Professional Documents
Culture Documents
Wi-Fi Networks
Introduction
• Wi-Fi networks employ the IEEE 802.11 protocol,
which uses the unlicensed 2.4 GHz ISM RF band.
• The ISM band is used by multiple devices (both Wi-Fi
and non-Wi-Fi), inherently causing interference for
one another.
• Non-Wi-Fi devices are oblivious to the 802.11
protocol.
• Deployment/operation of Wi-Fi networks often
happens without knowledge of the ambient usage of
the ISM band by non-Wi-Fi devices.
2
Objectives
• We consider 6 non-Wi-Fi devices:
– Unintentional interferers: a microwave oven, two cordless
phones (one analog and one digital) (omitted), an analog
wireless camera, and a Bluetooth headset.
– Intentional interferer: wireless jammer.
• We study:
– Physical layer characteristics of interferers (controlled
experiments)
– Interference on data, video, and voice traffic (controlled
experiments)
– Interference on the operational performance of production
network (passive measurements)
3
Channel Structure in Wi-Fi
Metrics
Unintentional Interferers
Microwave Oven
Analog Video Camera
Bluetooth Headset
Intentional Interferer
Wireless Jammer
5
Physical Layer Metrics
• Spectrograms:
– Representation of the RF power levels over time in the
spectrum.
– Offer a temporal perspective of RF power in the frequency
domain.
• Duty Cycle:
– Measures the RF power in the spectrum; indicator of the
impact of RF power on network performance.
– Calculated by measuring the percentage of time the RF
signal is 20 dBm above the noise floor.
• Tool: Off-the-shelf spectrum analyzer.
6
Microwave Oven
7
Analog Video Camera
Experimental Setup
Metrics
Data Traffic
Voice Traffic
11
Impact of Interferers on Wi-Fi Traffic
12
Experimental Setup
14
Experimental Results: Data Traffic
• Minimal impact due to
Bluetooth headset (20%
at close range).
• Microwave oven has
significant impact, even
at long range (25% at
25m).
• Similar impact for
camera and phone
(sharp decrease > 20m).
15
Experimental Results: Voice Traffic
• No impact due to
Bluetooth headset at
long range.
• Impact of microwave
oven sharply plummets
with increasing distance.
• Significant impact due to
camera/phone;
consistently decreases
with longer distances.
16
INTERFERENCE IN CAMPUS NETWORK
(PASSIVE MEASUREMENTS)
Channel Utilization
Active Time of Interferers
17
Interference in Campus Network
• Took physical-layer measurements for 8 hours
during a weekday in the campus Wi-Fi
network.
• Measurements were taken at a popular café
frequented by students and faculty.
• Tool: spectrum analyzer.
18
Channel Utilization
• Ch. utilization is the %tage of
time a transmission is
present from a known RF
source in a given ch.
• Ch. 1 and 6, utilization
peaked near 60%, while for
ch. 11 it was over 90%.
• Ch. 11 spikes caused due to
microwave ovens, cordless
phones, Bluetooth, and
other fixed-frequency
devices.
19
Active Time of Interferers
• Microwave ovens were active
31% of the time.
• Bluetooth devices were active
12.5% of the time and had an
avg. duty cycle of roughly 5%.
• Cordless phones were
cumulatively active for more
than the entire trace period.
• Other interferers were observed
active only 6% of the total trace
period, but had the highest
average duty cycle (15%) and
maximum duty cycle (60%).
20
SUMMARY
21
Summary
• The campus network is exposed to a large variety of
non-Wi-Fi devices; these devices can have a significant
impact on the interference level in the network.
• Controlled experiments showed that, even at
distances up to 30 m, some of these non-Wi-Fi devices
can have a significant negative impact on data, video,
and voice traffic.
• It is important to understand and quickly adapt to the
devices affecting the performance of the Wi-Fi
channels.
22