(30%)ES:-24.0 dBs RDSLK
68k
1.2V
Rch
24 1.3V Q404
C E1 1 6 C1 RDT
Lch
23 0V
P,J B1 2 5 B2
BEGND
22 GNDBE 0V R417 680
C2 3 4 E2
RDS_HSLK
21 R418 680 UMH1N RCK
0V
RDS_LOCK 3.3V
MAX.200mA
20 0V R420 680
RDS_DATA GNDD
19 R419
TUN33V
TUN_33 0V 680
RDS_CK L401 VDD33
DCH1201-A

18
0.01u/16

TUN_DGND BTH1100-A
0.01u/16

VDD_3.3
100u/16

3.3V R401 0
C404

C406

C407

R423
C410

17
FM/AM TUNER UNIT

COMP
16 0V NM C401 NM
R402
DGND
15 0V NM
NM
C412

DO
GNDRF
14 3.3V GNDD
ROM_VDD
U402

13 0V OSCGND R408 1k T_STUN


D OSCGND GNDRF
12 0V LDET LDET
LDET R410 NM
11 0V TUNDI S_TTUN
DI R411 680

TUNER BUS
10 0V TUNCK TUNCK
CK R412 680
9 0V TUNCE1 TUNCE
CE1 R413 680
8
WC 3.3V
7 TUNCE2 TUNCE2
CE2 R414 680
6 0V TUNSL TUNSL
SL
5 TUN8V R415 680 8.4V
R416

1.5k

VCC
4 0V
FM_ANT
3 0V RFGND2
SYS+B
L402
RF_GND GNDD
L403 ANT 8.4V
2 0V BTH1100-A
0.01u/50

AM_ANT (MAX140mA)
100u/16

E 1 BTH1104-A
JA402
CKX1070-A

KN401
M2R6TP_GND
1

C408

C409
IMSA-6802-01Y900

3
P401

P,J:(RDS) CWE2097-
2

Q,K,L,M:(W/O RDS) CWE2098-


RFGND

GNDRF

A 6/6
AVH-P3200BT/XNUC
138
1 2 3 4
5 6 7 8

AVH-P3200BT/XNUC
5 6 7 8
139
1 2 3 4

10.7 INTERFACE PCB

A
IP-BUS&WIREDREMOTE&BT-MIC&NAVI I/F

B INTERFACE PCB
B.CAMERA INPUT
BCAMIN B.CAM_IN
R2504 2
JA2501
CN2501 BCAMVGND CKB1065-A
CKS6062-A
75 1
0V BCV_GND

C2503
BCAMGND 1

0.1u/50
GND
0V
BCAMIN 2
0V GNDD
GNDD 3 AN
B 2.0V GND R2513
ANR 4
2.0V A
GNDSIG 5
NM A
2.0V
ANG 6
R2512 R2517 CS
GNDSIG 7
GND
2.0V NM NM
ANB 8
R2511
GNDSIG 9
2.0V R2507 NM
CSYNC 10
2.0V
GNDSIG 11
0V 75
ONSEI+ 12
0V
ONSEI- 13
0V
TVON 14
TVON2
3.3V
GUIDEON 15 R2514
GION2
3.3V
C SYSTONAVI 16 R2523
STON2 NM
NAVITOSYS 0V
17
NTOS2 GNDA NM
0V
GNDA 18
BTMICIN
R2508
100
BTMICIN2 JA2502
CKN1018-A
NC 19 R2524
A 5/6 2

NAVITOSYS
BTMICG R2509

SYSTONAVI
NC 20 GNDA 3
1 BTMICG2
D2512 NM

D2511 NM

D2515 NM

100 NM
0V
C2506

CN521
C2507

TVON
NC 21
220p/50
220p/50

NC 22 BT MIC
0V R2516 1k
BTMICGND 23
BTMICIN 24
0V P,Q R2515 1k
GND
NC 25
0V
BUSL- 26
0V R2519 470 S
BUSL+ 27
0V GND R2518 470 N
GND 28
D
0V GND
BUSR- 29
0V
BUSR+ 30

DZ2S068C
D2513

D2514

D2504

D2506

D2507

ASENBO
13.9V D2508
31
2.5V
BUS+ 32
2.5V
BUS- 33
GNDD
0V
GNDD 34
BZ
0V
BZ GND
BUZZ 35 GNDD
3.3V
WIREDAD 36
3.3V 1
WIRED 37 1
3.8V 2 BZ2501
RCAVR 38 2
RCAVR2 CPV1062-A
9.2V
REARMUTE 39
REARMUTE 3.8V
RCAVL 40
E RCAVL2 GNDD

C2501 R2502

4.7u/10 820 REAR AUDIO


R2505

JA2503
22k

CKN1081-A
C1
E2

B2

R2521 RCAVR 0V RCA_VR


4

4.7k 6
RCAVL 0V 5 RCA_VL
RT3C99M

R2506
Q2501

RCAGND 0V 4 RCA_GND
22k

WIRED 3.3V 3
WIREDAD 3.3V WIRED
2 WIREDAD
3

1
C2

B1

E1

1
R2522 GNDD
4.7k
DZ2S068C

>
DZ2S068C
D2501
D2502

D2503
D2505

miniSMDC075F/24
C2502 R2503
4.7u/10 820 2 1
WIRED REM
R2501
F P2501
1k R2510
1k

B GNDA GND GND GNDD

AVH-P3200BT/XNUC
140
1 2 3 4
5 6 7 8

C2505
TP2516

model
0.1u/50 P : AVH-P3200BT/XNUC
Q : AVH-P3250BT/XNRD
GND J : AVH-P3200DVD/XNUC
CN2502 K : AVH-P3250DVD/XNRC
CKS4497-A
L : AVH-P3250DVD/XNRD
ANR
2.0V CCR M : AVH-P3250DVD/XNRI B
1
ANG CCG
2.0V
2
ANB CCB
2.0V
3
R2517 CSYNC 2.0V CCSYNC
4
GNDSIG
NM 2.0V GNDSIG
5
DVDVBS
6
GNDDVD
7
YS
8
TP2515 13.9V NC
9
CCAUL
10
GNDAU CCAUR
11
GNDAU
NAVI I/F
12
ONSEI+
0V ONSEI+ C
R2523 13
NAVI GUIDE: +2.2 dBs
ONSEI- 14 ONSEI-
NM
15 REAUR
0V
16 REAUL
R2524
17 GNDRAU
NM
18 CCREM
0V
19 DSEN
6 1k TVON 0V
20 TVON
5 1k GION 3.3V
21 GION
22 MONON

9 470 STONAVI 3.3V


23 VSW5 J,K,L,M
24 SYS_TO_NAVI
470 0V
8 NAVITOS
25 NAVI_TO_SYS JA2504 D
0V
26
CKS3414-A
BUS+
IP BUS
GNDD D2509
1 2 2.5V
1 BUS+
C2504
GNDD NM 0V
2 BUSG
R2520
0.1u/50 0V
3 BUSLG
1 D2510 2 NM MAINTEST 4 MAINTEST
NM 2.5V BUS- 5 BUS-
GND BUSRG 6 BUSRG
0V BUSL+ 7 BUSL+
IP-BUS: +2.2 dBs 13.9V ASENBO 8 ASENBO
0V BUSR+ 9 BUSR+
0V BUSR- 10 BUSR-
0V BUSL- 11 BUSL-
E

REAR AUDIO OUT


RCA_VR
RCA_VL
REFERENCE REGEND 2501 CHIP SIZE LEGEND
RCA_GND
1608
WIRED
WIREDAD 2125
GNDD
3216 MONITOR I/F UNIT
Consists of
WIRED REMOTE INTERFACE PCB
KEYBOARD PCB F
MONITOR PCB
SD PCB
BT ANT PCB
B
AVH-P3200BT/XNUC
5 6 7 8
141
1 2 3 4

10.8 DVD CORE UNIT(GUIDE PAGE)

A
C-a
(2125)

SDODAC
SCKDAC
AVCC5

LTDAC

D+
C1801 R1803

COMPOSITE
D-
IECOUT
ROUT
ADAC D1901

FD

TD
4R7 820 NM
10

C1803
1800P
R1801
C1806

100K

R1957
NM
13 SDODAC
14 SCKDAC
NM

15 LTDAC
C1808 D1902
F R1601

R1672

200
NM NM
R1955 12K

C1604
C1602
100P
10

6 ZEROR/ZEROA 11

ZEROL/NA 12

16

68P
GNDAU1

AGND 9

DACCK
MD
MC
R1954

VCOM

ML

ADOUT

C1606
SCK
C1804
1800P

PCM1753DBQ
R1802

GNDV

SRCK
LRCK
100K

11

44
IC1801

IEC
NM C1673
GNDAU
27.000MHz R1602 T

VOUTR
R1

7 VOUTL
CSS1768

DGND
C1 8 0 2

LRCK
DATA
R1804

R1956
LOUT 12K

VCC

BCK

C1605
C1603
X1501

NM

100P
NC

68P
R1673 NM R1675

L1901
NM
4 X2 3

(IEC/IPFLG)
4 R7 820
(2125) GND2
NM R1679

5
4
3
2
1
NM
GNDD R1670 R1671
1 2

2 2

33
X1 GND1 R1603 C1601
10K 24K

220
R1508
C1674
AUDIO 2CH ANALOG OUT

R1504
C1807
C1805
C1510 C1512

12
R01

NM
10K

R1
R1
12P 10P

C1809
R1
GND

R1501

1R2K
GNDD GNDA

0R0

C1676
100
100
100
R1503
GNDAU GNDD

1
R1674

30K
VCC12 1M

TEMP

FE2
FE1
R1950

R1951
NM

NM
R1511
R1505
R1506
R1507

(1608)

TEMP
C1671

C1672
R1

R1
MDQ1

MDQ0
MDQ14

MDQ15
C1502

(2125)
10

AD2

GNDD5
C1511

C1514

C1515
B

R1

R1

R1
GNDD
GNDD GNDA

VCC33

T
F
162
161

MDQ14 160
MDQ0 159

158
157
156
155
154
153
152
151
150
149
148
147
146
145
144
143
142
141
140
139
138
137
136
135
134
133
132
131
130
129
128
127
126
125
124
123
122
121
120
119
118
117
116
115
114
113
OSCI

VSS_9
OSCO

AVDDG

COMP2

COMP1

VIN1
VIN2
VIN4
VIN3

VIN6
VIN5
MDQ1

VDD33_6

AVDDH

TEMP
VSS_10

FD
TD

VIN8

VIN7
IECOUT

ROUT

AVSSG

AVDDE
VDD12_4

VDSENS
SRCK

AVDDF

AVSSH
ADOUT

DACCK

LOUT

VREF

AD4
AD2
DAC5OUT

DAC1OUT
DAC2OUT
DAC3OUT
AVSSE
MDQ15

LRCK

AVSSF
163

COMPOSITE
MDQ13

AVDDI

AVSSI

IREF1
C1501

(2125)
10

MDQ2 164
165 MDQ13
MDQ2
GNDD C1504 166 VSS_11
VDD33_7
MDQ12 R1 167
STANDBY MDQ12
MDQ3 168
MDQ3
MDQ11 169
MDQ11
VCC33 MDQ4 170
MDQ4
MDQ10 171
L1904 MDQ10
MDQ5 172
MDQ5
173
C1490

C1489
R001

(2125)

VSS_12
10

C1505 174
VDD33_8
MDQ9 R1 175
MDQ9
IC1480 MDQ6 176
MDQ0 R1490 GNDD MDQ6
C1480 R1 1 54 177
56 MDQ8
VDD1 VSS3 R1485 MDQ8
R1480 2 53 56 178
56 DQ0 DQ15 MDQ7
C1481 3 52 MDQ15 MDQ7
MDQ1 R1 DQM0 179
C1494 NM VDDQ1 VSSQ4 5 4
5 4 4 51 MDQ14 DQM0
MDQ2 DQM1 180
DQ1 DQ14 6 3
6 3 5 50 MDQ13 DQM1
MDQ3 XWE 181
DQ2 DQ13 R1 7 2
7 2 6 49 NWE
MDQ4 C1488 182
VSSQ1 VDDQ4 8 1
8 1 7 48 NM R1512 VSS_13
C1491 L1512 183
DQ3 DQ12 R1486
8 47 MCK
C R1481
56
C1482
R1 9
DQ4 DQ11
46
56
MDQ12
C1506 100 184
185
VDD33_9
VDDQ2 VSSQ3 5 4 MCK R1
5 4 C1493 NM 10 MDQ11 MCKI
MDQ5 45 186
DQ5 DQ10 6 3
6 3 MDQ10 VSS_14
MDQ6 11 44 C1503 R1 187
DQ6 DQ9 R1 7 2
7 2 MDQ9 VDD12_5
MDQ7 12 43
8 1 13
VSSQ2 VDDQ3
42
C1487 8 1 XCAS 188
NCAS IC1501
C1492 NM MDQ8 189
DQ7 DQ8 XRAS
C1483 NM 14
VDD2 VSS2
41 R1489
56 XCSM R1538 190
NRAS MN2DS0018MAUB
C1484 R1 15 40 NCSM
DQM0 191
LDQM N.C/RFU
5 4 16 39 STANDBY
XWE 100K 192
R1482 WE UDQM MA11
6 3 17 38 DQM3
XCAS 56 MCK BA0 193
CAS CLK
7 2 18 37 BA0
XRAS MA9 194
RAS CKE
8 1 19 36 MA9
XCSM DQM1 195
CS N.C
5 4 20 35 56 5 4 VSS_15
BA0 MA11 C1507 196
R1483 BA0 A11
6 3 21 34 R1487 6 3 VDD33_10
BA1 56 MA9 BA1 R1 197
BA1 A9
7 2 22 33 7 2 BA1
MA10 MA8 MA8 198
A10/AP A8
8 1 23 32 8 1 MA8
MA0 56 MA7 MA10 199
A0 A7
5 4 24 31 R1488 5 4 MA10
MA1 MA6 MA7 200
R1484 A1 A6
6 3 25 30 6 3 MA7
MA2 56 MA5 MA0 201
A2 A5
7 2 26 29 7 2 MA0
MA3 MA4 MA6 202
A3 A4
8 1 C1485 27 8 1 MA6
28 203
VDD3 VSS1 MA1
MA1
R1 204
C1486 K4S641632N-LC75 VSS_16
C1508 205
DGND3 VDD33_11
NM
SDRAM MA5 R1 206
MA5
MA2 207
MA2
MA4 208
GNDD MA4
MA3 209
MA3
210
D C1509 211
VSS_17
VDD12_6
R1 212
EXADT0
213
NEXCE
214

USB CLOCK
NEXOE

CP_READY
EXDT0
EXADR16

EXADR19

EXADR18
EXADR17
EXADT15
EXADT14
EXADT13
EXADT12
EXADT11
EXADT10

215
VDD33_1

VDD33_2

VDD12_1

VDD33_3

VDD12_2

I2C_SCL
I2C_SDA

IRQPWR
EXDT8
EXADT9
EXADT8

EXADT7
EXADT6
EXADT5
EXADT4
EXADT3
EXADT2
EXADT1
EXDT10

EXDT11

EXDT12

EXDT13

EXDT14

EXDT15

NEXWE
EXDT1
3 EXDT9
EXDT2

EXDT3

EXDT4

EXDT5

EXDT6

EXDT7
VSS_1

VSS_2

VSS_3

VSS_4

VSS_5
216

08EJ
DEBUG
1
2

6
7
8
9
5

10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
41
42
43
44
45
46
47
48
49
50
VCC33
R1

C1516 R1

R1

C1518 R1

C1519 R1
GNDD

R1542

10K
C1517
C1513
1 20
2 19
3 18
4 17
5 16
6 15
7 14
8 13
9 12

CN1951
1011

6R8K
6R8K
R1546
R1527
DGND2
R1517
R1528
R1529
R1530

R1531
10K
10K
10K

10K

10K
10K

R1539
100K
R1518

NM

GNDD
A20 R1547
TRCDATA3
TRCDATA2
TRCDATA1
TRCDATA0

NM
SCLOCK
TRCCLK
EXTRG0

C1525
TRCST

SDATA

XCSF2

NM
XWR1
XRD

D10

D11

D12

D13

D14

D15

A16

A15
A14
A13
A12
A11
A10

A19

A18
A17
D0

D8

D1
D9
D2

D3

D4

D5

D6

D7
A0

A9
A8

A7
A6
A5
A4
A3
A2
A1

VD8
E
C1201
100/16

VC
FLASH 16M VCC33 FLASH 16M VCC33
PGND
IC1401 IC1402 HOM

A15 1 48 A16 A15 1 48 A16 C1203 08E


A15 A16 A15 A16 C1409
2 47 C1404 A14 2 47 4R7
A14 4R7 HUP 20 21 NM
A14 /BYTE A14 /BYTE HU+ VM_S
(2125) 3 46 (2125)
A13 3 46 A13 HUM 19 22 C1204
A13 Vss2 A13 Vss2 HU- BH
4 A12 45 R1213
A12 4 A12 45 D15 A12 D15 HVP 18 23 2200P COILW
1
DQ15_A-1 DQ15_A-1 HV+ SPRNF
A11 5 44 D7 A11 5 44 D7 C1209 R1214 COIL
A11 DQ7 A11 DQ7 HVM 17 24
HV- SPVM 1
A10 6 43 D14 A10 6 43 D14 R1215 COIL
A10 DQ14 HWP 16 25 R1
A10 DQ14 HW+ SPGND
7 42 A9 7 42 D6 S 1 HWP
A9 D6 A9 DQ6 HWM 15 26 COILU R1216
A9 DQ6 HW- U
A8 8 41 D13 A8 8 41 D13 R1212 S 1 HWM
A8 DQ13 A8 DQ13 HBM 14 27 COILV
270 HB V R1217
A19 9 40 D5 A19 9 40 D5 C1208 S HVP
A19 DQ5 A19 DQ5 13 28 COILW 1
R01 SPCNF W R1218
10 39 D12 A20 10 39 D12 FG HVM
XWR1 NC1 DQ12 NC1 DQ12 C1408 FG 12 FG 29
C1403 SLVM 1
XWR1 11 38 D4 XWR1 11 38 R1 D4 HUP
R1 /WE DQ4 11 TEST PGND 30 C1205
/WE DQ4 GND2
NRES R1401 12 /RESET 37 C1402 NRES R1403 12 /RESET 37 C1407 10 GND141 31
R1 C HUM
Vcc Vcc SL/LDO+
NM
C1405

220 13 36 NM C
C1401

13 36 D11 CONT2 HBM


NM

NM D11 R1201 220 9


R01

C1210

NC2 DQ11 CONT2 32


C1211

NC2 DQ11 CTL2 SL/LDO-


R1
(3216)
4R7

14 35 D3 14 35 D3 CONT1 8 33 F FOP2
NC3 DQ3 CONT1 R1202 220 FOP
NC3 DQ3 CTL1 FCO+
15 34 D10 15 RY_/BY 34 D10 MD1 S MD2 7 34 F FOM2
RY_/BY DQ10 MD FCO- FOM
GNDD DQ10 GNDD SPIN
A18 16 33 D2 A18 16 33 D2 LDIN 6 35 T TOM2
A18 DQ2 A18 DQ2 LDIN TOM
LDIN TKO+
A17 17 32 D9 A17 17 32 D9 R1204 5 36 T TOP2 PGND
A17 DQ9 A17 DQ9 CRGDRV R1203 C TOP
CRGDRV SLOPOUT
A7 18 31 D1 A7 18 31 D1 15K 4 TKO- 37
A7 DQ1 A7 DQ1 10K SLIN AVM
A6 19 30 D8 A6 19 30 D8 FD1 F 3 FCIN 38
A6 DQ8 A6 DQ8 FD
20 29 PREVcc
A5 20 29 D0 A5 D0 TD TD1 T 2 TKIN 39
A5 DQ0 A5 DQ0 C1207
21 28 PREGND R1
21 28 A4 XRD
42
A4 XRD A4 /OE VHALF 1 40
A4 /OE
F A3 22
A3 Vss1
27 A3 22
A3 Vss1
27
R1406
VHALF VC SUBGND

23 26 A2 23 26 100K IC1201
A2
R1405

A2 /CE
R1402

100K

A2 /CE PGND2 PGND1 BD8231EFV


100K

A1 24 25 GNDD A1 24 25
A1 A0 A1 A0
A0 XCSF1 A0 XCSF2
CWW2267 CWW2268 PGND
R1409
NM
GNDD

C
AVH-P3200BT/XNUC
142
1 2 3 4
5 6 7 8

C-b C DVD CORE UNIT


A
F
FOCUS SERVO LINE
FD

TD

T
VCC33 1000->1049 :POWER SUPPLY
TRACKING SERVO LINE
C

C1607
1100->1199 :PU
CARRIAGE SERVO LINE

10
(2125)
F R1601 1200->1299 :ACT+SPDL
1400->1449 :FLASH S
12K
AGND2
1480->1499 :SDRAM SPINDLE SERVO LINE
C1604
C1602
100P

68P

1500->1599 :DVN(SYS)
GNDA RF SIGNAL
C1606

1600->1669 :DVN(FE)
R1

1670->1699 :DVN(BE)
R1602 T 1700->1749 :VIDEO
1800->1849 :AUDIO (ANALOG)
12K 1850->1899 :AUDIO (DIGITAL)
5.0-3.3&1.2 V DC/DC
C1605
C1603
100P

68P

1900->1950 :OUTSIDE I/F


1950->1999 :USB

L1004

C1008
VDD5

C1009
603 C1601 C1014

10

10
0K R01 VCC12-1 DDF
VCC12 10
GNDA VOLTAGE DETECT L1003 8
IC1005
1 C1013
VDSENS
VCC33 FB12A LX PGND
7 2 10

R1002
100
AGND VIN
6 3
TEST VDD
TEMP

FE2
FE1

FB12B
F+H_G+H
E+G_E+F

R1001
5 4

NM
(1608)
VSENS R1011 VOUT CE
C1608

C1012
(1608) 1 R1008 IC1001

NM
1 4 NM
TEMP

VDSENS R1232D121B
C1623 OUT
VHALF NM
VSS GND_DD GND_DCON
(1608) 1 VREF (2125)
VD8 2 3 R1017
AD2 VREF VDD NC GND_DCON
NM NM

NJM2885DL1-33
GND_DD B

R1004
GNDD

47K

IC1004

2 GND
3 OUT

1 IN
VCC33-1

R1007

C1018
6R8K
123
122
121
120
119
118
117
116
115
114
113
112

E+G_E+F 111
VREFH 110
109

VCC33

R1
R1604 1M

C1010

C1011
2R2
VIN1
VIN2
VIN4
VIN3

VIN6
VIN5
TEMP

1
VIN8

VIN7

F+H_G+H
VDSENS
AD4
AD2

108 R1605
VHALF

1M
107 C1609 R1 GNDD
AVSSB
AVDDB 106 LPCO2
LPCO2
105 CDMPD GND_DD
CDMPD
104 LPCO1
LPCO1 EF1001
103 DVDMPD VD8_2 VD8_1
DVDMPD L1902
102 C1610 R1 1 3
VREFL5 VD8
101 C1611 R1

C1017

NM
VREFH5
100 C1612 2 PGND5 PGND4 PGND3
R1 GNDA B
VIN3RF
99 C1613 R1 A
VIN4RF
98 C1614 R1 C VCC5_1
VIN2RF PGND
97 C1615 R1 D
VIN1RF VCC5
96 C1616 R1 RF
RFINP IC1002
95 C1617 R1
RFINN S-1133B50-U5
94 ANAMONI2 ON/OFF VIN
ANAMONI2
93 ANAMONI1 3 4
ANAMONI1 VSS
92 GNDA USBGNDD GNDD 2
AVDDC NC VOUT
91 C1618 1 5

C1003 R1
100P

C1004
CDATA
90 C1619

(2125)
5600P
C1626

C1019
NM

CCAPA

4R7
89 C1625
AVSSC R1
88 C1620 R22 R1
VREFL7
PGND GNDD
AVSSD
87
86 C1621 R22
C1624
R1
GNDA
IC1003
C
AVCC5 VD
VREFH7
C1627

NM

85 C1622 R033 GNDA 5 1


VOUT VIN
PLFIL1
84
AVCC5 2
AVDDD VSS
HOST I/F
C1001

C1005
C1521 GNDA 4 3

(1608)
(1608)

83 R1
1

1
VDD12_3 C1953 NC ON/OFF

VSS_8
82 DEBUG NM
(1005) C1006 C1021
81 TRCST S-1200B50-M5
TRCST
TRCST C1954 NM 680P
80 VD8
TRCDATA3 (1608) C1007
TRCDATA3 47P
TRCDATA2
79 TRCDATA2
C1934
(1608)
NM C1022
680P
CN1901

C1015
78 CKS6025

R001
TRCDATA1 GNDAU
TRCDATA1 DGND1 GNDV GNDD GNDAU GNDD 1 VD8
77 68P
TRCDATA0
TRCDATA0 GNDD GNDA 2 VD8
76 TRCCLK PGND
TRCCLK R1524 GNDD (3216) DGND4 3 VD8
4R7K
75 AMUTE AGND1 AGND4 R1015
EXTRG1 4 PGND
74 EXTRG0
EXTRG0 R1509 GNDA NM 5 PGND
1K VDD5_2
73 SDATA SDATA L1903 VDD5_1
SDATA R1510 6 DGND
1K EF1002
72 SCLOCK SCLOCK
SCLOCK VD5

R001
R1516 7

C1016
71 10K FG 1 3
FG VDD5 8 AMUTE
70 R1523 220 NRES
NRES GNDD 9 XRESET
69 C1526 R01 NRES 2 GNDD
AMUTE IRQPWR
VDD33_5
VSS_7
CRGDRV
68
67 C
C1522
R1513
R1

10K
R1522 100K
C1523
R1 CRGDRV
AMUTE
NRES
IRQPWR
R1019
100 NRES

IRQPWR
10
11
12
HSTCMD

SLVSTS
A 2/6
C1524
66 S
MD
65
R1514
R1526
18K
10K
R047 MD
CMDCOMN CMDCOMN 13 STANBY CN751
HOME STSCOMN
HOME NM STSCOMN 14 AGND
64 CONT2
CONT2 STANDBY R1025 STANBY 15 ANALOG ROUT
C1527
63 CONT1 100
CONT1 16 AGND
62 LDIN RO
LDIN 17 ANALOG LOUT
61 ROUT
CP_Reset
60 CP_RESET
R1535
100K
R1532
CP_Reset

LO
18 AGND D
P13 NM 19 COMPOSIT
59 XCSF1 LOUT
XCSSR WAKEUP 20 VIDEO GND
58 SCKDAC R1026
SCKDAC COMPOSITE 21 WAKEUP
COMPOSITE R1027
SDODAC 57 1K
USB_CLOCK

R1519 SDODAC NM
100
CP_READY

CMDCOMN

D- 22 D-
STSCOMN

LTDAC
12EJ 56
VDD12_2

VDD33_4
I2C_SCL

LTDAC D-
I2C_SDA

IRQPWR
EXADT4
EXADT3
EXADT2
EXADT1

23 D+
VSS_5

VSS_6

55 D+ D+
08EJ

24 DGND
R1525 10K
IECOUT
25 IECOUT
R1540 220
40
41
42
43
44
45
46
47
48
49
50
51
52
53
54

R1537 STSCOMN
CMDCOMN 26 DGND
I2C_SCL SCL
R1541 220 100K R1536 27
R1534 IRQPWR SDA SCL
I2C_SDA
220 100K 28 SDA
C1529

CP_Reset RESET
NM
C1519 R1

29 RESET
C1520

C1528
R1542

R1
10K

470P 30 DGND
R1021
0R0

GNDV
GNDAU2
R1543
6R8K
6R8K
R1546

NM I2C_SCL
R1527

GNDAU3
R1539
100K

CP_READY
R1544 NM I2C_SDA
R1533 GNDAU GNDV GNDD

100K
08EJ
R01
A20 R1547

CN1101
NM

CKS5775
C1525

VCC5_3
NM

VCC5
C1108

1 GND
A4
A3
A2
A1

2 Vref
C1110 VREF
3 VCC
F+H_G+H R01 F+H_G+H
C1101

4 F+H/G+H
10

E+G_E+F E+G_E+F E+G/E+F


(1608*4) 5

AGND3 R1113 R1118 6 SW


CDLD0
CN1201 7 78LD
E
R1110

CKS6003
R1

GNDA 1R5 1R5


PICKUP UNIT (SERVICE)
3R3

DVDLD0
8 65LD
R1105

CDLD1
390

VCC5
C1105

R1114 R1117 9
C1112

LD GND
1 GNDD C1950 B B
48.000MHz 1R5 1R5 10 B
22

GNDD NM Q1104 A A
2 2SB1132 11 A
1M

HOME X1950
HOME 4 LPCO2 Q1102
X2 3
NM

3 HOME 5 1 C C
VCC NC GND2 2SC4081 12 C
R1102 100K

08EJ CD
10P R1953

08EJ 8cm 2 D D
4
R1106

C1107
NM

13 D
R01

IN_A
12EJ 1 2
560
C1952

5 12cm(DSCSNS) 4 3 FE1 FE1


NM

OUT_Y GND GND1 14 FE1


48MHz

R1222 HB+ X1
6 HALL_BIAS+ NM FE2 FE2
15 FE2
NM

R1213 S 270 COILW IC1951


COILW
1 7 COIL_W NM GNDA
16 78MDG
R1214 COILU S COILU
8 COIL_U GNDD CDMPD CDMPD
17 78MD
1 S
R1215

R1216
1
COILV
HWP
COILV

W+
9 COIL_V
10 HALL_W+
D R1301
(1608*4)
R1112 R1115
DVDMPD

1
DVDMPD
18 65MD
19 65MDG
C1113 R1109

1 HWM W- 1R5 1R5


11 HALL_W- CN701
3R3

TEMP
R1217 NM 20 TEMP
C1104
R1
R1103

HVP V+ R1300 DVDLD1


12 HALL_V+ <TC7SZ126FU>
390

1 21 TEMP GND
R1218 HVM V- 0R0
IC1006 VCC33 IN G OUT R1111 R1116
RF
13 HALL_V- RF
22

1 1 5 X L Z 1R5 1R5 22 RF
HUP U+ G VCC T TOP1
14 HALL_U+ L H L Q1103 TOP
23 T+
2 2SB1132
HUM U- IN F
15 HALL_U- H H H LPCO1 FOM
24 F-
HB- 3 4 Q1101
HBM GND OUT F
16 HALL_BIAS- X:Don’t Care FOP1
C1210

R1101 100K

DVD FOP
C1211

2SC4081 25 F+
R1
(3216)
4R7

C1106

C Z:High Impedance
R01

COM T
C1302

R1104
NM
C1301

17 CRG/LE- TOM
510
NM

C NM 26 T-
COP
18 CRG/LE+

3
C1109

C1111

PGND GNDA
(1608)

(1608)
R22

R22

GNDD

GNDD
GNDA PU(DP10)
F
MOTOR DRIVER

C
AVH-P3200BT/XNUC
5 6 7 8
143
F
E
B
A

D
C

144
C-a C-b
C-b
C DVD CORE UNIT

1
1

F
FOCUS SERVO LINE

FD
TD
T
VCC33 1000->1049 :POWER SUPPLY
TRACKING SERVO LINE
1100->1199 :PU C

10
R1601 1200->1299 :ACT+SPDL CARRIAGE SERVO LINE

C1607
1400->1449 :FLASH S

(2125)
AGND2 SPINDLE SERVO LINE
12K 1480->1499 :SDRAM
GNDA 1500->1599 :DVN(SYS)

68P

100P
1600->1669 :DVN(FE) RF SIGNAL

C1604

C1602
R1
1670->1699 :DVN(BE)

C1606
R1602 T 1700->1749 :VIDEO
1800->1849 :AUDIO (ANALOG)
12K 1850->1899 :AUDIO (DIGITAL)
1900->1950 :OUTSIDE I/F 5.0-3.3&1.2 V DC/DC

68P

100P
C1605

C1603
1950->1999 :USB

L1004
C1601 C1014 VDD5

10
10

C1008
R01

C1009
VCC12-1 DDF
VCC12 10
IC1005
GNDA VOLTAGE DETECT L1003 8 1 C1013
VDSENS FB12A
VCC33 LX PGND
7 2 10
AGND VIN

100
6 3

R1002
TEST VDD
FB12B 5 4
(1608)

FE2
FE1
NM
VOUT CE

TEMP
C1608 VSENS R1011

R1001

2
2

(1608) 1 R1008 IC1001

F+H_G+H
E+G_E+F
VDSENS 1 4 NM R1232D121B
NM

OUT
C1012

C1623 VSS GND_DD GND_DCON


VHALF NM
(1608) 1 VREF (2125)
VD8 2 3 R1017
VREF VDD NC GND_DCON
NM NM
GNDD GND_DD

47K

R1004
IC1004
3 OUT
2 GND
1 IN

VCC33-1
NJM2885DL1-33

R1604

R1
VCC33

122
121
120
119
118
117
116
115
114
113
112
109
1M

6R8K

R1007
C1018
1

2R2

108 R1605
1M
C1010
C1011

VIN1
VIN2
VIN4
VIN3
VIN6
VIN5

VIN8
VIN7
C1609

TEMP
107 R1 GNDD

VHALF
VREFH 110

VDSENS
AVSSB

E+G_E+F 111
F+H_G+H
AVDDB 106 LPCO2
LPCO2
105 CDMPD GND_DD
CDMPD
104 LPCO1
LPCO1

AVH-P3200BT/XNUC
EF1001
103 DVDMPD VD8_2 VD8_1
DVDMPD L1902
102 C1610 R1 1 3
VREFL5 VD8
101 C1611 R1
VREFH5

NM
100 C1612 2 PGND5 PGND4 PGND3
R1 B

C1017
VIN3RF GNDA
99 C1613 R1

3
3

A
VIN4RF
98 C1614 R1 C VCC5_1
VIN2RF PGND
97 C1615 R1 D
VIN1RF VCC5
96 C1616 R1 RF
RFINP IC1002
95 C1617 R1
RFINN S-1133B50-U5
94 ANAMONI2 ON/OFF VIN
ANAMONI2
93 ANAMONI1 3 4
ANAMONI1 VSS
92 GNDA USBGNDD GNDD 2
AVDDC NC VOUT
91 C1618 100P 1 5
CDATA
90 C1619 5600P C1019
C1004

CCAPA

NM
89 C1625
4R7
(2125)

C1626
C1003 R1

AVSSC R1
88 C1620 R22 R1
VREFL7
87 C1624 PGND GNDD
AVSSD GNDA
86 C1621 R22 R1 IC1003
AVCC5 VD
VREFH7
85 C1622 R033 GNDA 5 1

NM
PLFIL1 VOUT VIN

C1627
84
AVCC5 2
AVDDD VSS
C1521 GNDA 4 3
1

83 R1 NC ON/OFF HOST I/F


VDD12_3 C1953
C1005

C1001
(1608)

82
(1608)

VSS_8
DEBUG (1005) C1006
NM S-1200B50-M5 C1021
81 TRCST TRCST
TRCST C1954 NM 680P
80 VD8
TRCDATA3 (1608) C1007

4
4

TRCDATA3 47P
79 TRCDATA2 C1022
TRCDATA2 C1934 NM CN1901
78 (1608) 680P
TRCDATA1 CKS6025
TRCDATA1 DGND1 GNDAU GNDV GNDD GNDAU GNDD 1 VD8
68P
R001

77
C1015

TRCDATA0
TRCDATA0 GNDD GNDA 2 VD8
76 TRCCLK PGND
TRCCLK R1524 GNDD (3216) DGND4 3 VD8
4R7K
75 AMUTE AGND1 AGND4 R1015
EXTRG1 4 PGND
74 EXTRG0
EXTRG0 R1509 GNDA NM 5 PGND
1K VDD5_2
73 SDATA SDATA L1903 VDD5_1
SDATA R1510 6 DGND
1K EF1002
72 SCLOCK SCLOCK
SCLOCK R1516 7 VD5
71 10K FG 1 3
AMUTE
R001

FG VDD5 8
C1016

70 R1523 220 NRES


NRES GNDD 9 XRESET
69 C1526 R01 NRES 2 GNDD
AMUTE IRQPWR
VDD33_5 R1522 100K AMUTE R1019 10
68 C1522 R1 100
VSS_7 C1523 NRES NRES HSTCMD
11
R1513
67 C 10K R1 CRGDRV
A 2/6
TRCDATA0 GNDD GNDA 2 VD8
76 TRCCLK PGND
TRCCLK R1524 GNDD (3216) DGND4 3 VD8
4R7K
75 AMUTE AGND1 AGND4 R1015
EXTRG1 4 PGND
74 EXTRG0
EXTRG0 R1509 GNDA NM 5 PGND
1K VDD5_2
73 SDATA SDATA L1903 VDD5_1
SDATA R1510 6 DGND
1K EF1002
72 SCLOCK SCLOCK
SCLOCK R1516 7 VD5
71 10K FG 1 3
AMUTE

R001
FG VDD5 8

C1016
70 R1523 220 NRES
NRES GNDD 9 XRESET
69 C1526 R01 NRES 2 GNDD
AMUTE IRQPWR
VDD33_5 R1522 100K AMUTE R1019 10
68 C1522 R1 100
VSS_7 C1523 NRES NRES HSTCMD
11
R1513
CRGDRV
C 67 10K R1 CRGDRV
IRQPWR IRQPWR 12 SLVSTS
A 2/6
R1514 C1524
66 S 18K R047 MD
MD CMDCOMN CMDCOMN 13 STANBY CN751
65 R1526 10K
HOME STSCOMN
HOME NM STSCOMN 14 AGND
64 CONT2
CONT2 STANDBY R1025 STANBY 15 ANALOG ROUT
C1527
5

63

5
CONT1 100 AGND
CONT1 16
62 LDIN RO
LDIN 17 ANALOG LOUT
61 ROUT
R1535 CP_Reset
CP_Reset 100K 18 AGND
60 CP_RESET R1532 LO
P13 NM 19 COMPOSIT
59 XCSF1 LOUT
XCSSR WAKEUP 20 VIDEO GND
58 SCKDAC R1026
SCKDAC COMPOSITE 21 WAKEUP
COMPOSITE R1027
SDODAC 57 R1519 1K SDODAC NM
100 D- 22 D-
LTDAC
12EJ 56 LTDAC D-
23 D+
55 D+ D+
24 DGND

I2C_SCL
R1525

EXADT2
EXADT1
VSS_5
VDD12_2
IRQPWR
USB_CLOCK
VSS_6
VDD33_4
CMDCOMN
STSCOMN

CP_READY
I2C_SDA
08EJ
10K
IECOUT
25 IECOUT

41
42
43
44
45
46
47
48
49
50
51
52
53
54
R1537 R1540 220 STSCOMN
CMDCOMN 26 DGND
I2C_SCL SCL
R1541 220 100K R1536 27
R1534 IRQPWR SDA SCL
I2C_SDA
220 100K 28 SDA
CP_Reset RESET
29

NM
C1528 RESET

C1529
470P

R1
30 DGND

10K
C1520
GNDV

R1542

C1519 R1
GNDAU2
0R0
R1021

R1543 NM I2C_SCL GNDAU3


CP_READY

6R8K
6R8K
R1546
R1544 NM I2C_SDA

100K
R1527

R1539
R1533 GNDAU GNDV GNDD

6
6

100K
08EJ
R01

NM
CN1101 CKS5775
VCC5_3

NM
VCC5 1 GND

C1525

A2
A1
A20 R1547
C1108

2 Vref
C1110 VREF
3 VCC
F+H_G+H R01 F+H_G+H
4 F+H/G+H

10
E+G_E+F E+G_E+F E+G/E+F

C1101
(1608*4) 5

AGND3 R1113 R1118 6 SW


CDLD0
CN1201 CKS6003 1R5 1R5 7 78LD
R1

GNDA DVDLD0
3R3

8 65LD
R1110

CDLD1
VCC5 R1114 R1117
390

9 LD GND
R1105

1 GNDD C1950 B B
C1105

48.000MHz 1R5 1R5 10 B


22

C1112

GNDD NM Q1104 A A
2 2SB1132 11 A
HOME X1950

1M
HOME 5 1 4 LPCO2 Q1102 C
3 HOME X2 3 C

NM
VCC NC GND2 2SC4081 12 C
08EJ 08EJ 2 CD D
4 8cm D
IN_A 13 D

NM
12EJ 1 2
R01

5 12cm(DSCSNS) 4 3 FE1 FE1


560
R1106
C1107

AVH-P3200BT/XNUC
OUT_Y GND X1 GND1 14 FE1

NM
R1222 HB+ FE2

C1952
6 HALL_BIAS+ NM FE2
R1102 100K

10P R1953
R1213 15 FE2

48MHz
S 270 COILW IC1951

NM
COILW GNDA
1 7 COIL_W NM 16 78MDG
R1214 COILU S COILU CDMPD
GNDD CDMPD

7
7

8 COIL_U 17 78MD
1 COILV (1608*4)
R1215 COILV S DVDMPD DVDMPD
9 COIL_V 18 65MD
1 HWP W+ D R1112 R1115
R1216 10 HALL_W+ R1301 19 65MDG
1 HWM W-
11 HALL_W-
1R5 1R5 TEMP
1
R1217 NM 20 TEMP
3R3

HVP V+
CN701 R1300 DVDLD1
R1

12 HALL_V+ <TC7SZ126FU>
1
390

R1218 IC1006 R1111 R1116 21 TEMP GND


C1104

VCC33 IN G OUT
R1103

HVM V- 0R0 RF RF
13 HALL_V-
PICKUP UNIT (SERVICE)

1 5 X L Z 22 RF
22

1 U+ 1R5 1R5
C1113 R1109

HUP G VCC TOP T TOP1


14 HALL_U+ L H L Q1103
2 2SB1132
23 T+
HUM U- IN H H H FOM F
15 HALL_U- LPCO1 24 F-
HB- 3 4 Q1101
HBM GND OUT X:Don’t Care FOP F FOP1
16 HALL_BIAS- DVD 2SC4081
Z:High Impedance 25 F+

R1
C COM T

4R7
TOM
R01

C1210
17 CRG/LE-

C1211
NM
NM 26 T-

(3216)
510
C1106

NM
C COP

C1302
R1104

C1301
18 CRG/LE+
R1101 100K

PGND 3 GNDA
GNDD
R22
R22

C1109
C1111

(1608)
(1608)

GNDD PU(DP10)
GNDA
8

MOTOR DRIVER

8
C-a C-b
C-b

145
E
A

D
C

F
B
F
E
B
A

D
C

146
C-a C-b
C-b

C-a
(2125)
C1801 R1803

1
1

D+
D-
ROUT
ADAC D1901
4R7 NM
FD
TD

820

LTDAC

SDODAC
SCKDAC
IECOUT
10

AVCC5
C1806

COMPOSITE
NM

100K
NM

1800P
C1803

R1801
D1902

R1957
C1808 F R1601

LTDAC
NM NM

200
R1955 12K

R1672

10
13 SDODAC
14 SCKDAC
15
16
GNDAU1
68P

R1954
100P
C1604

C1602

MD
MC
ML
GNDV

SCK

AGND 9
11
44
NM C1673

100K
1800P
C1804
DACCK

LRCK
SRCK

R1802
IEC
ADOUT
27.000MHz R1602 T
GNDAU

ZEROL/NA 12
R1

IC1801
C1 8 0 2 R1804 CSS1768
LOUT X1501 12K

ZEROR/ZEROA 11
R1673 NM R1675

VOUTR
VOUTL VCOM
VCC
NC
DGND
LRCK
DATA
BCK
NM

PCM1753DBQ
4 R7 4
68P

NM
820 X2 3

R1956
100P

GND2
C1605

C1603

8
7
6
5
4
3
2
1
(2125) NM R1679 NM

L1901
GNDD R1670 R1671
1 2
GND1

(IEC/IPFLG)
X1

2 2
33
10K 24K R1603 C1601
C1674

220
C1510 C1512 R01

12
R1 10K

NM

R1
AUDIO 2CH ANALOG OUT

R1508

R1504
12P 10P

C1807

C1805
R1
C1809
GNDD GNDA

1R2K
R1503

0R0
100
100
100

R1501
1

GNDAU GNDD
C1676

VCC12 1M
30K

R1674
FE2
FE1

TEMP

NM
NM

2
2

R1950
R1951

R1511
R1505
R1506
R1507
(1608)

R1
TEMP

R1

C1671
C1672

10
MDQ1
MDQ0
AD2

C1502
MDQ14
MDQ15

(2125)
R1
GNDD

R1
R1

C1511
GNDD GNDA

C1514
C1515
GNDD5
VCC33
T
F

162
161
158
157
156
155
154
153
152
151
150
149
148
147
146
145
144
143
142
141
140
139
138
137
136
135
134
133
132
131
130
129
128
127
126
125
124
123
122
121
120
119
118
117
116
115
114

163
FD
TD

MDQ13
AD4
AD2
VIN1
VIN2
VIN4
VIN3
VIN6

VIN8
VIN7

OSCI
LOUT
VREF
TEMP

MDQ1
MDQ0 159
OSCO
LRCK
SRCK
ROUT

10
164

VSS_9
MDQ2
AVSSG
AVDDG
AVDDE
AVSSE
AVSSF
COMP2
IREF1
COMP1
AVDDF
AVDDH
AVSSH

MDQ14 160
MDQ15
ADOUT
DACCK
AVDDI
AVSSI

VSS_10
IECOUT

C1501
VDSENS

VDD33_6
MDQ13

VDD12_4

(2125)
165
DAC5OUT
DAC1OUT
DAC2OUT
DAC3OUT

MDQ2
VSS_11
COMPOSITE

GNDD C1504 166


VDD33_7
MDQ12 R1 167

AVH-P3200BT/XNUC
STANDBY MDQ12
MDQ3 168
MDQ3
MDQ11 169
MDQ11
VCC33 MDQ4 170
MDQ4
MDQ10 171
L1904 MDQ10
172

3
3

MDQ5
MDQ5
173
VSS_12

10
C1505 174

R001
C1490
C1489
VDD33_8

(2125)
MDQ9 R1 175
MDQ9
IC1480 GNDD MDQ6 176
MDQ0 R1490 MDQ6
C1480 R1 1 54 177
56 MDQ8
R1480 VDD1 VSS3 53 R1485 MDQ8
2 56 178
56 DQ0 DQ15 MDQ7
C1481 3 52 MDQ15 MDQ7
MDQ1 R1 DQM0 179
VDDQ1 VSSQ4 5 4
5 4 C1494 NM
4 51 MDQ14 DQM0
MDQ2 DQM1 180
DQ1 DQ14 6 3
6 3 5 50 MDQ13 DQM1
MDQ3 XWE 181
DQ2 DQ13 R1 7 2
7 2 6 49 NWE
MDQ4 C1488 182
VSSQ1 VDDQ4 8 1
8 1 7 48 NM R1512 VSS_13
C1491 L1512 183
DQ3 DQ12 R1486
8 47 MCK
R1481 56 C1506 100 184
56 DQ4 DQ11 MDQ12
C1482 9 46 VDD33_9
R1 5 4 MCK R1 185
VSSQ3 MDQ11
5 4 C1493 NM 10 VDDQ2 45 MCKI
MDQ5 6 3 186
DQ5 DQ10 MDQ10
6 3 11 44 VSS_14
MDQ6 7 2 C1503 R1 187
DQ6 DQ9 R1 MDQ9
7 2 12 43 VDD12_5
MDQ7 C1487 8 1 XCAS 188
VSSQ2 VDDQ3 IC1501
8 1 13 42 NCAS
C1492 NM MDQ8 189
DQ7 DQ8 XRAS
C1483 NM 14 41 R1489 NRAS MN2DS0018MAUB
VSS2 56 XCSM R1538 190
C1484 R1 15 VDD2 40 NCSM
DQM0 191

4
LDQM N.C/RFU
4

5 4 16 39 STANDBY
XWE 100K 192
R1482 WE UDQM MA11
6 3 17 38 DQM3
XCAS 56 MCK BA0 193
CAS CLK
7 2 18 37 BA0
XRAS MA9 194
RAS CKE
8 1 19 36 MA9
XCSM DQM1 195
CS N.C
5 4 20 35 56 5 4 VSS_15
BA0 MA11 C1507 196
R1483 BA0 A11
6 3 21 34 R1487 6 3 VDD33_10
BA1 56 MA9 BA1 R1 197
BA1 A9
7 2 22 33 7 2 BA1
MA10 MA8 MA8 198
A10/AP A8
8 1 23 32 8 1 MA8
MA0 56 MA7 MA10 199
A0 A7
5 4 24 31 R1488 5 4 MA10
MA1 MA6 MA7 200
R1484 A1 A6
6 3 25 30 6 3 MA7
MA2 56 MA5 MA0 201
A2 A5
7 2 26 29 7 2 MA0
MA3 MA4 MA6 202
A3 A4
8 1 C1485 27 8 1 MA6
28 203
VDD3 VSS1 MA1
MA1
R1 204
8 1 19 36 MA9
XCSM DQM1 195
CS N.C
5 4 20 35 56 5 4 VSS_15
BA0 MA11 C1507 196
R1483 BA0 A11
6 3 21 34 R1487 6 3 VDD33_10
BA1 56 MA9 BA1 R1 197
BA1 A9
7 2 22 33 7 2 BA1
MA10 MA8 MA8 198
A10/AP A8
8 1 23 32 8 1 MA8
MA0 56 MA7 MA10 199
A0 A7
5 4 24 31 R1488 5 4 MA10
MA1 MA6 MA7 200
R1484 A1 A6
6 3 25 30 6 3 MA7
MA2 56 MA5 MA0 201
A2 A5
7 2 26 29 7 2 MA0
MA3 MA4 MA6 202
A3 A4
8 1 C1485 27 8 1 MA6
28 203
VDD3 VSS1 MA1
MA1
R1 204
C1486 K4S641632N-LC75 VSS_16
C1508 205
NM DGND3 VDD33_11
SDRAM MA5 R1 206
MA5
MA2 207
MA2
5

208

5
MA4
GNDD MA4
MA3 209
MA3
210
C1509 VSS_17
211
VDD12_6
R1 212
EXADT0
213
NEXCE
214 NEXOE
215 EXDT0
EXDT8
216
I2C_SCL

EXDT1
EXDT2
EXDT10
VSS_1
VDD33_1
EXDT3
EXDT11
EXDT4
EXDT12
EXDT5
EXDT13
EXDT6
EXDT14
VSS_2
VDD33_2
EXDT7
EXDT15
VSS_3
VDD12_1
EXADR16
EXADT15
EXADT14
EXADT13
EXADT12
EXADT11
EXADT10
EXADT9
EXADT8
EXADR19
NEXWE
VSS_4
VDD33_3
EXADR18
EXADR17
EXADT7
EXADT6
EXADT5
EXADT4
EXADT3
EXADT2
EXADT1
VSS_5
VDD12_2
IRQPWR

CP_READY
I2C_SDA
08EJ

1
2
3 EXDT9
4
6
7
8
9

5
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
41
42
43
44
45
46
47
48
49

DEBUG
VCC33

R1
R1
GNDD
R1542

C1516 R1
C1517
C1519 R1

C1513
C1518 R1

CN1951

1 20
2 19
3 18
4 17
5 16
6 15
7 14
8 13
9 12
DGND2

1011
6R8K
6R8K

10K
10K
10K
10K
10K
10K

NM
R1546

100K
R1527

R1517
R1528
R1529
R1530
R1531
R1539

R1518

6
6

GNDD
NM
C1525

TRCST
TRCDATA3
TRCDATA2
TRCDATA1
TRCDATA0
TRCCLK
EXTRG0
SDATA
SCLOCK
A0
XCSF2
XRD
D0
D8
D1
D9
D2
D10
D3
D11
D4
D12
D5
D13
D6
D14
D7
D15
A16
A15
A14
A13
A12
A11
A10
A9
A8
A19
XWR1
A18
A17
A7
A6
A5
A4
A3
A2
A1
A20 R1547

VD8
C1201
100/16

VCC33 VCC33
FLASH 16M FLASH 16M PGND
IC1401 IC1402

A15 1 48 A16 A15 1 48 A16 C1203


A15 A16 A15 A16 C1409
2 47 C1404 A14 2 47 4R7
A14 4R7 HUP 20 21 NM
/BYTE
A14

AVH-P3200BT/XNUC
A14 /BYTE (2125) HU+ VM_S
A13 3 46 (2125) A13 3 46 C1204
A13 Vss2 A13 Vss2 HUM 19 22
HU- BH R1213
A12 4 A12 45 D15 A12 4 A12 45 D15 2200P C
HVP 18 23 1
DQ15_A-1 DQ15_A-1 HV+ SPRNF
A11 5 44 D7 A11 5 44 D7 C1209 R1214 C
HVM 17 24

7
7

A11 DQ7 A11 DQ7 HV- SPVM


6 43 1
A10 6 43 D14 A10 D14 HWP 16 25 R1 R1215 C
A10 DQ14 A10 DQ14 HW+ SPGND
7 42 A9 7 42 D6 S 1
A9 D6 A9 DQ6 HWM 15 26 COILU R1216
A9 DQ6 HW- U
A8 8 41 D13 A8 8 41 D13 R1212 S 1
A8 DQ13 A8 DQ13 HBM 14 27 COILV
270 HB V R1217
A19 9 40 D5 A19 9 40 D5 C1208 S
A19 DQ5 A19 DQ5 13 28 COILW 1
R01 SPCNF W R1218
10 39 D12 A20 10 39 D12 FG
XWR1 NC1 DQ12 NC1 DQ12 C1408 FG 12 FG 29
C1403 SLVM 1
XWR1 11 38 D4 XWR1 11 38 R1 D4
R1 /WE DQ4 C1205
/WE DQ4 11 TEST PGND 30
GND2
37 NRES R1403 12 /RESET 37 R1 C
NRES R1401 12 /RESET C1402 C1407 10 GND141 31
Vcc Vcc SL/LDO+
220 13 36 NM NM 13 36 NM D11 CONT2 220 C
D11 NC2 DQ11 CONT2 R1201 9
NC2 DQ11 NM

R01
CTL2 SL/LDO- 32
R1

14 35
C1405
14 35 D3 CONT1 F
4R7

C1401
D3 CONT1 R1202 220 8 33 FOP2 FOP
C1210

NC3 DQ3
C1211

NC3 DQ3 CTL1 FCO+


(3216)

15 RY_/BY 34 D10 15 RY_/BY 34 D10 MD1 S MD2 7 34 F FOM2


DQ10 MD FCO- FOM
GNDD DQ10 GNDD SPIN
A18 16 33 D2 A18 16 33 D2 LDIN 6 35 T TOM2
A18 DQ2 A18 DQ2 LDIN TOM
LDIN TKO+
A17 17 32 D9 A17 17 32 D9 R1204 5 36 T TOP2 PGND
A17 DQ9 A17 DQ9 CRGDRV R1203 C TOP
CRGDRV SLOPOUT
A7 18 31 D1 A7 18 31 D1 15K 4 TKO- 37
A7 DQ1 A7 DQ1 10K SLIN AVM
A6 19 30 D8 A6 19 30 D8 FD1 F 38
A6 DQ8 A6 DQ8 FD 3 FCIN
20 29 PREVcc
A5 20 29 D0 A5 D0 TD TD1 T 39
A5 DQ0 A5 DQ0 2 TKIN
C1207
21 28 PREGND R1
A4 21 28 XRD A4 XRD VHALF 1 40
A4 /OE A4 /OE VC SUBGND
A3 22 27 A3 22 27 42 VHALF
A3 Vss1 A3 Vss1 R1406
23 26 A2 23 26 100K IC1201
A2 A2 /CE PGND2 PGND1
A2 /CE BD8231EFV
A1 24 25 GNDD A1 24 25
100K

100K
R1405

A1 A0
8

R1402
A1 A0

8
A0 XCSF1 A0 XCSF2
CWW2267 CWW2268 PGND
R1409
NM
GNDD

C-a C-b

C-a
C-b

147
E
A

D
C

F
B
1 2 3 4

10.9 CONNECT PCB

D CONNECT PCB

B CN701
GND_B GND3 GND2 GND1 CKS6003

HOME 18 GND
S101 HOME1 HOME1_B HOME HOME_B
17 GND
4 3 1

R101
2

16 HOME
100
15 8SNS
CSN1068-A
14 DSCSNS
8SNS H+ HP
HALL BIAS+
S103 8SNS1 8SNS1_B 8SNS0 8SNS0_B 13
W W S
4 3 1

R102 COIL W
12
C
2

U U S
100 11 COIL U
CSN1068-A V V S

DSCSNS HW+ HWP


10 COIL V
CN1201
DSCSNS1 DSCSNS1_B DSCSNS0 DSCSNS0_B 9 HALL W+
CSN1068-A HW- HWM
R103 8 HALL W-
13 4

HV+ HVP
2

7 HALL V+
100 HVM
S102 HV-
6 HALL V-
C HU+ HUP
5 HALL U+
HU- HUM
4 HALL U-
H- HM
3 HALL BIAS-
CRGP C
CRG+
M1 C CRGM C
2

LOAD/CRG MOTOR 1 CRG-

CXC4026
BR
1 2
1
1

C101

0.1u/50

GY C
1
1

M2
H+,H-,HU+,HU-,HV+,HV-,HW+,HW-,U,V,W

SPINDLE MOTOR
D EXM1050 CKS6063

CN101
V S V
1 1
U S U
2 2
W S W
3 3
H- H-
4 4
HW+ HW+
5 5
H3 HW- HW-
6 6
HU+ HU+
7 7
H1 HU- HU-
8 8
HV+ HV+
9 9
H+ H+
H2 10 10
HV- HV-
11 11

D
AVH-P3200BT/XNUC
148
1 2 3 4
5 6 7 8

AVH-P3200BT/XNUC
5 6 7 8
149
1 2 3 4

10.10 KEYBOARD PCB

A
PART REFERENCE LEGEND

3501 ; KEYBOARD SECTION CHIP SIZE LEGEND


1608
VCC33
2125
3216

ILMB
A 5/6 CN541
8.0V
VCC33

CN3501 IC3501
GP1UXC14RK
CKS3861-A C3501
REM

R3510
VCC33 LEDB 1

47
1 NM

D3507
20 GND

NM
REM LEDG C3502 2
B 2 19 VCC
ILMB 3 18 LEDR 3
DCH1201-A
GNDKEY 4 17 RST

5 16 KDT1 ILMGND GNDKEY


6 15 KDT0

7 14 US5V

8 13 USG

9 12 USB-

10 11 USB+

GNDKEY

1 USB5V
2 USDM
3 USDP USB
4 USBGND
5 USBGND

CN3502
EMZC6.8N-TLB

D3506

C3507

YKS5032-A
4.7u/10

AUVG
E AUXV
AUAG
AUXR
AUXL
CTF1346-A
R3502 75 L3501
NM

NM

R3504 NM JA3501
CKN1084-A
DZ2S068C
D3501
D3502
D3503

D3504
D3505

R3505 NM AUXV
1 1

CTF1346-A L3502
2 2
3 3
AUXL
AUXR AUX
GND
4 4
R3501 R3503 L3503
AUX: +2.2 dBs
CTF1346-A
22k 22k
D3509

NM
C3506
0.1u/10

F ILMGND

ILMGND

E
AVH-P3200BT/XNUC
150
1 2 3 4
5 6 7 8

GEND E KEYBOARD PCB

VCC33

0.0~0.5V 0.5~1.2V 1.2~1.8V 1.8~2.4V 2.4~3.0V 3.0~3.3V


KDT0 EJECT DISP.OFF VOL+ VOL- x x
R3510

47

KDT1 SOURCE FORWARD REVERSE MODE MENU x B

R3514 R3515 R3516 R3517

1.8k 2.2k 4.7k 12k

SOURCE FORWARD REVERSE MODE MENU


RESET

R3511 R3512 R3513


1

1
2

2
2

2
CSG1155-A
CSG1155-A

CSG1155-A

CSG1155-A

CSG1155-A

CSG1155-A
1.8k 2.2k 4.7k
S3501

S3506

S3507

S3508

S3509

S3510
EJECT DISP.OFF VOL+ VOL-
3

3
4

4
C
1

1
2

2
CSG1155-A

CSG1155-A

CSG1155-A
CSG1155-A
S3504

S3505
S3502

S3503
3

3
4

GNDKEY
D3508
NSSM025A-A0886 ILMB D
B R3509 8.0V
4
G
3 1 NM
R
2 Common_Anode

C3503 0.1u/16

USB C3504
C3505
0.1u/16
0.1u/16
Q3501
UMX1N
1 6
02
A
R3521
E1
2
C1
5 R3526 R3531
Q3502
B1 B2 LSC4081UB
10k 3 4 10k 10k
C2 E2
(RED) (GREEN) (BLUE)
R3518

R3523

R3528
200

270

220

E
R3519
R3522

R3524

R3527

R3532
NM

NM

NM

R3529
150

270

220
NM

NM

NM
R3525
R3520

R3530

01 MONITOR I/F UNIT


-A
AUXV Consists of
AUXL
AUXR AUX ILMGND
INTERFACE PCB
GND KEYBOARD PCB
2 dBs MONITOR PCB
SD PCB
BT ANT PCB
F

E
AVH-P3200BT/XNUC
5 6 7 8
151
1 2 3 4

10.11 MONITOR PCB(GERDA)(GUIDE PAGE)

A F-a 1/2
R5200

C5808 0
GD12V
R5001 R5002 1000p/50
POWER PWRVI
for LCD
NM NM
GD12V for GERDA-L 5V
NM
1.2V PNLVI
IC5201 IC5202 D5202 IC5203
GNDV AVAGND GNDV C5201 GR33 D5201 PNLVI 3.4V
0.01u/16 1 5
GD33V 1 6 1SR154-400 1 5
R5003
SG001552 R5004 Nr Vo VOUT VIN VIN VOUT
2 SG001549 2 5 2
GND GD33V VSS1 VSS2 VSS
NM NM

C5203

DCH1201-A
3 4 3.3V 3 4 R5209 3 4
Vc Vin ON/OFF NC ON/OFF NC
AVBGND GNDD GNDBL NM

C5204
S-1172B34-E6 NM
PQ1LA125MSPQ

NM

R5203

NM
5V 3.4V

SG001549
5V 3.4V

10u 10V
3.4V 1.2V

10u 10V
DCH1201-A

1u/10
C5202

C5206

R5205
NM
C5205
R5201

NM

NM
C5212
1u/10
C5211

C5208
NM

1u/10

R5202
R5207

1k
10k

V33A V33A
68

R5900

5.6k
R5902
R5901

4.7u/10
C5210

0.1u/10
GNDD

C5209
100

R5903
B

27
GNDD Q5900
1 E1 C1 6
MONPW R5904 R5905 2 E2 5
47k 100k 3 B1 4
B2 C2

1
4
3
2

R5524
10k
UMX2N
GNDD
T

5
6
7
8
RGBVI GNDV RGBVI
C5308
0.1u/10
C5307
R5313 R5314
15k 10k 0.1u/10
AVAGND

0.1u/10
AVAGND

C5532
C5314
TC75S57FU IC5312
C5809
1 IN- R5317 1 5
VDD 5 INB Vcc
0.1u/10
NM AVAGND
2 VSS 1k 2

R5559

NM
(from NAVI) INA
to TOUCH PANEL

47k
R5311 3 IN+ R5318 3 4 R5322 3.3V(max)
CSYNC OUT 4 GND OUTY
270 1k 6.8k
R5312

R5521
C5311

R5321
NM
ADVX
ADVX
ADVY

680k

IC5311 TC7SET08FUS1
PLYV
PLYV
PLXV
PLXV

10k
ADVY
NC

NC

RGBVI
AVAGND

44
43
42
41
40
39
AVAGND C5525
10
1
2
3
4
5
6
7
8
9

R5518 (D) 10k 33p/50

VDD3
DV0HSY

VSS3
L5807

DV0VSY
DV0R5

DV0R4
DV0CLK
AVAGND
CTF1545-A C5507 45
C AVAGND

0.1u/10
C5807 46 CMPAOUT 0.1u/10

C5518
CN5101
CKS5561-A 0.1u/10
AV0IREF
47 AV0VREFH C5508
AV0VREFL
Q5807 AVAGND 48 0.1u/10
C5101 LSC4081UB AV0VCMO
NM R5836 C5526 10u 10V (max1.0V) 49 C5514
ANA_G NM
AV0INA
1.2k DCH1201-A V33A L5501 50 0.1u/10
D5101 AVDDA
R5840

NM CTF1473-A 51

C5513

C5527
2.2k

1000p/50
R5835

AV0INB

0.1u/10
390

C5506 52
CVIDEO 0.8Vp-p(max1.0V) 10u/10_Ta C5570
C5102 C5504 AVSSA
NM 53
AV1VREFH

0.1u/10
DCH1201-A 54
C5509

C5516
AVAGND AVAGND 10u 10V AVAGND
D5102 AVAGND 0.1u/10 AV1VREFL
NM 55
RGBVI C5510 AV1VCMO
RGBVI 0.1u/10 C5515 56
C5524
C5103 (max1.0V) NM AV1IN
NM L5305 57
5.1V C5511 AVDDA2
CTF1545-A DCH1201-A 0.1u/10 58

C5517
C5529

0.1u/10
C.VIDEO
R5309

D5103 0.1u/10 AV2VREFH


0

NM 59
C5512
0.1u/10 AV2VREFL
C5304

60
C5305
0.1u/10

C5104 AVSSA2
R5316

NM C5301 NM NM 61
IC5301 C5520
470

R5302 DCH1201-A AV2VCMO


C5303

0.1u/10

100 10V 10u AVAGND (max1.0V) AVAGND 62


MONVBS C5521
R5300

D5104 Vin V+ AV2IN


4.7k

NM 4 3 DCH1201-A L5502 CTF1545-A 63


C5302 10u 10V
DCH1201-A GND C5309 AVDDP
2 R5303 V33A C5571 64
GNDV 10u 10V Q5808
VGND Vout 0.1u/10 C5519 TSTIO
R5301 5 1 DCH1201-A 750 LSA1576UB R5511 C5505 470p/10 65
GNDD 100 1k 10u/10_Ta AVSSP
R5315

NJM2505AF 10V 10u R5508 66


4.7k

AVAGND EPDI AVBGND


GPIO15
NM 5 4 67
EPDO
GPIO14
EPCK 6 3 68
GPIO13
R5509 EPCE 7 2 69
GPIO12
1 70
4
3
2
1

56k 8 L5522 CTF1545-A


AVAGND
DO

PWRVI VDD4
CS

NM
SK
DI

RGBVI RGBVI GtoS R5516 270


71

D L5002
CTF1469-A
5.1V
StoG R5517 270 R5560
C5522
0.1u/10
72
GPIO11
GPIO10
TEST

L5808 73
GND

R5510
VCC

DtoG R5513 470 10k


NC

CTF1545-A R5561 GPIO0


GtoD R5514 10k 74
GPIO1
5
6
7
8

C5528
C5003

470 75
1u/6.3

L5528 0.1u/10
0.1u/10 CTF1545-A VDDI2
PWRVI Q5805 C5503 0.1u/10 DGCLK R5515 76
LSC4081UB C5805 GPIO2
5V R5838 GNDD IC5501 180 R5501 77
ANA_B
50 S-93C66BD0I-I8 10k GPIO3
AVAGND 1.2k AVAGND 78
49 VSS4
R5555 TP5502
79
R5833

48 GPIO4
390
R5841

RGBVI R5556 10k TP5503 80


2.2k

R5323
47 5.1V 10k GPIO5
GNDD1 R5502 81
0V NM
46 L5806 GPIO6
AVAGND CTF1545-A Hi Lo R5553 10k 82
45 GPIO7
AVAGND C5806 83
MONPW 10k
44
0.1u/10
82PIN 1DIN 2DIN R5324 84
GPIO8
3.3V GNDD NM
43 L5523 VDD5
3.3V ANA_R R5839 CTF1545-A 85 VSS5
Q5806 AVAGND C5523
42 83PIN 6.95 5.8 GPIO9

LCDMUTE
LSC4081UB
0V 1.2k SHUT R5534 100 0.1u/10 86 LCD0CLK
R5310

LCD0C1
LCD0C0
LCD0C2
F 2/2 OSCXO
41
2.2k

OSCXI
87

VSS6
3.3V LCD0CLK 1 2
40
R5834

R5512 L5512 88
390

0V
39 270 CTF1748-A
ILR AVAGND
89
90
91
92
93
94
0V ILR
38 KEY BUS
ILG ILG
0V AVAGND
37
0V ILB ILB
10k
R5570

36
470

GNDKEY
R5520

0V
35
34
0V GNDKEY VCC33
3.3V VCC33
33
0V REM REM R5519
32
0V KEY1 KEY1 NM
31
KEY0 KEY0 X5501
30 0V GNDD
E 1

A 5/6 0V GNDILM 2
29 GNDILM 1 2
C5531 12p/50

28 ILMB ILMB 4
R5523 270
270

8.0V 33
CN511 27
0V
HDRST
HDRST
4
C5530
9p/50

R5522

26
DtoG
3.3V DtoG
25
GtoD CSS1792-A
0V GtoD 33MHz
24 GNDD
LHSY
LVSY

DGCLK
3.3V DGCLK
23
3.3V StoG StoG
22
GtoS GtoS GRST
21 3.3V
GRST GRST
20 3.3V
0V
19
ANAG ANA_G GERDA BUS
18 2.4V
2.4V ANAR ANA_R
17
2.4V CSYNC CSYNC
16
2.4V ANAB ANA_B
15
GNDV
14
2.1V MOVBS MONVBS
13
R5891 VIDEO BUS
12
NM GNDBL
11 GNDV
10 GNDBL
9 PWRBL
8.0V PWRBL
8 8V

7
6
1.2V BLERR1 BLERR1
5
0V BLCLK BLCLK
4
F 3
3.3V MBLPW
DIMPLS
MBLPW
DIMPLS
2 0V
2.3V TEMP1
BACKLIGHT BUS
1

CN5002
DKN1385-A

F 2/2
F 1/2
AVH-P3200BT/XNUC
152
1 2 3 4
5 6 7 8

F-b 1/2 A

GD33V
3.3V
F 1/2 MONITOR PCB (GERDA)

CTF1545-A
L5401

FAD0
NFR0E

NFRCS0
FAD16

FDATA7

FDATA6

FDATA5

FDATA4

FDATA3

FDATA2
FDATA9
FDATA1
FDATA8
FDATA0
FDATA15

FDATA14

FDATA13

FDATA12

FDATA11

FDATA10

RB MOUNT
0.1u/10
C5403
PNLVI

R*16
PNLVI 3.4V

18
C5401

R5401

R5889
CN5501

R5870
18 R5871
18 R5872
18 R5873
18 R5874
18 R5875
18 R5876
18 R5877

R5878
18 R5879
18 R5880

18 R5882
18 R5883
18 R5884
18 R5885

R5886
10k
4.7u/6.3

18 R5881

39

68
VKN2040-A

18
GD33V C5402

3.3V
10u 10V

1
R5205

SYSTEM UNIT PART 5001


C5205

NM

NM

2 TOUCH PANELPART 5101

48
47
46
45
44
43
42
41
40
39
38
37
36
35
34
33
32
31
30
29
28
27
26
25

64M Flash
3 POWER PART 5201
GNDD

OE
VCC

CE
DQ7

DQ6

DQ5

DQ4

WP/ACC DQ3

DQ2
DQ9
DQ1
DQ8
DQ0

A0
BYTE

DQ14

DQ13

DQ12

DQ11

RY/BY DQ10
VSS2

VSS1
VIDEO PART 5301

A16
GRST1
4

DQ15/A-1
CWW2019
FLASH ROM PART 5401

IC5703
TRCST
5 GERDA IC PART 5501

RESET
TRCCLK LCD PANEL PART 5601

A15
A14
A13
A12
A11
A10

A19
A20

A21

A18
A17
6

WE
A9
A8

A7
A6
A5
A4
A3
A2
A1
BACKLIGHT PART 5701
7
68 KEY BOARD PART 5801

1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
8 SDATA
5902 SCLOCK
9
10 GNDD

11
TRCD3 CHIP SIZE LEGEND
1608
B
TRCD2

1k
R5403
22
R5402
12
TRCD1 2125
13
3216
TRCD0
14
3225

NFRWE
FAD15
FAD14
FAD13
FAD12
FAD11

FAD19
FAD20

GRST1
FAD10

FAD21

FAD18
FAD17
FAD9
FAD8

FAD7
FAD6
FAD5
FAD4
FAD3
FAD2
FAD1
1
4
3
2
1
4
3
2

R5532
10k
R5524
10k

SCLOCK
5
6
7
8

TRCCLK SCLK
5
6
7
8

SDATA
TRCST SDATA GRST1
TRCD3 GRST1
TRCD2

TRCD1 GD33V GD12V


FDATA9
FDATA8
FDATA7
FDATA6
FDATA5
FDATA4
FDATA3
FDATA2
FDATA1
FDATA0
FDATA15
FDATA14
FDATA13
FDATA12
FDATA11

FDATA10

TRCD0 3.3V 1.2V

CTF1473-A
L5504
L5506
CTF1473-A
CTF1545-A

C5555
L5534

47u/10_Ta
47u/10_Ta
0.1u/10
C5532

R5533

C5542
10k
R5559

NM
47k

27 CTF1545-A
C5534

0.1u/10
13 CTF1545-A

C5539
0.1u/10

L5538

0.1u/10
C5536

L5503
R5521
44
43
42
41
40
39
38
37
36
35
34
33
32
31
30
29
28

26
25
24
23
22
21
20
19
18
17
16
15
14

12
11
10

5
9
8
7
6

4
3
2
1

C5525
33p/50
VDD3

VDD2

VDD1
DV0HSY

DV0G5
DV0G4
DV0G3
DV0G2
DV0G1
DV0G0
VSS3

VSS2

VSS1
DV0VSY
DV0R5

DV0R4
DV0R3
DV0R2
DV0R1
DV0R0
DV0CLK

DV0B5
DV0B4
DV0B3
DV0B2
DV0B1
DV0B0

FDATA9
FDATA8
FDATA7
FDATA6
FDATA5
FDATA4
FDATA3
FDATA2
FDATA1
FDATA0
FDATA15
FDATA14
FDATA13
FDATA12
FDATA11

FDATA10
VDDI1

45 C5547

46 CMPAOUT VSS14 175


176 0.1u/10
C
AV0IREF VDD13 L5548
47 AV0VREFH VDDI7 174 CTF1545-A
C5548
AV0VREFL FAD22 0.1u/10
48 173 FAD21
AV0VCMO FAD21
49 172 C5502
1u/10
AV0INA VDDI6 C5549
50 171 0.1u/10 FAD20
AVDDA FAD20
51
C5527

170 FAD19
AV0INB FAD19
0.1u/10

52 169 FAD18
AVSSA FAD18 C5550
53 168 L5507 GD33V
0.1u/10
AV1VREFH AVDDR
54 167 CTF1473-A
AV1VREFL VSS13 C5557
55 166 C5544
0.1u/10 47u/10_Ta
AV1VCMO VDD12 L5543
56 165 CTF1545-A
AV1IN PVPPDRAM
57 164 C5545 FAD17
AVDDA2 FAD17
C5529 58 163 0.01u/16
FAD16
1u/10 AV2VREFH FAD16
59 162 FAD15
60
AV2VREFL FAD15
161 FAD14
CN5601
AVSSA2 FAD14 CKS6062-A
NM 61 160 FAD13
AV2VCMO FAD13 40 GND
62 159 LCK
FAD12 LCD0CLK 1.7V
AV2IN FAD12 39 DCLK
63

GERDA-L
158
AVDDP VSS12 38 GND
64 157 FAD11 LB0 LB0 0.6V
19 TSTIO FAD11 37 B0
0 65 156 FAD10 LB1 LB1 1.0V
AVSSP FAD10 36 B1
66 155 LB2
FAD9 LB2 1.0V
GPIO15 FAD9 35 B2
67 154 FAD8 LB3 LB3 0.9V
GPIO14 FAD8 34 B3
68 IC5502 153 FAD7 LB4 LB4 0.7V
GPIO13 FAD7 33 B4
69 MN103SH13UB 152 L5551 LB5 LB5 0.6V
GPIO12 VDD11 CTF1545-A 32 B5
5-A 70 151 FAD6
VDD4 FAD6 C5551 31 GND
71 150 LG0
0.1u/10 FAD5 LG0 0.6V
2
10
72
GPIO11
GPIO10
FAD5
FAD4
149 FAD4 LG1 LG1 0.8V
30 G0
29 G1
D
73 148 C5501 LG2 LG2 0.7V
GPIO0 VDDI5 1u/10 28 G2
74 147 C5552 LG3 LG3 0.6V
GPIO1 27 G3

to LCD MODULE
8 PINMD0 0.1u/10
0.1u/10 75 146 SCLOCK LG4 LG4 0.4V
VDDI2 SCLOCK 26 G4
76 145 C5546
1u/10 L5546 LG5 LG5 0.4V
GPIO2 VDD10 CTF1545-A 25 G5
1 77 144 C5553
10k GPIO3 VSS11 24 GND
78 143 0.1u/10
SDATA LR0 LR0 0.2V
VSS4 SDATA 23 R0
5 TP5502
79 142 LR1 LR1 0.7V
GPIO4 TSTC2 22 R1
6 10k TP5503 80 141 GD33V LR2 LR2 0.6V
10k GPIO5 TSTC1 21 R2
81 140 L5508
LR3 LR3 0.5V
GPIO6 PINMD2 20 R3
82 139 CTF1545-A LR4 LR4 0.3V
GPIO7 VSS10 19 R4
(from Jig)

83 138 LR5 LR5 0.2V


GPIO8 TSTCK 18 R5
84 137
VDD5 TSTC0 17 GND
C5523 85 VSS5 LCDICLK 136 SHUT SHUT 0V
GPIO9 NMI 16 SHUT
LCDMUTE

0.1u/10 86 LCD0CLK NRST 135 R5543 10k LCDICLK


NFRCS1
NFRCS0
LCD0G0
LCD0G1
LCD0G2
LCD0G3
LCD0G4
LCD0G5
LCD0C1
LCD0C0
LCD0C2

LCD0C3
LCD0C4

LCD0R0
LCD0R1
LCD0R2
LCD0R3
LCD0R4
LCD0R5
LCD0B0
LCD0B1

LCD0B2
LCD0B3
LCD0B4
LCD0B5

NFRWE
OSCXO

NFROE

LHSY 15 GND
OSCXI

VDDI3

VDDI4

R5544
VDD6

VDD7

VDD8

VDD9

87 134
VSS6

VSS7

VSS8

FAD0

VSS9

FAD1
FAD2
FAD3

R5557 GRST1 LHSY 3.4V


0 14 HSYNC
88 133 1k LVSY
(to FlashROM)

LVSY 3.4V
(from System -Com)

13 VSYNC
89
90
91
92
93
94
95
96
97
98
99
100
101
102
103
104
105
106
107
108
109
110
111
112
113
114
115
116
117
118
119
120
121
122
123
124
125
126
127
128
129
130
131
132

R5549

12 TEST
C5543
1000p/50

IC5503
11 TEST
1 5
CTF1545-A

CTF1545-A
10k
R5570

C5533

C5535
0.1u/10

C5537

NC Vcc 10 TEST
0.1u/10
470

C5538

C5540

C5541
0.1u/10

0.1u/10
L5705

0.1u/10

0.1u/10

2
R5520

PNLVCC
L5706

INA PNLVI 9 NC
GRST

3 4 R5547
GND0 OUTY 8 VCC
22 L5601 3.4V
7 VCC
R5519 TC7SHU04FUS1 CTF1473-A
R5546
DCH1201-A

6 VCC
C5602
10u 10V

0.1u/10
CTF1545-A
L5535

C5601

NM 1M 5 VCC
NM

X5501
R5548

4 33
3.3k

4 4
1 2
NC
E
100
100

0.1u/10

2 3 GND
18p/50

C5559
C5560

1 2
C5531 12p/50

5 R5551
100
100

1 2 2 GND
C5558

18p/50
100

4
R5523 270
270

33
100
100

X5502 1 GND
R5539
R5540

C5556
R5536
R5537

CSS1787-A
8
7
6
5

8
7
6

8
7
6
5
R5522

R5552

9.597MHz
R5550

NFRCS0
R5530
R5531

100

100

GNDD
NFRWE
NFR0E

FAD0

FAD1
FAD2
FAD3

CSS1792-A
2
3
4

LG3 2
LG4 3
LG5 4

LR3 2
LR4 3
LR5 4

33MHz
1

LG2 1

LR2 1

GNDD
LHSY
LVSY

GNDD
LG0

LG1

LR0
LR1
LB0
LB1

LB2
LB3
LB4
LB5

MONITOR I/F UNIT


Consists of
INTERFACE PCB
KEYBOARD PCB
MONITOR PCB
SD PCB
BT ANT PCB F

F 1/2
AVH-P3200BT/XNUC
5 6 7 8
153
4 3 2 1
154
AVH-P3200BT/XNUC
0
5

68
67
66
65
64
63
62
61
60
59
58
57
56
55
54
53
52
51
50
49
48
45
PNLVI

R5205
4 NM
44 R5559 5
AV2IN
AV1IN

TSTIO
AVSSP
AVSSA

AVDDP
AVDDA
AV0INB
AV0INA

GPIO14
GPIO15
AVSSA2
AVDDA2
AV0IREF

F-b 1/2
43 R5521 6 3
AV2VCMO
AV1VCMO
AV0VCMO

NM
PNLVI

46 CMPAOUT

AV2VREFL
AV1VREFL
AV0VREFL

DV0HSY
AV2VREFH
AV1VREFH
47 AV0VREFH
3.4V

DV0VSY 42 47k 7 2
DV0CLK
DV0R5 41 8 1
R5524
VDD3
F
10k
40 C5532
VSS3 0.1u/10
39
DV0R4
38
9
8
7
6
5
4
3
2
1

14
13
12
11
10

DV0R3
37
TRCCLK

DV0R2
36
TRCST

DV0R1 5 4
TRCD3

35
TRCD2
TRCD0
TRCD1
TRCD2
TRCD3
TRCST
GRST1

SDATA

6 3
TRCCLK

DV0R0
SCLOCK
GD33V

34
VKN2040-A

TRCD1

L5534 7 2
3.3V
CN5501

VDDI1
33 CTF1545-A
TRCD0

DV0G5 8 1
32 C5534 R5532
0.1u/10 10k
DV0G4
31
DV0G3
30
GRST1

DV0G2
29
SDATA

DV0G1
28 L5538
SCLK

DV0G0
27 CTF1545-A R5533
VDD2
26 10k
VSS2 C5536
GNDD

25 0.1u/10
DV0B5
24
DV0B4
23
IC5502

DV0B3
22
DV0B2
E
21 L5401
DV0B1
20 CTF1545-A
DV0B0
GD33V

GERDA-L

19 FDATA15
3.3V

C5402

FDATA15
4.7u/6.3
C5401

18 FDATA14
FDATA14
17 FDATA13
FDATA13
16 FDATA12
FDATA12
15 FDATA11 IC5703
FDATA11 CWW2019
14 L5503
VSS1 FAD15 1 48 FAD16
13 CTF1545-A A15 A16
VDD1 FAD14 2 47 R5401
12 FDATA10 A14 BYTE
FDATA10 C5539 FAD13 3 46 10k
11 0.1u/10 FDATA9 A13 VSS2
FDATA9 FAD12 4 45 R5870 FDATA15
10 FDATA8 A12
DQ15/A-1
FDATA8 FAD11 5 44 18 R5871
9 A11 DQ7 FDATA7
FDATA7
FDATA7 FAD10 6 43 18 R5872
8 A10 DQ14 FDATA14
FDATA6
FDATA6 FAD9 7 42 18 R5873
7 A9 DQ6 FDATA6
FDATA5
FDATA5 FAD8 8 41 18 R5874
6 A8 DQ13 FDATA13
FDATA4
FDATA4 FAD19 9 40 18 R5875
5 A19 DQ5 FDATA5
FDATA3
FDATA3 FAD20 10 39 18 R5876
4 A20 DQ12 FDATA12
FDATA2 FDATA2
FDATA1 NFRWE 11 38 18 R5877 FDATA4
3 FDATA1 WE DQ4 C5403
FDATA0
D
GRST1 R5402 12 37 18 0.1u/10
2 FDATA0 RESET VCC
22 13 36
VDDI6

FAD21 R5878

FAD10
FAD11
VSS12
FAD12
FAD13
FAD14
FAD15
FAD16
FAD17
VSS13
FAD18
FAD19
FAD20
FAD21
FAD22

FAD8
VDD12
VDD13

FAD9
FDATA11

PVPPDRAM
AVDDR
1 A21 DQ11
R5403 14 35 18 R5879 FDATA3
L5504 WP/ACC DQ3

157
158
159
160
161
162
163
164
166
167
168
169
170
171
172
173
VDDI7 174
VSS14 175
176

1 3
154
155
156
1k 15 34 18 R5880
CTF1473-A RY/BY DQ10 FDATA10

You might also like